油页岩灰渣浸取铝酸钠溶液试验研究

以油页岩废渣为原料,通过酸浸法浸取油页岩灰渣中的铝酸钠溶液。采用焙烧活化方法将废渣中含铝的低活性晶体物质活化为高活性半晶体或非晶体物质,利用酸浸法浸取焙烧后的高活性含铝废渣,得到铝液;依据试验分析了影响酸浸法浸取铝酸钠溶液的主要影响因素为焙烧温度、焙烧时间、浸取酸浓度和浸取温度;得出酸浸法的最佳工艺参数：活化温度850℃,活化时间3h,选用酸浓度40％,浸取温度60℃,此时油页岩废渣铝浸取率为75％。     

从废次烟叶中提取茄尼醇的研究

采用有机溶剂浸取法从烟草废弃物中提取茄尼醇,对萃取溶剂和工艺条件进行了筛选,实验结果表明以石油醚作溶剂,提取时间3h,温度35℃为提取茄尼醇较适宜的条件,茄尼醇提取率达2．8％,溶剂回收率为68．6％。     

闪锌矿常压酸浸含硫气体排放量控制研究

采用铁闪锌矿常压直接酸浸制取硫酸锌、研究了浸取条件对气体硫化物排放量的影响。试验结果表明:浸取时硫酸浓度为20％～40％(m),温度为120～140℃,液固比为(4:1)～(8:1)(m),通氧速度为35～50cm~3·(min.dm~3)~(-1),含硫气体排放量最低,常压酸浸2h,锌的一次浸取率达90％以上,闪锌矿中的硫绝大部分转化为单质硫。     

氧化亚铁硫杆菌脱除不同煤种硫分实验研究

利用氧化亚铁硫杆菌对煤中硫分的脱除作用,探讨了其对3种不同地域且不同矿物含量煤的脱硫作用。进行了未酸化与酸化处理煤样脱硫试验、温度影响试验、初始pH值影响试验。结果表明：未预处理条件下煤样I、n、Ⅲ的脱硫率分别为29．3％、3．9％、3．5％,酸处理后迭到39．8％、40．7％、4．2％。煤样Ⅰ、Ⅱ的最佳脱硫温度分别为35℃、30℃;温度30℃,初始pH为2．3时,煤样Ⅰ、Л的脱硫效果最好,分别为54％、67％;温度和pH的变化对煤样山的影响不大。30℃,初始pH为2．3时煤样Ⅰ、Ⅱ、Ⅲ的黄铁矿硫去除率分别为77％、83％、67％。     

烟气生物脱硫污泥中单质硫的回收工艺中试研究

针对烟气生物脱硫污泥中单质硫磺难以回收和利用的问题,研究设计了一条以有机溶剂四氯乙烯(PCE)高温萃取-降温结晶技术为主体工艺的路线.经过几个月的中试研究表明,PCE萃取工艺是一种有效的回收硫泥中单质硫磺的方法,得出如下最优的运行参数:干燥后的硫泥粉碎到粒径0.05～0.15 mm(100～300目)、接触反应时间为10～15min、接触反应的温度范围85～100℃,PCE与硫泥的投加比例为4～5 mL/g,降温结晶至25℃以下.试验结果表明,回收的硫磺纯度在96.5%以上,硫的回收率在90%以上.最后从所需蒸汽费、冷却水费、电耗费、人工费、PCE消耗费等几个方面对该工艺应用于拟建的硫回收工程进行了经济效益分析,拟建工程的运行成本为230元/t,净收益为770元/t,年收益可达到281万元,可产生可观的经济、环境和社会效益.     

综合治理合成氨装置硫化氢恶臭

镇海炼化股份公司化肥厂合成氨装置，通过挖潜改造，工艺上进行优化操作，提高了流化氢废气处理量，使硫磺装置开工率和回收率分别达到99．7％和99．0％；使合成氨装置H：S废气全部回收，消除了装置区H2S恶臭，年增产硫磺2503t，取得了明显的环境效益和经济效益．     

广州石化硫磺回收联合装置建成中交

2005年12月26日，广州石化炼油改扩建工程硫磺回收联合装置建成中交。该装置年制硫能力达到140kt，是目前国内处理能力最大的硫磺回收环保装置。该项目计划投资3．57亿元，计划在2006年3月1日正式投产。该装置投产后可以确保广州石化炼油改扩建后增产不增污，能满足国家大气污染物综合排放标准及广东省地方大气污染物限制标准的要求，SO2排放浓度小于850mg／m^3，硫回收率达到99．8％以上。     

硫磺回收尾气处理调查

一、概述硫磺回收工艺虽然硫的转化率和收率得到不断提高,但终究不能将原料酸性气中H_2S 全部转化成元素硫并且得到回收。例如一般采用掺合法的两级转化器的硫磺回收装置硫收率为90～94.0%;采用间接加热的两级转化器的硫收率为93～96.9%三级转化器的硫收率为95～97.8%,所以尾气中必然存在 H_2S、SO_2等有害气体,一般硫化物浓度约     

从低含硫尾渣中回收元素硫的研究

以硫酸烧渣强化酸浸提铁后的低含硫尾渣为原料,对硫化铵溶硫—热分解析硫的硫磺回收工艺进行了优化研究。分析了硫化铵浓度、液固比、溶解温度、溶解时间、热分解温度、分解时间对硫磺提取效果的影响。结果表明:硫化铵浓度1.17 mol/L,液固比10 mL/g,在25℃下振荡溶解5 min,100℃下热分解120 min,硫的溶浸率和析出率可分别达到97%和99%以上。此优化既可有效减少尾渣对环境的污染,又能实现资源再利用。     

湿式提砷法在处理工业废水及废渣中的应用

采用硫化法去除冶金工业酸性废水中的砷．除砷形成的含砷（ 主要成分 As₂S₃） 废渣用浓硫酸处理,废渣中的砷元素以 As₂O₃ 形式回收,纯度达99.4 ％ ,同时回收副产物硫磺等．试验结果表明,该方法的化学反应速度快,工艺过程稳定,砷的总回收率达95 ％ 以上,除砷效率可达99.99 ％ ．     

Effects of two sludge application on fractionation and phytotoxicity of zinc and copper in the soil

The potential harm of heavy metals is a primary concern in application of sludge to the agricultural land. A pot experiment was conducted to evaluate the effect of two sludges on fractionation of Zn and Cu in soil and their phytotoxicity to pakchoi. The loamy soil was mixed with 0%, 20%, 40%, 60% and 80% (by weight) of digested sewage sludge (SS) and composted sludge (SC). The additions of both sludges caused a significant raise in all fractions, resulting in that exchangeable (EXCH) and organic bound (OM) became predominance of Zn and organic bound Cu occupied the largest portion. There was more available amount of Zn and Cu in SS treatments than SC treatments. During the pot experiment, the concentration of Zn in EXCH, carbonate (CAR) and OM and Cu in EXCH and OM fractions decreased in all treatments, so their bioavailability reduced. Germination rate and plant biomass decreased when the addition rate was high and the best yield appeared in 20% mixtures at the harvest of pakchoi. The two sludges increased tissue contents of Zn and Cu especially in the SS treatments. Zn in pakchoi was not only in relationship to ΔEXCH and ΔCAR forms but also in ΔOM forms in the sludge-soil mixtures. Tissue content of Cu in pakchoi grown on SC-soils could not be predicted by ΔEXCH. These correlation rates between Zn and Cu accumulation in pakchoi and variation of different fractions increased with time, which might indicate that sludges represented stronger impacts on the plant in long-term land application.     

Intraspecific differences in effects of co-contamination of cadmium and

A hydroponic experiment was carried out to study intraspecific differences in the effects of different concentrations of cadmium (Cd)(0-10 mg/L) and arsenate (As(V)) (0-8 mg/L) on the growth parameters and accumulation of Cd and As in six wheat varieties Jing-9428, Duokang-1, Jingdong-11, Jing-411, Jingdong-8 and Zhongmai-8. The endpoints of wheat seedlings, including seed germination,biomass, root length and shoot height, decreased with increasing the Cd and As concentrations. Significant differences in seed germination, biomass, root length, shoot height and the accumulation of Cd and As were observed between the treatments and among the varieties (p ＜ 0.05). The lethal dosage 50% were about 20, 80, 60, 60, 80 and 20 mg As/L for Jing-9428, Duokang-1, Jingdong-11,Jing-411, Jingdong-8 and Zhongmai-8, respectively, and the corresponding values for Cd were about 30, 80, 20, 40, 60 and 10 mg Cd/L, respectively. Among the six varieties, Duokang-1 was found to be the most resistant to Cd and As toxicity, and Zhongmai-8 was the most sensitive to Cd and As co-contamination. The resistance of the six varieties was found dependant on the seedling uptake of Cd and As. Duokang-1 was the most suitable for cultivation in Cd and As co-contaminated soils.     

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Degradation of metabolites accumulated of benzo[a]pyrene by coupling Penicillium Chrysogenum with KMnO4

Several main metabolites of benzo[a]pyrene （BaP） formed by Penicillium chrysogenum, Benzo[a]pyrene-1,6-quinone （BP 1,6- quinone）, trans-7,8-dihydroxy-7,8-dihydrobenzo[a]pyrene （BP 7,8-diol）, 3-hydroxybenzo[a]pyrene （3-OHBP）, were identified by high-performance liquid chromatography （HPLC）. The three metabolites were liable to be accumulated and were hardly further metabolized because of their toxicity to microorganisms. However, their further degradation was essential for the complete degradation of BaP. To enhance their degradation, two methods, degradation by coupling Penicillium chrysogenum with KMnO4 and degradation only by Penicillium chrysogenum, were compared; Meanwhile, the parameters of degradation in the superior method were optimized. The results showed that （1） the method of coupling Penicillium chrysogenum with KMnO4 was better and was the first method to be used in the degradation of BaP and its metabolites; （2） the metabolite, BP 1,6-quinone was the most liable to be accumulated in pure cultures; （3） the effect of degradation was the best when the concentration of KMnO4 in the cultures was 0.01% （w/v）, concentration of the three compounds was 5 mg/L and pH was 6.2. Based on the experimental results, a novel concept with regard to the bioremediation of BaP-contaminated environment was discussed, considering the influence on environmental toxicity of the accumulated metabolites.     

Impact of atrazine and nitrogen fertilizers on the sorption of chlorotoluron in soil and model sorbents

Sorption of chlorotoluron in ammonium sulfate, urea and atrazine multi-solutes system was investigated by batch experiments. The results showed application of nitrogen fertilizers to the soil could affect the behavior of chlorotoluron. At the same concentration of N, sorption of chlorotoluron decreased as the concentration of atrazine increased on the day 0 and 6 in soil, respectively. The sorption of chlorotoluron increased from 0 to 6 d when soils were preincubated with deionized water, ammonium sulfate and urea solution for 6 d. That indicated incubation time was one of the most important factors for the sorption of chlorotoluron in nitrogen fertilizers treatments. The individual sorption isotherms of chlorotoluron in rubbery polymer and silica were strictly linear in single solute system, but there were competition sorption between pesticides or between pesticides and nitrogen fertilizers. That indicated the sorption taken place by concurrent solid-phase dissolution mechanism and sorption on the interface of water-organic matter or water-mineral matter.     

Distribution and ecological effect of mercury in Laogang landfill, Shanghai, China

Laogang landfill near Shanghai is the largest landfill in China, and receives about 10000 t of daily garbage per day, Samples of topsoil and plants were analyzed to evaluate mercury pollution from the landfill. For topsoil samples, there were significant correlations among total mercury （HgT）, combinative mercury （Hgc） and gaseous mercury （HgG）, and content of total organic carbon （TOC）, but, no significantly relationship was found between Hg content and filling time. Hg content changes in vertical profiles with time showed that the average Hgv of profiles 1992, 1996, and 2000 was similar, but their average HgG was quite different. HgT was significantly correlated with Hgc in profile 1992 and 2000, and Hgv was significantly correlated with Hg6 in profile 1996. HgG/Hgv ratio in profile samples decreased in the order of （HgG,/HgT）1992〉（HgG/HgT）1996〉〉（HgG/HgT）2000. A simple outline of Hg release in landfill could be drawn： with increasing of filling time, degradation undergoes different biodegradation, accordingly, gaseous mercury goes through small, more, and small proportion to total mercury. Distribution of Hg in plants was inhomogeneous, following the order of leaf〉root〉stem. The highest value of leaf may be associated with higher atmospheric Hg from landfill. Ligneous plants （e.g. Phyllostachys glanca, Prunus salicina and Ligustrum lucidum） are capable of enriching more Hg than herbaceous plants.     

EDTA-enhanced phytoremediation of lead contaminated soil by Bidens maximowicziana

Phytoremediation is a potential cleanup technology for the removal of heavy metals from contaminated soils.Bidens maximowicziana is a new Pb hyperaccumulator,which not only has remarkable tolerance to Pb but also extraordinary accumulation capacity for Pb.The maximum Pb concentration was 1509.3 mg/kg in roots and 2164.7 mg/kg in overground tissues.The Pb distribution order in the B. maximowicziana was:leaf>stem>root.The effect of amendments on phytoremediation was also studied.The mobility of soil Pb and the Pb concentrations in plants were both increased by EDTA application.Compared with CK(control check),EDTA application promoted translocation of Pb to overground parts of the plant.The Pb concentrations in overground parts of plants was increased from 24.23-680.56 mg/kg to 29.07-1905.57 mg/kg.This research demonstrated that B.maximowicziana appeared to be suitable for phytoremediation of Pb contaminated soil,especially,combination with EDTA.     

Potential of plant polyphenol oxidases in the decolorization and removal of textile and non-textile dyes

In this study an effort has been made to use plant polyphenol oxidases; potato （Solanum tuberosum） and brinjal （Solanum melongena）, for the treatment of various important dyes used in textile and other industries. The ammonium sulphate fractionated enzyme preparations were used to treat a number of dyes under various experimental conditions. Majority of the treated dyes were maximally decolorized at pH 3.0. Some of the dyes were quickly decolorized whereas others were marginally decolorized. The initial first hour was sufficient for the maximum decolorization of dyes. The rate of decolorization was quite slow on long treatment of dyes. Enhancement in the dye decolorization was noticed on increasing the concentration of enzymes. The complex mixtures of dyes were treated with both preparations of polyphenol oxidases in the buffers of varying pH values. Potato polyphenol oxidase was significantly more effective in decolorizing the dyes to higher extent as compared to the enzyme obtained from brinjal polyphenol oxidase. Decolorization of dyes and their mixtures, followed by the formation of an insoluble precipitate, which could be easily removed simply by centrifugation.     

Decomposition of alachlor by ozonation and its mechanism

Decomposition and corresponding mechanism of alachlor, an endocrine disruptor in water by ozonation were investigated. Results showed that alachlor could not be completely mineralized by ozone alone. Many intermediates and final products were formed during the process, including aromatic compounds, aliphatic carboxylic acids, and inorganic ions. In evoluting these products, some of them with weak polarity were qualitatively identified by GC-MS. The information of inorganic ions suggested that the dechlorination was the first and the fastest step in the ozonation of alachlor.