Sludge reduction during brewery wastewater treatment by hydrolyzation-food chain reactor system

During brewery wastewater treatment by a hydrolyzation-food chain reactor (FCR) system, sludge was recycled to the anaerobic segment. With the function of hydrolyzation acidification in the anaerobic segment and the processes of aerobic oxidation and antagonism, predation, interaction and symbiosis among microbes in multilevel oxidation segment, residual sludge could be reduced effectively. The 6-month dynamic experiments show that the average chemical oxygen demand (COD) removal ratio was 92.6% and average sludge production of the aerobic segment was 8.14%, with the COD of the influent at 960–1720 mg/L and hydraulic retention time (HRT) of 12 h. Since the produced sludge could be recycled and hydrolyzed in the anaerobic segment, no excess sludge was produced during the steady running for this system.     

Fermentative hydrogen production from beet sugar factory wastewater treatment in a continuous stirred tank reactor using anaerobic mixed consortia

A low pH, ethanol-type fermentation process was evaluated for wastewater treatment and bio-hydrogen production from acidic beet sugar factory wastewater in a continuous stirred tank reactor (CSTR) with an effective volume of 9.6 L by anaerobic mixed cultures in this present study. After inoculating with aerobic activated sludge and operating at organic loading rate (OLR) of 12 kgCOD?m^-3·d^-1, HRT of 8h, and temperature of 35°C for 28 days, the CSTR achieved stable ethanol-type fermentation. When OLR was further increased to 18 kgCOD?m^-3·d^-1 on the 53rd day, ethanol-type fermentation dominant microflora was enhanced. The liquid fermentation products, including volatile fatty acids (VFAs) and ethanol, stabilized at 1493 mg·L^-1 in the bioreactor. Effluent pH, oxidation-reduction potential (ORP), and alkalinity ranged at 4.1–4.5, -250–(-290) mV, and 230–260 mgCaCO₃?L^-1. The specific hydrogen production rate of anaerobic activated sludge was 0.1 L?gMLVSS^-1·d^-1 and the COD removal efficiency was 45%. The experimental results showed that the CSTR system had good operation stability and microbial activity, which led to high substrate conversion rate and hydrogen production ability.     

污泥臭氧化减量技术的影响因子

采用臭氧作为剩余污泥的细胞裂解剂,并与生物接触氧化工艺相结合进行污泥减量的实验研究,臭氧化后的污泥上清液回流入曝气池与污水合并处理。结果表明:在臭氧投量为0.05kgO3/kgMLSS,臭氧化污泥量为进水量的5%条件下,生物接触氧化系统对SCOD和NH4-N的平均去除率分别为87.06%和84.80%,出水水质同对比实验相当;同时获得了0.054(gMLSS/去除1gSCOD)的剩余污泥产率,与对比实验相比降低了78.4%。     

Use of gamma-irradiation pretreatment for enhancement of anaerobic digestibility of sewage sludge

The effects of γ-irradiation pretreatment on anaerobic digestibility of sewage sludge was investigated in this paper. Parameters like solid components, soluble components, and biogas production of anaerobic digestion experiment for sewage sludge were measured. The values of these parameters were compared before and after γ-irradiation pretreatment. Total solid (TS), volatile solid (VS), suspended solid (SS), volatile suspended solid (VSS), and average floc size of samples decreased after γ-irradiation treatment. Besides, floc size distribution of sewage sludge shifted from 80–100 μm to 0–40 μm after γ-irradiation treatment at the doses from 0 to 30 kGy, which indicated the disintegration of sewage sludge. Moreover, microbe cells of sewage sludge were ruptured by γ-irradiation treatment, which resulted in the release of cytoplasm and increase of soluble chemical oxygen demand (SCOD). Both sludge disintegration and microbe cells rupture enhanced the subsequent anaerobic digestion process, which was demonstrated by the increase of accumulated biogas production. Compared with digesters fed with none irradiated sludge, the accumulated biogas production increased 44, 98, and 178 mL for digesters fed sludge irradiated at 2.48, 6.51, and 11.24 kGy, respectively. The results indicated that γ-irradiation pretreatment could effectively enhance anaerobic digestibility of sewage sludge, and correspondingly, could accelerate hydrolysis process, shorten sludge retention time of sludge anaerobic digestion process.     

污水处理中的污泥减量新技术

污水好氧处理会产生大量污泥，剩余污泥的处理成本高昂，减少污泥产量势在必行。文章介绍了代谢解偶联、增加维持能量消耗、隐性生长、微型动物捕食、高溶解氧工艺和膜生物反应器等污泥减量技术，比较了各种技术的优缺点，指出了不同技术结合将成为污泥减量技术的发展方向。     

废水生物脱氮中N_2O和NO_x的产生和作用

废水生物脱氮中N2O和NOx来源于硝化、反硝化、厌氧氨氧化和化学反硝化等过程.电子受体和供体浓度、pH、缓冲剂类型、有机负荷、微生物种类及其相互作用等都会影响这些气态中间产物的产生.NO2能够氧化氨和强化好氧和厌氧氨氧化,NO能够阻止C2H2对好氧氨氧化活性的抑制,两者对好氧氨氧化活性的恢复至关重要.所有这些表明,废水生物脱氮的气态中间产物N2O和NOx在氮的生物转化中具有重要的正面作用,甚至必不可少.基于NO2曝气技术和Brocadiaanammoxidans与Nitrosomonas协同作用的废水生物脱氮新技术开发是今后一段时间的重要研究方向.图4参35     

Vacuum promotes metabolic shifts and increases biogenic hydrogen production in dark fermentation systems

The successful operation of any type of hydrogen-producing bioreactor depends on the performance of the microorganisms present in the system. Both substrate and partial gas pressures are crucial factors affecting dark fermentation metabolic pathways. The main objective of this study was to evaluate the impact of both factors on hydrogen production using anaerobic granular sludge as inoculum and, secondly, to study the metabolic shifts of an anaerobic community subjected to low partial gas pressures. With this goal in mind, seven different wastewater (four synthetic media, two industrial wastewater, and one domestic effluent) and the effect of applying vacuum on the systems were analyzed. The application of vacuum promoted an increase in the diversity of hydrogenproducing bacteria, such as Clostridium, and promoted the dominance of acetoclastic- over hydrogenotrophic methanogens. The application of different media promoted a wide variety of metabolic pathways. Nevertheless, reduction of the hydrogen partial pressure by application of vacuum lead to further oxidation of reaction intermediates irrespective of the medium used, which resulted in higher hydrogen and methane production, and improved the COD removal. Interestingly, vacuum greatly promoted biogenic hydrogen production from a real wastewater, which opens possibilities for future application of dark fermentation systems to enhance biohydrogen yields.     

Performance of a hybrid anaerobic-contact oxidation biofilm baffled reactor for the treatment of decentralized molasses wastewater

A novel hybrid anaerobic-contact oxidation biofilm baffled reactor （HAOBR） was developed to simultaneously remove nitrogenous and carbonaceous organic pollutants from decentralized molasses wastewater in the study. The study was based on the inoculation of anaerobic granule sludge in anaerobic compartments and the installation of combination filler in aerobic compartments. The performance of reactor system was studied regarding the hydraulic retention time （HRT）, microbial characteristics and the gas water ratio （GWR）. When the HRT was 24h and the GWR was 20：1, total ammonia and chemical oxygen demand （COD） of the effluent were reduced by 99% and 91.8%, respectively. The reactor performed stably for treating decentralized molasses wastewater. The good performance of the reactor can be attributed to the high resistance of COD and hydraulic shock loads. In addition, the high solid retention time of contact oxidation biofilm contributed to stable performance of the reactor.     

厌氧条件下剩余污泥中磷及相关指标的释放和变化规律

污水处理过程中产生的剩余污泥富含大量的氮磷元素,从剩余污泥中回收磷是解决磷资源日益缺乏的一种有效途径。探寻出剩余污泥中磷的释放规律是实现剩余污泥中磷回收的首要前提。因此,以实际污水处理厂污泥为研究对象,建立污泥停留时间为5d的中试模型系统。通过系统分析5d停留时间的厌氧条件下污泥中污泥浓度、上清液总磷和氨氮浓度的变化情况,为后续的污泥磷回收提供支撑条件。研究结果表明,在中试系统污泥停留时间5d的厌氧条件下,剩余污泥微生物衰亡自溶或被分解,胞内物质释放,从而使固态物质转化为液态,污泥中磷及相关的氮等物质得到了较大的释放,污泥上清液总磷和氨氮质量浓度可分别达到100和40 mg·L^-1以上。所释放出的氮磷浓度足以满足鸟粪石回收氮磷方法所需的最低经济性要求,为污泥进行厌氧消化后采用鸟粪石的方法回收释放的氮磷提供了重要的基础依据。研究中还发现5d停留时间下, SS和VSS都有不同程度的降低,二者分别减少8.34%和10.14%以上,其中VSS的减少量占SS减少量的65%左右。同时,进入厌氧反应系统的初始污泥浓度对于氮磷的释放有着较大的影响,反应系统的SS在6300~7200 mg·L^-1的条件下,磷和氮的单位质量污泥释放量达到最佳,分别达到单位干污泥0.015和0.006 mg·mg^-1。研究结果为剩余污泥中回收氮磷提供了重要的依据。     

厌氧-膜生物反应器处理垃圾渗滤液中多环芳烃的研究

采用固相萃取前处理和气相色谱／质谱联用的方法,分析厌氧．膜生物反应器处理垃圾渗滤液中多环芳烃的去除效果．结果表明,对多环芳烃的总去除效率超过80％;大部分三环、四环和五环的芳烃可在处理过程中被厌氧降解．多环芳烃的主要降解反应发生在厌氧滤池工艺段,然而SCOD(溶解性化学耗氧量),BOD和TOC的主要去除工艺段则是膜生物反应器．     

Circulating fluidized bed biological reactor for nutrients removal

A new biological nitrogen removal process, which is named herein “The circulating fluidized bed bioreactor (CFBBR)”, was developed for simultaneous removal of nitrogen and organic matter. This process was composed of an anaerobic bed (Riser), aerobic bed (Downer) and connecting device. Influent and nitrified liquid from the aerobic bed enters the anaerobic bed from the bottom of the anaerobic bed, completing the removal of nitrogen and organic matter. The system performance under the conditions of different inflow loadings and nitrified liquid recirculation rates ranging from 200% to 600% was examined. From a technical and economic point of view, the optimum nitrified liquid recirculation ratewas 400%. With a shortest total retention time of 2.5 h (0.8 h in the anaerobic bed and 1.5 h in the aerobic bed) and a nitrified liquid recirculation rate of 400% based on the influent flow rate, the average removal efficiencies of total nitrogen (TN) and soluble chemical oxygen demand (SCOD) were found to be 88% and 95%, respectively. The average effluent concentrations of TN and SCOD were 3.5 mg/L and 16 mg/L, respectively. The volatile suspended solid (VSS) concentration, nitrification rate and denitrification rate in the system were less than 1.0 g/L, 0.026-0.1 g NH₄ ⁺-N/g VSS·d, and 0.016–0.074 g NO_x ^?-N/g VSS·d, respectively.     

PCR-DGGE研究Carrousel 2000氧化沟工艺调试过程中的微生物多样性

收集Carrousel 2000型氧化沟工艺启动过程中活性污泥样品,直接提取微生物的基因组DNA并纯化,然后对细菌16S rDNA的V3高变区进行PCR扩增和DGGE分离,通过比较DGGE图谱的相似性来研究工艺调试过程中微生物种群的变化情况.研究表明,活性污泥中具有非常丰富的微生物种群.调试初期水质波动对氧化沟中微生物种群的影响非常明显,但接种的成熟活性污泥中微生物种群能够很快适应新型氧化沟工艺的结构及水力特性.调试从4月开始,4月氧化沟中微生物种群相似性Cs最大值为68.9%,5~6月Cs最大值为70.8%,8月Cs最大值为73.0%,可见氧化沟中微生物种群相似性逐渐增加,直至稳定.在此过程中,系统对COD、氨氮的处理效果同步提高并趋于稳定.综合分析好氧活性污泥在氧化沟中驯化期为2个月.图4表4参12     

移动床生物膜反应器在污水处理中的应用研究

应用好氧移动床生物膜反应器处理生活污水，厌氧复合生物反应器处理高浓度有机废水，厌氧－好氧移动床生物膜工艺处理食品废水的试验均取得良好的效果。试验结果表明，该工艺具有处理效率高，出水水质稳定，耐冲击负荷能力强，占地少，结构紧凑，维护管理简单的特点。     

磺胺嘧啶在水中的微生物降解研究

为了探明磺胺嘧啶在水中的环境行为,通过室内模拟降解实验分别研究了磺胺嘧啶在湖水和猪场废水中的好氧和厌氧微生物降解,考察了供氧方式和有机质含量对磺胺嘧啶微生物降解的影响。结果表明:磺胺嘧啶在猪场废水中厌氧微生物降解速率高于其好氧组,而磺胺嘧啶在湖水中厌氧微生物降解速率低于其好氧组。磺胺嘧啶在湖水和猪场废水中的好氧或厌氧微生物降解均较缓慢,这可能与其较强的抑菌性和微生物的营养状况有关。通过微生物培养还研究了好氧降解时磺胺嘧啶对湖水中微生物种群生长的影响,数据显示:磺胺嘧啶对湖水和猪场废水中细菌的生长具有一定的刺激作用,而对真菌和放线菌的生长影响不明显。     

Enhanced atrazine removal using membrane bioreactor bioaugmented with genetically engineered microorganism

Bioaugmentation with genetically engineered microorganisms (GEMs) in a membrane bioreactor (MBR) for enhanced removal of recalcitrant pollutants was explored. An atrazine-degrading genetically engineered microorganism (GEM) with green fluorescent protein was inoculated into an MBR and the effects of such a bioaugmentation strategy on atrazine removal were investigated. The results show that atrazine removal was improved greatly in the bioaugmented MBR compared with a control system. After a start-up period of 6 days, average 94.7% of atrazine was removed in bioaugmented MBR when atrazine concentration of influent was 14.5 mg/L. The volumetric removal rates increased linearly followed by atrazine loading increase and the maximum was 65.5 mg/(L·d). No negative effects were found on COD removal although carbon oxidation activity of bioaugmented sludge was lower than that of common sludge. After inoculation, adsorption to sludge flocs was favorable for GEM survival. The GEM population size initially decreased shortly and then was kept constant at about 10⁴–10⁵ CFU/mL. Predation of micro-organisms played an important role in the decay of the GEM population. GEM leakage from MBR was less than 10² CFU/mL initially and was then undetectable. In contrast, in a conventionally activated sludge bioreactor (CAS), sludge bulking occurred possibly due to atrazine exposure, resulting in bioaugmentation failure and serious GEM leakage. So MBR was superior to CAS in atrazine bioaugmentation treatment using GEM.     

Evidence of nitrification and denitrification in high and low microbial abundance sponges

Aerobic and anaerobic microbial key processes were quantified and compared to microbial numbers and morphological structure in Mediterranean sponges. Direct counts on histological sections stained with DAPI showed that sponges with high microbial abundances (HMA sponges) have a denser morphological structure with a reduced aquiferous system compared to low microbial abundance (LMA) sponges. In Dysidea avara, the LMA sponge, rates of nitrification and denitrification were higher than in the HMA sponge Chondrosia reniformis, while anaerobic ammonium oxidation and sulfate reduction were below detection in both species. This study shows that LMA sponges may host physiologically similar microbes with comparable or even higher metabolic rates than HMA sponges, and that anaerobic processes such as denitrification can be found both in HMA and LMA sponges. A higher concentration of microorganisms in the mesohyl of HMA compared to LMA sponges may indicate a stronger retention of and, hence, a possible benefit from associated microbes.     

Inactivation and risk control of pathogenic microorganisms in municipal sludge treatment: A review

• Diversity and detection methods of pathogenic microorganisms in sludge. • Control performance of sludge treatment processes on pathogenic microorganisms. • Risk of pathogen exposure in sludge treatment and land application. The rapid global spread of coronavirus disease 2019 (COVID-19) has promoted concern over human pathogens and their significant threats to public health security. The monitoring and control of human pathogens in public sanitation and health facilities are of great importance. Excessive sludge is an inevitable byproduct of sewage that contains human and animal feces in wastewater treatment plants (WWTPs). It is an important sink of different pollutants and pathogens, and the proper treatment and disposal of sludge are important to minimize potential risks to the environment and public health. However, there is a lack of comprehensive analysis of the diversity, exposure risks, assessment methods and inactivation techniques of pathogenic microorganisms in sludge. Based on this consideration, this review summarizes the control performance of pathogenic microorganisms such as enterovirus, Salmonella spp., and Escherichia coli by different sludge treatment technologies, including composting, anaerobic digestion, aerobic digestion, and microwave irradiation, and the mechanisms of pathogenic microorganism inactivation in sludge treatment processes are discussed. Additionally, this study reviews the diversity, detection methods, and exposure risks of pathogenic microorganisms in sludge. This review advances the quantitative assessment of pathogenic microorganism risks involved in sludge reuse and is practically valuable to optimize the treatment and disposal of sludge for pathogenic microorganism control.     

竹炭固定床-聚氨酯流化床一体化反应器处理生活污水

为解决剩余污泥问题,研制了产泥率少的片状竹炭固定床-聚氨酯切块流化床一体化反应器,在保证流化床高浓度微生物的同时,维持竹炭固定床的好氧,兼性厌氧,以实现污泥的原位分解.试验采用南京林业大学紫湖溪生活污水,COD为140—170 mg·L-1,TP为1—2 mg·L-1,TN为35—45 mg·L-1,氨氮25—30 mg·L-1,SS为35—40 mg·L-1.反应器在第30 d启动成功.稳定的运行结果显示,水力停留时间为10 h时,反应器对有机物的去除效果较好,出水中COD、TN、TP、氨氮的浓度分别为19 mg·L-1、7 mg·L-1、0.47 mg·L-1、4.5 mg·L-1,去除率达到87%、76%、72%、84%,出水中各指标均满足《城镇污水处理厂污染物排放标准》(GB18918—2002)中的一级B排放标准.经竹炭固定床处理的出水SS浓度很低,长期维持在14 mg·L-1左右,二沉池出水中的SS平均浓度为12.7 mg·L-1,整个反应器对二沉池依赖性较小.     

Carbon substrate usage by zooplankton-associated bacteria,phytoplankton-associated bacteria,and free-living bacteria under aerobic and anaerobic conditions

Mesozooplankton provide oxic and anoxic microhabitats for associated bacteria, whose carbon substrate usage activities complement those of the ambient bacteria. The metabolic profiles of bacterial communities associated with the calanoid copepod Acartia tonsa under aerobic and anaerobic conditions were examined in comparison with phytoplankton-associated bacteria. Carbon substrate usage by phytoplankton-associated bacteria was significantly different than that of copepod-associated bacteria in both aerobic and anaerobic conditions. Substrate utilization by copepod-associated bacteria was more dependent upon oxygen condition than whether the bacteria were located on the copepod exoskeleton or within the gut. Results suggest that gut bacteria were responsible for a large portion of anaerobic substrate usage by copepod-associated bacteria. The metabolic profiles of bacteria associated with six common zooplankton groups and free-living bacteria collected in July 2012 from the York River estuary, Virginia, (37°14′50.36″N, 76°29′58.03W) were also compared, and there were significant differences in their substrate utilization patterns between aerobic and anaerobic incubations, and among the different zooplankton groups. Through trophic interactions, phytoplankton-associated or free-living bacteria may be introduced to the anoxic zooplankton gut and its associated bacterial community. Inclusion of these anaerobic microenvironments and their microbial inhabitants increased the total number of substrates used by 57 % over what was used by aerobic phytoplankton-associated bacteria alone, and by 50 % over what was used by aerobic free-living bacteria in the York River. Therefore, the presence of zooplankton-associated microhabitats and their bacteria expanded the functionality of aquatic microbial communities and led to a more comprehensive substrate usage.     

Aerobic granular sludge formation based on substrate availability: Effects of flow pattern and fermentation pretreatment

• Penetration depth and substrate characters affect AGS formation and performance. • The relationship between substrate gradient and particle size affects AGS stability. • The fermentation process is proposed as a pretreatment to improve AGS stability. The influences of flow patterns (mixed-flow and plug-flow) and fermentation pretreatment on aerobic granular sludge (AGS) formation with various substrate availability levels were investigated by running four identical laboratory-scale sequencing batch reactors (R1–R4), comparing two anaerobic feeding strategies and three kinds of substrates. R1 achieved faster granulation with a fast influent fill step followed by a modified anaerobic mixed-flow phase, but the AGS showed poorer stability with a cracked structure and a high suspended solids concentration in the effluent. The anaerobic plug-flow feeding mode (with influent fed slowly from the bottom) in R2 provided deeper penetration depth for the substance to reach the core of AGS and accordingly strengthen AGS stability. An acidogenic up-flow sludge bed reactor was introduced as a pretreatment to improve the AGS performance by enhancing glucose pre-fermentation (R4). AGS fed with mixed volatile fatty acids (VFA) after glucose fermentation showed similar performance compared with the reactor fed with acetate in the aspects of stability, structure, size distribution and nitrogen removal efficiency, and 74% similarity in the microbial community. For actual wastewater with low VFA concentrations, fermentation treatment was suggested as a promising pretreatment for stable AGS granulation and operation.