Biodegradation of organic matters from mixed unshredded municipal solid waste through air convection before landfilling

Landfilling is a dominant municipal solid waste (MSW) disposal method in most developing countries. In China, approximately 85% of the generated MSW is being disposed of in the landfills. The amount of MSW is growing rapidly with the rate of approximately 8-10% annually, which contains a high quantity of moisture and organic matters. The problems of leachate treatment and landfill gas (LFG) emissions are increasing gradually. Reducing the hazard before emplacement, pretreatment of MSW before landfilling has become very important for the conventional landfill. In this study, aerobic pretreatment of mixed MSW was used, and much attention has been given to the natural convection of air in the mixed and unshredded MSW for bioconversion of organic matter (OM). This study is an attempt to investigate aerobic pretreatment suitability for the mixed and unshredded MSW at Beijing. A pilot-scale aerobic pretreatment simulator (APS) was developed at Beishen Shu Landfill in Beijing. To work out the biodegradation of the OM in the APS, fresh and pretreated MSW samples were collected and analyzed for OM, moisture content, temperature, chemical oxygen demand, total organic carbon, carbon, nitrogen, hydrogen, lignocelluloses, and biochemical methane potential at various stages of the pretreatment. Furthermore, results of the fresh and pretreated MSW are compared. Significant reduction in the observed parameters of the pretreated waste samples is observed. This work demonstrates that pretreatment is significantly effective in reducing the landfill emissions that is leachate and LFG.     

模拟成藏地质填埋及诱导填埋有机质生气的理论初探

填埋处理和垃圾生物气的开发利用是实现城市生活垃圾资源化、无害化、减量化处理的有效途径,引入模拟生物气成藏和含气系统的思路,开展地质填埋与诱导填埋有机质生气研究是对能源地质学和填埋设计理念的新探索.通过对比研究地质填埋结构与地质学中生物气藏系统的异同点、生气机理和影响因素的共性与差异,初步论证了将模拟生物气藏理论引入地质填埋设计、优化地质填埋结构、提高填埋有机质生物气化效率和抽排利用效率的可行性;探讨了生物气藏理论在构建地质填埋结构中的可能应用和启示.研究表明:模拟生物气藏地质填埋设计和非常规生物气开发理念具有理论依据和现实基础;生物气藏生、储、盖要素和运、圈、保过程的模拟可应用于垃圾地质填埋场的构建,微生物地球化学理论有助于对诱导填埋有机质生气条件优化的认识.     

渗滤液回流对不同填埋结构甲烷变化规律的影响研究

建立了大型模拟填埋试验装置,研究了渗滤液回流对不同填埋结构甲烷变化规律的影响.每周对填埋气体中甲烷浓度进行监测.结果表明:厌氧填埋中回流操作使甲烷浓度峰值提前了147 d,峰值为59.6%(体积分数,下同);准好氧填埋中回流操作使甲烷浓度峰值提前259 d,峰值为44.7%.回流操作使甲烷产气高峰提前,增加产气量,加快填埋垃圾稳定,减轻渗滤液污染.厌氧填埋中进行回流操作有利于甲烷的回收利用;准好氧填埋结构可有效减少甲烷的排放,减小对环境的危害.稳定期的垃圾填埋体进行回流产生一定的甲烷,但浓度较低,最高仅26.0%,没有利用价值.     

Optimization for municipal solid waste treatment based on energy consumption and contaminant emission

This paper analyzes the characterization of energy consumption and contaminant emissions from a municipal solid waste (MSW) treatment system that comprises transfer station, landfill site, combustion plant, composting plant, dejecta treatment station, and an integrated MSW treatment plant. The consumed energy and energy medium materials were integrated under comprehensive energy consumption (CEC) for comparison. Among typical MSW disposal methods such as combustion, composting, and landfilling, landfilling has the minimum CEC value. Installing an integrated treatment plant is the recommended MSW management method because of its lower CEC. Furthermore, this method is used to ensure process centralization. In landfill sites, a positive linear correlation was observed between the CEC and contaminant removal ratios when emitted pollutants have a certain weight coefficient. The process should utilize the minimum CEC value of 5.3702 kgce/t MSW and consider energy consumption, energy recovery, MSW components, and the equivalent of carbon dioxide emissions.     

西南地区某已封场非规范垃圾填埋场垃圾稳定化进程分析

以重庆某非规范填埋场为例,针对西南地区已封场非规范垃圾填埋场的稳定化进程进行了分析。按照场地布局选取4个采样点,在垃圾体上进行钻孔取样,分析不同深度的垃圾样pH值、有机质、含水率、生物可降解度以及垃圾样浸出液和填埋气组成以及各个指标随着填埋深度的变化规律,确定不同深度垃圾体的稳定化程度。结果表明,场内垃圾已呈现矿化垃圾特征;有机质、BDM、浸出液COD以及填埋气CH4含量等4个指标与填埋深度均较好地符合一级降解反应,可以预测垃圾体稳定化临界填埋深度。根据有机质、BDM、浸出液COD以及填埋气CH4含量等4个指标与填埋深度一级降解反应函数预测临界稳定化深度为15 m,与实测值判定的稳定化填埋深度相一致性。在对非规范垃圾填埋场场地利用过程中,需要先对未稳定的上层垃圾进行清理,并在已稳定的底层垃圾体上充填其他稳定介质后利用该地块。     

城市生活垃圾半好氧生物反应器填埋技术试验研究

对城市生活垃圾半好氧生物反应器填埋技术与传统垃圾填埋技术进行了对比试验,由试验结果可知,半好氧生物反应器填埋技术可缩短填埋垃圾产酸时间,净化渗滤液,加速填埋垃圾稳定化进程.城市生活垃圾半好氧生物反应器填埋技术是中国中小城市垃圾填埋处理的发展方向.     

生活垃圾填埋场不同填埋方式填埋气特性研究

对于国内外在传统的厌氧填埋和新型的准好氧填埋两种不同运行方式下对填埋气的特性研究作了简介。通过比较分析，传统的厌氧填埋结构中填埋气的甲烷含量比较高（40％～60％），而准好氧填埋中填埋气的甲烷含量只有10％～20％。对于中小型的填埋场，由于技术和成本的制约，建立准好氧填埋场，不仅有利于加快垃圾的稳定化进程，还可以减少甲烷的生成量，减轻对环境所造成的污染。     

城市生活垃圾填埋初期有机质演化规律研究

为阐明生活垃圾填埋初期有机质演化规律,于填埋场打井采集填埋1～3年3个不同时期垃圾样品,用水浸提制备水溶性有机物(DOM)。采用红外光谱、同步荧光光谱及紫外光谱,对浸提液中DOM的结构和演化特征进行了研究。结果显示,生活垃圾中含有脂肪类、蛋白类、糖类及木质素类物质,在填埋初期,有机质中的脂肪类、蛋白质类、糖类及木质素类物质均发生了降解,羧基、氨类及水溶性芳香结构物质减少,DOM分子量降低。研究结果表明,垃圾填埋初期有机质以降解为主。     

Methane emissions from domestic waste management facilities in Jordan--applicability of IPCC methodology

In this paper, methane emissions from municipal wastewater treatment plants and municipal solid waste (MSW) landfills in Jordan for 1994 have been estimated using the methodology developed by the Intergovernmental Panel on Climate Change (IPCC). For this purpose, the 14 domestic wastewater treatment plants in the country were surveyed. Generation rates and characterization of MSW components as well as dumping and landfilling practices were surveyed in order to estimate 1994 CH4 emissions from these sites. Locally available waste statistics were used in cases where those of the IPCC guidelines were not representative of Jordan's statistics. Methane emissions from domestic wastewater in Jordan were estimated at 4.66 gigagrams (Gg). Total 1994 CH4 emissions from MSW management facilities in Jordan are estimated at 371.76 Gg--351.12 Gg (94.45%) from sanitary landfills, 19.83 Gg (5.33%) from MSW open dumps, and 0.81 Gg (0.22%) from raw sewage-water dumping ponds. Uncertainties associated with these estimations are presented.     

Modelling methane and vinyl chloride in soil surrounding landfills

Sanitary landfilling is used in many countries as a preferred method for disposal of household wastes for reasons of simplicity and economics. Immediately following its deposition within a landfill, most of the organic fraction of waste will begin to undergo degradation through chemical and bacterial action. Landfill gas (LFG) is a product of biodegradation and consists of primarily methane (explosive) and carbon dioxide, with trace amounts of other volatiles that are often toxic gases (for example, vinyl chloride). LFG can migrate through the soil away from the landfill site and appear at the surface away from where it started. Since methane presents a fire or explosive threat, LFG must be controlled to protect property and public safety. To aid this, consideration must be given to models. Therefore, this study was undertaken to develop a simple numerical model by using a finite difference method in order to predict gas migration through the soil surrounding the landfill. The model construction was described as well as the landfill and its surrounding soil. The model was applied to predict methane and vinyl chloride concentrations at different distances from the landfill. Comparison between the predicted and measured values was calculated to evaluate the validity of the model. The agreement between measured and predicted concentrations was found, and this agreement is sufficiently good     

A survey of municipal solid waste landfills in Beijing during 2009–2011

The investigation of municipal solid waste (MSW) treatment in China is rare due to its sensitivity and difficulty in terms of access. We chose Beijing, the capital of China, as an example to identify the characteristics of MSW landfill treatments using a 2-month investigation with 20 participants. MSW landfill treatments account for nearly 70% of the annual MSW disposal in Beijing; the landfill processes are equipped with many kinds of technologies and consume a large amount of energy and produce a variety of contaminants. The cover method (the most obvious difference in landfill tamping) mainly includes high-density polyethylene (HDPE) geomembranes with loess and soil alone (i.e., loess or sandy soil). We investigated the actual conditions of landfills and collected data on leachate and landfill gas (LFG) emissions and energy consumption during 2009–2011. The results indicated that the cover method employed by landfills was related to treatment quantity, operation, and especially landfill location. Early large-scale landfills located in plains were covered with HDPE geomembranes, and newly built landfills covered with soil tended to be equipped with HDPE covers. Using HDPE cover also contributed greatly to LFG production due to its impermeability but had no remarkable effect on leachate yield reduction due to the dry climate in Beijing. The potential was reinforced by the potentials of decrement and reuse. The disposal method of LFG can be optimized, and the power generated by the LFG process can meet the landfill demand. The gray water recycled from the leachate could be used in the landfill process.

     

Methane Emissions from Domestic Waste Management Facilities in Jordan—Applicability of IPCC Methodology

ABSTRACT

In this paper, methane emissions from municipal wastewater treatment plants and municipal solid waste (MSW) landfills in Jordan for 1994 have been estimated using the methodology developed by the Intergovernmental Panel on Climate Change (IPCC). For this purpose, the 14 domestic wastewater treatment plants in the country were surveyed. Generation rates and characterization of MSW components as well as dumping and landfilling practices were surveyed in order to estimate 1994 CH₄ emissions from these sites. Locally available waste statistics were used in cases where those of the IPCC guidelines were not representative of Jordan's statistics.

Methane emissions from domestic wastewater in Jordan were estimated at 4.66 gigagrams (Gg). Total 1994 CH₄ emissions from MSW management facilities in Jordan are estimated at 371.76 Gg—351.12 Gg (94.45%) from sanitary landfills, 19.83 Gg (5.33%) from MSW open dumps, and 0.81 Gg (0.22%) from raw sewage-water dumping ponds. Uncertainties associated with these estimations are presented.     

北京市生活垃圾处理的环境影响评价

目前北京市生活垃圾产生量不断增加,处理设施能力日渐不足,生活垃圾管理正面临着减量化与资源化必然趋势。在未来5～10年内,堆肥处理、焚烧处理和综合处理等方式将取代卫生填埋成为北京市垃圾处理的主要方式。本研究采用生命周期评价的方法,对北京市4处垃圾处理设施采用的不同工艺（卫生填埋、好氧堆肥、焚烧处理和综合处理）的环境影响进行比较。评价结果表明4,种处理方式中填埋、堆肥、焚烧和综合处理的环境影响负荷分别为4.82×10-2、1.10×10-21、.31×10-1和2.31×10-2,焚烧处理的总环境影响潜值最大,填埋处理次之,综合处理再次,堆肥处理最小。4种处理方式的资源耗竭系数分别为-2.39×10-51、.11×10-5、-3.45×10-4和-1.04×10-6,焚烧处理的资源耗竭系数最小。     

Codisposal of municipal refuse, sewage sludge and marine dredgings for methane production

As marine disposal of sewage sludge and dredged sediments may impose serious adverse effects to marine ecosystems, landfilling seems to be the most feasible method for the final disposal of these wastes. A batch experiment was conducted to study waste degradation and gas production after sewage sludge and marine dredgings were mixed with municipal refuse at 13 different ratios for 36 days. The addition of sludge and dredgings to municipal refuse enhanced gas production, compared with the degradation of refuse or sludge alone. A proper mixing ratio of wastes can also shorten the time to reach the final phase of anaerobiosis. The highest gas production was obtained from the ratio of 75-20-5 (refuse-sludge-dredgings) (wet weight basis). Its average daily gas production rate was 1.42 l kg(-1) waste mixture; methane content was 68.3%. The results indicated that codisposal of the three wastes would be beneficial for energy recovery from landfill gas.     

Household hazardous waste disposal to landfill: using LandSim to model leachate migration

Municipal solid waste (MSW) landfill leachate contains a number of aquatic pollutants. A specific MSW stream often referred to as household hazardous waste (HHW) can be considered to contribute a large proportion of these pollutants. This paper describes the use of the LandSim (Landfill Performance Simulation) modelling program to assess the environmental consequences of leachate release from a generic MSW landfill in receipt of co-disposed HHW. Heavy metals and organic pollutants were found to migrate into the zones beneath a model landfill site over a 20,000-year period. Arsenic and chromium were found to exceed European Union and US-EPA drinking water standards at the unsaturated zone/aquifer interface, with levels of mercury and cadmium exceeding minimum reporting values (MRVs). The findings demonstrate the pollution potential arising from HHW disposal with MSW.     

1988 APCA Government Agencies Directory

The biowaste fractions in municipal solid waste (MSW) are the main odor sources in landfill and cause widespread complaints from residents. The ammonia (NH₃) and hydrogen sulfide (H₂S) generation processes were simulated and compared between four typical biowaste fractions individually and combined in the mixed MSW. Food waste was found to be the main contributor to odor emission in mixed MSW, with H₂S generation potential of 48.4 μg kg^?1 and NH₃ generation potential of 4742 μg kg^?1. Fruit waste was another source for NH₃ generation, with 3933 μg kg^?1 NH₃ generation potential. Meanwhile, nitrogen (N) was released in a faster way than sulfur (S) in waste, since 31% and 46% of total NH₃ and H₂S were generated in the first 90 days after disposal, with 1811 and 72 μg kg^?1, and more emphasis should be placed in this initial period.

Implications:?Monitoring of odor generation from biowastes in MSW on a laboratory scale showed that food waste is the main source for NH₃ and H₂S generation, whereas waste fruit is another main contributor for NH₃ released. Generally, N was released in a faster way than S from mixed-waste landfilling.     

城市生活垃圾卫生填埋场恶臭的防治技术进展

恶臭污染已成为垃圾处理和处置过程中的严重公害。在分析中,介绍了填埋场各区域恶臭的控制措施,综述了卫生填埋场恶臭的常规防治技术,重点讨论了生物技术在填埋场脱臭中的应用,这些防治技术对各类环境卫生设施,如垃圾收集站、中转站、焚烧场、堆肥厂及粪便处理厂的臭气治理均有借鉴意义。     

Pyrolysis of wastewater sludge and composted organic fines from municipal solid waste: laboratory reactor characterisation and product distribution

Sludge from municipal wastewater treatment plants and organic fines from mechanical sorting of municipal solid waste (MSW) are two common widespread waste streams that are becoming increasingly difficult to utilise. Changing perceptions of risk in food production has limited the appeal of sludge use on agricultural land, and outlets via landfilling are diminishing rapidly. These factors have led to interest in thermal conversion technologies whose aim is to recover energy and nutrients from waste while reducing health and environmental risks associated with material re-use. Pyrolysis yields three output products: solid char, liquid oils and gas. Their relative distribution depends on process parameters which can be somewhat optimised depending on the end use of product. The potential of pyrolysis for the conversion of wastewater sludge (SS) and organic fines of MSW (OF) to a combustion gas and a carbon-rich char has been investigated. Pyrolysis of SS and OF was done using a laboratory fixed-bed reactor. Herein, the physical characterisation of the reactor is described, and results on pyrolysis yields are presented. Feedstock and chars have been characterised using standard laboratory methods, and the composition of pyrolysis gases was analysed using micro gas chromatography. Product distribution (char/liquid/gas) from the pyrolysis of sewage sludge and composted MSW fines at 700°C for 10 min were 45/26/29 and 53/14/33%, respectively. The combustible fractions of pyrolysis gases range from 36 to 54% for SS feedstock and 62 to 72% from OF. The corresponding lower heating value range of sampled gases were 11.8–19.1 and 18.2–21.0 MJ m^?3, respectively.     

长江流域水电站施工区生活垃圾特性及处理处置决策模型研究

随着中国长江流域水电开发进入高峰期,大量的建设人员进入水电站施工营地,导致施工区的生活垃圾处理处置问题日益凸显。通过对金沙江HPS1水电站、雅砻江HPS2水电站和HPS3水电站、大渡河HPS4水电站施工区生活垃圾状况的调查表明,水电站施工生活区生活垃圾人均产量平均值约为0.68kg/d;以厨余、渣土、纸类塑料和橡胶为主,电池等危险废物含量甚微;容重、低位热值、生物可降解物质量分数的平均值分别为358kg/m3、5 234kJ/kg、43.22%。结合施工区所处的环境条件和周围的市政设施现状,采用层次分析法和最小成本法,构建了长江流域水电站施工区生活垃圾处理处置决策模型,可为大型水电站开发过程中施工区生活垃圾全过程管理提供指导。根据决策模型计算得出,HPS1、HPS2、HPS4水电站施工区生活垃圾最优处理处置技术为卫生填埋,HPS3水电站以外运综合处理最优。     

Heavy metals mobility in full-scale bioreactor landfill: initial stage

Selected heavy metals (HMs) including Cd, Cr, Cu, Ni, Pb and Zn initially released from a full-scale bioreactor landfill were monitored over the first 20 months of operation. At the initial landfill stage, the leachate exhibited high HMs release, high organic matter content (27000-43000gl(-1) of TOC) and low pH (5-6). By the fifth month of landfilling, the methanogenic stage had been established, and HMs release was reduced below the Chinese National Standards. Total released HMs accounted for less than 1% of landfill deposited during the investigated period. Most landfill HMs were inorganic. Fourier-transform infrared (FT-IR) spectra data and model calculations using Visual MINTEQ indicated that humic substances strongly affected the mobility of organic fractions of HMs in the methanogenic landfill. The initial rates of HMs release could be enhanced by recycling the leachate back to bioreactor landfill, but the total quantity released may be reduced by early establishment of methanogenic stage in bioreactor landfill.