Tetracycline as a selector for resistant bacteria in activated sludge

Tetracycline, one of the most widely used antibiotics, is excreted into wastewater after consumption by humans and animals. The focus of this research was to evaluate the fate of tetracycline resistant bacteria in the activated sludge process as a function of tetracycline loading. The studies were conducted with aerobic biological sequencing batch reactors (SBRs). When comparing 250 microgl(-1) tetracycline fed SBRs with parallel SBRs having a background influent wastewater tetracycline concentration of approximately 1 microgl(-1), tetracycline fed reactors were found to have increased concentrations and production rates of tetracycline resistant bacteria, higher net growth rates of resistant bacteria, and higher percentages of tetracycline resistant bacteria, which were amplified by increase in organic loading and growth rates.     

UniFed SBR工艺除磷脱氮机理研究

采用UniFed SBR工艺试验装置处理实际生活污水,确定了出水不受进水扰动影响的合适排水比.当将进水/排水时间固定为2 h,排水比不高于41.67%时,可以实现进水与出水的分离,保证良好的出水水质.通过试验分析了UniFed SBR工艺的除磷脱氮机理在于:进水/排水阶段在反应池底部先后发生了反硝化作用和厌氧释磷反应,后续曝气阶段发生硝化作用和好氧吸磷,因此通过该工艺,可实现同步除磷脱氮.     

UASB-SBR处理涤纶短纤维废水的实验研究

分别采用水解酸化与好氧（SBR）、厌氧（UASB）与好氧（SBR）工艺对涤纶短纤维废水的生物降解性能进行研究。水解酸化与好氧工艺在进水COD为1 900 mg/L的时候,去除率在80%左右。采用UASB-SBR工艺,进水COD为2700 mg/L时,COD去除率可以达到96%,出水COD〈100 mg/L。实验研究表明,涤纶短纤维废水更适合采用UASB-SBR工艺来处理,并且能够取得较好的效果。     

序批式反应器用于牛场污水的处理

对序批式反应器 (SBR)用于牛场污水的处理进行了试验研究 ,主要研究了三个水力停留时间 (HRT)和有机负荷率对污染物去除率、出水水质和污泥特性的影响。试验结果表明 ,对 10 0 0 0mg/LCOD牛场污水 ,使用 1dHRT ,相应有机负荷率为 10gCOD/L·d时 ,混合出水COD、TS、VS、TKN和TN的去除率分别为 45 %、2 1.4%、34 .2 %、5 3.2 %和 2 2 .2 % ,上清液出水的分别为 80 .2 %、6 3.4%、6 6 .2 %、75 %和 38.3% ;两种出水的SCOD和NH3 N去除率相同 ,分别为 5 0 .0 %和 76 .5 %。经SBR处理后 ,污泥的沉降浓缩性能也有了比较明显的改善。     

Understanding the granulation process of activated sludge in a biological phosphorus removal sequencing batch reactor

The granulation of activated sludge was investigated using two parallel sequencing batch reactors (SBRs) operated in biological nitrogen and phosphorus removal conditions though the reactor configuration and operating parameters did not favor the granulation. Granules were not observed when the SBR was operated in biological nitrogen removal period for 30 d. However, aerobic granules were formed naturally without the increase of aeration intensity when enhanced biological phosphorus removal (EBPR) was achieved. It can be detected that plenty of positive charged particles were formed with the release of phosphorus during the anaerobic period of EBPR. The size of the particles was about 5-20 μm and their highest positive ζ potential was about 73 mV. These positive charged particles can stimulate the granulation. Based on the experimental results, a hypothesis was proposed to interpret the granulation process of activated sludge in the EBPR process in SBR. Dense and compact subgranules were formed stimulated by the positive charged particles. The subgranules grew gradually by collision, adhesion and attached growth of bacteria. Finally, the extrusion and shear of hydrodynamic shear force would help the maturation of granules. Aerobic granular SBR showed excellent biological phosphorus removal ability. The average phosphorus removal efficiency was over 95% and the phosphorus in the effluent was below 0.50 mg L⁻¹ during the operation.     

AFB-SBR工艺处理蓝皮制革工业废水

采用厌氧流化床(AFB)-序批式反应器(SBR)工艺处理蓝皮制革工业废水。分别考察了水力停留时间(HRT)、容积负荷对厌氧流化床以及曝气时间、污泥浓度、溶解氧浓度对SBR反应器处理效果的影响。试验结果表明,AFB将实验废水的BOD_5/COD(B/C)值由0.19～0.26提高至0.35～0.42,有效提高了其可生化性;在进水COD浓度为1 700～1 890 mg/L、HRT为1 d、容积负荷为1.792 kg COD/(m~3·d)时,COD去除率达65.2%～68.5%,且具有良好的抗冲击负荷能力。SBR在进水COD浓度为628～712 mg/L、污泥浓度为2.9 g/L、曝气时间为10 h、溶解氧浓度为2 mg/L工况下,COD去除率达87.6%,NH_3-N去除率达93.6%,处理后出水水质符合污水综合排放标准(GB 8978-1996)中的一级标准要求。     

填料对厌氧移动床生物膜反应器运行效果的影响

通过对装有不同填料的2个厌氧移动床生物膜反应器(R1和R2)的有机负荷、COD去除率、沼气产量及其组成、出水挥发性有机酸(VFA)和出水pH值的对比,得出在填料充填率相同、进水COD和进水pH相似的情况下,填料比表面积是影响厌氧移动床生物膜反应器运行效果的主要因素.R1中填料的比表面积为528 m2/m3,R2中填料比表面积为211m2/m3.在整个运行阶段,填料比表面较大的R1反应器的运行结果较好.试验结束时,R1与R2的有机负荷比为1.61,而R1与R2填料上的污泥量之比为4.42.     

COD对强化生物除磷系统的影响及OUR的变化规律

以实际生活污水为研究对象,在SBR系统中采用厌氧/好氧运行方式,考察强化生物除磷(EBPR)系统中好氧阶段COD浓度对聚磷菌除磷性能的影响以及不同好氧阶段COD浓度下的OUR变化规律.实验分4个阶段进行,分别为不投加外碳源、厌氧结束时投加不同体积的乙酸钠作为外碳源,使COD分别提高50、100和300mg/L.4种工况...     

混凝沉淀-厌氧折流板反应池-两级好氧生化工艺处理毛毯废水

采用混凝沉淀 厌氧折流板反应池 两级好氧生化工艺处理毛毯废水。在废水 pH为 4 .6 3— 6 .95、CODCr为96 6— 1990mg/L、BOD5为 2 4 3— 4 97mg/L、SS为 344— 4 36mg/L、色度 4 0 0倍时 ,处理出水达到一级排放标准。该处理技术先进、可靠。     

COD对生物除磷颗粒污泥稳定性影响研究

颗粒污泥稳定性是影响其应用的主要因素之一.以SBR中成熟的生物除磷颗粒污泥为研究对象,探讨进水COD浓度对系统稳定性的影响.结果表明,当进水COD浓度由300 mg/L逐渐升高到500 mg/L时,磷去除率由93%降低到88%;当进水COD浓度在400 mg/L以下时,污泥的最大比释磷速率和比吸磷速率分别为45.2 m...     

厌氧／缺氧SBR反硝化除磷效能的研究

采用厌氧 缺氧SBR反应器对以硝酸盐作为电子受体的反硝化除磷过程进行了研究。结果表明 ,反硝化聚磷菌完全可以在厌氧 缺氧交替运行条件下得到富集。稳定运行的厌氧 缺氧SBR反应器的反硝化除磷效率 >90 % ,出水磷浓度 <1mg L。进水COD浓度对反硝化除磷的效率影响很大 ,在COD浓度 <180mg L时 ,进水COD浓度越高 ,除磷效率也就越高。较高浓度的进水COD浓度将导致有剩余的COD进入缺氧段 ,对反硝化吸磷构成不利影响。污泥龄为 16d时 ,厌氧 缺氧SBR反应器取得稳定和理想的反硝化除磷效果。污泥龄减少到 8d ,由于反硝化聚磷菌的流失导致反硝化除磷效率的下降。当污泥龄恢复到 16d时 ,经过一段时间的运行 ,反硝化聚磷菌重新得到富集 ,除磷效率恢复到 90 %以上。     

铬离子对SBR工艺活性污泥毒性作用研究

针对重金属铬离子对SBR工艺系统中活性污泥的毒性作用,通过检测不同初始污泥容积指数(SVI)下SBR工艺活性污泥在不同铬负荷下的COD值、挥发性污泥浓度以及受铬离子影响的污泥容积指数(SVI),研究重金属铬离子对活性污泥的毒性作用以及对SBR工艺系统处理污水的影响。研究表明,重金属铬离子会导致SBR工艺系统出水COD升高;将铬离子对活性污泥的毒性作用按照挥发性污泥(MLVSS)铬负荷可划分为耐受范围、非耐受范围、细胞失活范围以及细胞分解范围。耐受范围铬负荷低于约30 mg Cr3+/gMLVSS,此范围内铬离子对于活性污泥的毒性作用不大,不致于导致系统出水水质变差;非耐受范围铬负荷在约30~65 mg Cr3+/g MLVSS,在铬离子作用下系统出水COD值明显高于对照系统;细胞失活范围铬负荷在约70~100 mg Cr3+/gMLVSS范围内,SVI大幅下降,微生物部份死亡和失活,出水COD尽管有一些下降,但与进水COD相比差不了多少;细胞分解范围铬负荷在约100 mg Cr3+/gMLVSS以上,微生物大量死亡,部分死亡细胞分解,系统出水COD值因微生物的死亡分解而超出进水COD值,受铬离子影响的系统SVI值大幅度降低。     

UASB-SBR组合工艺处理畜禽养殖废水的研究

近年来,随着中国畜禽养殖业的快速发展,落后的养殖模式和污染防治设施,使畜禽养殖污染日趋严重,畜禽养殖污染已居农业污染源之首,已成为中国环境污染的重要因素,对环境质量乃至人体健康都会产生不良影响。文中采用UASB—SBR组合工艺处理畜禽养殖废水,通过试验探讨SBR反应器启动方法及最佳运行模式,同时研究UASB反应器的启动方法。结果表明,SBR运行的最佳模式为进水0.5 h、反应8 h、沉淀1 h、出水0.5 h、闲置14 h。经过一段时间的启动,UASB和SBR反应器均成功启动,UASB—SBR组合工艺在处理畜禽养殖废水时可获得稳定的处理效果,COD、氨氮、总磷等出水水质均达到《畜禽养殖业污染物排放标准》(GB18596-2001)要求,为畜禽养殖废水处理的工程化应用提供了参考依据。     

SBR脱氮系统污泥对磷的去除研究

为了研究缺氧(75 min)-好氧(294 min)交替运行的SBR系统中除磷的原因,采用静态实验,对比了不同碳源、水质及运行环境下对磷的去除情况。实验结果表明,该SBR脱氮系统中的好氧段磷的减少是生物去除的结果。当供给碳源为丙酸-乙酸混合物(摩尔比为2∶1)、葡萄糖、淀粉或蛋白胨时,污泥都可将磷去除,去除效率依次降低;COD/NO3--N为8.77∶1(400 mg/L∶45.6 mg/L)时除磷效果明显好于5.41∶1(400 mg/L∶73.9 mg/L)和3.57∶1(400 mg/L∶112 mg/L);进水磷浓度为8 mg/L时,COD由50 mg/L增加到400 mg/L,污泥对磷的去除效果基本一样;完全的缺氧或完全的好氧环境下,污泥对磷的去除能力逐渐丧失。     

Formation of aerobic granules in the presence of a synthetic chelating agent

This paper examines the development of aerobic granular sludge in the presence of a synthetic chelating agent, nitrilotriacetic acid (NTA), in sequencing batch reactors (SBR). The growth of seed sludge at 0.26 mM, 0.52 mM and 1.05 mM of NTA was found to be significantly lower as compared to that in the absence of NTA. Aerobic granulation was significantly enhanced in the three SBRs (R2, R3 and R4), which were fed with 0.26 mM, 0.52 mM and 1.05 mM of NTA as a co-substrate, in comparison to the acetate-alone fed SBR (R1). After 2 months of operation, the mean diameter of the biomass stabilized at 0.35 mm in R1 (acetate alone), as compared to 2.18 mm in R4 (1.05 mM NTA+acetate). NTA degradation was established in SBRs, with almost complete removal during the SBR cycle. Batch experiments also showed efficient degradation of NTA by the aerobic granules.     

利用亚硝酸盐为电子受体反硝化聚磷菌的筛选与富集

依据DPB原理,利用SBR动态反应器和静态释/聚磷装置.以A2/O工艺厌氧段污泥为种泥,研究以亚硝酸盐为电子受体反硝化聚磷菌的筛选与富集,同时对选择、富集污泥的反硝化聚磷性能进行了考察.结果表明:利用亚硝酸盐为电子受体的反硝化聚磷菌存在于A2/O厌氧段污泥中,通过厌氧/好氧和厌氧/缺氧方式运行后,聚磷菌总数由1400个/mL增加到32 000个/mL,其中反硝化聚磷菌占聚磷菌总数的比例也由14.5%提高到81%,磷酸盐和亚硝酸盐去除率分别由最初的8.65%和7.55%上升到91%和95.62%;筛选与富集利用亚硝酸盐为电子受体的反硝化聚磷菌时,缺氧段进水COD的浓度须控制在10 mg/L以下;当体系处于稳定状态,且亚硝酸盐氮浓度高达30 mg/L时,并未对反硝化聚磷菌的生存产生抑制和体系运行产生干扰,此时磷酸盐出水低至1.06 mg/L.     

Load maximization of a liquid-solid circulating fluidized bed bioreactor for nitrogen removal from synthetic municipal wastewater

A novel liquid-solid circulating fluidized bed bioreactor (LSCFB) configured with anoxic and aerobic columns and lava rock as the biofilm carrier was used to treat synthetic municipal wastewater. Four different empty bed contact times (EBCTs) of 0.82, 0.65, 0.55, and 0.44 h were examined to optimize nutrient removal capability of the system. The LSCFB demonstrated tertiary effluent quality organic and nitrogen removal efficiencies. Effluent characteristics of the LSCFB were soluble biological oxygen demand (SBOD)10 mg l(-1) and total nitrogen (TN)<10 mg l(-1) at organic loading rate (OLR) of 5.3 kg m(-3)d(-1) and nitrogen loading rate of 0.54 kg Nm(-3)d(-1). Remarkably low yields of 0.14, 0.17, 0.19, and 0.21 g VSS g(-1)COD were observed at OLR of 2.6, 3.2, 4.1 and 5.3 kg COD m(-3)d(-1), where increment of biomass growth and detachment rate were also experienced with increasing OLR. However the system demonstrated only 30% phosphorus removal, and mass balances along the anoxic and aerobic columns showed biological phosphorus removal in the system. Organic mass balance showed that approximately 40% of the influent COD was utilized in the anoxic column and the remaining COD was oxidized in the aerobic column. The system is very efficient in nitrification-denitrification, with more than 90% nitrification of ammonium and overall nitrogen removal in the LSCFB was 70+/-11% even at an EBCT of 0.44 h.     

悬浮填料-SBR工艺处理难降解青霉素制药废水的研究

采用悬浮填料 SBR工艺处理青霉素制药废水 ,结果表明 :青霉素废水中含有的抗生素对微生物有抑制作用 ,宜采用非限制曝气的进水方式 ;最佳运行工艺为一周期 8h ,非限制曝气进水 1h ,反应 5h ,沉淀、排水和闲置 2h ;该工艺与单一SBR工艺相比 ,可提高CODCr去除率 2 0 %以上 ,缩短反应时间 2h ;且具有良好的稳定性 ,当进水CODCr浓度变化较大( 80 0— 2 5 0 0mg L)时 ,CODCr去除率一直稳定于 83 %— 85 %之间 ,出水CODCr在 136— 35 0mg L之间 ,达到国家二级排放标准。     

原位臭氧氧化污泥减量工艺的运行效能

采用ASBR/SBR原位臭氧污泥减量工艺,重点研究了原位臭氧氧化对SBR段污泥产率和出水水质的影响。两个相同的ASBR/SBR组合工艺同时运行,每隔3个周期向臭氧投加组SBR的曝气阶段原位间歇投加臭氧,臭氧投加量为0.027 g O3/g MLSS,连续运行40 d;对照组不投加臭氧作为对比。结果表明,原位臭氧氧化实现污泥减量约43.9%,臭氧投加组SBR段平均污泥产率系数为0.1447 g SS/g SCOD,而对照组为0.2580 g SS/g SCOD,投加组没有惰性污泥的累积,并且污泥沉淀性能得到改善。原位臭氧氧化对出水水质影响不大,投加组与对照组相比,臭氧投加3周期后的出水COD、NH4+-N、TN和TP平均值分别为47.8、0.76、14.1和6.4 mg/L,去除率分别下降了4%、2%、3%和7.7%,其中COD、NH4+-N和TN均能达到《城镇污水处理厂污染物排放标准》(GB18918-2002)一级A标准。     

低曝气下PAC强化SBR工艺同步脱氮除磷

采用序批式反应器(SBR)处理模拟生活污水,研究不同曝气量(30、24、18和12 L/h)下活性污泥同步脱氮除磷规律,并在最佳曝气量下,比较了粉末活性炭-序批式反应器(PAC-SBR)和SBR的脱氮除磷效率,分析了低曝气下PAC-SBR的运行特性和优越性。实验结果表明,当曝气量为24 L/h时,SBR内出水效果较好,其COD、TN和TP的平均去除率分别可以达到90.02%、81.13%和88.12%。在这个最佳曝气量下,PAC-SBR具有明显的优势,其COD、TN和TP的平均去除率均高于SBR,并且PAC-SBR具有较好的污泥沉降性能和较高的活性污泥浓度。在PAC-SBR中,活性污泥以PAC作为微生物载体强化了生物降解效果,并改善了低曝气下污泥絮体的结构,促使反应器内先后形成缺氧-厌氧-微氧/缺氧-缺氧的环境,利于同步硝化反硝化和反硝化聚磷,提高了PAC-SBR的同步脱氮除磷效率。