宝钢中厚板分公司煤干燥机除尘系统风量调整技术探究

文章针对宝钢股份中厚板分公司炼铁厂煤干燥机除尘系统吸尘点冒灰,粉尘无组织排放超标的现象进行了测试分析,数据表明主要由除尘系统风量匹配不佳、吸尘点风量不合理造成。笔者通过不断调整阀门及风机档板开摩,测试调整后的风量、除尘性能、岗位粉尘浓度等参数,确定了一个合理的系统风量,不仅可以达到环境排放及职业卫生的要求,而且充分挖掘了除尘系统潜力,达到了节能降耗、经济运行的目的,同时对类似除尘系统风量匹配不佳、扬尘等问题也形成了有效的解决方案。     

煤及矿石转运系统集尘风量估算

以往,对煤及矿石转运系统集尘风量计算及布置位置,除尘风量外,无一具体规定。最近,美国政府工业卫生会议及一些杂志提出了各种集尘点的设计风量范围或最小值。特别是对煤在皮带运输中各转接点、过筛处、简仓、漏斗、筒处的除尘风量提出了推荐值或较佳吸尘点,为设计人员提供了计算数据。     

两种粉尘收集系统在环境治理中的应用和对比

针对粉尘治理工程设计中经常混淆的设计理念,介绍了两种粉尘收集系统在环境治理中的各自应用特点,通过对两个工程实例的系统分析和经验总结,得出以下结论:脉冲袋式除尘系统和真空负压吸尘系统是两种不同的粉尘收集系统,脉冲袋式除尘系统是以控制粉尘逸散为原则,在尘源点密闭的基础上形成一定的负压,须合理确定系统的设计风量和吸尘罩的设置;真空负压吸尘系统则是以尽可能多收集粉尘减少人工清扫强度为原则,须优化设计吸尘管网,保证最远处吸尘点能有效吸力。     

转炉二次烟气除尘变工况及风机调速

根据转炉二次烟气除尘风量随冶炼周期变化的特征,利用工艺设备工况特征信号控制各除尘阀门的开闭,并根据各个除尘分支管道工况的变化,确定系统在不同工作点的总阻力、风量和风机转速,达到自动控制风机调速,节约电能的目的。     

多级除尘系统优化初探

本文探讨了多级除尘系统网络布置的优化方法,一是将低浓度点粉尘直接由风机引入第二级除尘器进行处理,以减少系统的压力损失;二是将系统管路并联,通过调节阀调节第一级除尘器的入口风量,使其达到最佳入口经济风量,降低系统运行成本。本文还对最佳入口经济风量的确定进行了推算。     

某塑料公司生产车间除尘系统改造与实践研究

针对重庆某塑料公司车间生产工艺、现场条件及粉尘污染现状,对其生产线进行除尘系统改造。改造后的除尘系统在充分考虑车间尘源点的变动情况,通风阻力和风量要求的基础上重新设计,实施后关键工位总粉尘平均浓度为2．6mg／m。,除尘效果显著。     

不同类型除尘器改造为脉冲除尘器技术

介绍了除尘器改造的原则、技术和方法,并结合多个除尘器改造的工程实例,分享了不同类型除尘器改造为脉冲除尘器成功经验。经过改造的除尘器能够满足集气吸尘罩处风量的要求,减少了除尘器出口排放浓度,降低了除尘器的运行阻力。     

柳钢360m~2烧结系统除尘工程设计

以柳钢360 m2烧结系统为例,结合工业通风分析了烧结系统配料、混料、烧结以及筛分转运等工艺过程,提出了烧结系统除尘工程设计形式及布置。根据烧结系统特点,将除尘工程分为混合、机头、机尾、成品除尘系统,针对各系统特点确定相应风量设计参数、设备选型参数,并提出了各系统设计要点。     

低阻电旋风除尘器性能研究

本文对用对数螺旋筒体与静电结合而成的电旋风除尘器的性能进行了初步研究，分析了影响其除尘效率的因素，得到了该型（一定结构）除尘器的效率与风量（风速），工作电压，入口浓度之间的基本关系，阻力与风量（风速）之间的关系，初步的研究表明，该型除尘器有极低的阻力和较高的效率。     

旋流除尘器阻力损失及除尘效率影响因素的模拟研究

基于Fluent软件建立了某型旋流除尘器内部流场模拟的仿真模型,研究了旋流除尘器叶片宽度、叶片倾角,以及处理风量对旋流除尘器阻力损失和除尘效率的影响。结果表明,叶片宽度和叶片倾角的减小以及风量的增大都会导致旋流除尘器阻力损失的显著增大,但同时旋流除尘器内旋流体上部的烟气离心加速度明显增大,即除尘效率会提高。由此可见,研究旋流除尘器内流场及相关参数对阻力损失和除尘效率的影响对工程实际具有重要的指导意义。最后,通过工程实例验证了计算结果的合理性和准确性。     

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

EDTA-enhanced phytoremediation of lead contaminated soil by Bidens maximowicziana

Phytoremediation is a potential cleanup technology for the removal of heavy metals from contaminated soils.Bidens maximowicziana is a new Pb hyperaccumulator,which not only has remarkable tolerance to Pb but also extraordinary accumulation capacity for Pb.The maximum Pb concentration was 1509.3 mg/kg in roots and 2164.7 mg/kg in overground tissues.The Pb distribution order in the B. maximowicziana was:leaf>stem>root.The effect of amendments on phytoremediation was also studied.The mobility of soil Pb and the Pb concentrations in plants were both increased by EDTA application.Compared with CK(control check),EDTA application promoted translocation of Pb to overground parts of the plant.The Pb concentrations in overground parts of plants was increased from 24.23-680.56 mg/kg to 29.07-1905.57 mg/kg.This research demonstrated that B.maximowicziana appeared to be suitable for phytoremediation of Pb contaminated soil,especially,combination with EDTA.     

Distribution and ecological effect of mercury in Laogang landfill, Shanghai, China

Laogang landfill near Shanghai is the largest landfill in China, and receives about 10000 t of daily garbage per day, Samples of topsoil and plants were analyzed to evaluate mercury pollution from the landfill. For topsoil samples, there were significant correlations among total mercury （HgT）, combinative mercury （Hgc） and gaseous mercury （HgG）, and content of total organic carbon （TOC）, but, no significantly relationship was found between Hg content and filling time. Hg content changes in vertical profiles with time showed that the average Hgv of profiles 1992, 1996, and 2000 was similar, but their average HgG was quite different. HgT was significantly correlated with Hgc in profile 1992 and 2000, and Hgv was significantly correlated with Hg6 in profile 1996. HgG/Hgv ratio in profile samples decreased in the order of （HgG,/HgT）1992〉（HgG/HgT）1996〉〉（HgG/HgT）2000. A simple outline of Hg release in landfill could be drawn： with increasing of filling time, degradation undergoes different biodegradation, accordingly, gaseous mercury goes through small, more, and small proportion to total mercury. Distribution of Hg in plants was inhomogeneous, following the order of leaf〉root〉stem. The highest value of leaf may be associated with higher atmospheric Hg from landfill. Ligneous plants （e.g. Phyllostachys glanca, Prunus salicina and Ligustrum lucidum） are capable of enriching more Hg than herbaceous plants.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Enzymatic oxidation of aqueous pentachlorophenol

The influence of the nonionic surfactant Tween 80 on pentachlorophenol （PCP） oxidation catalyzed by horseradish peroxidase was studied. The surfactant was tested at concentrations below and above its critical micelle concentration （CMC）. Enhancement of PCP removal was observed at sub-CMCs. The presence of Tween 80 in the reaction mixture reduced enzyme inactivation which occurred through a combination of free radical attack and sorption by precipitated products. A simple first-order model was able to simulate time profiles for enzyme inactivation in the presence or absence of Tween 80. At supra-CMCs, the surfactant caused noticeable reductions in PCP removal, presumably through micelle partitioning of PCP which precluded the hydrophobic PCP molecule from interacting with the enzyme.     

Decomposition of alachlor by ozonation and its mechanism

Decomposition and corresponding mechanism of alachlor, an endocrine disruptor in water by ozonation were investigated. Results showed that alachlor could not be completely mineralized by ozone alone. Many intermediates and final products were formed during the process, including aromatic compounds, aliphatic carboxylic acids, and inorganic ions. In evoluting these products, some of them with weak polarity were qualitatively identified by GC-MS. The information of inorganic ions suggested that the dechlorination was the first and the fastest step in the ozonation of alachlor.     

基于综合水质标识指数和对应分析法的校园河道水质评价

以三峡大学的校园河道求索溪为研究对象,利用综合水质标识指数法确定求索溪水质类别,分析其水质时空变化规律,并利用对应分析法得出求索溪中不同监测点的主要污染因子.研究结果表明:求索溪整体的综合水质标识指数为7.423,整体水质为劣V类(地表水环境质量标准GB 3838-2002)且黑臭.从时间变化来看,求索溪4月份的水质最差,5月份次之,4、5月份所有监测点的水质都劣于V类且黑臭;8月份水质最好,水质为Ⅳ类;从空间分布来看,8个监测点综合水质标识指数均超过6.0,水质为劣V类,其中6号监测点的水质相对最好,监测点3号的水质相对最差;对应分析法得出求索溪的整体水体污染程度受总氮因子的影响最大,其次为总磷.该研究拟为求索溪及类似校园河道的水环境治理研究提供基础依据和参考.     

Potential of plant polyphenol oxidases in the decolorization and removal of textile and non-textile dyes

In this study an effort has been made to use plant polyphenol oxidases; potato （Solanum tuberosum） and brinjal （Solanum melongena）, for the treatment of various important dyes used in textile and other industries. The ammonium sulphate fractionated enzyme preparations were used to treat a number of dyes under various experimental conditions. Majority of the treated dyes were maximally decolorized at pH 3.0. Some of the dyes were quickly decolorized whereas others were marginally decolorized. The initial first hour was sufficient for the maximum decolorization of dyes. The rate of decolorization was quite slow on long treatment of dyes. Enhancement in the dye decolorization was noticed on increasing the concentration of enzymes. The complex mixtures of dyes were treated with both preparations of polyphenol oxidases in the buffers of varying pH values. Potato polyphenol oxidase was significantly more effective in decolorizing the dyes to higher extent as compared to the enzyme obtained from brinjal polyphenol oxidase. Decolorization of dyes and their mixtures, followed by the formation of an insoluble precipitate, which could be easily removed simply by centrifugation.     

Effects of chitosan on growth of an aquatic plant (Hydrilla verticillata) in polluted waters with different chemical oxygen demands

Effects of chitosan on a submersed plant, Hydrilla verticillata, were investigated. Results indicated that H. venicillata could prevent ultrastructure phytotoxicities and oxidativereaction from polluted water with high chemical oxygen demand (COD). Superoxide dismutase (SOD) activity and malondialdehyde (MDA) contents in H. verticillata treated with 0.1% chitosan in wastewater increased with high COD (980 mg/L) and decreased with low COD (63 mg/L), respectively. Ultrastructural analysis showed that the stroma and grana of chloroplast basically remained normal. However, plant cells from the control experiment (untreated with chitosan) were vacuolated and the cell interval increased. The relict of protoplast moved to the center, with cells tending to disjoint. Our findings indicate that wastewater with high COD concentration can cause a substantial damage to submersed plant, nevertheless, chitosan probably could alleviate the membrane lipid peroxidization and ultrastructure phytotoxicities, and protect plant cells from stress of high COD concentration polluted water.     

Removal of heavy metals from sewage sludge by low costing chemical method and recycling in agriculture

ＲｅｍｏｖａｌｏｆｈｅａｖｙｍｅｔａｌｓｆｒｏｍｓｅｗａｇｅｓｌｕｄｇｅｂｙｌｏｗｃｏｓｔｉｎｇｃｈｅｍｉｃａｌｍｅｔｈｏｄａｎｄｒｅｃｙｃｌｉｎｇｉｎａｇｒｉｃｕｌｔｕｒｅＷｕＱｉｔａｎｇ，ＮｙｉｒａｎｄｅｇｅＰａｓｃａｓｉｅ，ＭｏＣｅｈｕｉＦ...