Removal of NOx from Flue Gas with Iron Filings Reduction Following Complex Absorption in Ferrous Chelates Aqueous Solutions

Abstract

A novel process for removal of nitrogen oxides (NO_x) from flue gases with iron filings reduction following complex absorption in iron-ethylenediaminetetraacetic acid aqueous solution is proposed. The reaction mechanism involved in the process is discussed briefly. The parameters influencing the process, including the concentration of ferrous chelates, initial pH, amount of iron filings, temperature, flow rate of the flue gas, and inlet nitric oxide concentration and oxygen content of the flue gas, are researched in detail. The optimal NO_x removal conditions are established. The regeneration and circular utilization of the absorption solution also is studied.     

尿素/三乙醇胺吸收烟气NO_x的实验研究

以尿素作为吸收液,与NOx反应生成N2和CO2,脱除烟气中的氮氧化物。以一套双级串连的填料塔为主体反应器,分别对气速、液气比、反应物浓度、添加剂浓度和反应温度等参数对尿素溶液吸收NOx反应的影响进行了实验研究,获得了优化实验工况,研究结果显示,在气速为0.1 m/s、液气比为16 L/m3、三乙醇胺为0.01%（质量比）、尿素浓度为13%（质量比）工况下,反应温度为30~70℃,脱硝总效率可达50%以上,且随着NOx体积分数增加而提高。     

尿素添加剂湿法烟气脱氮的试验研究

在填有金属鲍尔环的管式吸收反应器中,分别研究了尿素含量、添加剂(三乙醇胺)浓度、吸收柱彳丁效高度、烟气浓度对NOx脱除效率的影响。试验结果表明,尿素含量和添加剂浓度的增加可以少量提高脱氮效率：烟气浓度的大小对脱氮效率的影响不大;吸收柱有效高度对脱氮效率的影响较大。     

尿素/高锰酸钾湿法烟气脱氮的试验研究

采用高锰酸钾和尿素配制成不同浓度的吸收溶液,在填有金属鲍尔环的管式吸收反应器中,对模拟烟气进行湿法烟气脱氮的研究。试验结果表明,用尿素和高锰酸钾配制成的吸收液进行湿法烟气脱氮,可以高效地脱除模拟烟气中的氮氧化物,高锰酸钾含量的增加可以显著提高脱氮效率,是决定脱氮效率高低的重要因素,在尿素和高锰酸钾含量分别为5%和0.60g/L时可以达到91.5%的平均脱氮效率;尿素含量、吸收液有效柱高和外加的SO2气体均对脱氮效率产生不同程度的影响。     

Simultaneous absorption of NO and SO2 into hexamminecobalt(II)/iodide solution

An innovative catalyst system has been developed to simultaneously remove NO and SO2 from combustion flue gas. Such catalyst system may be introduced to the scrubbing solution using ammonia solution to accomplish sequential absorption and catalytic oxidation of both NO and SO2 in the same reactor. When the catalyst system is utilized for removing NO and SO2 from the flue gas, Co(NH3)(6)2+ ions act as the catalyst and I- as the co-catalyst. Dissolved oxygen, in equilibrium with the residual oxygen in the flue gas, is the oxidant. The overall removal process is further enhanced by UV irradiation at 365 nm. More than 95% of NO is removed at a feed concentration of 250-900 ppm, and nearly 100% of SO2 is removed at a feed concentration of 800-2500 ppm. The sulfur dioxide co-existing in the flue gas is beneficial to NO absorption into hexamminecobalt(II)/iodide solution. NO and SO2 can be converted to ammonium sulfate and ammonium nitrate that can be used as fertilizer materials. The process described here demonstrates the feasibility of removing SO2 and NO simultaneously only by retrofitting the existing wet ammonia flue-gas-desulfurization (FGD) scrubbers.     

Thermodynamic behaviour of sodium and calcium based sorbents in the emission control of waste incinerators

The dry treatment of flue gas produced by incineration processes is discussed thermodynamically. The study investigates the theoretical limits achieved by sodium and calcium based sorbents in the removal of the pollutant species HCl, NOx and SO2. Calculations were performed varying the temperature and the molar ratio between the amount of the injected alkaline sorbent and the content of the pollutant gaseous species in the flue gas. Results show that sodium cation based sorbents are more efficient than calcium based ones in the whole investigated temperature range (100-600 degrees C). The higher effectiveness of sodium based sorbents is particularly remarkable towards hydrogen chloride, whose concentration can always be reduced below the values set by the environmental regulations. Possible improvements in the treatment efficiency of combustion fumes obtainable with sodium based sorbents can be mainly summarised in a lower concentration of HCl in the treated gas and in a partial reduction of NOx concentration.     

H2O2溶液同时脱硫脱硝实验研究

二氧化硫和氮氧化物是电厂产生的主要大气污染物，研究焦点越来越集中在在一个反应器内实现同时脱硫脱硝。实验以H2O溶液作为吸收液，在自制的鼓泡反应器内，对模拟烟气进行同时脱硫脱硝的实验研究，实验结果表明：H2O浓度、反应温度、NO浓度、SO2浓度、烟气流量对脱除率影响显著，pH、氧含量对脱硝率影响不大。在整个实验范围内脱硫效率总是保持在98．5％以上，脱硝效率最高达到67．4％。     

铁屑微电解-共沉淀法处理屠宰场废水的研究

利用铁屑微电解-共沉淀法处理屠宰场废水,介绍其作用机理,考察了废水pH值、铁屑用量、反应时间、曝气时间和操作方式等因素对色度和CODCr去除率的影响.结果表明,在废水pH值为4,铁屑用量为15%,常温反应4 h,曝气时间2 h条件下,色度去除率可达100%,CODCr去除率达92.68%.     

气升式反应器中微生物烟气脱硫研究

基于微生物酸性铁溶液烟气脱硫特性,实验构建了一套内循环气升式反应器.在反应器中,利用处于对数生长期的氧化亚铁硫杆菌(Thiobacillus ferrooxidans)酸性铁溶液进行了模拟烟道气SO2脱除实验研究.为寻求高脱硫率,实验研究了铁离子浓度、入口氧含量、细菌数和pH值的变化对脱硫率的影响.考察了反应液中Fe(Ⅱ)离子浓度的变化规律.实验表明,含T.f菌酸性铁溶液的脱硫效果较高;Fe离子浓度在7.67 g/L左右时脱硫率最佳;入口气中氧含量、反应液中细菌数和pH值越高,反应液的脱硫率也就越高.反应液中的Fe(Ⅱ)离子浓度是一先扬后抑的变化过程.     

亚铁螯合剂液相脱除烟气中NOx

总结了近20多年来液相络合法脱除烟气中NOx的研究成果,详细叙述了亚铁氨羧和亚铁含-SH基二类螯合剂单独脱氮和同时脱硫脱氮的反应机理、动力学、吸收液的再生和过程的影响因素,指出了该工艺存在的主要问题,提出了今后的研究方向.     

生物法同时脱硫脱硝试验研究

采用轻质陶粒生物滴滤塔处理摸拟燃煤烟气中二氧化硫和氮氧化物的试验研究，探讨生物法同时脱硫脱硝的影响因素及生物降解宏观动力学。研究结果表明，生物法能有效同时去除烟气中的二氧化硫和氮氧化物，烟气同时脱硫脱硝效率分别可达99.9%和88.9%。为获得最佳烟气同时脱硫脱硝效果，二氧化硫和氮氧化物进气负荷应分别＜140 g/（m³·h）和20 g/（m³·h），循环液pH=7～8，空床停留时间为30.28 s，喷淋密度为8.81 L/（m³·h）。     

Study on NOx removal from simulated flue gas by an electrobiofilm reactor: EDTA-ferrous regeneration and biological kinetics mechanism

Environmental Science and Pollution Research - The regeneration of EDTA-FeII is a key step in electrobiofilm reduction-integrated systems for NOx removal from industrial boiler flue gas. The...     

非平衡放电等离子体治理有害气体

重点分析了常温常压下非平衡放电等离子体产生的条件及其物理和化学性能，综合评述了放电技术的理烟气中有害气体ＳＯ２，ＮＯｘ，ＣＯ２的机理和研究现状。     

好氧反硝化去除低浓度NO_x的动力学模型研究

在好氧条件下,对利用生物滴滤塔（bio-trickling filter,BTF）反硝化净化废气中NOx的过程进行了理论模型探讨,并用实验结果进行了验证。在分析NOx在BTF内传质以及生物降解过程的基础上,建立了NOx在气相和生物膜相的质量守恒方程,结合Fick定律和好氧条件下的Monod微生物反应动力学方程,最终得到了NOx在BTF中＂吸附-微生物降解＂过程的动力学方程。模型计算值与实验结果表明,BTF中好氧反硝化过程为一级反应过程,利用该模型可以较好地模拟进口浓度、停留时间等因素对出口浓度的影响,对实际应用具有指导意义。     

废铁屑处理难生物降解染料废水

研究了用废铁屑处理难生物降解的染料废水，考察了进pH值、曝气时间、固液比、铁屑粒度对废水处理效果的影响，并确定了适宜实验条件。实验证明，该法可以有效去除染料废水的色度和CODcr，在实验考察范围内，脱色率和CODcr去除率分别可达90％、61.7%。同时废水可生化性也得到了改善，BOD5／CODcr从19.6%上升到29.5%，提高了50％,有利于后续生化处理。该法以废治废，是一种很有实用价值的废水处理方法。     

Effect of NOx control processes on mercury speciation in utility flue gas

The speciation of Hg in coal-fired flue gas can be important in determining the ultimate Hg emissions as well as potential control options for the utility. The effects of NOx control processes, such as selective catalytic reduction (SCR) and selective non-catalytic reduction (SNCR), on Hg speciation are not well understood but may impact emissions of Hg. EPRI has investigated the reactions of Hg in flue gas at conditions expected for some NOx control processes. This paper describes the methodology used to investigate these reactions in actual flue gas at several power plants. Results have indicated that some commercial SCR catalysts are capable of oxidizing elemental Hg in flue gas obtained from the inlets of SCR or air heater units. Results are affected by various flue gas and operating parameters. The effect of flue gas composition, including the presence of NH3, has been evaluated. The influence of NH3 on fly ash Hg reactions also is being investigated.     

超重力脱除模拟烟气中一氧化氮简

以NO和N₂的混合气作模拟烟气，以酸性尿素溶液为吸收剂，在超重力机中进行了脱除模拟烟气中NO实验研究。实验考察了混合气中NO初始含量、进气流量、吸收液流量、超重力机转速对NO脱除率的影响，确定了在超重力中尿素吸收NO的适宜条件。实验结果表明，在常温常压下，N₂体积流量为1.0 m³/h，控制NO初始浓度为3 300 mg/m³，吸收液流量为250 L/h，超重力机转速为650 r/min时，NO脱除率可达89.5%。     

电子束烟气脱硫技术工业示范工程进展

处理成都电厂２００ＭＷ机组锅炉的３０万Ｎｍ３／ｈ烟气。它是目前世界上已投入运行的处理烟气量最大的电子束脱硫装置。其脱硫率及脱硝率均超过８０％及１０％的设计值,各项运行消耗指标均低于设计值。处理过程为干法,无废水废渣,副产品硫（硝）铵可用作化肥。该装置的自动化程度较高,操作简便,对烟气ＳＯ２浓度及烟气量的变化有较好的适应性和负荷跟踪性。烟气中残氨浓度及周围的辐射剂量低于国家标准的规定。     

氧化镁烟气脱硫反应特性研究

利用实验室规模的鼓泡式反应装置,对比了碳酸钙、氧化镁和氧化镁/硫酸镁脱硫剂的反应活性,证实脱硫液中高浓度硫酸镁的存在是保证镁法脱硫效率高于钙法的重要因素,并考察了硫酸镁浓度、脱硫剂(氧化镁)浓度、烟气量、SO2浓度和吸收液温度等因素对脱硫效率的影响。结果表明,脱硫反应可以根据pH分为2个不同阶段;反应过程中脱硫效率随着硫酸镁浓度的增加而显著升高;烟气量增加将会导致脱硫效率有所下降;入口SO2浓度升高,脱硫效率下降;氧化镁浓度、温度对脱硫效率影响不显著。结合实验现象进行推断,氧化镁脱硫的反应过程受SO2在气液两相界面的传质扩散和其水解产物在液相的扩散控制。     

旋转填料床/柠檬酸盐法吸收-解吸SO2

提出采用旋转填料床结合柠檬酸盐法脱除烟气中SO2的方法,考察了旋转填料床转子转速、液气比、初始柠檬酸根浓度和初始pH值等因素对脱硫效率的影响。结果表明,采用超重力法超重机转子转速为1 000 r/min、液气比为7L/m3、初始柠檬酸根浓度为1.5 mol/L、吸收液的初始pH值为5.0,脱硫效率稳定在99%左右。研究了水蒸气汽提法解吸SO2时初始柠檬酸根浓度、初始pH值、SO2浓度、富液流量和水蒸气流量对解吸效率的影响,得出了影响SO2解吸率的基本规律,并进行了分析。通过实验证明该方法在技术上是可行的,具有良好的应用前景。