The potential of cost-effective coconut husk for the removal of toxic metal ions for environmental protection

Coconut (Cocos nucifera) husk, an agricultural waste, has been thoroughly investigated for the removal of toxic Cd(II), Cr(III) and Hg(II) ions from aqueous media. The parameters like nature and composition of electrolyte, concentration of toxic ions, dosage of coconut husk, and equilibration time between the two phases were optimized for their maximum accumulation onto the solid surface. The effect of common ions on the uptake of metal ions has been monitored under optimal conditions. The variation of retention of each metal ion with temperature was used to compute the thermodynamic quantities DeltaH, DeltaS and DeltaG. The values 18.1+/-0.6 kJmol(-1), 74+/-2 Jmol(-1)K(-1), and -3.8+/-0.04 kJmol(-1) at 298 K; 10.8+/-0.8 kJmol(-1), 48.8+/-2.7 Jmol(-1)K(-1), and -4.6+/-0.3 kJmol(-1) at 298 K; and -37.4+/-2k Jmol(-1), 105+/-7 Jmol(-1)K(-1) and -2.58+/-0.5 kJmol(-1) at 298 K were obtained for Cd(II), Cr(III) and Hg(II) ions, respectively. The sorption data were analysed by applying different sorption isotherms. The sorption capacity and energy were evaluated for each metal ion. The values of the Freundlich constants 1/n and C(m) were 0.92+/-0.04 and 52.6+/-22.2 mmolg(-1); 0.85+/-0.05 and 56.0+/-0.03 mmolg(-1); and 0.88+/-0.03 and 6.84+/-0.45 mmolg(-1) for Cd(II) Cr(III) and Hg(II) ions, respectively. Similarly, the Dubinin-Radushkevich (D-R) constants beta, X(m,) and E were evaluated for the three metal ions. To check the selectivity of the sorbent, sorption of a number of elements was measured under similar conditions. Separation of Zn(II) from Cd(II); Cr(III) from I(I), Zr(IV), Se(IV), and Hg(II) from Se(IV) and Zn(II) can be achieved using this sorbent. This cheap material has potential applications in analytical chemistry, water decontamination, industrial effluent treatment and in pollution abatement.     

ABR反应器的碱度变化及调控研究

研究了折流厌氧反应器(ABR)运行中碱度的变化情况及其与ABR各格室中VFA、pH和COD变化之间的关系.结果表明,碱度沿程变化与反应器的VFA浓度变化密切相关,碱度和pH值的最低点出现在VFA浓度最高点.碱度条件是通过pH值影响系统的运行.ABR沿程碱度和pH值变化都存在一个先降低后上升的过程.碱度控制一般以保证ABR沿程最低pH值不低于6.0为准,6.5以上为佳.进水碱度的下限与反应器的进水浓度密切相关.在低负荷COD条件下[3.7 kg/(m³·d)],保持ABR运行良好的最低碱度为800 mg/L.     

乳化液废水均相催化湿式氧化动力学

在2L高压间歇反应釜中,以高浓度难降解乳化废水为处理对象,研究了温度对铜盐均相湿式氧化的影响和动力学特征.结果表明:升高温度对加快后期反应速度更为有利,催化剂有利于中间产物氧化,在200℃催化活性最高,在进水COD48 400mg/L,反应2h去除率为86.6%;催化剂在不同温度作用下机制有所差别:200℃时3个途径反应速度均加快,中间产物加速氧化更明显;220～240℃时反应向生成中间产物方向偏移,活性降低;通用模型能较好地预测均相催化过程.     

厌氧-好氧活性污泥法处理高浓度甲醇废水

介绍了厌氧一好氧活性污泥法处理电管厂高浓度甲醇废水的动态试验结果。试验结果表明：该方法处理高浓度甲醇废水,可以克服甲醇废水厌氧处理容易酸化的问题．运行稳定．抗负荷冲击性强．处理效果良好。     

草酸作用下海洋疏浚物中Cr的释放动力学研究

采用恒温振荡实验装置,系统研究了有机酸草酸降解海洋疏浚物中重金属Cr的动力学过程。结果表明,恒温振荡6 h后,浓度为0.05~0.4 mol/L的草酸可使Cr的释放百分率达到24%~44%。Cr的释放总体上可分为快速反应和慢速反应2个阶段,0~2 h为快反应阶段,解吸速率快,2~6 h后为慢反应阶段。草酸对Cr的释放动力学数据可用双常数方程很好的拟合,说明在草酸的存在下,疏浚物颗粒表面对Cr的释放可能更多表现出能量的不均匀性。温度升高时Cr的解吸量增加,反应速度加快,根据阿累尼乌斯公式估算出的活化能为26.53 kJ/mol。     

产酸脱硫反应器中碳硫比对群落生态特征的影响

通过产酸脱硫反应器处理高浓度含硫酸盐废水的连续流试验,从群落动态的角度研究碳硫比(COD/SO₄^2-)从4.2降低到2.0的过程中,pH值、氧化还原电位(ORP)、碱度(ALK)和末端产物(VFAs)组成、优势种群分布等群落生态特征的变化规律试验证明,在此过程中ORP和ALK提高,而pH值和VFAs中乙酸的分布比例降低,群落类型由高碳硫比稳定型转化为低碳硫比亚稳定型,但仍未改变乙酸型顶极群落的典型特征.     

产酸脱硫反应器中COD/SO42-比制约的群落生态演替规律

通过产酸脱硫反应器的动态试验和配套的静态试验,考察致变因子 COD/SO₄^2-比制约的乙酸型顶极群落的结构、优势种群的组成和生态演替的规律; 阐明乙酸型代谢和乙酸型顶极群落是产酸脱硫生态系统的典型特征;揭示乙酸型顶极群落内平衡与反馈调节的生理代谢机制,并以因变因子**pH值、氧化还原电位和碱度来表征生态演替过程中优势种群的三维实现生态位.     

Decontamination of Cr(VI) facilitated formation of persistent free radicals on rice husk derived biochar

PFRs were produced on biochar during Cr(VI) decontamination. PFRs formation on biochar was owing to the oxidization of phenolic-OH by Cr(VI). Appearance of excessive oxidant led to the consumption of PFRs on biochar. Biochar charred at high temperature possessed great performance to Cr(VI) removal. This study investigated the facilitation of Cr(VI) decontamination to the formation of persistent free radicals (PFRs) on rice husk derived biochar. It was found that Cr(VI) remediation by biochar facilitated the production of PFRs, which increased with the concentration of treated Cr(VI). However, excessive Cr(VI) would induce their decay. Biochar with high pyrolysis temperature possessed great performance to Cr(VI) removal, which was mainly originated from its reduction by biochar from Inductively Coupled Plasma Optical Emission Spectroscopy and X-ray Photoelectron Spectroscopy. And the corresponding generation of PFRs on biochar was primarily ascribed to the oxidization of phenolic hydroxyl groups by Cr(VI) from Fourier Transform Infrared Spectroscopy analysis, which was further verified by the H₂O₂ treatment experiments. The findings of this study will help to illustrate the transformation of reactive functional groups on biochar and provide a new insight into the role of biochar in environmental remediation.     

进口与国产COD消解测定仪测定废水COD的比对研究

应用消解分光光度法,比对了一款进口仪器和一款国产仪器应用于实际水样中COD含量测定的差异性。通过精密度、回收率、方法比对等实验分析得出,2款仪器应用电热消解分光光度法测定COD,实验结果与国标回流滴定法的实验结果基本一致,无显著性差异,具有可比性,可广泛用于水质评价和环境监测。与国产仪器相比,进口测定仪具有较小的偏差,较高的回收率。国产测定仪偏差较大的原因主要在于其比色装置,而不是用于前处理的消解装置。比较分析了2款仪器的购买和使用经济成本,为广大企事业及科研单位选用COD消解测定仪提供了有价值的基础数据和参考建议。     

600 MW机组低压转子叶片裂纹分析

针对某台600 MW亚临界参数汽轮机低压转子的末三级叶片(2Cr12NiMo1W1V钢)出汽侧裂纹进行了宏观形貌观察、化学成分分析、金相组织分析、室温冲击韧性试验、硬度试验，并对断口进行了扫描电镜及能谱分析。结果表明：此次开裂的低压转子叶片，是由于其化学成分Mo元素含量低于标准要求，导致材料的KISCC降低，以及硬度偏低造成裂纹扩展所需的外界启动应力降低，进而在运行过程中拉应力和湿蒸汽的氧化腐蚀共同作用下，发生了应力腐蚀开裂。