白炭黑补强氟硅橡胶热空气老化机理研究

目的研究热空气老化过程中白炭黑补强氟硅橡胶的老化机理。方法开展不同加速老化温度点下白炭黑补强氟硅橡胶热空气老化试验,对老化过程中材料的力学性能进行研究,同时采用热重分析、衰减全反射红外光谱、交联密度分析以及固体核磁等技术,对200℃热空气老化过程中材料的微观结构变化进行分析。结果低温环境中白炭黑氟硅橡胶拉伸强度和扯断伸长率变化较小,高温环境中变化趋势增大,邵尔A硬度在整个老化过程中没有明显变化。结论白炭黑补强氟硅橡胶的老化机理主要是交联键的断裂和侧链三氟丙基的分解,同时还可能伴随有部分主链的破坏。     

FX-4和FX-17典型橡胶密封圈加速老化性能研究

目的 研究FX-4和FX-17典型橡胶密封圈的加速老化性能。方法 对初始压缩率为14%和20%的FX-4和FX-17这2种橡胶密封圈,进行5个温度点不同时长的加速老化试验,通过试验测定FX-4和FX-17橡胶密封圈的拉伸强度、扯断伸长率、硬度以及压缩永久变形等4个性能指标,并进行分析和比较。结果 硬度指标随老化温度以及老化时间的变化不明显。拉伸强度与扯断伸长率在200℃老化试验后,均出现明显的下降趋势,但在同一老化温度下老化10、70d后,拉伸强度与扯断伸长率未发生明显的变化。在较低的老化温度时,压缩永久变形率随老化温度以及老化时间的变化不明显;在150、200℃温度老化后,压缩永久变形率随着老化时间的增加而呈上升趋势。结论 FX-4与FX-17橡胶密封圈的压缩永久变形率在老化温度点较低时,受温度的影响不显著,在同一温度下随老化时间的增加呈上升趋势;在老化温度点较高时,压缩永久变形率随着老化时间的增加而呈上升趋势。     

润滑油中橡胶5880耐老化性能研究

为了掌握润滑油中橡胶5880制品耐受情况,并进行寿命评估.采用加速老化方法,针对压缩和自由放置两种状态,分别测试分析橡胶5880在润滑油和热空气中20％恒定压缩永久变形率、拉伸强度、拉断永久变形、拉断伸长率等基本性能随时间和温度的老化衰减规律.无论是热空气还是润滑油中,橡胶5880的拉伸强度和拉断永久变形指标对热老化不敏感,无法定量表征寿命和性能之间关系,而压缩永久变形率和拉断伸长率基本符合时温等效原理.总体上,润滑油中因为屏蔽氧气,橡胶5880性能衰减更慢.同时采用指数型性能-时间衰减规律和Arrhenius公式定量描述了橡胶5880性能-时间-温度之间的关系,推算润滑油中橡胶5880密封制品的寿命约为5 a,其他不受力制品的寿命将大于25 a.     

丁腈橡胶密封圈高温老化行为——自由状态和承压状态

目的研究丁腈橡胶密封圈自由状态和承压状态下的高温老化行为。方法以拉伸强度和拉断伸长率为参数,对各温度下的老化行为进行表征和分析。结果 70℃条件下机械应力大大加快了橡胶密封件拉伸强度的下降速率,以致试验64 d时拉伸强度甚至比110℃时还低,拉断伸长率的下降速率也明显加快了;90℃加速条件下机械应力对拉伸强度的下降有一定的促进作用,但对拉断伸长率的变化基本无影响;110℃加速条件下机械应力对拉伸强度和拉断伸长率均没有明显的影响。结论机械应力在较低温度下可以显著促进丁腈橡胶密封圈热氧老化,高温条件下促进作用不明显。     

星用热缩套管力学性能钴源辐照效应研究

目的研究星用热缩套管的力学性能(断裂伸长率和拉伸强度)在空间辐射环境中的退化情况。方法利用钴源放射的γ射线模拟地球轨道粒子辐照环境,通过表面形貌分析、辐解气体分析、X射线光电子能谱分析、红外光谱分析等多种手段分析热缩套管力学性能退化的原因。结果辐照后热缩套管颜色变深,力学参数出现严重退化现象。在最大辐照剂量下,材料断裂伸长率由414.3%下降为0.06%,拉伸强度由17.43 MPa下降为2.15 MPa,热缩套管原有力学性能几乎完全丧失。结论热缩套管主链出现断链现象,生成可挥发的CO2,CH4等气体,从而导致样品力学性能严重退化。     

高温高压高含CO2环境下两种氟橡胶密封可靠性评价

目的 研究两种氟橡胶O型圈在总压为25 MPa,CO2体积分数为5%,温度为120 ℃,液相介质Cl^?质量浓度为7000 mg/L的高温高压高含CO2工况下的密封可靠性。方法 通过高温高压釜模拟井下实际工况,采用自研橡胶O型圈密封装置实现试样的承压状态,以物理性能、腐蚀形貌和抗渗透性能为考察指标,对两种氟橡胶O型圈的耐蚀性能和密封性能进行测试评价。结果 氟硅橡胶O型圈在承压状态下腐蚀后,拉伸强度由18.1 MPa下降为13.4 MPa,拉断伸长率由172.8%下降为151.9%。AFLAS橡胶O型圈在承压状态下腐蚀后,拉伸强度由21 MPa下降为14.6 MPa,拉断伸长率由277%下降为212.3%,硬度从84HA下降为75.5HA,表面破损严重。两种橡胶O型圈抗渗透性能随压差增大、温度上升而减弱。结论 承压状态下,两种橡胶O型圈性能衰减程度低于自由状态,氟硅橡胶O型圈在承压状态下表现出更好的密封可靠性。     

T300/QY8911复合材料湿热行为的研究

目的为保证复合材料结构的完整性和使用安全,对树脂基复合材料的湿热行为、湿热环境下的宏观力学性能和物理行为进行研究。方法采用加速老化法,在高温下对T300/QY8911复合材料进行湿热老化行为的研究。借助动态力学热分析(DMTA)、力学性能测试研究湿热条件下的玻璃化转变温度和力学性能的变化规律。结果 T300/QY8911复合材料吸湿率的变化在湿热处理初期符合Fick第二定律,T300/QY8911复合材料的玻璃化转变温度均随着复合材料吸湿率的增加呈下降趋势,在饱和吸湿条件下tanδ峰对应的θg值具有较大的下降幅度,复合材料的拉伸强度和压缩强度均随着湿热处理时间的增加而出现下降,湿热处理条件对复合材料拉伸断裂宏观形貌的影响比较明显,而对复合材料压缩断裂宏观形貌的影响较小。结论 T300/QY8911复合材料在432 h到达饱和吸湿,饱和吸湿率为1.34%,水分子在复合材料中的扩散系数为7.38×10-5 mm2/s,吸湿速率为1.29×10-2 s-1,饱和吸湿条件下T300/QY8911复合材料的θg下降了59.2℃。T300/QY8911复合材料拉伸强度的下降幅度为16.2%,压缩强度的下降幅度为0.6%。     

聚甲醛耐候性研究

研究了自然老化和人工加速老化试验中聚甲醛力学性能的变化规律，考察了人工加速老化与自然老化试验的相关性。结果表明：光、热、水的综合作用是造成聚甲醛力学性能显著下降的主要原因；聚甲醛的断裂伸长率和缺口冲击强度对材料老化十分敏感，老化初期就显著下降；热老化无法模拟自然老化中聚甲醛力学性能变化规律，而试验中紫外灯光老化所采用的试验条件可模拟海拉尔、苍山等自然环境条件下聚甲醛力学性能变化规律，但对海南、广州等具有强日照、高温、高湿、多雨的自然环境模拟效果不好。     

PI纤维在空间带电粒子辐照下的力学性能损伤

目的研究聚酰亚胺(PI)纤维在电子辐照、质子辐照、应力耦合质子辐照条件下力学性能的损伤行为。方法采用中国科学院长春应用化学研究所自主合成并纺丝制备的聚酰亚胺纤维,在空间环境模拟设备辐照的条件下,研究空间带电粒子对聚酰亚胺纤维辐照后的力学损伤行为,并通过XQ-1型纤维强度仪对辐照前后的样品进行拉伸试验。结果在低能电子辐照条件下,聚酰亚胺纤维的拉伸强度、模量和断裂伸长率均有所降低,但变化不太显著;高能电子辐照会提高材料的模量;质子辐照后,材料的拉伸强度和断裂伸长率随着辐照注量的增加明显降低;单一施加5%的应变会使聚酰亚胺纤维的拉伸力学性能有一定量下降。与单一应变样品相比,应力耦合质子辐照样品的拉伸强度和断裂伸长率进一步下降,但是与单一质子辐照样品相比,应力耦合辐照样品的拉伸强度和断裂伸长率都更高。结论无论是在低能电子辐照条件下,还是在高能电子辐照条件下,电子辐照对聚酰亚胺纤维力学性能影响均较微弱,而质子辐照会较大程度地降低材料的力学性能,增加应力耦合效应之后,质子辐照对材料的力学性能影响减弱。     

系留气球囊体材料快速老化试验研究

目的估算某系留气球在某地区的使用寿命。方法分析环境因素对系留气球的影响,确定采用太阳辐射快速老化的方法对囊体材料开展老化试验研究,时间为3000 h。采用等时间间隔法对试验件进行测试,间隔时间为375 h,测试9次,每组试验件为5件,试验数据采用5个试验件的平均值。对老化前后囊体材料的表面状况、拉伸强度、拉伸强度变化率及断裂伸长率进行分析。结果试验之后,囊体材料表面发黄,有粉末状的颗粒,拉伸强度为395.2N/cm,下降了56.01%,断裂伸长率在3.9%～7.7%间波动变化。将实验室老化辐射量等同于室外紫外辐射量,根据室外紫外辐射量约占室外自然老化太阳辐射总量8%及某地区全年太阳辐射总量,估算囊体材料的实验室老化相当于室外自然老化的年限,结合囊体材料设计限制条件,评估出了系留气球的使用寿命。结论通过太阳辐射快速老化的方法对囊体材料开展老化试验研究,可估算出某系留气球在某地区的使用寿命。     

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

EDTA-enhanced phytoremediation of lead contaminated soil by Bidens maximowicziana

Phytoremediation is a potential cleanup technology for the removal of heavy metals from contaminated soils.Bidens maximowicziana is a new Pb hyperaccumulator,which not only has remarkable tolerance to Pb but also extraordinary accumulation capacity for Pb.The maximum Pb concentration was 1509.3 mg/kg in roots and 2164.7 mg/kg in overground tissues.The Pb distribution order in the B. maximowicziana was:leaf>stem>root.The effect of amendments on phytoremediation was also studied.The mobility of soil Pb and the Pb concentrations in plants were both increased by EDTA application.Compared with CK(control check),EDTA application promoted translocation of Pb to overground parts of the plant.The Pb concentrations in overground parts of plants was increased from 24.23-680.56 mg/kg to 29.07-1905.57 mg/kg.This research demonstrated that B.maximowicziana appeared to be suitable for phytoremediation of Pb contaminated soil,especially,combination with EDTA.     

Distribution and ecological effect of mercury in Laogang landfill, Shanghai, China

Laogang landfill near Shanghai is the largest landfill in China, and receives about 10000 t of daily garbage per day, Samples of topsoil and plants were analyzed to evaluate mercury pollution from the landfill. For topsoil samples, there were significant correlations among total mercury （HgT）, combinative mercury （Hgc） and gaseous mercury （HgG）, and content of total organic carbon （TOC）, but, no significantly relationship was found between Hg content and filling time. Hg content changes in vertical profiles with time showed that the average Hgv of profiles 1992, 1996, and 2000 was similar, but their average HgG was quite different. HgT was significantly correlated with Hgc in profile 1992 and 2000, and Hgv was significantly correlated with Hg6 in profile 1996. HgG/Hgv ratio in profile samples decreased in the order of （HgG,/HgT）1992〉（HgG/HgT）1996〉〉（HgG/HgT）2000. A simple outline of Hg release in landfill could be drawn： with increasing of filling time, degradation undergoes different biodegradation, accordingly, gaseous mercury goes through small, more, and small proportion to total mercury. Distribution of Hg in plants was inhomogeneous, following the order of leaf〉root〉stem. The highest value of leaf may be associated with higher atmospheric Hg from landfill. Ligneous plants （e.g. Phyllostachys glanca, Prunus salicina and Ligustrum lucidum） are capable of enriching more Hg than herbaceous plants.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Enzymatic oxidation of aqueous pentachlorophenol

The influence of the nonionic surfactant Tween 80 on pentachlorophenol （PCP） oxidation catalyzed by horseradish peroxidase was studied. The surfactant was tested at concentrations below and above its critical micelle concentration （CMC）. Enhancement of PCP removal was observed at sub-CMCs. The presence of Tween 80 in the reaction mixture reduced enzyme inactivation which occurred through a combination of free radical attack and sorption by precipitated products. A simple first-order model was able to simulate time profiles for enzyme inactivation in the presence or absence of Tween 80. At supra-CMCs, the surfactant caused noticeable reductions in PCP removal, presumably through micelle partitioning of PCP which precluded the hydrophobic PCP molecule from interacting with the enzyme.     

Decomposition of alachlor by ozonation and its mechanism

Decomposition and corresponding mechanism of alachlor, an endocrine disruptor in water by ozonation were investigated. Results showed that alachlor could not be completely mineralized by ozone alone. Many intermediates and final products were formed during the process, including aromatic compounds, aliphatic carboxylic acids, and inorganic ions. In evoluting these products, some of them with weak polarity were qualitatively identified by GC-MS. The information of inorganic ions suggested that the dechlorination was the first and the fastest step in the ozonation of alachlor.     

基于综合水质标识指数和对应分析法的校园河道水质评价

以三峡大学的校园河道求索溪为研究对象,利用综合水质标识指数法确定求索溪水质类别,分析其水质时空变化规律,并利用对应分析法得出求索溪中不同监测点的主要污染因子.研究结果表明:求索溪整体的综合水质标识指数为7.423,整体水质为劣V类(地表水环境质量标准GB 3838-2002)且黑臭.从时间变化来看,求索溪4月份的水质最差,5月份次之,4、5月份所有监测点的水质都劣于V类且黑臭;8月份水质最好,水质为Ⅳ类;从空间分布来看,8个监测点综合水质标识指数均超过6.0,水质为劣V类,其中6号监测点的水质相对最好,监测点3号的水质相对最差;对应分析法得出求索溪的整体水体污染程度受总氮因子的影响最大,其次为总磷.该研究拟为求索溪及类似校园河道的水环境治理研究提供基础依据和参考.     

Potential of plant polyphenol oxidases in the decolorization and removal of textile and non-textile dyes

In this study an effort has been made to use plant polyphenol oxidases; potato （Solanum tuberosum） and brinjal （Solanum melongena）, for the treatment of various important dyes used in textile and other industries. The ammonium sulphate fractionated enzyme preparations were used to treat a number of dyes under various experimental conditions. Majority of the treated dyes were maximally decolorized at pH 3.0. Some of the dyes were quickly decolorized whereas others were marginally decolorized. The initial first hour was sufficient for the maximum decolorization of dyes. The rate of decolorization was quite slow on long treatment of dyes. Enhancement in the dye decolorization was noticed on increasing the concentration of enzymes. The complex mixtures of dyes were treated with both preparations of polyphenol oxidases in the buffers of varying pH values. Potato polyphenol oxidase was significantly more effective in decolorizing the dyes to higher extent as compared to the enzyme obtained from brinjal polyphenol oxidase. Decolorization of dyes and their mixtures, followed by the formation of an insoluble precipitate, which could be easily removed simply by centrifugation.     

Effects of chitosan on growth of an aquatic plant (Hydrilla verticillata) in polluted waters with different chemical oxygen demands

Effects of chitosan on a submersed plant, Hydrilla verticillata, were investigated. Results indicated that H. venicillata could prevent ultrastructure phytotoxicities and oxidativereaction from polluted water with high chemical oxygen demand (COD). Superoxide dismutase (SOD) activity and malondialdehyde (MDA) contents in H. verticillata treated with 0.1% chitosan in wastewater increased with high COD (980 mg/L) and decreased with low COD (63 mg/L), respectively. Ultrastructural analysis showed that the stroma and grana of chloroplast basically remained normal. However, plant cells from the control experiment (untreated with chitosan) were vacuolated and the cell interval increased. The relict of protoplast moved to the center, with cells tending to disjoint. Our findings indicate that wastewater with high COD concentration can cause a substantial damage to submersed plant, nevertheless, chitosan probably could alleviate the membrane lipid peroxidization and ultrastructure phytotoxicities, and protect plant cells from stress of high COD concentration polluted water.     

Removal of heavy metals from sewage sludge by low costing chemical method and recycling in agriculture

ＲｅｍｏｖａｌｏｆｈｅａｖｙｍｅｔａｌｓｆｒｏｍｓｅｗａｇｅｓｌｕｄｇｅｂｙｌｏｗｃｏｓｔｉｎｇｃｈｅｍｉｃａｌｍｅｔｈｏｄａｎｄｒｅｃｙｃｌｉｎｇｉｎａｇｒｉｃｕｌｔｕｒｅＷｕＱｉｔａｎｇ，ＮｙｉｒａｎｄｅｇｅＰａｓｃａｓｉｅ，ＭｏＣｅｈｕｉＦ...