城市污水厂混合污泥好氧消化处理研究

以城市污水处理厂的初沉污泥与剩余污泥的混合污泥为对象,研究了影响污泥好氧消化处理的各项因素.通过测定氧摄取速率(OUR)和此污泥好氧速率(SOUR),对实验结果进行了探讨.     

Support of sustainable management of nitrogen contamination due to septic systems using numerical modeling methods

Nitrogen contamination is a serious concern to sustainable environmental management, and one important source of nitrogen contaminant is due to wastewater treatment using onsite sewage treatment and disposal systems (OSTDS, a.k.a., septic systems). This paper presents a study in which numerical modeling is used to support sustainable decision-making and management of nitrogen contamination by utilizing a recently developed GIS-based software, VZMOD, a Vadose Zone MODel for simulating nitrogen transformation and transport in vadose zone between drainfield of septic systems and water table. VZMOD is based on a physical model of unsaturated flow and nitrogen transformation and transport, and the model is solved numerically using the finite element methods. This is the major difference between VZMOD and other GIS-based software of nitrogen modeling. Using GIS techniques, VZMOD considers spatial variability of a number of hydrogeologic parameters such as hydraulic conductivity and porosity. A unique feature of VZMOD is that VZMOD addresses spatial variability of water table by using VZMOD together with ArcNLET, an ArcGIS-based software developed to simulate groundwater flow and nitrate load from septic systems to surface water bodies. VZMOD is designed to execute in different modes to be compatible with different levels of data availability in various management projects of nitrogen contamination. This paper presents an application of VZMOD at a neighborhood with hundreds of septic systems and heterogeneous hydraulic conductivity, porosity, and water table depth. The modeling results indicate that using septic systems at the considered neighborhood is unsustainable and more management means are necessary.     

城市污泥干燥焚烧一体化处理工艺的研究

城市污泥的产量日益增加,若不进行处理,不仅浪费土地资源而且污染环境。对污泥中的水分形式和污泥的处理工艺进行了分析,认为污泥的干燥和焚烧是最完全、稳定的处理工艺。提出一种城市污泥干燥焚烧一体化处理工艺,利用污泥自身焚烧产生的热值,提供干燥系统所需的热量,达到整个污泥处理系统能量的基本自给。对该系统的流程和各工艺进行了分析,结果表明该系统的污泥减量大、干燥效率高、运行成本低、尾气排放有效控制。     

Economic evaluation of sewage treatment processes in India

This paper evaluates the total annual cost including capital and operation and maintenance (O&M) costs for the up-flow anaerobic sludge blanket (UASB) and waste stabilization pond (WSP) systems operated in India. It also compares UASB and WSP systems with the activated sludge process (ASP) and biological aerated filter (BAF) systems in terms of total annual cost and chemical oxygen demand (COD) removal cost by assuming various annual interest rates and land prices. It was found that the relationship between capital and O&M costs per unit size of a UASB or WSP system and its treatment capacity can be established by a first-order equation. The relation between the cost of organic removal and capital or O&M cost for various sewage treatment systems at various annual interest rates revealed that, for the Indian context, UASB could be the most suitable option in terms of expenses and treatment efficiency.     

Solidification of tannery wastes

The high chromium concentrations in tannery-wastewater treatment-plant sludges, render them unsuitable for direct disposal. Therefore, one aims to fix the chromium of the tannery waste by adding different additive materials to cause solidification. The properties of the raw sludge were determined and subsequently, the sludge was mixed with cement and additives and left to solidify for 28 days. During the study, 28 different mixtures were prepared and their compressive strengths were determined. Standard elutriation tests were carried out with each solidified sample. Compressive strengths were obtained below the desired concrete strengths. Most of the pollutant parameters in eluate were under the required values.     

FACTORS THAT AFFECT ACTIVATED SLUDGE PHOSPHATE RELEASE1

The activated sludge process can remove significant amounts of phosphorus from sewage, but the removal efficiency is usually significantly reduced by the release of phosphate back to solution during subsequent treatment steps. This research presents a study of soluble phosphate release from activated sludge with emphasis on defining the factors that affect such release and the actual release mechanisms. Laboratory units were used for experimental purposes. The experiments were designed to study the relationship between soluble phosphate release and various environmental factors such as redox potential (ORP), dissolved oxygen (DO), pH, solids concentration, solids destruction, and sulfate salt addition. The effect of substrate utilization on phosphate uptake and the relationship between uptake characteristics and subsequent phosphate release were also studied. The results show that some phosphate storage occurs during aerobic substrate utilization. Following substrate utilization, activated sludge phosphate release is directly related to the amount of biological stress the organisms are subjected to, and the mechanism of release is primarily cell lysis. The phosphate released per unit sludge under anoxic conditions is relatively constant. Under normal environmental conditions, neither ORP or pH change have a significant affect on phosphate release.     

鸟粪石沉淀法回收污泥处理构筑物中氮磷的研究进展

污水处理厂氮磷的处理和回收已经成为必然。而污泥处理构筑物中氮磷的释放则进一步要求对其中释放的氮磷进行回收。本文介绍了国内外对鸟粪石形成条件、外加镁源以及各种利用鸟粪石沉淀法进行污泥处理构筑物中氮磷回收的研究现状，并对其在污泥处理构筑物氮磷回收中存在的问题进行了论述。     

污水厂污泥与厨余垃圾厌氧/混合厌氧消化研究进展

本文主要对国内外城市污水厂污泥与厨余垃圾混合厌氧消化的研究进行了综述,介绍了厌氧消化技术在污水厂污泥和厨余垃圾处理处置中的应用,对两种废物单独厌氧消化和混合厌氧消化技术进行了比较,分析了城市污水厂污泥与厨余垃圾混合厌氧消化的可行性以及工艺参数对混合厌氧消化的影响,并对城市污水厂污泥与厨余垃圾的混合厌氧消化技术的研究和应用提出了展望。     

常用钻井液填加剂对钻井污水化学需氧量的影响

针对石油工业钻井污水化学需氧量（ＣＯＤ）严重超标的状况,从分析测定目前油田常用的８种钻井液添加剂的ＣＯＤ入手,探讨了钻井液添加剂对钻井污水的影响。实验结果表明：８种钻井液添加剂按油田现场配比复配后,对钻井污水ＣＯＤ的影响程度各不相同,其大小依次为：柴油、ＨＰＡＮ、磺化沥青、ＰＡＮ、ＰＡＭ－１、ＦＡ－３６７、ＸＹ－２７、ＣＭＣ;钻井污水中ＣＯＤ值严重超标的主要因素是钻井液添加剂;并且钻井液添加剂浓度与其对应的ＣＯＤ之间存在良好的一元线性关系。根据一元线性回归方程可较好地预测油田现场各钻井液添加剂对ＣＯＤ的影响,为解决钻井污水处理这一难题提供科学依据。     

Composting and compost application in China

The current situation of municipal solid waste (MSW) and sewage sludge production (in terms of volume as well as composition) in China is introduced. Composting and compost application in China are reviewed. In China, the production of municipal solid waste and sewage sludge is changing rapidly along with economic development. Composting is mainly applied for treating MSW, about 20% of the total amount of MSW being disposed. MSW composting is mainly co-composted with night soil or sewage sludge. Compost is used in agriculture, forestry and horticulture. Compost application is the key factor influencing the composting development in China. To promote composting and compost application in China, a state-wide survey on the production, composition and physical and chemical properties of MSW and sewage sludge should be carried out. More effort should be made to develop low cost and high efficient composting technologies according to China's conditions. The environmental impact of compost application should also be given more attention.     

上海市污泥集装化运输可行性研究

随着上海市生活垃圾集装化运输系统的逐步完善和发展,上海市污泥的集装化运输逐渐被提上日程。本文通过对上海市中心城区的10座城市污水处理厂的污泥产量、污泥含水率、污泥运输道路和装卸环境等进行系统调研,综合分析和研究了上海市各污水处理厂污泥集装化运输的可行性,并进一步研究了污泥性质对集装化运输的影响。结果表明,上海市中心城区仅白龙港污水处理厂含水率约为60%的深度脱水污泥符合污泥集装化运输的要求;深度脱水污泥性质较为稳定,对各种钢材料的腐蚀性为0.00016~0.00125 mm/a,对集装化运输影响较小,但污泥释放的氨气浓度高达173.66 mg/m3,影响集装化运输,需采取水雾喷洒等措施进行控制。     

A CLOSED WATER REUSE SYSTEM FOR POWER PLANT COOLING AND DIGESTER HEATING1

ABSTRACT: A model consisting of closed water reuse and productive use of various types of wastes for energy generation is presented. The sewage after treatment would be used as the cooling water for power plants, and the condenser discharge therefrom be used as heating water for sludge digesters. The water is then purified for municipal water supply for continuous use. The advantages of this system are that water resources and energy are conserved while various types of wastes including waste heat are controlled. With a preliminary system analysis, it appears that the design for power plant based on the total heating value of wastes and digester capacity based on sewage sludge generation is feasible in terms of acquisition and full utilization of various types of wastes as generated in a single metropolitan area. The system as shown in this design is in balance among various factors such as the generation rate of municipal refuse, municipal sewage, waste heat in the condenser discharge, and raw sewage sludge.     

废活性污泥破乳作用研究初探

利用污水处理厂的废弃活性污泥作为破乳剂，对柴油－水乳状液体系进行了破乳实验研究。结果表明，温度高时活性污泥的破乳效果好，水的脱除率可达９０％。在此基础上将活性污泥用溶剂进行抽提，提取液的破乳作用优于活性污泥。该法既能利用废活性污泥，还为替代化学破乳剂提供了可能性。     

Strength and durability characterization of pelletized coal–biomass household briquettes

Increase in waste sludge disposal is always seen as a problem from the point of production industry. However, it is clear that the reuse and recycle of sewage sludge could be a serious economic input. The most important action should be to determine the sludge characterizations and direct the producers towards appropriate reuse and recycling opportunities. In this study, reuse method was examined to produce coal briquette, which will constitute an example for waste sludge. In order to make use of the waste sludge, five different coal briquette samples were produced by mixing powdered coal and bitumen together with waste sludge, at different ratios. The overall results indicated that the sample named CB3 having 70% powdered coal, 20% waste sludge, and 10% bitumen was found to be the optimum coal briquette among the other samples produced. The proximate analysis of the optimum briquette sample was carried out according to the Turkish standards and regulations and it was found out that the produced briquette coal can have commercial value with a gross calorific value of 30.03 MJ/kg and 7.30% ash content.     

厌氧消化在城市生活污水处理中的应用及技术经济指标研究

本文就生活污水的厌氧处理常见装置的原理、性能进行了简要介绍，并通过省内现正在运行的几种化粪池的处理效果和国外粪便污水处理装置试验结果比较，来论证化粪池设计的主要参数确定原则，在保证污水有效处理的前提下，控制“无效”地容，以降低成本。     

Methane production during storage of anaerobically digested municipal organic waste

Anaerobic digestion of source-separated municipal organic waste is considered feasible in Denmark. The limited hydraulic retention in the biogas reactor (typically 15 d) does not allow full degradation of the organic waste. Storage of anaerobically digested municipal organic waste can therefore be a source of methane (CH4) emission that may contribute significantly to the potential global warming impact from the waste treatment system. This study provides a model for quantifying the CH4 production from stored co-digested municipal organic waste and estimates the production under typical Danish climatic conditions, thus quantifying the potential global warming impact from storage of the digested municipal organic waste before its use on agricultural land. Laboratory batch tests on CH4 production as well as temperature measurements in eight full-scale storage tanks provided data for developing a model estimating the CH4 production in storage tanks containing digested municipal organic waste. The temperatures measured in separate storage tanks on farms receiving digested slurry were linearly correlated with air temperature. In storage tanks receiving slurry directly from biogas reactors, significantly higher temperatures were measured due to the high temperatures of the effluent from the reactor. Storage tanks on Danish farms are typically emptied in April and have a constant inflow of digested material. During the warmest months the content of digested material is therefore low, which limits the yearly CH4 production from storage.     

成都市污水管道输送和处理的模拟试验研究

本文针对成都市污水输送和污染现状，提出管式活性污泥处理法，并进行了有关模拟试验研究。     

稠油罐底泥碳化处理技术研究与应用*

为解决油田生产过程中产生的稠油罐底泥的环境污染和资源浪费问题,在分析含油污泥性质和特点的基础上开发了稠油罐底泥碳化处理工艺及配套装置。介绍了该技术的原理及工艺流程,在小试、中试研究的基础上,进行了工业化应用,稠油罐底泥的处理效果表明:油气回收率可达90%以上,轻质油品占回收油总量的78%以上,焚烧处理后的残渣未检出矿物油;烟气和废水相关项目的监测值符合相关标准。     

城市垃圾和污水脱水污泥、排水管污泥混合堆肥工艺研究

城市垃圾和污水脱水污染、排水管污泥已成为现代城市污染的主要总是。由于这些废弃物中有机物质的含量较高,因此可以利用堆肥的方法来进行处理,使其转化为农田的有机肥料,本文用城市生活垃圾和污水处理厂污泥、排水管污泥混合进行堆肥的研究。     

A comparison of disposal methods for on-site sewage facilities within the state of Texas,USA

Currently, 1.5 million homes in Texas, USA utilize an on-site sewage facility to manage their household waste. This study compares the conventional septic dispersal technology of perforated pipe drain field with two of the new technologies recently implemented in Texas, multi-pipe and chamber systems, determining if soil classification and climate are influencing factors in functional ability for each of the technologies. There is no statistical significance for failure of a system with respect to system type or climate zone. The textural classification of soil is a statistically significant variable in septic system failures. Soil type III, which includes the clay groups except pure clays and silty clay, appears to significantly influence system failures. Additionally, occupant misuse and lack of maintenance are contributing factors to system failure.