液体发动机涡轮泵端面密封贮存变形研究

为研究长期贮存下涡轮泵端面密封变形对液体火箭发动机安全使用的影响,对端面密封在长期贮存条件下的变形情况和失效机理进行了研究,给出了长期贮存的端面密封静环组件最大变形量,对端面密封泄漏率进行了理论计算.为开展地面漏气和漏液试验设计,加工了模拟变形静环组件,通过试验建立了静环组件变形与漏气和漏液关系数学模型.研究表明长期贮存条件下涡轮泵端面密封变形导致的介质泄漏会给发动机安全使用造成隐患,研究结果将为长期贮存条件下的液体火箭发动机安全使用提供重要参考.     

新型膜-生物反应器中膜丝长度对临界通量的影响

为了优化膜-生物反应器中的膜组件长度,考察了4组不同长度膜组件(膜丝长度为0.2、0.4、0.6、0.7m)在不同曝气量下的临界通量区.试验结果发现,曝气强度相同时,膜丝长度为0.4m膜组件的临界通量区高于膜丝长度为0.2m、0.6m和0.7m的膜组件,说明膜丝长度存在最优值;膜组件中膜丝长度相同时,曝气强度越大临界通量区越高.膜丝(膜组件)长度对临界通量产生影响主要体现在2方面:一是膜丝长度的变化会改变膜丝上局部通量的非均匀分布状况;二是曝气气泡对不同长度膜丝的冲刷作用不同.应用局部通量分布方程模拟了清洁膜丝上局部通量的分布状况;结果表明,膜丝长度越长,沿膜丝长度方向的局部通量分布越不均匀,则膜组件的临界通量越小.从曝气气泡对膜丝的冲刷作用看,相同曝气量下膜组件(即膜丝)长度越长,形成的气泡越大,在大气泡的作用下膜丝更易于摇摆和震动以达到减轻膜表面污染物沉积的效果,即可能达到的临界通量越大.因此,对于减轻膜污染而言,即得到最高的临界通量区,膜丝(膜组件)长度存在最优值.     

微泄漏静密封的研制和应用

针对目前国内外密封安全环保问题的严峻性,综合国内外调研情况,研制微泄漏法兰密封组件技术,采用恒应力先进理念设计和材料处理技术,进一步提升微泄漏密封的长期密封可靠性和微泄漏密封性能,结合现场应用和资质认证,通过微泄漏密封技术的应用,提高石化装置的本质安全水平。     

F108氟橡胶湿热老化影响双因素方差分析

目的研究湿热因素对F108氟橡胶老化的影响。方法采用χ2检验的方法,对氟橡胶圆柱形试样的初始高度进行假设检验,推断F108氟橡胶材料压缩永久变形服从正态分布。采用方差分析的方法,结合湿热老化试验数据,对F108氟橡胶湿热老化不同时间的压缩永久变形进行湿热双因素方差分析。结果在开始阶段(即老化1 d后),温度和湿度的F值分别为77.25和9.34,均大于Fα(α=0.05),温湿度交互作用的F值为14.19,大于Fα。在试验中期和后期(即老化6、12、16 d),温度对应的F值急剧增加,分别达到365.38、458.03和354.13,湿度对应的F值也分别增至31.69、34.03和31.02,均远大于Fα。结论老化初期,温度、湿度及温湿度交互作用对F108氟橡胶性能的影响均为显著,显著程度由大到小为温度>温湿度交互作用>湿度。随着老化时间的增加,温度和湿度的影响有不同程度的增强,温度的作用占主导地位,温湿度交互作用由显著变为不显著。     

T型槽密封结构的有限元分析及试验验证

目的通过有限元分析,实现T型密封结构的优化设计。方法利用ABAQUS建立液压系统用T型槽密封结构的二维轴对称模型,分析计算密封结构中过渡圆角、槽宽、倾斜角度等对密封圈应力分布、接触应力的影响,通过设计密封圈老化寿命试验,验证分析结论。结果随着过渡圆角(R0.5～R2)的增大、倾斜角度(10°～3°)的减小,密封圈的局部应力最大值和接触应力均减小。随着槽宽(10～18mm)的增加,密封圈的局部应力最大值逐渐增加,接触应力逐渐减小。分析用密封结构的接触应力均大于密封介质压力0.7 MPa。最终通过试验证实了分析用密封结构均满足密封性能,且不合理的设计会降低密封圈寿命。结论在密封介质压力较小的情况下,建议选用较大的过渡圆角(推荐值为R2),较小的倾斜角度(推荐值为5°～6°)及槽宽(推荐值为密封圈截面直径的1.2～1.5倍)。     

直流电晕自由基簇射治理甲苯的试验研究

利用直流电晕自由基簇射对甲苯有机废气进行试验,分别考察了有机污染物浓度、温度、电压、湿度和停留趑时间等不同因素对去除率的影响.试验结果表明,降低气体温度和一定的湿度能够提高脱除效率,电压增高可以提高脱除效率,停留时间长使得脱除效率升高,但能量效率降低.有机物的浓度增大,会使得脱除效率降低,但同时能提高能量的利用效率.本实验的目的旨在为降解烟气中的多环芳烃(二噁英等)打下基础.     

影响机械密封寿命的外部因素分析

在对离心泵中各种形式的机械密封更换、维修、保养的基础上,通过对机械密封的理论分析,提出了机械密封的使用寿命不仅与机械密封自身相关性能有关,并且还会与其它零部件以及密封辅助系统等提供的条件有关,所以说分析机械密封故障原因及对填料密封进行机械密封改造时,应将机械密封的外部条件放到一个重要的位置上。     

臭氧-CNT膜改性联用工艺阈通量及膜污染分析

采用碳纳米管(carbon nanotube,CNT)对聚偏氟乙烯(polyvinylidene fluoride,PVDF)中空纤维超滤膜进行改性,结合臭氧预氧化技术,考察了臭氧-CNT膜改性联用工艺的阈通量及膜表面污染情况.结果表明,原膜阈通量为45 L·(m~2·h)~(-1),联用工艺下阈通量为81 L·(m~2·h)~(-1),联用工艺相对原膜阈通量提高了约80%;且联用工艺的污染速率最低,约为0. 001 37k Pa·min-1·L-1·m~2·h.相同臭氧投量与CNT负载量下,对比联用工艺阈通量与临界通量运行情况,得出阈通量下运行过水量高于临界通量运行,表明阈通量下运行能够缓解膜污染,延长膜组件的运行时间.膜污染碳平衡实验结果表明,采用CNT对膜改性后,膜组件的纳污能力与可恢复性得到明显提高,臭氧氧化能够进一步提高CNT改性膜组件的可恢复性,大幅提高其过水性能和使用时间.     

密封包装容器微环境温湿度模型的建立与仿真

目的建立温湿度模型和仿真软件,对贮存环境下一段时间内包装容器微环境温湿度进行预计,为提前预测容器内产品的性能变化情况提供技术支撑。方法分析微环境温湿度与密封包装材料、环境的关系,建立温湿度模型,用有限元方法进行仿真,并用实测数据对仿真模型进行对比和验证。结果与试验实测结果相比较,温度仿真结果的最大相对误差不超过8%,湿度仿真结果的最大相对误差不超过11%。结论微环境温湿度仿真软件能对贮存时间较长、不同规格的包装容器微环境温湿度进行准确预计,具有良好的应用前景。     

滨岸带水华堆积与消散特征及其营养盐效应

为了解滨岸带植被、地形等地貌要素对蓝藻水华堆积及消散过程的影响,在太湖滨岸带设置不同形式的围格和植被实验区,通过逐日监测水体叶绿素a（Chl-a）的消长过程及同步营养盐变化,研究夏季蓝藻水华在湖泊滨岸带堆积与消散特征和营养盐效应.结果表明,滨岸带的地形地貌及植被状况对蓝藻水华的堆积程度及消散过程影响较大,软围隔营造的滨岸带静水环境,以及不同植被所形成的不同滞水区,显著加剧了蓝藻水华的局部堆积,从岸边挺水和浮叶植被区到开敞水域对照区,蓝藻水华的堆积程度依次递减;近岸挺水和浮叶植被区蓝藻水华堆积最严重,堆积时间最早,持续时间长;蓝藻水华堆积对营养盐等水质指标影响极大,堆积严重时该区域Chl-a含量达到了457.42μg/L,总氮（TN）达到11.04mg/L,总磷（TP）达到1.32mg/L;橡胶围格内浮叶植物区藻类堆积程度与近岸区类似,而浮叶植物与沉水植物混合区藻类堆积程度低于单一浮叶植物区;水体围隔能够加剧蓝藻水华的堆积,没有围隔的浮叶植物区藻类堆积程度最低.在蓝藻水华堆积过程中,蓝藻细胞仍在继续增殖,水体Chl-a仍会明显增加,而同期的水体营养盐的增幅小于Chl-a,甚至随着藻类生长消耗及生态系统的脱氮效应,溶解态氮磷下降明显.蓝藻水华消散过程中,TN、TP与Chl-a同步下降,但藻体中的氮磷释放到水中,导致堆积区的溶解态氮、磷有所增加,显示出明显的营养盐效应.本研究定量刻画了蓝藻水华局部堆积并快速致灾的地形地貌要素特点,揭示了蓝藻水华的水质与生态效应,为科学评估富营养化水体蓝藻水华的生态灾害风险提供科学依据.     

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

EDTA-enhanced phytoremediation of lead contaminated soil by Bidens maximowicziana

Phytoremediation is a potential cleanup technology for the removal of heavy metals from contaminated soils.Bidens maximowicziana is a new Pb hyperaccumulator,which not only has remarkable tolerance to Pb but also extraordinary accumulation capacity for Pb.The maximum Pb concentration was 1509.3 mg/kg in roots and 2164.7 mg/kg in overground tissues.The Pb distribution order in the B. maximowicziana was:leaf>stem>root.The effect of amendments on phytoremediation was also studied.The mobility of soil Pb and the Pb concentrations in plants were both increased by EDTA application.Compared with CK(control check),EDTA application promoted translocation of Pb to overground parts of the plant.The Pb concentrations in overground parts of plants was increased from 24.23-680.56 mg/kg to 29.07-1905.57 mg/kg.This research demonstrated that B.maximowicziana appeared to be suitable for phytoremediation of Pb contaminated soil,especially,combination with EDTA.     

Distribution and ecological effect of mercury in Laogang landfill, Shanghai, China

Laogang landfill near Shanghai is the largest landfill in China, and receives about 10000 t of daily garbage per day, Samples of topsoil and plants were analyzed to evaluate mercury pollution from the landfill. For topsoil samples, there were significant correlations among total mercury （HgT）, combinative mercury （Hgc） and gaseous mercury （HgG）, and content of total organic carbon （TOC）, but, no significantly relationship was found between Hg content and filling time. Hg content changes in vertical profiles with time showed that the average Hgv of profiles 1992, 1996, and 2000 was similar, but their average HgG was quite different. HgT was significantly correlated with Hgc in profile 1992 and 2000, and Hgv was significantly correlated with Hg6 in profile 1996. HgG/Hgv ratio in profile samples decreased in the order of （HgG,/HgT）1992〉（HgG/HgT）1996〉〉（HgG/HgT）2000. A simple outline of Hg release in landfill could be drawn： with increasing of filling time, degradation undergoes different biodegradation, accordingly, gaseous mercury goes through small, more, and small proportion to total mercury. Distribution of Hg in plants was inhomogeneous, following the order of leaf〉root〉stem. The highest value of leaf may be associated with higher atmospheric Hg from landfill. Ligneous plants （e.g. Phyllostachys glanca, Prunus salicina and Ligustrum lucidum） are capable of enriching more Hg than herbaceous plants.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Enzymatic oxidation of aqueous pentachlorophenol

The influence of the nonionic surfactant Tween 80 on pentachlorophenol （PCP） oxidation catalyzed by horseradish peroxidase was studied. The surfactant was tested at concentrations below and above its critical micelle concentration （CMC）. Enhancement of PCP removal was observed at sub-CMCs. The presence of Tween 80 in the reaction mixture reduced enzyme inactivation which occurred through a combination of free radical attack and sorption by precipitated products. A simple first-order model was able to simulate time profiles for enzyme inactivation in the presence or absence of Tween 80. At supra-CMCs, the surfactant caused noticeable reductions in PCP removal, presumably through micelle partitioning of PCP which precluded the hydrophobic PCP molecule from interacting with the enzyme.     

Decomposition of alachlor by ozonation and its mechanism

Decomposition and corresponding mechanism of alachlor, an endocrine disruptor in water by ozonation were investigated. Results showed that alachlor could not be completely mineralized by ozone alone. Many intermediates and final products were formed during the process, including aromatic compounds, aliphatic carboxylic acids, and inorganic ions. In evoluting these products, some of them with weak polarity were qualitatively identified by GC-MS. The information of inorganic ions suggested that the dechlorination was the first and the fastest step in the ozonation of alachlor.     

基于综合水质标识指数和对应分析法的校园河道水质评价

以三峡大学的校园河道求索溪为研究对象,利用综合水质标识指数法确定求索溪水质类别,分析其水质时空变化规律,并利用对应分析法得出求索溪中不同监测点的主要污染因子.研究结果表明:求索溪整体的综合水质标识指数为7.423,整体水质为劣V类(地表水环境质量标准GB 3838-2002)且黑臭.从时间变化来看,求索溪4月份的水质最差,5月份次之,4、5月份所有监测点的水质都劣于V类且黑臭;8月份水质最好,水质为Ⅳ类;从空间分布来看,8个监测点综合水质标识指数均超过6.0,水质为劣V类,其中6号监测点的水质相对最好,监测点3号的水质相对最差;对应分析法得出求索溪的整体水体污染程度受总氮因子的影响最大,其次为总磷.该研究拟为求索溪及类似校园河道的水环境治理研究提供基础依据和参考.     

Potential of plant polyphenol oxidases in the decolorization and removal of textile and non-textile dyes

In this study an effort has been made to use plant polyphenol oxidases; potato （Solanum tuberosum） and brinjal （Solanum melongena）, for the treatment of various important dyes used in textile and other industries. The ammonium sulphate fractionated enzyme preparations were used to treat a number of dyes under various experimental conditions. Majority of the treated dyes were maximally decolorized at pH 3.0. Some of the dyes were quickly decolorized whereas others were marginally decolorized. The initial first hour was sufficient for the maximum decolorization of dyes. The rate of decolorization was quite slow on long treatment of dyes. Enhancement in the dye decolorization was noticed on increasing the concentration of enzymes. The complex mixtures of dyes were treated with both preparations of polyphenol oxidases in the buffers of varying pH values. Potato polyphenol oxidase was significantly more effective in decolorizing the dyes to higher extent as compared to the enzyme obtained from brinjal polyphenol oxidase. Decolorization of dyes and their mixtures, followed by the formation of an insoluble precipitate, which could be easily removed simply by centrifugation.     

Effects of chitosan on growth of an aquatic plant (Hydrilla verticillata) in polluted waters with different chemical oxygen demands

Effects of chitosan on a submersed plant, Hydrilla verticillata, were investigated. Results indicated that H. venicillata could prevent ultrastructure phytotoxicities and oxidativereaction from polluted water with high chemical oxygen demand (COD). Superoxide dismutase (SOD) activity and malondialdehyde (MDA) contents in H. verticillata treated with 0.1% chitosan in wastewater increased with high COD (980 mg/L) and decreased with low COD (63 mg/L), respectively. Ultrastructural analysis showed that the stroma and grana of chloroplast basically remained normal. However, plant cells from the control experiment (untreated with chitosan) were vacuolated and the cell interval increased. The relict of protoplast moved to the center, with cells tending to disjoint. Our findings indicate that wastewater with high COD concentration can cause a substantial damage to submersed plant, nevertheless, chitosan probably could alleviate the membrane lipid peroxidization and ultrastructure phytotoxicities, and protect plant cells from stress of high COD concentration polluted water.     

Removal of heavy metals from sewage sludge by low costing chemical method and recycling in agriculture

ＲｅｍｏｖａｌｏｆｈｅａｖｙｍｅｔａｌｓｆｒｏｍｓｅｗａｇｅｓｌｕｄｇｅｂｙｌｏｗｃｏｓｔｉｎｇｃｈｅｍｉｃａｌｍｅｔｈｏｄａｎｄｒｅｃｙｃｌｉｎｇｉｎａｇｒｉｃｕｌｔｕｒｅＷｕＱｉｔａｎｇ，ＮｙｉｒａｎｄｅｇｅＰａｓｃａｓｉｅ，ＭｏＣｅｈｕｉＦ...