电镀废水处理及回用工程实例

将某电镀废水原水按水质分类,分别进行沉淀、氧化等预处理,然后综合进行中和、生物接触氧化、沉淀等工艺,出水水质指标达到地方污水排放标准,对部分出水进行砂滤、活性炭吸附、膜过滤处理等深度处理后达到回用要求。结果表明,该方法对中小企业处理含氰及多种重金属的电镀废水是经济、可行的。     

阿海水电站新源沟砂石加工废水处理工艺浅谈

新源沟砂石加工系统生产废水SS浓度高,采用水力旋流/加药絮凝/多级沉淀工艺处理,运行结果表明,处理出水水质满足《污水综合排放标准》（GB8978-1996）一级标准中的给定限值70mg/L,达标出水全部回用。     

水危机与中水回用技术方法的探讨

世界与国内水资源短缺的现状表明中水回用十分迫切。本文介绍了国内外中水回用的应用情况，表明该技术对缓解世界与国内的用水压力起着举足轻重的作用。阐述了中水回用的技术方法、水质要求及工艺流程，讨论了中水回用的实际意义，结论表明：中水回用提高了水的利用率，实现了水资源的可持续发展。     

应用反渗透技术处理垃圾填埋场渗滤液

垃圾填埋场渗滤液属于高浓度氨氮废水，其水量、水质特性变化大，成分复杂，因此较难处理。反渗透分离技术能有效截留垃圾渗滤液中溶解态的有机和无机污染物。采用三级反渗透处理垃圾渗滤液工艺处理后的出水水质，能够满足《生活垃圾填埋污染控制标准》（DB16889-2008）要求，并把渗滤液浓缩液回灌于填埋场。     

Contribution of Wastewater Treatment Plant Effluents to Nutrient Dynamics in Aquatic Systems: A Review

Excessive nutrient loading (considering nitrogen and phosphorus) is a major ongoing threat to water quality and here we review the impact of nutrient discharges from wastewater treatment plants (WWTPs) to United States (U.S.) freshwater systems. While urban and agricultural land uses are significant nonpoint nutrient contributors, effluent from point sources such as WWTPs can overwhelm receiving waters, effectively dominating hydrological characteristics and regulating instream nutrient processes. Population growth, increased wastewater volumes, and sustainability of critical water resources have all been key factors influencing the extent of wastewater treatment. Reducing nutrient concentrations in wastewater is an important aspect of water quality management because excessive nutrient concentrations often prevent water bodies from meeting designated uses. WWTPs employ numerous physical, chemical, and biological methods to improve effluent water quality but nutrient removal requires advanced treatment and infrastructure that may be economically prohibitive. Therefore, effluent nutrient concentrations vary depending on the particular processes used to treat influent wastewater. Increasingly stringent regulations regarding nutrient concentrations in discharged effluent, along with greater freshwater demand in populous areas, have led to the development of extensive water recycling programs within many U.S. regions. Reuse programs provide an opportunity to reduce or eliminate direct nutrient discharges to receiving waters while allowing for the beneficial use of reclaimed water. However, nutrients in reclaimed water can still be a concern for reuse applications, such as agricultural and landscape irrigation.     

稠油污水回用热采锅炉技术研究

针对曙光油田稠油污水的特点,在原有工艺流程的基础上,根据实际处理能力,选择合适的设备,对不同的污染物采取优先强化处理和逐段处理方式,在曙四联进行了现场试验,确定了最佳运行参数及合理的加药量。结果表明:稠油污水深度处理后达到锅炉回用水指标,真正实现污水资源化。此项研究符合清洁生产和循环经济的核心理念,实现了污水的资源化,取得了良好的经济、环境和社会效益。     

Environmental management of the stone cutting industry

Environmental Management of the stone cutting industry in Hebron is required to reduce the industry's adverse impact on the downstream agricultural land and the adverse impact on the drinking water aquifers. This situation requires the implementation of an industrial wastewater management strategic approach and technology, within the available technical and financial resources. Ten pilot projects at different locations were built at Hebron to reduce or eliminate the incompatible discharge of the liquid and solid waste to the environment and improve the stone cutting industry's effluent quality. A review of existing practices and jar test experiments were used to optimize the water recycling and treatment facilities. The factors reviewed included influent pumping rates and cycles, selection of the optimal coagulant type and addition methods, control of the sludge recycling process, control over flow rates, control locations of influent and effluent, and sludge depth. Based on the optimized doses and Turbidity results, it was determined that the use of Fokland polymer with an optimal dose of 1.5mg/L could achieve the target turbidity levels. The completion of the pilot projects resulted in the elimination of stone cutting waste discharges and an improvement in the recycled effluent quality of 44-99%. This in turn reduced the long term operating costs for each participating firm. A full-scale project that includes all the stone cutting firms in Hebron industrial area is required.     

Anaerobic/aerobic treatment of meat processing wastewater

The meat processing industry is believed to produce highly polluted wastewater. Analysis of such wastewater indicated that the waste was highly contaminated with organic compounds as indicated by COD (1544mgO2l–1), BOD (646mgO2l–1), and TSS (1155 mgl–1). Moreover, oil and grease concentrations reached 144mgl–1 treatment of raw wastewater using Upflow Anaerobic Sludge Blanket (UASB) followed by Rotating Biological Contactors (RBC) was studied. Efficiency of the UASB for the removal of CODtotal, BODtotal, TSS, and oil and grease was 56%, 56%, 85%, and 58%, respectively. The quality of the UASB effluent barely complies with the regulatory standards for discharging wastewater into the sewerage network. UASB effluent was subjected for further treatment using a RBC unit to improve the quality of the treated effluent for reuse in irrigation purposes. Residual COD, BOD, TSS, and oil and grease, following RBC, was 132mgO2l–1, 40mgO2l–1, 44mgl–1, and 10mgl–1 respectively. The overall efficiency of the treatment units provided good quality effluent. The overall percentage removal of COD, BOD, TSS, and oil and grease was 91.5%, 94%, 96%, and 91%, respectively. Based on the quality of the treated effluent and guidelines recommended for wastewater reuse, it may be concluded that a slight to moderate restricted irrigation is applicable to reuse the treated effluent in the green belt around the factory. Disinfection should be applied to ensure the safety of such a process.     

MBR/RO组合工艺回收处理己内酰胺废水的中试研究

对己内酰胺生产过程废水的回用处理工艺进行了研究。以某己内酰胺化工厂的LUCAS出水作为研究对象,采用膜生物反应器和反渗透膜处理工艺,研究此系统对己内酰胺废水的处理效果。试验结果表明,膜生物反应器工艺适用于该化工厂的生产废水,出水COD平均值为31.33mg/L,平均浊度为0.2NTU,氨氮平均值为2.81mg/L,可以满足反渗透膜的进水要求。在浓缩倍数为3时,反渗透膜系统运行稳定,且产水可以满足化工部循环冷却水用再生水水质标准。     

A SURVEY OF THE MICROBIAL QUALITY OF RECYCLED HOUSEHOLD GRAYWATER1

ABSTRACT: In arid regions where populations are expanding and water is scarce, people are searching for ways to conserve and reuse water. One way homeowners can conserve water is by recycling graywater‐wastewater from household sinks, showers, bathtubs, and washing machines. Graywater is used mostly for landscape irrigation. Since graywater is wastewater, reusing it raises concerns about disease transmission, either by contact with the water or the irrigated soil. The purpose of this study was to assess how factors such as number and age of household occupants, types of graywater storage, and sources of graywater used affect the microbial quality of graywater and soil irrigated with graywater. Samples were collected over twelve months from eleven Tucson, Arizona households recycling graywater. Samples of graywater, soil irrigated by graywater, and soil irrigated by potable water were collected. We found that graywater irrigation causes a statistically significant increase in levels of fecal coliforms in soil when compared to soil irrigated with potable water. Graywater from the kitchen sink significantly increases levels of these bacteria in water and soil. Children also cause a statistically significant increase in fecal coliform levels in graywater and soil, possibly introducing a small amount of additional risk in graywater reuse.     

超稠油污水深度处理工艺技术

针对辽河油田超稠油污水的特点设计了处理工艺流程,进行了药剂的筛选,根据各工艺设备的出水水质要求确定了合适的净水剂、除硅剂、阻垢剂的加量,并进行了现场实际应用,外输出水达到锅炉给水指标要求,用于锅炉注汽使用,效果良好,分析了该超稠油污水处理技术的特点和优势,提出了超稠油污水回用锅炉的建议。     

红浅稠油污水回用锅炉处理技术研究与应用

文章介绍了红浅稠油污水处理站采用的"离子调整旋流反应+216t/h软化水"处理工艺,该工艺创新性的采用了分置式反应罐,将混凝、反应、加药、沉降、颗粒吸附有机结合,优选出高效的污水处理药剂,首次在新疆油田公司污水处理工艺中应用改性纤维束过滤器和216t/h软化水处理装置,优化了各节点的配套工艺,使处理后的污水水质达到回用锅炉水质标准,取得了良好的效果。同时,通过对加药浓度、隔油、反冲洗周期等参数优化,保证了红浅稠油污水回用锅炉处理系统的平稳运行,累计处理回用污水约730万m3,有效地节约了水资源,保护了环境,综合效益显著。     

THE IMPACT OF WATER QUALITY OBJECTIVES ON URBAN WATER SUPPLY PLANNING1

ABSTRACT: Optimal policies for supplying rapidly expanding urban centers with additional water supplies are shown to be dependent on water quality goals for the urban effluent. As effluents are required to meet increasingly stringent standards, the unit costs associated with adding capacity to existing wastewater treatment systems to renovate some waters for reuse are shown to substantially decrease. A nonlinear elimination algorithm is developed to delineate optimal policies. A model employing the technique was applied to the wastewater treatment system of a typical urban system and the water quality objectives varied. A comparison of costs with and without various levels of reuse were made and unit costs of reused water under these conditions determined.     

Water conservation due to greywater treatment and reuse in urban setting with specific context to developing countries

In India, the per capita water availability is reducing day by day due to rapid growth in population and increasing water demand. Greywater treatment and reuse is one of the feasible options in developing countries like India to overcome this problem. A greywater collection, treatment and reuse system was designed and implemented in an urban household having a water requirement of 165 liter per capita per day (lpcd) and a greywater generation rate of 80 lpcd. An upflow-downflow greywater treatment plant having a screening, sedimentation, filtration and disinfection as major treatment processes was constructed and treated greywater is used for toilet flushing and to irrigate the vegetables in the backyard of the household. Greywater characterisation indicates that COD and BOD are sufficiently reduced during the treatment and there is also substantially reduction in Escherichia coli count. The payback period of this greywater treatment and reuse system is estimated to be 1.6 year.     

初级再生水对循环水处理药剂的影响

初级再生水回用过程中所要解决的两个难题是腐蚀和微生物的控制。通过对锦西石化分公司初级再生水对各循环水场现用药剂的缓蚀阻垢效果及杀菌效果进行了实验室综合评价,考察缓蚀阻垢性能、杀菌性能及药剂加药量的影响,并根据水质情况及药剂评价结果提出了初级再生水的最佳pH值及COD值范围,并根据水场及水质情况选出最优药剂,为合理加药剂提供依据。     

POTENTIALS FOR REUSE OF WASTEWATER IN NORTH CENTRAL TEXAS1

ABSTRACT There are several possible ways in which wastewater from municipalities may be reclaimed and reused so as to minimize the need for imported water in North Central Texas. The rationale for reuse is enhanced by the fact that new water quality requirements in the Trinity River system will necessitate a very high degree of treatment at municipal sewage plants, just for discharge to surface streams. The largest potential market for municipal effluent is the steam-electric power industry. Within the next decade the generating capacity for electric power in North Central Texas will have to be more than doubled to meet increasing demand. Adequate supplies of condenser cooling water for such expansion will be difficult to obtain and assure. New large power stations might advantageously be located adjacent to municipal wastewater treatment plants, to utilize effluent as make-up water for cooling towers. Experience elsewhere has shown that well-treated wastewater can be used for cooling tower make-up with a minimum of trouble, with a considerable saving in overall cost, and with conservation of pristine water for other uses.     

ARE WE READY FOR A CLOSED SYSTEM OF WATER SUPPLY TREATMENT,AND REUSE - TECHNOLOGY VS. PSYCHOLOGY?1

ABSTRACT: Up to date there are still not many instances that can be found on the practice of a totally closed system of water supply, treatment, and reuse. In the United States, this is partly because the Public Health Service has discouraged such a practice. However, are there sound scientific reasons to support such a decision or is it purely a matter of psychological reason? Are the treatment technologies available today able to achieve the integrated closed system at a reasonable cost, yet without risking the public health? Are there some extra precautions that must be taken in practicing the direct reuse for the drinking purpose? These questions are discussed in this article. Current available technologies for advanced waste treatment are briefly reviewed and the treated effluent qualities obtained by the authors and others are used as a focal point of discussion on the feasibility of practicing the closed system. For this purpose, the treated effluent qualities are compared to the “Ranges of Promulgated Standards for Raw Water Sources of Domestic Water Supply” which have been used by the Public Health Service and several state regulatory agencies.     

WATER REUSE FROM SEWAGE EFFLUENT BY IRRIGATION: A PERSPECTIVE FOR HAWAII1

ABSTRACT: Surrounded by an ocean, the Hawaiian Islands are limited in their natural fresh water resources. The major readily developable potable sources are the high quality ground water sources which serve both domestic uses and sugarcane irrigation although irrigation water does not require as high a quality as drinking water. The increasing overall fresh water requirements for the island of Oahu will outstrip the potential yield of fresh ground water sources, as developed by present technology, by the year 2000 according to Honolulu Board of Water Supply projections. There are water shortage regions on other islands. Water reuse from sewage effluent for irrigation will augment natural water resources, furnish supplemental or alternative fertilizer, and reduce ocean water pollution and the costs of engineering systems. In cooperative field testing from 1971 to 1975, it was demonstrated that effluent can be applied as supplemental water for furrow irrigation of sugarcane without detriment to ground water quality and sugar yield. Studies are in progress to test different dilutions of effluent and its use with chemical ripeners to improve crop yield. Sugarcane plantations on Oahu, Maui, and Kauai are in various stages of water reuse by effluent irrigation. Reuse is presently practiced for irrigation of golf courses and is being planned for forage crops in Hawaii.     

四川某小区人工湿地中水回用技术

中水回用是提高生活用水重复利用率的主要形式。提高水的重复利用率,是实现城市污水资源化是解决水资源短缺的根本途径。人工湿地既具有景观价值,又有污水处理功能。可以为市政绿化、农田灌溉景观提供水资源。经人工湿地处理的中水水质,出水水质符合我国的城市杂用水水质标准(GB/T18920-2002)、景观环境用水水质标准(GB/T18920-2002)和农田灌溉水质标准(GB5084-2005)。     

Public acceptance potential for reuse applications in Turkey

The water reuse applications are becoming increasingly important in Turkey due to fresh water scarcity problems. However, the success of reuse practices depends on the public's acceptance. Therefore, this study was designed to determine the public awareness, and the potential for acceptance, of reuse applications in Turkey by way of a survey carried out for this purpose. 500 questionnaires were sent to different regions of Turkey and 375 of them were returned. The study indicated that both women and men have concerns about usage of wastewater, especially regarding the use of treated wastewater as drinking water. Results also showed that the area of greatest concern among the public is the health risks associated with recycled water. Respondents of both genders felt that treated wastewater reuse for applications not involving close personal contact was acceptable, due to reduced health risk concerns. On the other hand, the cost of reclamation is another major public concern.