残余应力对焊接角接头裂纹扩展性能的影响分析

目的 分析焊接残余应力对角接接头裂纹扩展特性的影响。方法 基于热弹塑性力学法,建立角接头的有限元模型,计算焊接温度场,并采用热机耦合方法计算焊接残余应力。采用断裂力学方法,分析计算焊趾部位的应力强度因子和裂纹扩展寿命,并对比分析残余应力对裂纹扩展的影响。结果 计算得到焊缝的残余应力达到了材料屈服极限,呈拉伸应力状态,其Von Mises应力值为345 MPa。在应力为200 MPa以内,考虑残余应力的前提下,分别使用文献试验得到的数据和IIW标准中的数据作为裂纹扩展参数,应力比R=–1时的裂纹扩展寿命分别为2.61×10⁶和6.84×10⁵次循环;在应力比R=0时的裂纹扩展寿命分别为1.16×10⁵和2.90×10⁴次循环。结论 残余应力会加速裂纹扩展。采用控制变量法,将应力范围设定为常值,当应力比R<0时,残余应力扩大了应力强度因子的范围;在应力比R>0时,残余应力一方面会增大最大应力强度因子,使其接近材料的断裂韧度,同时拉伸残余也提高了平均应力强度因子或者提高了应力比R,在这种情况下,残余应力均会加速裂纹的扩展速度。随着裂纹长度的增加,残余应力对裂纹扩展速率的影响会增大。外载荷和残余应力共同对裂纹扩展产生影响,应力比R和残余应力对裂纹扩展的影响机制相同,在焊接结构寿命评估时,需要综合考虑这2个影响因素。     

疲劳裂纹扩展对高强钢电化学性能的影响

采用线性极化、电化学交流阻抗等方法,研究了施加疲劳载荷前后高强钢在质量分数为3.5%的NaCl溶液中的电化学行为.结果表明,施加疲劳载荷后,开路电位变化值在裂纹扩展过程中经历先负移后稳定最后稍有正移,由线性极化和交流阻抗拟合得到的极化电阻都呈先增大后减小的趋势.     

热-力循环载荷下身管镀层裂纹扩展规律研究

目的研究身管镀层裂纹的扩展机理,提高身管寿命。方法针对身管镀层裂纹损伤,提出一种基于扩展有限元方法(XFEM)结合内聚力模型(CZM)的方法。建立热–力耦合的镀层身管有限元模型,通过间接耦合的方式,将温度场导入有限元模型,通过CZM本构模型来模拟其损伤失效行为。对镀层初始裂纹在热–力载荷下扩展到镀层/基体界面的情况进行仿真分析。结果在高温高压环境下,镀层初始裂纹扩展速度很快,在第1发射击完成后便扩展到基体结合面,初始裂纹扩展到镀层/基体界面时,裂纹尖端的存在使局部具有较大切应力,达到1180 MPa。在连续射击工况下,造成镀层结合面的开裂。结论在高温高压载荷下,镀层初始裂纹很快扩展到镀层/基体界面,且身管镀层承受的热应力是导致镀层开裂的重要因素。     

APEC前后北京SO2垂直分布特征及其对二次硫酸盐生成的影响

SO_2是北京大气中重要的污染气体.为探讨亚太经合组织(APEC)峰会前后北京大气SO_2的垂直分布及其对二次硫酸盐(SO_4~(2-))生成的影响,我们于2014年10月21日至11月30日在地面和北京325 m气象塔260 m高度处同步开展了气体SO_2和亚微米颗粒物中硫酸盐(SO_4~(2-))实时连续在线观测.结果显示,采暖前,北京地面SO_2浓度较低,但高层由于显著受到区域输送的影响浓度较高,两层污染物变化趋势也存在明显差异.采暖后,即APEC后,受本地供暖排放影响,SO_2和SO_4~(2-)浓度显著增加,两层的总体差异也相应减小,变化趋势也更为一致.湿度对SO_2的液相转化起关键作用.我们发现近地面SO_2的转化率(SOR)显著高于260 m,这主要与地面较高的湿度相关.事实上,SOR随着湿度增加而迅速增大,进一步凸显了湿度对SO_2液相氧化的影响.另外,我们也发现SO_2特别是260 m在低湿范围(RH40%)内随湿度增加而逐渐升高,但在高湿范围(RH50%)内则呈下降趋势,说明不同湿度范围内的来源或者生成机制可能有所不同.SO_4~(2-)和PM_(2.5)浓度均随着湿度的增加而增加,但不同湿度范围,增加速率不同.通过相关性和和后向轨迹分析表明,区域输送(特别是途经北京西部和南部的气团)和本地燃煤排放分别是采暖前后污染物的主要来源.     

冷变形和溶解氧对308L不锈钢焊材应力腐蚀开裂的影响规律

目的 探究冷变形和溶解氧(DO)对308L不锈钢焊材在高温高压水环境中应力腐蚀开裂(SCC)行为的影响规律.方法 采用直流电压降法对308L试样裂纹扩展速率(CGR)进行在线测量,对比原始态、冷变形态308L焊材在DO和氢气除氧两种水环境中的SCC性能.参照F-A模型,结合冷变形前后材料微观组织和试样的断口形貌及裂纹扩...     

预腐蚀铝合金材料裂纹萌生寿命评估

铝合金在航空工业中广泛应用,因此对于铝合金构件的寿命评估很重要。利用扫描电子显微镜(SEM)原位观测技术,研究了预腐蚀铝合金试件在循环应力作用下的疲劳裂纹萌生和扩展行为。结果表明腐蚀坑对于裂纹萌生扩展行为具有强烈的影响。基于局部应变法,提出了一种预测带有腐蚀损伤的铝合金疲劳裂纹萌生寿命的评估公式。     

填料初始湿度对气态乙酸乙酯生物过滤的影响

以堆肥 珍珠岩作为生物过滤器填料 ,研究了填料初始湿度对去除气态乙酸乙酯的影响 .当进气乙酸乙酯负荷为 2 65—376g (m3·h)时 ,通过 1 2 3h的运行实验 ,发现初始湿度低至 30 % (以重量计 )的填料对乙酸乙酯去除能力较低 ,达到稳定运行状态需要较长时间 .而初始湿度较高的填料 (40 %— 70 % )去除乙酸乙酯能力较强 ,可以较快达到稳定运行状态 ,在稳定状态时对乙酸乙酯的去除率较高 .初始湿度高至 70 %的填料不利于实际操作 .在初始湿度高的填料中 ,微生物细胞总数以及细菌和霉菌数量较多 ,酵母菌和放线菌的含量较少 .填料的初始湿度为 40 %— 60 %比较适宜     

海洋大气对TA15钛合金应力腐蚀影响研究

采用恒位移WOL试样测定KISCC的原理对已在海洋平台户外和海水飞溅区暴露2a的TA15钛合金样及原始TA15钛合金样进行了应力腐蚀行为研究。探讨了TA15钛合金预制裂纹的条件,并用裂纹终止法测量应力腐蚀临界应力场强度因子,确立了应力场强度因子KISCC与裂纹瞬时扩展速率da/dt之间的联系,并绘制了lg （da/dt）-KI曲线。通过扫描电镜对试件断面进行了分析,对其断裂特征进行了描述。     

力学载荷条件下 EB-PVD 热障涂层损伤行为研究

目的研究力学载荷条件下EB-PVD热障涂层的损伤行为。方法采用电子束物理气相沉积工艺(EB-PVD)制备热障涂层(TBCs),利用SEM和体式显微镜对力学性能试验后带涂层试样的断口特征、裂纹形貌和金相组织进行观察,分析热障涂层在拉伸、持久和旋转弯曲疲劳等典型力学载荷条件下的损伤行为。结果在室温拉伸条件下,陶瓷层内先出现垂直于应力轴、沿柱状晶簇扩展的平行环状周向微裂纹,随着拉伸塑变量的增加,局部区域裂纹贯穿粘结层并进入合金基体;900℃高温拉伸条件下裂纹也产生于陶瓷层,但裂纹均钝化于粘结层与陶瓷层的界面,并穿透粘结层。在持久条件下,试样在弹性变形阶段涂层即发生开裂,随后沿着陶瓷层柱状晶簇间扩展,但未扩展至粘结层;在高温高周疲劳条件下,裂纹首先出现在粘结层,随后向基体逐渐扩展,扩展深度较浅,而基体疲劳裂纹在粘结层裂纹末端萌生并倾斜滑移扩展。结论提高粘结层韧性、减少粘结层中裂纹萌生和向基体扩展,是热障涂层材料和工艺优化的有效途径。     

环境因素对气相甲苯光氧化反应机制的影响

以低压汞灯为光源,采用石英管连续流动态反应系统和特氟龙气袋静态反应系统,研究了环境因素〔RH(相对湿度)、温度、光照强度、有氧(空气)/无氧(氮气)气氛条件〕对低浓度(10~20 mg/L)气相甲苯光氧化过程的影响. 结果表明:①RH对甲苯光氧化反应影响显著. 干燥条件(RH为0%~5%)下甲苯光氧化去除率在8.3%~8.7%之间;当环境中有水蒸气存在(RH为20%)时,甲苯光氧化去除率降至6.5%~7.2%,其后光氧化去除率随着RH的进一步增加而逐渐增大,在RH为60%时达到最大值(9.4%~11.5%);但当RH继续增至80%时,去除率迅速降至4.4%~5.6%. ②甲苯光氧化去除率随着温度、光照强度的增加而提高. ③无论是干燥(RH为0%~5%)还是湿润(RH为60%)环境下,甲苯在有氧气氛下的去除率均高于无氧气氛;甲苯在有氧气氛下光氧化产物主要是苯和苯甲醛,在无氧气氛中的产物主要是苯. ④在干燥、有氧条件下,O(1D)应是甲苯光氧化的活性物种;在湿润、有氧条件下,甲苯的光氧化主要是通过·OH氧化降解;在无氧条件下,甲苯的光氧化主要是通过甲苯的直接光解完成.      

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

EDTA-enhanced phytoremediation of lead contaminated soil by Bidens maximowicziana

Phytoremediation is a potential cleanup technology for the removal of heavy metals from contaminated soils.Bidens maximowicziana is a new Pb hyperaccumulator,which not only has remarkable tolerance to Pb but also extraordinary accumulation capacity for Pb.The maximum Pb concentration was 1509.3 mg/kg in roots and 2164.7 mg/kg in overground tissues.The Pb distribution order in the B. maximowicziana was:leaf>stem>root.The effect of amendments on phytoremediation was also studied.The mobility of soil Pb and the Pb concentrations in plants were both increased by EDTA application.Compared with CK(control check),EDTA application promoted translocation of Pb to overground parts of the plant.The Pb concentrations in overground parts of plants was increased from 24.23-680.56 mg/kg to 29.07-1905.57 mg/kg.This research demonstrated that B.maximowicziana appeared to be suitable for phytoremediation of Pb contaminated soil,especially,combination with EDTA.     

Distribution and ecological effect of mercury in Laogang landfill, Shanghai, China

Laogang landfill near Shanghai is the largest landfill in China, and receives about 10000 t of daily garbage per day, Samples of topsoil and plants were analyzed to evaluate mercury pollution from the landfill. For topsoil samples, there were significant correlations among total mercury （HgT）, combinative mercury （Hgc） and gaseous mercury （HgG）, and content of total organic carbon （TOC）, but, no significantly relationship was found between Hg content and filling time. Hg content changes in vertical profiles with time showed that the average Hgv of profiles 1992, 1996, and 2000 was similar, but their average HgG was quite different. HgT was significantly correlated with Hgc in profile 1992 and 2000, and Hgv was significantly correlated with Hg6 in profile 1996. HgG/Hgv ratio in profile samples decreased in the order of （HgG,/HgT）1992〉（HgG/HgT）1996〉〉（HgG/HgT）2000. A simple outline of Hg release in landfill could be drawn： with increasing of filling time, degradation undergoes different biodegradation, accordingly, gaseous mercury goes through small, more, and small proportion to total mercury. Distribution of Hg in plants was inhomogeneous, following the order of leaf〉root〉stem. The highest value of leaf may be associated with higher atmospheric Hg from landfill. Ligneous plants （e.g. Phyllostachys glanca, Prunus salicina and Ligustrum lucidum） are capable of enriching more Hg than herbaceous plants.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Enzymatic oxidation of aqueous pentachlorophenol

The influence of the nonionic surfactant Tween 80 on pentachlorophenol （PCP） oxidation catalyzed by horseradish peroxidase was studied. The surfactant was tested at concentrations below and above its critical micelle concentration （CMC）. Enhancement of PCP removal was observed at sub-CMCs. The presence of Tween 80 in the reaction mixture reduced enzyme inactivation which occurred through a combination of free radical attack and sorption by precipitated products. A simple first-order model was able to simulate time profiles for enzyme inactivation in the presence or absence of Tween 80. At supra-CMCs, the surfactant caused noticeable reductions in PCP removal, presumably through micelle partitioning of PCP which precluded the hydrophobic PCP molecule from interacting with the enzyme.     

Decomposition of alachlor by ozonation and its mechanism

Decomposition and corresponding mechanism of alachlor, an endocrine disruptor in water by ozonation were investigated. Results showed that alachlor could not be completely mineralized by ozone alone. Many intermediates and final products were formed during the process, including aromatic compounds, aliphatic carboxylic acids, and inorganic ions. In evoluting these products, some of them with weak polarity were qualitatively identified by GC-MS. The information of inorganic ions suggested that the dechlorination was the first and the fastest step in the ozonation of alachlor.     

Degradation of metabolites accumulated of benzo[a]pyrene by coupling Penicillium Chrysogenum with KMnO4

Several main metabolites of benzo[a]pyrene （BaP） formed by Penicillium chrysogenum, Benzo[a]pyrene-1,6-quinone （BP 1,6- quinone）, trans-7,8-dihydroxy-7,8-dihydrobenzo[a]pyrene （BP 7,8-diol）, 3-hydroxybenzo[a]pyrene （3-OHBP）, were identified by high-performance liquid chromatography （HPLC）. The three metabolites were liable to be accumulated and were hardly further metabolized because of their toxicity to microorganisms. However, their further degradation was essential for the complete degradation of BaP. To enhance their degradation, two methods, degradation by coupling Penicillium chrysogenum with KMnO4 and degradation only by Penicillium chrysogenum, were compared; Meanwhile, the parameters of degradation in the superior method were optimized. The results showed that （1） the method of coupling Penicillium chrysogenum with KMnO4 was better and was the first method to be used in the degradation of BaP and its metabolites; （2） the metabolite, BP 1,6-quinone was the most liable to be accumulated in pure cultures; （3） the effect of degradation was the best when the concentration of KMnO4 in the cultures was 0.01% （w/v）, concentration of the three compounds was 5 mg/L and pH was 6.2. Based on the experimental results, a novel concept with regard to the bioremediation of BaP-contaminated environment was discussed, considering the influence on environmental toxicity of the accumulated metabolites.     

Impact of atrazine and nitrogen fertilizers on the sorption of chlorotoluron in soil and model sorbents

Sorption of chlorotoluron in ammonium sulfate, urea and atrazine multi-solutes system was investigated by batch experiments. The results showed application of nitrogen fertilizers to the soil could affect the behavior of chlorotoluron. At the same concentration of N, sorption of chlorotoluron decreased as the concentration of atrazine increased on the day 0 and 6 in soil, respectively. The sorption of chlorotoluron increased from 0 to 6 d when soils were preincubated with deionized water, ammonium sulfate and urea solution for 6 d. That indicated incubation time was one of the most important factors for the sorption of chlorotoluron in nitrogen fertilizers treatments. The individual sorption isotherms of chlorotoluron in rubbery polymer and silica were strictly linear in single solute system, but there were competition sorption between pesticides or between pesticides and nitrogen fertilizers. That indicated the sorption taken place by concurrent solid-phase dissolution mechanism and sorption on the interface of water-organic matter or water-mineral matter.     

基于综合水质标识指数和对应分析法的校园河道水质评价

以三峡大学的校园河道求索溪为研究对象,利用综合水质标识指数法确定求索溪水质类别,分析其水质时空变化规律,并利用对应分析法得出求索溪中不同监测点的主要污染因子.研究结果表明:求索溪整体的综合水质标识指数为7.423,整体水质为劣V类(地表水环境质量标准GB 3838-2002)且黑臭.从时间变化来看,求索溪4月份的水质最差,5月份次之,4、5月份所有监测点的水质都劣于V类且黑臭;8月份水质最好,水质为Ⅳ类;从空间分布来看,8个监测点综合水质标识指数均超过6.0,水质为劣V类,其中6号监测点的水质相对最好,监测点3号的水质相对最差;对应分析法得出求索溪的整体水体污染程度受总氮因子的影响最大,其次为总磷.该研究拟为求索溪及类似校园河道的水环境治理研究提供基础依据和参考.     

Potential of plant polyphenol oxidases in the decolorization and removal of textile and non-textile dyes

In this study an effort has been made to use plant polyphenol oxidases; potato （Solanum tuberosum） and brinjal （Solanum melongena）, for the treatment of various important dyes used in textile and other industries. The ammonium sulphate fractionated enzyme preparations were used to treat a number of dyes under various experimental conditions. Majority of the treated dyes were maximally decolorized at pH 3.0. Some of the dyes were quickly decolorized whereas others were marginally decolorized. The initial first hour was sufficient for the maximum decolorization of dyes. The rate of decolorization was quite slow on long treatment of dyes. Enhancement in the dye decolorization was noticed on increasing the concentration of enzymes. The complex mixtures of dyes were treated with both preparations of polyphenol oxidases in the buffers of varying pH values. Potato polyphenol oxidase was significantly more effective in decolorizing the dyes to higher extent as compared to the enzyme obtained from brinjal polyphenol oxidase. Decolorization of dyes and their mixtures, followed by the formation of an insoluble precipitate, which could be easily removed simply by centrifugation.