不锈钢薄板拉伸、冲压成形性能的试验研究

采用德国产SCHENCKTREBELRM2 5 0电子万能试验机对SUS3 0 4不锈钢 0 .5mm薄板进行了拉伸试验 ,研究了SUS3 0 4不锈钢薄板的硬化指数 (n值 )、屈服强度 (σs)、极限强度 (σb)、均匀延伸率(δ)等机械性能 ,并分析了SUS3 0 4薄板的冲压成形性能     

RE对慢冷条件下B319铝合金组织性能的影响

利用等离子发射光谱仪、能谱仪、差分扫描量热仪 (DSC)以及金相分析等手段 ,研究了稀土 (RE)对慢冷条件下B319铝合金组织和性能的影响。研究结果表明 ,在铸件冷却速度为0 .3℃ /s的慢冷条件下 ,B319铝熔体中加入 0 .15 %RE ,可以使硅相得到一定程度的变质。随着RE加入量的增加 ,合金的抗拉强度和延伸率得以提高 ,当RE含量为 0 .15 %时 ,相对于未加RE时的情况 ,σb 和δ分别增加了 14 %和 2 3.5 %。当RE含量大于 0 .15 %时 ,出现富稀土的块状金属间化合物Ti2LaAl2 0 ,使合金的机械性能 ,尤其是塑性降低     

拉伸类冲压成形性能非线性关系评定

同时用板材的加工硬化指数n值与各向异性系数r值对极限翻边系数K_(f,c)和极限胀形系数K_(b,c)的定量预报作用和公式;K_(f,c)=1/((1+r)n+1),K_(b,c)=(1+r)n+1.从而获得了板材拉伸类冲压成形性能用r×n去作非线性关系评定的实验研究结果.     

三层复合板的r值研究

通过拉伸实验测试了不锈钢 /铝合金 /不锈钢三层复合板的厚向异性系数r,并分析了扩散退火对r值的影响及r值对板材成形性能的影响。分析表明 :扩散退火会降低r值和提高n值。用平均r值和rmin 来判断拉延危险断面的抗拉强度其误差在 6 %左右。     

AZ31B镁合金挤压工艺研究

在油炉中熔炼AZ31B镁合金 ,用熔剂保护 ,石墨模铸造圆锭。铸锭经 40 0℃× 1 2h的均匀化处理后 ,进行热挤压 ,其挤压温度为 40 0℃ ,挤压速度为 1～ 2 .5m/min ,挤压比为 1 0～ 45。共挤出了 1 1种规格的棒材、管材、型材 (工字型、槽型、角形、方形、T形等 ) ,挤压过程中均发生了动态再结晶 ,其抗拉强度σb 在 2 75～ 2 85MPa之间 ,屈服强度σ0 .2　在 2 2 0～ 2 2 5MPa之间 ,延伸率δ在 1 5 %～ 1 7%之间。所制订的工艺合理 ,挤压出的棒材、管材、型材有较好的力学性能     

润滑条件对超深冲IF钢成形性能的影响

研究了不同润滑条件下钢板FLD和LDH的变化规律。研究结果表明 :润滑影响了钢板冲压成形过程中的应变路径 ,但对FLD0 没有影响 ;润滑对LDH0 影响显著。     

滇池浮游植物碳氮同位素时空分布特征及其影响因子分析

通过对旱季、旱雨季过渡期和雨季3个不同时期滇池浮游植物δ¹³C、δ¹⁵N的研究发现,滇池浮游植物δ¹³C、δ¹⁵N存在显著的时空分布特征.从旱季、过渡期到雨季,浮游植物δ¹³C值分别为-20.44‰±0.72‰、-17.32‰±1.09‰和-15.92‰±1.74‰,呈逐渐升高趋势;而浮游植物δ¹⁵N值的季节变化模式则相反,雨季（13.55‰±0.85‰）显著低于旱季（15.33‰±0.31‰）和过渡期（15.02‰±1.12‰）.空间分布上,浮游植物δ¹³C值呈现南高北低的变化特征,极差为13.17‰,δ¹⁵N值则中部湖区高,南北部湖区低,极差为11.37‰.统计分析表明,浮游植物δ¹³C值与水温、降水量、电导率和pH值等多因素相关,反映了生物生长速率和无机碳源的影响显著;浮游植物δ¹⁵N值季节变化受降水量、总氮（TN）、总磷（TP）的影响,其空间变化与滇池流域内土地利用的空间分布格局一致.上述结果显示,城市生活污水仍然是滇池重要的污染来源,而农业化肥等面源污染对δ¹⁵N值的时空变化起到显著的调控作用.因此,滇池流域土地利用与营养盐来源的空间差异以及西南季风区降水的季节变化是影响湖泊生态系统碳氮循环与同位素生物示踪信号的重要因子.     

内蒙古夏季大气降水同位素特征及影响因素

为探明内蒙古地区夏季大气降水中δD和δ¹⁸O组成特征及其对气象因子变化的响应关系,于2017~2019年夏季采集了内蒙古阿拉善左旗、呼和浩特市市区、正蓝旗、克什克腾旗（达里湖）、通辽科尔沁左翼中旗和呼伦贝尔新巴尔虎右旗（呼伦湖）等6个区域共计82次大气降水样品,结合来自全球降水同位素观测网（GNIP）的包头、张掖等6个区域大气降水样品中δD和δ¹⁸O数据,分析了内蒙古地区大气降水中δD和δ¹⁸O变化的区域差异及其主要影响因素,结果表明：内蒙古局地大气降水中δD和δ¹⁸O值存在自西向东不断偏负的趋势,其中呼伦贝尔新巴尔虎右旗大气降水中δD和δ¹⁸O值最偏负;相对地,西部阿拉善左旗大气降水中δD和δ¹⁸O值最偏正;内蒙古地区局地大气降水线斜率和截距同样表现出自西向东逐渐偏正的变化趋势,显示二次蒸发作用的影响逐渐下降,且局地蒸发水汽团对西部地区大气降水影响明显,如位于西风环流影响区的阿拉善左旗等区域局地蒸发气团占到8月部分单次大气降水来源水汽团的100%,而7月份,东亚夏季风环流对内蒙古局地大气降水的影响最为明显;整体上,虽然区域大气湿度变化引起的二次蒸发是影响内蒙古局地大气降水过程的一个关键因素,不过大气降水量对夏季大气降水稳定同位素组成的影响最明显.即西风环流影响区大气湿度变化对氘盈余指数d值的影响程度明显强于东亚夏季风区大气湿度变化的影响,而东亚夏季风环流影响区大气降水量对d值的影响程度则相对明显.     

镁合金净化技术研究

利用金相分析、电镜、岛津材料试验机等方法研究了不同净化工艺对镁合金力学性能、组织、断口形貌的影响。结果表明 ,对于AZ91镁合金 ,精炼剂的用量不宜超过 3 .5 % ,浇注温度应控制在 72 0～ 730℃。采用熔剂、吹氩和过滤的复合净化处理工艺可以有效清除镁熔体中的夹杂物和气孔 ,使镁合金的性能得到极大的提高。经复合净化处理后的AZ91的σb和δ可分别达到 2 0 6 .1MPa和 5 .2 1 %。金相观察表明 ,净化处理对金相组织无明显的影响 ,不改变AZ91镁合金的断裂机理 ,断口均成准解理断裂     

海州香薷对铜的蓄积及铜的毒性效应

研究了不同浓度铜对海州香薷的毒性及海州香薷对铜的蓄积结果表明0.5 mmol/kg的铜能促进海州香薷的生长,使其生物量增大.低浓度的Cu²⁺使叶绿素a含量上升,而高浓度Cu²⁺则使叶绿素a下降,但Cu²⁺对叶绿素b的影响并不明显.反映到a/b上则表现为低浓度下Cu²⁺处理会提高a/b值.海州香薷的蓄铜浓度随土壤中铜浓度的增加而升高,可达1500mg/kg,达到了超量积累植物的标准.铜对SOD、POD活性的影响也表现为低浓度的刺激效应和高浓度的抑制效应,最高值出现在0.5 mol/kg.     

Evaluation of phytoextracting cadmium and lead by sunflower, ricinus, alfalfa and mustard in hydroponic culture

Soil contaminated with heavy metals cadmium(Cd)and lead(Pb)is hard to be remediated.Phytoremediation may be a feasible method to remove toxic metals from soil,but there are few suitable plants which can hyperaccumulate metals.In this study,Cd and Pb accumulation by four plants including sunflower(Helianthus annuus L.),mustard(Brassica juncea L.),alfalfa(Medicago sativa L.), ricinus(Ricinus communis L.)in hydroponic cultures was compared.Results showed that these plants could phytocxtract heavy metals, the ability of accumulation differed with species,concentrations and categories of heavy metals.Values of BCF(bioconcentration factor)and TF(translocation factor)indicated that four species had dissimilar abilities of phytoextraction and transportation of heavy metals.Changes on the biomass of plants,pH and Eh at different treatments revealed that these four plants had distinct responses to Cd and Pb in cultures.Measurements should be taken to improve the phytoremediation of sites contaminated with heavy metals,such as pH and Eh regulations,and so forth.     

Oxidation of As(Ⅲ) by potassium permanganate

The oxidation of As(Ⅲ) with potassium permanganate was studied under conditions including pH, initial As(Ⅲ) concentration and dosage of Mn(Ⅶ). The results have shown that potassium permanganate was an effective agent for oxidizing of As(Ⅲ) in a wide pH range. The pH value of tested water was not a significant factor affecting the oxidation of As(Ⅲ) by Mn(Ⅶ). Although theoretical redox analyses suggest that Mn(Ⅶ) should have better performance in oxidization of As(Ⅲ) within lower pH ranges, the experimental results show that the oxidation efficiencies of As(Ⅲ) under basic and acidic conditions were similar, which may be due to the adsorption of As(Ⅲ) on the Mn(OH)2 and MnO2 resulting from the oxidation of As(Ⅲ).     

Distribution and ecological effect of mercury in Laogang landfill, Shanghai, China

Laogang landfill near Shanghai is the largest landfill in China, and receives about 10000 t of daily garbage per day, Samples of topsoil and plants were analyzed to evaluate mercury pollution from the landfill. For topsoil samples, there were significant correlations among total mercury （HgT）, combinative mercury （Hgc） and gaseous mercury （HgG）, and content of total organic carbon （TOC）, but, no significantly relationship was found between Hg content and filling time. Hg content changes in vertical profiles with time showed that the average Hgv of profiles 1992, 1996, and 2000 was similar, but their average HgG was quite different. HgT was significantly correlated with Hgc in profile 1992 and 2000, and Hgv was significantly correlated with Hg6 in profile 1996. HgG/Hgv ratio in profile samples decreased in the order of （HgG,/HgT）1992〉（HgG/HgT）1996〉〉（HgG/HgT）2000. A simple outline of Hg release in landfill could be drawn： with increasing of filling time, degradation undergoes different biodegradation, accordingly, gaseous mercury goes through small, more, and small proportion to total mercury. Distribution of Hg in plants was inhomogeneous, following the order of leaf〉root〉stem. The highest value of leaf may be associated with higher atmospheric Hg from landfill. Ligneous plants （e.g. Phyllostachys glanca, Prunus salicina and Ligustrum lucidum） are capable of enriching more Hg than herbaceous plants.     

EDTA-enhanced phytoremediation of lead contaminated soil by Bidens maximowicziana

Phytoremediation is a potential cleanup technology for the removal of heavy metals from contaminated soils.Bidens maximowicziana is a new Pb hyperaccumulator,which not only has remarkable tolerance to Pb but also extraordinary accumulation capacity for Pb.The maximum Pb concentration was 1509.3 mg/kg in roots and 2164.7 mg/kg in overground tissues.The Pb distribution order in the B. maximowicziana was:leaf>stem>root.The effect of amendments on phytoremediation was also studied.The mobility of soil Pb and the Pb concentrations in plants were both increased by EDTA application.Compared with CK(control check),EDTA application promoted translocation of Pb to overground parts of the plant.The Pb concentrations in overground parts of plants was increased from 24.23-680.56 mg/kg to 29.07-1905.57 mg/kg.This research demonstrated that B.maximowicziana appeared to be suitable for phytoremediation of Pb contaminated soil,especially,combination with EDTA.     

Decomposition of alachlor by ozonation and its mechanism

Decomposition and corresponding mechanism of alachlor, an endocrine disruptor in water by ozonation were investigated. Results showed that alachlor could not be completely mineralized by ozone alone. Many intermediates and final products were formed during the process, including aromatic compounds, aliphatic carboxylic acids, and inorganic ions. In evoluting these products, some of them with weak polarity were qualitatively identified by GC-MS. The information of inorganic ions suggested that the dechlorination was the first and the fastest step in the ozonation of alachlor.     

Enzymatic oxidation of aqueous pentachlorophenol

The influence of the nonionic surfactant Tween 80 on pentachlorophenol （PCP） oxidation catalyzed by horseradish peroxidase was studied. The surfactant was tested at concentrations below and above its critical micelle concentration （CMC）. Enhancement of PCP removal was observed at sub-CMCs. The presence of Tween 80 in the reaction mixture reduced enzyme inactivation which occurred through a combination of free radical attack and sorption by precipitated products. A simple first-order model was able to simulate time profiles for enzyme inactivation in the presence or absence of Tween 80. At supra-CMCs, the surfactant caused noticeable reductions in PCP removal, presumably through micelle partitioning of PCP which precluded the hydrophobic PCP molecule from interacting with the enzyme.     

Chlorobenzenes in waterweeds from the Xijiang River （Guangdong section） of the Pearl River

The Xijiang River is the major source of water for about 4.5 millions of urban population and 28.7 millions of rural population. The water quality is very important for the health of the rural population. The concentration and distribution of chlorobenzenes (CBs) in both water and waterweeds collected from 4 stations in the Xijiang River (Gangdong section) of the Pearl River in April and November were determined. The result showed that nearly every congener of CBs was detected. The total contents of CBs (∑CBs) in the river water ranged from 111.1 to 360.0 ng/L in April and from 151.9 to 481.7 ng/L in November, respectively. The pollution level of CBs in the water in April was higher than that in November. The contents of ∑ CBs in waterweeds ranged from 13.53×102 μg/g to 38.27×102μg/g dry weight (dw). There was no significant difference between April and November in waterweeds. The distribution of CBs in roots, caulis, and leaves of Vallisneria spiralis L. showed different patterns. The leaves mainly contained low-molecular-weight CBs(DCBs), whereas the roots accumulated more PCBs and HCBs. The average lgBCFlip (bioconcentration factor) of CBs ranged from 0.64 to 3.57 in the waterweeds. The spatial distribution character of CBs in the Xijiang River was: Fengkai County ＜ Yunan County ＜Yun'an County ＜ Gaoyao County according to the ∑CBs, and the pollution deteriorated from the upstream to the downstream of the Xijiang River. Further analysis demonstrated that the discharge of waste containing CBs may be the main source of CBs pollution in the Xijiang River.     

Degradation of 2,4-dichlorophenol with a novel TiO2/Ti-Fe-graphite felt photoelectrocatalytic oxidation process

Degradation of 2,4-dichlorophenol(2,4-DCP)was studied in a novel three-electrode photoelectrocatalytic(PEC)integrative oxidation process,and the factors influencing the degradation rate,such as applied current,flow speed of O_2,pH,adscititious voltage and initial 2,4-DCP concentration were investigated and optimized.H_2O_2 was produced nearby cathode and Fe~(2 )continuously generated from Fe anode in solution when current and O_2 were applied,so,main reactions,H_2O_2-assisted TiO_2 PEC oxidation and E-Fenton reaction,occurred during degradation of 2,4-DCP in this integrative system.The degradation ratio of 2,4-DCP was 93% in this integrative oxidation process,while it was only 31% in E-Fenton process and 46% in H_2O_2-assisted TiO_2 PEC process.So,it revealed that the degradation of 2,4-DCP was improved greatly by photoelectrical cooperation effect.By the investigation of pH,it showed that this integrative process could work well in a wide pH range from pH 3 to pH 9.     

Effect of copper on the degradation of pesticides cypermethrin and cyhalothrin

The influence of coexisting copper (Cu) ion on the degradation of pesticides pyrethroid cypermethrin and cyhalothrin in soil and photodegradation in water system were studied.Serial concentrations of the pesticides with the addition of copper ion were spiked in the soil and incubated for a regular period of time,the analysis of the extracts from the soil was carried out using gas chromatography (GC).The photodegradation of pyrethroids in water system was conducted under UV irradiation.The effect of Cu~(2 ) on the pesticides degradation was measured with half life (t_(0.5)) of degradation.It was found that a negative correlation between the degradation of the pyrethroid pesticides in soil and Cu addition was observed.But Cu~(2 ) could accelerate photodegradation of the pyrethroids in water.The t_(0.5) for cyhalothrin extended from 6.7 to 6.8 d while for cypermethrin extended from 8.1 to 10.9 d with the presence of copper ion in soil.As for photodegradation,t_(0.5) for cyhalothrin reduced from 173.3 to 115.5 rain and for cypermethrin from 115.5 to 99.0 min.The results suggested that copper influenced the degradation of the pesticides in soil by affecting the activity of microorganisms.However, it had catalyst tendency for photodegradation in water system.The difference for the degradation efficiency of pyrethroid isomers in soil was also observed.Copper could obviously accelerate the degradation of some special isomers.     

基于综合水质标识指数和对应分析法的校园河道水质评价

以三峡大学的校园河道求索溪为研究对象,利用综合水质标识指数法确定求索溪水质类别,分析其水质时空变化规律,并利用对应分析法得出求索溪中不同监测点的主要污染因子.研究结果表明:求索溪整体的综合水质标识指数为7.423,整体水质为劣V类(地表水环境质量标准GB 3838-2002)且黑臭.从时间变化来看,求索溪4月份的水质最差,5月份次之,4、5月份所有监测点的水质都劣于V类且黑臭;8月份水质最好,水质为Ⅳ类;从空间分布来看,8个监测点综合水质标识指数均超过6.0,水质为劣V类,其中6号监测点的水质相对最好,监测点3号的水质相对最差;对应分析法得出求索溪的整体水体污染程度受总氮因子的影响最大,其次为总磷.该研究拟为求索溪及类似校园河道的水环境治理研究提供基础依据和参考.