浅谈预焙阳极生产过程中的废气污染及防治措施

介绍了预焙阳极生产过程中废气产生的主要工段——原料破碎、石油焦煅烧、煅后料冷却、配料、混捏成型、阳极焙烧，主要废气污染物为粉尘、煅烧废气、沥青烟气。结合国内外现有的烟气治理措施，详细评述了现有的废气的治理技术及存在的问题。同时，针对沥青烟气产生的不同工段，提出采用不同净化处理措施。     

改性硅酸盐矿物吸附剂在污水处理中的应用

国内外许多学者对硅酸盐吸附剂进行了改性研究,通过增大吸附剂的比表面积、改变表面化学性质、增强离子交换能力以及扩大层间间距等来提高吸附剂对污染物的吸附量.研究发现改性硅酸盐吸附剂在染料脱色、去除重金属离子、有机毒物以及氮磷等方面有很好的效果.     

粉煤灰改性吸附材料处理沥青烟气

分析了粉煤灰改性后的物质基础 ,采用吸附法 ,利用改性粉煤灰作为吸附剂对沥青烟气进行处理 ,通过实验研究得到一定的运行参数 ,为沥青烟气的处理提供了理论依据     

铜基改性非碳基吸附剂汞脱除性能研究

对以CuCl2及CuBr2为活性物质,6种大比表面积非碳基载体制成的吸附剂在不同烟气条件下的汞吸附性能及价态分布进行了研究.在纯N2条件下以氧化铝、沸石、皂土为载体的吸附剂具有很高的汞脱除率.水蒸气会降低吸附剂的汞脱除率,SO2对非碳基吸附剂有抑制作用,对CuBr2改性吸附剂及以皂土为载体的吸附剂的影响尤为突出.NO的影响更多地取决于吸附剂载体的性质.HCl的加入对CuCl2改性吸附剂及以皂土为载体的吸附剂的汞脱除率有抑制效果.模拟真实烟气的作用是几种酸性气体的叠加.其中CuCl2改性氧化铝在所有烟气条件下均表现出较好的汞吸附性能及很高的汞氧化率.     

碳基吸附剂原位吸附底泥重金属离子研究进展

本文综述了碳基吸附剂去除湖泊底泥中重金属离子的研究进展,具体介绍了生物炭基吸附剂、碳纳米管基吸附剂以及氧化石墨烯基吸附剂在修复湖泊重金属污染底泥中的应用,分析了影响重金属污染底泥修复的影响因素.结果表明,生物炭基吸附剂,碳纳米管基吸附剂,氧化石墨烯基吸附剂以及改性碳基吸附剂均能够有效修复底泥重金属,抑制重金属的生物有效性,同时上覆水pH值、氧化还原电位、有机质和水体扰动会影响重金属修复效果.最后针对碳基吸附剂在修复底泥重金属方面的局限性,展望了未来碳基吸附剂修复湖泊重金属污染底泥的发展方向.     

重金属吸附剂

为了除去工厂废水中的有毒金属和低浓度放射废水中的放射物质等,可以使用吸附剂吸附处理的方法。与有机物的吸附一样,也可使用活性炭处理。对于金属来说,可使用沸石、蛭石、螯合型树脂、磺化媒、硝基腐殖酸等来处理。使用这种重金属吸附剂处理的优点是:装置简单,处理所需时间少,装置小型化。但是,它的吸着容量大,必须使用完全;吸附剂若价贵则实用性差。该吸附剂的废弃物处理时必须十分注意。对于这种吸附剂来说,金属离子有离子结合和螯合结合两种。最近,在工业技术研究院的化学技术研究所,利用硝酸氧化、亚硫酸还原工艺从石油精制残渣的沥青中制造螯合物质,已成功地制得了廉价的吸附剂。用重金属     

新型污泥基吸附材料制备及其氨氮去除性能评价

采用高温焙烧法制备了一种以给水厂终端铝盐混凝污泥为原料的新型吸附剂.通过静态吸附实验探讨其对氨氮的吸附性能,实验中主要考察了不同初始p H、接触时间和温度等因素对氨氮吸附效果的影响,同时分析了吸附剂对氨氮的吸附等温线,动力学和热力学特性.结果表明,在中性条件下吸附剂对氨氮有较好的去除效果;吸附过程在6 h基本达到平衡,吸附过程符合准二级动力学模型,Langmuir吸附模型可较好地拟合吸附剂对氨氮的吸附;热力学参数表明陶粒吸附剂对NH_4~+-N的吸附过程是自发的、吸热反应(ΔG~θ0、ΔH~θ0),且由平均吸附能得到该吸附属于物理吸附.因此,混凝污泥处理氨氮废水具有良好的应用前景.     

流化吸附法净化处理沥青烟气的研究

以炉灰渣为吸附剂，在流化状态下吸附净化沥青烟气的实验室小试表明，炉灰渣的吸附容量高达１８５ｍｇ／ｇ，一次性净化效率为９９％。该工艺具有运转成本低．操作简单和以废治废的特点，为治理沥青烟气污染提供一条新途径。     

沥青固化城市生活垃圾焚烧飞灰的实验研究

对利用沥青固化城市生活垃圾焚烧飞灰的处理效果进行了实验研究.探讨了沥青与飞灰以不同比例混合对飞灰重金属Pb,Cr,Cd,Ni,Cu,Zn固化效果的影响.并对沥青与飞灰的质量比(mAS mFA,其中AS代表沥青,FA代表飞灰)为0 2时作了进一步的研究,在此基础上加入不同比例的添加剂S和NaOH.结果表明,在沥青与飞灰的混合物中再加适当比例的添加剂,对飞灰的固化效果大大提高.     

吸附剂用量对二级出水中氨氮去除效果的研究

以二级出水中氨氮的吸附处理为研究对象,对活性炭吸附法和沸石吸附法去除二级出水中氨氮进行试验研究。在一定范围内,吸附剂用量对氨氮的去除效果有较大的影响,相同条件下,吸附剂投加量越大,氨氮去除率越高,但增加到一定程度后,对氨氮的吸附作用减弱,在实际应用中控制吸附剂的投加量是必要的。当吸附剂用量为15 mg时,活性炭吸附效果要明显高于沸石的;当吸附剂用量大于30 mg时,沸石的吸附效果要远远好于活性炭的。     

Distribution and ecological effect of mercury in Laogang landfill, Shanghai, China

Laogang landfill near Shanghai is the largest landfill in China, and receives about 10000 t of daily garbage per day, Samples of topsoil and plants were analyzed to evaluate mercury pollution from the landfill. For topsoil samples, there were significant correlations among total mercury （HgT）, combinative mercury （Hgc） and gaseous mercury （HgG）, and content of total organic carbon （TOC）, but, no significantly relationship was found between Hg content and filling time. Hg content changes in vertical profiles with time showed that the average Hgv of profiles 1992, 1996, and 2000 was similar, but their average HgG was quite different. HgT was significantly correlated with Hgc in profile 1992 and 2000, and Hgv was significantly correlated with Hg6 in profile 1996. HgG/Hgv ratio in profile samples decreased in the order of （HgG,/HgT）1992〉（HgG/HgT）1996〉〉（HgG/HgT）2000. A simple outline of Hg release in landfill could be drawn： with increasing of filling time, degradation undergoes different biodegradation, accordingly, gaseous mercury goes through small, more, and small proportion to total mercury. Distribution of Hg in plants was inhomogeneous, following the order of leaf〉root〉stem. The highest value of leaf may be associated with higher atmospheric Hg from landfill. Ligneous plants （e.g. Phyllostachys glanca, Prunus salicina and Ligustrum lucidum） are capable of enriching more Hg than herbaceous plants.     

EDTA-enhanced phytoremediation of lead contaminated soil by Bidens maximowicziana

Phytoremediation is a potential cleanup technology for the removal of heavy metals from contaminated soils.Bidens maximowicziana is a new Pb hyperaccumulator,which not only has remarkable tolerance to Pb but also extraordinary accumulation capacity for Pb.The maximum Pb concentration was 1509.3 mg/kg in roots and 2164.7 mg/kg in overground tissues.The Pb distribution order in the B. maximowicziana was:leaf>stem>root.The effect of amendments on phytoremediation was also studied.The mobility of soil Pb and the Pb concentrations in plants were both increased by EDTA application.Compared with CK(control check),EDTA application promoted translocation of Pb to overground parts of the plant.The Pb concentrations in overground parts of plants was increased from 24.23-680.56 mg/kg to 29.07-1905.57 mg/kg.This research demonstrated that B.maximowicziana appeared to be suitable for phytoremediation of Pb contaminated soil,especially,combination with EDTA.     

Decomposition of alachlor by ozonation and its mechanism

Decomposition and corresponding mechanism of alachlor, an endocrine disruptor in water by ozonation were investigated. Results showed that alachlor could not be completely mineralized by ozone alone. Many intermediates and final products were formed during the process, including aromatic compounds, aliphatic carboxylic acids, and inorganic ions. In evoluting these products, some of them with weak polarity were qualitatively identified by GC-MS. The information of inorganic ions suggested that the dechlorination was the first and the fastest step in the ozonation of alachlor.     

Enzymatic oxidation of aqueous pentachlorophenol

The influence of the nonionic surfactant Tween 80 on pentachlorophenol （PCP） oxidation catalyzed by horseradish peroxidase was studied. The surfactant was tested at concentrations below and above its critical micelle concentration （CMC）. Enhancement of PCP removal was observed at sub-CMCs. The presence of Tween 80 in the reaction mixture reduced enzyme inactivation which occurred through a combination of free radical attack and sorption by precipitated products. A simple first-order model was able to simulate time profiles for enzyme inactivation in the presence or absence of Tween 80. At supra-CMCs, the surfactant caused noticeable reductions in PCP removal, presumably through micelle partitioning of PCP which precluded the hydrophobic PCP molecule from interacting with the enzyme.     

基于综合水质标识指数和对应分析法的校园河道水质评价

以三峡大学的校园河道求索溪为研究对象,利用综合水质标识指数法确定求索溪水质类别,分析其水质时空变化规律,并利用对应分析法得出求索溪中不同监测点的主要污染因子.研究结果表明:求索溪整体的综合水质标识指数为7.423,整体水质为劣V类(地表水环境质量标准GB 3838-2002)且黑臭.从时间变化来看,求索溪4月份的水质最差,5月份次之,4、5月份所有监测点的水质都劣于V类且黑臭;8月份水质最好,水质为Ⅳ类;从空间分布来看,8个监测点综合水质标识指数均超过6.0,水质为劣V类,其中6号监测点的水质相对最好,监测点3号的水质相对最差;对应分析法得出求索溪的整体水体污染程度受总氮因子的影响最大,其次为总磷.该研究拟为求索溪及类似校园河道的水环境治理研究提供基础依据和参考.     

Effects of chitosan on growth of an aquatic plant (Hydrilla verticillata) in polluted waters with different chemical oxygen demands

Effects of chitosan on a submersed plant, Hydrilla verticillata, were investigated. Results indicated that H. venicillata could prevent ultrastructure phytotoxicities and oxidativereaction from polluted water with high chemical oxygen demand (COD). Superoxide dismutase (SOD) activity and malondialdehyde (MDA) contents in H. verticillata treated with 0.1% chitosan in wastewater increased with high COD (980 mg/L) and decreased with low COD (63 mg/L), respectively. Ultrastructural analysis showed that the stroma and grana of chloroplast basically remained normal. However, plant cells from the control experiment (untreated with chitosan) were vacuolated and the cell interval increased. The relict of protoplast moved to the center, with cells tending to disjoint. Our findings indicate that wastewater with high COD concentration can cause a substantial damage to submersed plant, nevertheless, chitosan probably could alleviate the membrane lipid peroxidization and ultrastructure phytotoxicities, and protect plant cells from stress of high COD concentration polluted water.     

Removal of cadmium using MnO2 loaded D301 resin

MnO2 loaded weak basic anion exchange resin D301 （Anion exchange resin, macroreticular weak basic styrene） as adsorbent has been prepared and applied to the removal of cadmium. The adsorption characteristics have been investigated with respect to effect of pH, equilibrium isotherms, removal kinetic data, and interference of the coexisting ions. The results indicated that the Cd^2＋ could be efficiently removed using MnO2 loaded D301 resin in the pH range of 3-8 from aqueous solutions with the co-existence of high concentration of alkali and alkaline-earth metals ions. The saturate adsorption capacity of the Cd^2＋ was 77.88 mg/g. The adsorption process followed the pseudo first-order kinetics. The equilibrium data obtained in this study accorded excellently with the Langmuir adsorption isotherm.     

Effect of coagulation pretreatment on the fouling of ultrafiltration membrane

The purpose of this study is to understand the effect and mechanism of preventing membrane fouling, by coagulation pretreatment, in terms of fractional component and molecular weight of natural organic matter （NOM）. A relatively higher molecular weight （MW） of hydrophobic compounds was responsible for a rapid decline in the ultrafiltration flux. Coagulation could effectively remove the hydrophobic organics, resulting in the increase of flux. It was found that a lower MW of neutral hydrophilic compounds, which could remove inadequately by coagulation, was responsible for the slow declining flux. The fluxes in the filtration of coagulated water and supernatant water were compared and the results showed that a lower MW of neutral hydrophilic compounds remained in the supernatant water after coagulation could be rejected by a membrane, resulting in fouling. It was also found that the coagulated flocs could absorb neutral hydrophilic compounds effectively. Therefore, with the coagulated flocs formed on the membrane surface, the flux decline could be improved.     

Penetration analysis of elements and bioleaching treatment of spent refractory for recycling

Acidithiobacillus ferrooxidans ATCC23270 and Acidithiobacillus thiooxidans TM-32 were used for bioleaching of spent refractories of aluminium and copper melting furnaces for their recycling.Firstly,penetration of elements into aluminium melting furnace refractory was investigated and it was found that up to 7 cm from surface was contaminated.Comparison on leaching efficiency by the strains ATCC23270 and TM-32 found that the strain ATCC23270 could treat larger amount of the refractories than the strain TM-32 could do.In the experiment of bioleaching of spent refractory aluminium melting furnace by the strain ATCC23270,high leaching efficiency were obtained on Al,Si,and Ca,and extremely low leaching performance was,however,shown on the rest of elements i.e.,Na,Mn,and Zn.Under the strain TM-32 use,relatively high leaching performance was recognized on Al,Si,Ca,Na,Mn,and Zn.In the experiment of bioleaching for spent refractory copper melting furnace,almost the same leaching trends were shown on Cu,Zn,Al,and Si under the strains ACTT23270 and TM-32 uses.     

Simultaneous removal of ammonium and phosphate by zeolite synthesized from coal fly ash as influenced by acid treatment

Zeolite synthesized from fly ash （ZFA） without modification is not efficient for the purification of NH4＋ and phosphate at low concentrations that occur in real effluents, despite the high potential removal capacity. To develop an effective technique to enhance the removal efficiency of ammonium and phosphate at low concentrations, ZFA was modified with acid treatment and the simultaneous removal of ammonium and phosphate in a wide range of concentration was investigated. It was seen that when compared with untreated ZFA, only the treatment by 0.01 mol/L of H2SO4 significantly improved the removal efficiency of ammonium at low initial concentrations. The behavior was well explained by the pH effect. Treatment by more concentrated H2SO4 led to the deterioration of the ZFA structure and a decrease in the cation exchange capacity. Treatment by 0.01 mol/L H2SO4 improved the removal efficiency of phosphate by ZFA at all initial P concentrations, while the treatment by concentrated H2SO4 （≥0.9 mol/L） resulted in a limited maximum phosphate immobilization capacity （PIC）. It was concluded that through a previous mild acid treatment （e.g. 0.01 mol/L of H2SO4）, ZFA can be used in the simultaneous removal of NH4＋ and P at low concentrations simulating real effluent.