锰渣堆肥过程中理化性质及基于Tessier法的重金属行为分析

通过堆肥发酵,研究了电解锰渣、废糖蜜和甘蔗渣在一定配比下添加活性污泥、猪粪水、城市河湖污泥、树林腐土、生物菌剂以及不添加微生物来源物对废渣中重金属化学形态和理化特性的影响。堆肥处理30 d监控其物理特性,采用ICP法分析了6种重金属元素总量,并利用Tessier五步连续浸取法对堆肥前后做重金属的形态分析。结果表明:堆肥过程中系统温度均高于环境温度;6种条件下,堆肥体系的pH值均得到了显著提高;堆肥可以降低电解锰渣态中重金属的生物有效性。堆肥处理有利于降低电解锰渣利用中重金属污染的风险。     

不同菌种组合对发酵残余物好氧堆肥进程及氮素变化的影响

适宜菌剂组合对于初始电导率(Electronic conductivity,EC)较高的发酵残余物二次干化腐熟效果具有重要影响。通过在发酵残余物(猪场沼渣、城市生活污泥)好氧发酵过程中添加不同菌种组合,研究堆肥腐熟指标变化,特别是不同形态氮素指标变化,以期更好提升发酵残余物的干化和腐熟程度。结果表明:F3菌剂组合处理高温期达16 d,最高温度为69.5℃,最早进入腐熟阶段,全氮损失比例最少,为8.72%;对照组在高温期(14 d、69.3℃)及全氮损失比例(9.21%)指标上仅低于F3处理组,表明自然堆体存在耐盐菌种;在促进堆肥腐熟效果方面,霉菌起着关键的作用,堆肥后期酵母菌的存在促进堆体腐熟度的提升;菌种比例和种类的合理设置对于堆体腐熟度提高的重要性要高于活菌添加量;在堆肥保氮过程中,真菌(霉菌和酵母菌)起着重要作用。F3处理(即芽孢杆菌∶霉菌∶酵母菌=1∶2∶2),是实现发酵残余物快速高效堆肥的理想菌剂配方,其他复配菌种组合保氮效果改良侧重点各不相同。     

猪粪堆肥发酵菌种的分离筛选及特性研究

从多种样品材料中分离筛选出8株能以猪粪为基质生长的菌种,对其中4株菌(8B、8C、8E、2B)进行了初步分类鉴定,并对它们发酵猪粪培养基的特性作了研究.结果表明,这4株菌均属于芽孢杆菌属,其中8C、2B菌种生长最好,8B次之,而8E菌种则不适合作为发酵菌种;对培养基采取完全灭菌对菌种生长繁殖是有利的,间歇灭菌和不灭菌效果相对较差,甚至会对菌种产生不利影响;pH值的变化在一定程度上反映出微生物生长繁殖能力的强弱;较低的pH值不利于微生物菌种生长.     

添加小麦秸秆对猪粪高温堆肥腐熟进程的影响

选用猪粪与小麦秸秆为堆肥原料进行高温好氧堆肥实验,研究添加小麦秸秆对猪粪高温好氧堆肥过程中堆体温度、pH值、种子发芽指数、碳氮比和养分等理化指标的影响,寻求猪粪高温堆肥时的最佳秸秆配比,旨在为猪粪快速资源化利用提供科学依据。结果表明,猪粪高温堆肥时添加小麦秸秆可以缩短进入高温发酵阶段的时间,减少氮素损失,加快C/N的降低速率,加速有毒有害物质分解。其中猪粪和小麦秸秆6∶4处理各层温度在2~5 d内上升至50℃,并持续37~46 d,在堆肥结束时,有机质和速效氮含量较堆肥初期下降幅度最小,分别为33.90%和23.76%,全氮、全磷、全钾、速效磷和速效钾含量较堆肥初期提高幅度最大,分别为13.34%、20.24%、53.19%、41.53%和16.57%。若以种子发芽指数80%作为堆肥腐熟的评价指标,猪粪和小麦秸秆6∶4配比堆肥的腐熟速度比纯猪粪快18 d,36 d即可腐熟。综合判断,实际应用中,猪粪与小麦秸秆按体积6∶4进行堆肥较为适宜。     

调理剂对堆肥产品重金属生物有效性的影响

城市污泥中重金属含量及其生物有效性是限制污泥农用的主要因素,因此,研究污泥堆肥化处理过程中重金属生物有效性,对污泥的农用具有重要意义。实验以城市污泥为原料,以菌菇渣和秸秆为调理剂,设置4个处理:A(污泥∶菌菇渣∶秸秆=1∶0.4∶0.025)、B(污泥∶菌菇渣∶秸秆=1∶0.3∶0.025)、C(污泥∶秸秆=1∶0.12)和D(污泥∶秸秆=1∶0.09),进行好氧堆肥实验,采用BCR顺序提取法测定各种形态的重金属,研究堆肥前后重金属形态的变化规律。结果表明,城市污泥中Cu、Ni、Pb和Cr主要以可氧化态及残渣态存在,生物有效性较低,而Zn和Cd主要以酸溶态和可还原态存在,生物有效性较高;堆肥过程显著降低了Cu、Zn、Ni和Pb的生物有效性,并改变了Cu、Zn、Ni、Pb、Cr和Cd的形态分布,使污泥中的Cu、Zn、Ni、Pb和Cd向着更稳定的可氧化态或残渣态转变;污泥经过堆肥处理后,Cu、Zn和Ni 3种重金属生物有效性关系为:ABCD,与其他处理相比,处理A残渣态的Pb和Cr增加比例较多,综合来看,处理A对重金属生物有效性的降低最为明显,重金属钝化效果最佳。     

卧式螺旋污泥好氧动态堆肥技术的研究

利用卧式螺旋式污泥好氧堆肥装置进行间歇式动态堆肥,对污水厂厌氧消化污泥进行了中温堆肥试验研究.通过控制各组堆肥的含水率、物料配比和通气量,重点探讨各种条件下堆体温度与有机物降解的关系.试验结果表明,厌氧消化污泥以木屑为调理剂在装置中可以实现好氧堆肥处理,其适宜的物料控制参数为:污泥:木屑=10:1～1.5(湿重比),堆肥含水率50%～60%;过程控制参数为:通风量为6.7～8.3 m3/h·t,发酵周期为8 d,温度45℃.     

堆肥法处理含油污泥研究进展

含油污泥是炼油厂和石油化工厂的日产固体废弃物 ,是当前石化行业所面临的污染问题。本文给出了近期国内外对含油污泥的处理方法 ,并对堆肥法处理含油污泥进行了综述。含油污泥的堆肥处理需提供氧气、菌种和营养 ,为保持油泥的疏松状态 ,还需加入填充剂。本文对高速生物反应器的结构、运行、调控进行了详细介绍 ,并从经济核算角度指出了其运营可行性     

一种新型可控堆肥反应器系统的快速好氧堆肥实验

研究自制可控堆肥反应器对城市污泥进行快速好氧堆肥的工艺效能。实验结果表明:新型堆肥反应器的可控性强。当初始入料堆体温度控制在40℃左右,含水率控制在50%左右时,堆体温度能在第3天就升至55℃以上,并维持5 d以上。含水率、pH、电导率、种子发芽指数(G I)和可挥发性固体(VS)等指标均具有良好的变化规律,均可作为堆肥腐熟度的表征和评价参数。反应器13 d即可完成一个堆肥周期,且堆肥产品的腐熟程度极高。     

城市污泥堆肥过程中堆体表面沉降及减容率的研究

通过测定堆肥过程中堆体表面沉降量的动态变化，结合堆肥温度、含水量和挥发性固体（VS）含量的变化，对堆体表面沉降和减容率及其影响因素进行研究。研究结果表明，城市污泥：树皮（1：1）处理的升温速率、最高温度和高温维持时间、含水量和VS含量去除率等均高于城市污泥：秸秆（1：1）处理，其灭菌、生物干燥和有机质降解效果较好。堆体表面沉降可分为物理压实沉降和有机质降解沉降，城市污泥：树皮（1：1）的物理压缩沉降量低于城市污泥：秸秆（1：1），主要是因为秸秆作为调理剂的支撑作用比树皮差；前者的有机质降解沉降量大于后者，这与堆肥温度、含水量和VS含量的去除率等因素有关。     

聚丙烯酸钠作为调理剂对好氧堆肥的保氮影响

实验以污泥、锯末、猪粪为原料,以聚丙烯酸钠(PAAS)为调理剂,利用自制好氧堆肥反应器,研究了PAAS在污泥好氧堆肥中的保氮效果。实验显示,PAAS会提高堆体的pH水平,抑制氨氮的生成,从而减少NH3的挥发源,在PAAS对水溶性氨的吸附作用下,堆肥产品的最终氨氮水平依然得到提高;PAAS对硝化反应有一定的促进作用,添加PAAS的堆体在堆肥周期内的硝氮平均增幅可达到未添加PAAS的空白堆体的4.64倍;添加PAAS的堆体在堆肥周期内全氮平均降幅只有空白堆体的52.24%。PAAS做为堆肥调理剂起到了较为明显的保氮效果。     

Ammonia emissions from the composting of different organic wastes. Dependency on process temperature

Ammonia emissions were quantified for the laboratory-scale composting of three typical organic wastes with medium nitrogen content: organic fraction of municipal solid wastes, raw sludge and anaerobically digested sludge; and the composting of two wastes with high nitrogen content: animal by-products from slaughterhouses and partially hydrolysed hair from the leather industry. All the wastes were mixed with the proper amount of bulking agent. Ammonia emitted in the composting of the five wastes investigated revealed a strong dependence on temperature, with a distinct pattern found in ammonia emissions for each waste in the thermophilic first stage of composting (exponential increase of ammonia emitted when increasing temperature) than that of the mesophilic final stage (linear increase of ammonia emissions when increasing temperature). As composting needs high temperatures to ensure the sanitisation of compost and ammonia emissions are one of the main environmental impacts associated to composting and responsible for obtaining compost with a low agronomical quality, it is proposed that sanitisation is conducted after the first stage in large-scale composting facilities by a proper temperature control. CAPSULE: Ammonia emission pattern and correlation with process temperature are presented for the composting process of different organic wastes.     

Removal of DEHP in composting and aeration of sewage sludge

The potential of composting and aeration to remove bis(2-ethylhexyl) phthalate (DEHP) from municipal sewage sludge was studied with two dewatered sludges: raw sludge and anaerobically digested sludge. Composting removed 58% of the DEHP content of the raw sludge and 34% of that of the anaerobically digested sludge during 85 days stabilisation in compost bins. A similar removal for the anaerobically digested sludge was achieved in a rotary drum in 28 days. Less than 1% of DEHP was removed with the compost leachate. Although DEHP removal was greater from raw sludge compost than anaerobically digested sludge compost, the total and volatile solids removals were on the same level in the two composts. In the aeration of raw sludge at 20 degrees C the DEHP removals were 33-41% and 50-62% in 7 and 28 days, respectively. Both composting and aeration are concluded to have the potential to reduce the DEHP contents typically found in sewage sludges to levels acceptable for agricultural use.     

高温堆肥与蚯蚓堆肥对城市污泥重金属形态的影响

采用高温堆肥和蚯蚓堆肥工艺，研究了城市污泥与锯末、粉煤灰或磷矿粉按不同比例混合堆肥前后重金属（Cu、Pb、Zn、Cd和As）交换态、碳酸盐结合态、铁锰氧化物结合态、有机结合态和残留态的变化。研究表明：高温堆肥和蚯蚓堆肥前后各试验污泥的重金属形态和含量呈现出不同的变化，都可以降低污泥中交换态Cu、Pb、Zn、Cd和As的含量；对于Cu和Pb，高温堆肥优于蚯蚓堆肥；对于Zn、Cd和As，蚯蚓堆肥优于高温堆肥。2种堆肥方式中，粉煤灰用量为10%的钝化效果优于20%，磷矿粉的钝化效果同粉煤灰一样。     

污泥好氧堆肥预处理混合破碎机实验研究

针对污泥高温好氧堆肥技术对粒径和含水率的要求,研制开发出了污泥混合破碎机。该破碎机采用螺旋式布置弯刀,实现污泥和辅料(包括熟料和平菇渣)的混合、破碎和输送三重功能,并能连续作业。实验表明:通过调节污泥与辅料的混合比,可以满足堆肥所需的混合料粒径(20 mm)和含水率(60%左右)要求;采用V熟:V平=1∶1作辅料,破碎机污泥处理量小于7 t/h时,满足粒径和含水率要求所需的污泥/辅料体积比R为1∶(2.5~3.5);分别采用平菇渣和熟料作辅料,结果表明,与污泥混合后都可以满足堆肥要求;平菇渣起到膨松作用,需要的量相对少。     

Changes of polycyclic aromatic hydrocarbons during composting of sewage sludges with chosen physico-chemical properties and PAHs content

The aim of the experiment was to determine changes in the PAH content during sewage sludge composting. The extent was evaluated to which sewage sludge properties influences on PAHs losses during composting. Five municipal sewage sludges were studied from sewage treatment plants located in the south-east of Poland, i.e. in Stalowa Wola, Kra?nik, Lublin, Zamo?? and Bi?goraj. The treatment plants selected were characterised by their differentiation with catchments area as well as the industrial character of the areas. Sludge composting was carried out in aerobic conditions in plastic containers for a period of 76 days. The content of 14 polycyclic aromatic hydrocarbons (PAHs) and some physical-chemical (TOC, Nt, TOC/Nt, CEC, BS, TEB, pH, available potassium and phosphorus, total forms of cations) sewage sludge properties were monitored. In the present study correlations between PAHs losses (during various phases of composting) and physical-chemical properties of sewage sludges and composts were also evaluated. The sewage sludges were characterised both by differentiated properties and by PAH content. The total PAH content (the sum of 14 PAHs from the EPA List with exception of naphthalene and acenaphthene) in the sludges ranged from 3674 to 11236 microg kg(-1). Four- and three-ring compounds were predominant in the sewage sludges. Almost all of the sludges were characterised by differentiated content levels of both individual PAHs groups and PAHs sum. After 76 days of composting, a significant lowering of the PAH content was observed in all sludges as compared to the beginning of the experiment. The range of total observed PAH losses was from 15.8% to 48.6%, depending on the sewage sludge. The largest lowering of the PAH content was observed in the sludge with the lowest concentration of the xenobiotics studied. The largest losses in individual PAHs were observed in the case of five- and six-rings compounds, and were probably related to strong pollutant binding by other components of the sewage sludge. The few significant relationships showed that PAH losses during composting were only slightly determined by the analysed physical-chemical properties.     

生物表面活性剂在城市污泥静态强制通风好氧堆肥中的作用

采用静态强制通风好氧堆肥模式对城市剩余污泥进行堆肥降解,并研究了生物表面活性剂鼠李糖脂对堆肥过程的作用。结果表明,堆肥过程中,添加了质量分数为0.015%鼠李糖脂溶液堆制处理和空白对照堆制处理的堆温变化都明显呈现出中温期0～5 d、高温期6～12 d和降温期13～28 d 3个阶段。实验组比空白组的堆体升温快、高温期持续时间长、堆体的含水率高。鼠李糖脂的添加,使实验组的微生物数量高于空白组。添加鼠李糖脂的堆体和空白堆体的种子发芽指数(GI)在堆肥结束时分别为53.70%和50.80%,说明鼠李糖脂促进了堆肥的腐熟,但由于相对浓缩效应,堆肥产品的重金属含量略高于空白堆体。生物表面活性剂的介入促进了堆肥中木质纤维素的初步降解。研究表明,添加鼠李糖脂能够改善堆肥处理的微环境,促进有机质降解和堆肥的腐熟。     

Effects of lime amendment on availability of heavy metals and maturation in sewage sludge composting

A batch composting study was performed to evaluate the feasibility of co-composting sewage sludge with lime, aiming at reducing the availability of heavy metals in the sludge compost. Sewage sludge with sawdust as bulking agent was amended with lime at 0, 0.63, 1.0, and 1.63% w/w, and composted for 100 days in laboratory batch reactors. The changes in temperature, pH, electrical conductivity (EC), and extractable heavy metal contents were measured while compost maturity was determined by C/N(organic) and cress seed germination during the composting period. Liming raised pH of compost effectively at the initial stage of composting and caused a decrease in EC through precipitation of soluble ions. Lime amendment also significantly reduced water-soluble and Diethylene triamine pentracetic acid (DTPA)-extractable metal contents. The maximum reductions were 60 and 40% for Cu, 80 and 40% for Mn, 55 and 10% for Zn, and 20 and 25% for Ni at the end of the composting period for the lime-amended sludge as compared to the control. In spite of the inhibitory effect of lime amendment on the decomposition activity of sewage sludge, all treatments reached maturation after 63 days of composting as indicated by the results of C/N(organic) ratio and cress seed germination test results. A lime amendment of < or =1.0% is recommended to co-compost with sewage sludge.     

垃圾堆肥高效纤维素分解菌的筛选与培育技术

从堆肥、马粪、果园土、污泥等20个样品中，分离筛选出3株对滤纸分解旺盛的纤维素分解菌：C1、C2、C3，并外购康氏木霉、白腐菌、变色栓菌一起作为出发株，经紫外诱变处理后，在含葡萄糖的产酶培养基平板上筛选到能形成较大透明圈的突变株，并进行CMC酶活、微晶纤维素酶活及天然粗纤维分解能力测定。实验结果证明白腐菌经紫外线照射60s诱变而得的C16不仅透明圈大，CMC酶活高（60.08U/mL）是出发株的2倍，而且其对天然粗纤维分解能力强，10d分解率达35％。     

复合微生物菌剂强化堆肥技术研究

采用复合微生物菌剂对生活垃圾的接种堆肥技术进行了实验研究。通过测定堆肥过程中反应器出口O2、CO2与H2S气体浓度及对堆肥样品扫描电镜照片分析，比较了3个接种组与1个对照组中堆料中微生物总数变化、种群结构演替及堆肥腐熟速度。试验结果表明，在原料成分为：生活垃圾／成熟堆肥=80／20，有机物约为60％，初始含水率为55％，初始C／N-30时，对于不同接种量的复合微生物接种系统堆料中分别接种0．2％、0．3％、0．5％(质量百分含量)，与加入0．3％灭活菌的对照组进行对比实验，接种复合微生物菌剂堆肥系统不仅微生物总数高于对照组，而且其种群结构合理，能明显提高堆肥效率，有效控制臭气的产生，提高堆肥腐熟度。