LNG池火热辐射模型及安全距离影响因素研究

重点对LNG池火热辐射模型,模型应用方式,以及热辐射安全距离的影响因素做了详细研究,给出池火热辐射模型采用及安全距离计算的方法。对常用的热辐射计算模型(点源模型、LNGFire3和PoFM ISE模型)加以介绍,并对3种模型做了对比研究。PoFM ISE模型充分考虑大池火直径时不完全燃烧的因素以及风速对火焰高度的影响,建议当风速大于1.5 m/s,池火直径大于20 m时采用。同时,进一步研究影响LNG池火热辐射安全距离的各种因素,包括池火直径、风速、环境温度和湿度,从而得出不同条件下池火热辐射安全距离的要求。     

Developing a CFD heat transfer model for applying high expansion foam in an LNG spill

Liquefied natural gas (LNG) is widely used to cost-effectively store and transport natural gas. However, a spill of LNG can create a vapor cloud, which can potentially cause fire and explosion. High expansion (HEX) foam is recommended by the NFPA 11 to mitigate the vapor hazard and control LNG pool fire. In this study, the parameters that affect HEX foam performance were examined using lab-scale testing of foam temperature profile and computational fluid dynamics (CFD) modeling of heat transfer in vapor channels. A heat transfer model using ANSYS Fluent® was developed to estimate the minimum HEX foam height that allows the vapors from LNG spillage to disperse rapidly. We also performed a sensitivity analysis on the effect of the vaporization rate, the diameter of the vapor channel, and the heat transfer coefficient on the required minimum height of the HEX foam. It can be observed that at least 1.2 m of HEX foam in height are needed to achieve risk mitigation in a typical situation. The simulation results can be used not only for understanding the heat transfer mechanisms when applying HEX foam but also for suggesting to the LNG facility operator how much HEX foam they need for effective risk mitigation under different conditions.     

Analysis of the boiling liquid expanding vapor explosion (BLEVE) of a liquefied natural gas road tanker: The Zarzalico accident

The road accident of a tanker transporting liquefied natural gas (LNG) originated a fire and, finally, the BLEVE of the tank. This accident has been analyzed, both from the point of view of the emergency management and the explosion and fireball effects. The accidental sequence is described: fire, LNG release, further safety valves release, flames impingement on vessel unprotected wall, vessel failure mode, explosion and fireball. According to the effects and consequences observed, the thermal radiation and overpressure are estimated; a mathematical model is applied to calculate the probable mass contained in the vessel at the moment of the explosion. The peak overpressure predicted from two models is compared with the values inferred from the accident observed data. The emergency management is commented.     

水面LNG液池扩展模型的分析与对比研究

为了评价在开阔水面上的液化天然气（LNG）火灾和蒸气云爆炸灾害后果，分析了LNG水面扩展动态过程；对比分析了Fay模型、FERC模型和计算流体力学软件FLACS的计算结果，探讨了LNG液池面积随时间的动态变化过程，分析了泄漏量、泄漏速率等参数对LNG液池扩展半径的影响；根据液池扩展模型的计算结果，确定了LNG液池的最大面积，并以此分析了LNG流淌火灾的辐射危害。研究结果表明:对于相同的泄漏条件，3种方法模拟的泄漏LNG水面扩展动态过程相似，一般情况下，FLACS模型，FERC模型和Fay模型所计算的最大液池半径依次增大;由于FERC模型与FLACS软件的模拟结果接近且偏于保守，故此在一般的工程应用时，采用FERC模型即可方便快捷地获得较为准确的结果。     

3m直径煤油池火灾火焰特性的数值研究

为了预测油池火灾的火焰特性,采用CFD模拟技术开展静风状态下3 m直径煤油液池的火灾场景模拟,探讨火焰温度、火焰羽流速度、辐射热通量、燃烧产物质量分数等油池火焰特性参数随高度的变化关系;并结合火焰形态分布,提出一种4区域模型,即将湍流扩散火焰划分为油气混合燃烧区、燃烧火焰区、烟尘区和热烟气区来分析燃烧气流在不同高度的实际物理化学特性。此外,通过经验公式和CFD模拟2种方法分别计算出3 m直径煤油池火灾的火焰高度、火焰表面的辐射通量及热辐射破坏半径,并对计算结果进行比较分析,结果表明:2种方法可互相补充完善,有助于池火灾的热辐射危害性评估。     

LNG accident dynamic simulation: Application for hazardous consequence reduction

The evaluation of exclusion (hazard) zones around the LNG stations is essential for risk assessment in LNG industry. In this study, computational fluid dynamics (CFD) simulations have been conducted for the two potential hazards, LNG flammable vapor dispersion and LNG pool fire radiation, respectively, to evaluate the exclusion zones. The spatial and temporal distribution of hazard in complex spill scenario has been taken into account in the CFD model. Experimental data from Falcon and Montoir field tests have been used to validate the simulation results. With the valid CFD model, the mitigation of the vapor dispersion with spray water curtains and the pool fire with high expansion foam were investigated. The spray water curtains were studied as a shield to prevent LNG vapor dispersing, and two types of water spray curtain, flat and cone, were analyzed to show their performance for reduction and minimization of the hazard influencing distance and area. The high expansion foam firefighting process was studied with dynamic simulation of the foam action, and the characteristics of the foam action on the reduction of LNG vaporization rate, vapor cloud and flame size as well as the thermal radiation hazard were analyzed and discussed.     

Methodology for consequence analysis of LNG releases at deepwater port facilities

A methodology to perform consequence analysis associated with liquefied natural gas (LNG) for a deepwater port (DWP) facility has been presented. Analytical models used to describe the unconfined spill dynamics of LNG are discussed. How to determine the thermal hazard associated with a potential pool fire involving spilled LNG is also presented. Another hazard associated with potential releases of LNG is the dispersion of the LNG vapor. An approach using computational fluid dynamics tools (CFD) is presented. The CFD dispersion methodology is benchmarked against available test data. Using the proposed analysis approach provides estimates of hazard zones associated with newly proposed LNG deepwater ports and their potential impact to the public.     

Acoustic analysis of blast waves produced by rapid phase transition of LNG released on water

Massive offshore and onshore storage of fuel have led the international community to raise questions about the hazards on the surrounding installations and people. Among the possible accidental scenarios when cryogenic gas as liquefied natural gas (LNG) is spilled on water at a very fast rate, the phenomenon of rapid phase transition (RPT) may occur: large amounts of energy are released during phase transition which can generate explosions. The related consequences should be added to the possible consequences of fire in terms of flash fire, fireball, pool fire, and vapour cloud explosion for confined and congested geometry surrounding the release point.In this paper, the analysis of RPT of LNG has been studied from the point of view of blast wave production, through ab initio acoustic analysis for monopole source. Maximum overpressures, as calculated at the source point and along the blast pathway are compared with results of large scale experiments. Safety distances are given for the sake of comparison with threshold distances reported in the open literature.     

LNG加气站槽车卸车直供过程泄漏后果分析*

为研究LNG加气站槽车直接供液过程泄漏后果严重程度,采用HAZOP辨识槽车供液和储罐供液典型泄漏场景,基于PHAST分析不同泄漏场景下LNG液池半径、蒸汽云扩散距离及积聚时长、爆炸超压和池火热辐射影响范围,定量评价槽车供液可能造成的事故后果扩大程度。结果表明:槽车供液泄漏事故的LNG液池最大半径、蒸汽云最大扩散距离、爆炸超压最大影响半径和池火热辐射最大半径,分别为储罐供液的5.7,1.7,2.3,7.9倍;槽车在无人值守条件下泄漏形成的LNG液池最大半径和蒸汽云积聚时长,分别为有人值守下的1.85,56倍;日供液量较大加气站不宜采用槽车直接为汽车供液模式,而应采用先卸车入罐、再储罐供液的模式;应落实槽车卸车轮班值守制度,并与周边社区建立有效的应急联动方案。     

Dynamic simulation of hazard analysis of radiations from LNG pool fire

Because of its highly flammable nature, any accidental release of liquefied natural gas (LNG) could possibly pose significant fire hazard. In this study, a computational fluid dynamics (CFD) model was used to analyze this hazard around an existing LNG station. By assuming an LNG pool fire occurring in an impoundment area, dynamic simulations of flame development have been carried out. In order to provide more reliable simulation results, a study was first conducted to determine the mesh independence and suitable time step. The results of CFD simulations were also compared with those using the commonly-used phenomenological model. The simulation results showed that LNG tanks in the neighbor dike area could withstand the received radiant heat flux, and the areas involving human activities, such as security office and public area, were also secure enough for people to escape from the hazards. LNG vaporizers, which are often located close to tank area, could possibly receive relatively higher radiant heat flux. High temperature achieved on vaporizers could cause material failure. CFD calculations have also indicated that increasing the spacing distance or using flowing water curtain could reduce this temperature. It is concluded that CFD method is significantly more effective to account for LNG hazard analysis and provide realistic results for complicated scenarios, thus providing meaningful information for safety consideration.     

不同通风条件下柴油池火的实验研究

为了分析不同通风条件对柴油池火燃烧特性及引燃特性的影响,进行205 mm带水垫层柴油池火的引燃实验,通过对池火燃料的质量损失速率、火焰高度、温度及热辐射等的监测,分析通风环境中柴油池火的热传递规律。结果表明:当风速为0.5 m/s时,火灾进入旺盛阶段的时间提前,火焰平均温度最高;当风速为1 m/s时,风速的增加导致油池火的质量损失速率增加,位于主火源下风向的待引燃火源获得的热辐射通量增大,火灾旺盛阶段火焰的平均温度降低,火焰高度降低,下风向相邻油盘引燃的时间提前;1 m/s情况下,205 mm带水垫层柴油池火的安全间距需增加到1D以上;通风环境对池火发展及蔓延的影响是显著的,应适当加大下风向可燃物的安全间距,合理选择通风排烟风速,优化火灾应急救援策略。     

Configuration predictions of large liquefied petroleum gas (LPG) pool fires using CFD method

Liquefied petroleum gas (LPG) has potential pool fire risks due to its flammability. The configuration of pool fires plays a significant role when applying the solid flame model or point source model to assess the risks from heat radiation. However, no existing correlations can precisely predict the configuration of large LPG (100% propane) pool fires. To enhance the fundamental understanding on how pool diameter and wind velocity can influence the configuration of large LPG pool fires, an experimentally validated Computational Fluid Dynamics (CFD) model is employed to simulate fires using different burning rate models. Fire temperature profiles, flame heights, and flame tilts predicted by the CFD model were compared with empirical models and experimental data. Accordingly, new correlations for flame height and flame tilt as functions of pool diameter D and wind velocity u_w have been developed. The comparisons demonstrate that the new correlations have the best overall accuracy in the prediction of flame height and tilt for large LPG pool fires under different conditions (10 m ≤ D ≤ 20 m, 0 ≤ u_w ≤ 3 m·s⁻¹).     

Numerical simulation of LNG dispersion under two-phase release conditions

The use of LNG (liquefied natural gas) as fuel brings up issues regarding safety and acceptable risk. The potential hazards associated with an accidental LNG spill should be evaluated, and a useful tool in LNG safety assessment is computational fluid dynamics (CFD) simulation. In this paper, the ADREA-HF code has been applied to simulate LNG dispersion in open-obstructed environment based on Falcon Series Experiments. During these experiments LNG was released and dispersed over water surface. The spill area is confined with a billboard upwind of the water pond. FA1 trial was chosen to be simulated, because its release and weather conditions (high total spill volume and release rate, low wind speed) allow the gravitational force to influence the cold, dense vapor cloud and can be considered as a benchmark for LNG dispersion in fenced area. The source was modeled with two different approaches: as vapor pool and as two phase jet and the predicted methane concentration at sensors' location was compared with the experimental one. It is verified that the source model affect to a great extent the LNG dispersion and the best case was the one modeling the source as two phase jet. However, the numerical results in the case of two phase jet source underestimate the methane concentration for most of the sensors. Finally, the paper discusses the effect of neglecting the ?9.3° experimental wind direction, which leads to the symmetry assumption with respect to wind and therefore less computational costs. It was found that this effect is small in case of a jet source but large in the case of a pool source.     

池火灾热辐射下的最小安全距离

防火间距是石油化工企业平面设计中的一个重要参数 ,笔者旨在从流体力学角度研究池火灾发生情况下邻罐之间最小安全距离 ,从而给防火间距的制定提供依据。辐射是储罐区池火灾的主要传热方式 ,作者对池火灾形状以及介质辐射吸收性质进行了适当的简化 ,用CFD软件Fluent对丙烷液化烃储罐池火灾热辐射进行了数值模拟。模拟结果表明对于锰钢材料、内径为 1 2 4 1 0mm液化烃压力储罐 ,稳态池火灾情况下 ,相邻两储罐之间的最小安全距离为 1 5m。     

Fuzzy logic approach to calculation of thermal hazard distances in process industries

In this paper, a general procedure to deal with uncertainties in each stage of consequence modeling is presented. In the first part of the procedure, the sources of uncertainty are identified and confirmed by sensitivity analysis for the source term, dispersion, physical effects and consequence analysis. While the second part comprises an application of the fuzzy logic system to each step of the consequence modeling. The proposed procedure is verified by the case study for a pool fire liquefied natural gas (LNG) on water. The results in terms of thermal radiation distances are compared with calculations obtained using the Monte Carlo method and with experimental data. The consequence model based on fuzzy logic approach provides less uncertain and more precise results in comparison to the deterministic consequence model.     

Estimation of safety distances in the vicinity of fuel gas pipelines

In this paper, safety distances around pipelines transmitting liquefied petroleum gas and pressurized natural gas are determined considering the possible outcomes of an accidental event associated with fuel gas release from pressurized transmission systems. Possible outcomes of an accidental fuel gas release were determined by performing the Event Tree Analysis approach. Safety distances were computed for two pipeline transmission systems of pressurized natural gas and liquefied petroleum gas existing in Greece using real data given by Greek Refineries and the Greek Public Gas Enterprise. The software packages chetah and breeze were used for thermochemical mixture properties estimation and quantitative consequence assessment, respectively. Safety distance determination was performed considering jet fire and gas dispersion to the lower flammable limit as the worst-case scenarios corresponding to immediate and delayed cloud ignition. The results showed that the jet fire scenario should be considered as the limiter for safety distances determination in the vicinity of natural and petroleum gas pipelines. Based on this conclusion, the obtained results were further treated to yield functional diagrams for prompt safety distance estimation. In addition, qualitative conclusions were made regarding the effect of atmospheric conditions on possible events. Thus, wind velocity was found to dominate during a jet fire event suppressing the thermal radiation effect, whereas gas dispersion was found to be affected mainly by solar radiation that favors the faster dissolution of fuel gas below the lower flammable limit.     

障碍物对天然气喷射火影响的数值模拟研究

为研究障碍物控制天然气喷射火对周围设施危害的有效性,基于流体力学基本原理与湍流模型,采用FDS模拟软件,分别研究高度为10 m的障碍物宽度和障碍物与泄漏孔间距对喷射火的影响。研究得出:障碍物对喷射火阻挡效果明显,减缓了火焰在速度方向的传播;障碍物越宽,控制火焰向前传播的效果越好,障碍物后方受火焰高温和热辐射危害越小,但随着宽度的增加,后方温度和热辐射下降率减小,障碍物宽3 m时,对火焰控制效果最好;随着障碍物与泄漏孔间距增加,障碍物后方热辐射先增加后减小,间距为5 m时,障碍物对火焰的控制效果最好,此时喷射火下游受保护的区域最宽。研究结果可为储气罐发生泄漏火灾事故处置及应急设施设计提供参考。     

液化天然气加注船安全定量风险分析

液化天然气（LNG）加注船是一种为LNG动力船提供燃料的新型船舶,国内目前尚处于起步阶段,缺乏相关安全标准和规范。采用国际定量风险评价（QRA）的通用理念,研究适用于我国LNG加注船的安全评价方法,提出具体实施步骤和依据准则,并以国内某LNG加注船作为实例分析说明。建立加注船LNG火灾事故树,确定相关火灾事故概率;研究适合加注船火灾事故后果的方形火焰模型,以及LNG火灾热辐射对人体伤害的计算方法;参考国际海事组织（IMO）的风险准则,确定LNG加注船个人风险和社会风险;最后与按NFPA-59A计算的防火间距作对比分析。通过计算,例中加注船的风险位于须采取相关安全措施的ALARP区域,风险控制区域半径20m。若按NFPA-59A要求计算防火间距,该加注船对外部须划定半径52m区域作为安全区域,且须将船身增长37m以满足内部防火要求,在实际工程中无法实现,相比较QRA方法更适合我国LNG加注船的安全评价工作。     

On the effectiveness of mitigation strategies for cryogenic applications

The need for sustainable energy sources, as well as the current energetic crisis involving the majority of markets, has promoted the use of cryogenic liquefaction for the transportation and storage of natural gas (i.e., LNG). To guarantee the development of a robust and safe infrastructure, a complete understanding of the main phenomena occurring at low temperatures is paramount. In this sense, the largest grey areas are the characterization of the combustion at low-initial temperature and the interactions between water and cryogenic liquid. For these reasons, this work presents an experimental campaign on the possible mitigation strategies for the mitigation of consequences related to the accidental release of LNG. Particular emphasis was posed on the direct and indirect effects of water on cryogenic pool fire. The former resulted in a significant increase in the dimensions of fire (∼+50%) and burning rate (∼300%) with respect to the case with no direct contact between water and LNG, whereas the latter generated an abrupt decrease in the measured temperatures (<100 °C). The use of an emergency flare to empty an LNG tank was tested, as well. The spatial distribution of temperature was monitored along with the time to guarantee the safe operability of this equipment in the case of LNG combustion. The explanations for the observed phenomena and trends were provided, allowing for the development of safe procedures for the emergency response related to cryogenic fuels.     

火灾事故后果评价方法在LNG储罐发生BLEVE爆炸上的应用

介绍了LNG储罐站的发展背景和现状；采用火灾事故后果分析方法建模，分析计算了LNG储罐站发生BLEVE爆炸所产生的火球直径、持续时间、提升高度、热辐射能量、冲击波破坏的范围、火灾爆炸事故对人及周围设施破坏的程度等；提出了在我国开展此类工程评估工作过程中的一些观点和设想。