油田化学添加剂对污水处理系统腐蚀行为的影响

目的明确净水剂、絮凝剂、助凝剂、缓蚀剂对污水处理系统腐蚀行为的作用效果。方法通过工艺流程分析、腐蚀形貌观察、腐蚀产物成分分析、腐蚀失重测试等手段,分析污水处理系统腐蚀原因,考察油田化学添加剂对SSF污水处理系统腐蚀行为的影响。结果输送介质中溶解的二氧化碳、高浓度氯离子、氧是导致SSF净化装置内腐蚀的主要原因。分别添加质量浓度为150、0.3、60 mg/L的净水剂、絮凝剂、助凝剂后,动态腐蚀速率可从1.8544 mm/a降到0.6674、0.8627、0.3530 mm/a,静态腐蚀速率可从1.2515 mm/a降到0.9565、0.9474、0.6256 mm/a。添加160 mg/L缓蚀剂,动态腐蚀速率从1.8544 mm/a降低到0.0822 mm/a,静态腐蚀速率从1.2515 mm/a降低到0.0238 mm/a。同时添加净水剂、絮凝剂、助凝剂三种药剂,动态腐蚀速率为0.7672 mm/a,静态腐蚀速率为0.8742 mm/a;同时添加净水剂、絮凝剂、助凝剂、缓蚀剂四种药剂,动态腐蚀速率为0.3069 mm/a,静态腐蚀速率为0.0263 mm/a。结论添加缓蚀剂能有效控制SSF污水处理系统内腐蚀。污水处理用净水剂、絮凝剂、助凝剂对腐蚀有一定抑制作用。在动态条件下,净水剂、絮凝剂、助凝剂降低了缓蚀剂的缓蚀效果,在静态条件下,三种添加剂对缓蚀剂的缓蚀效果影响较小。     

Effect of nitrification inhibitor DMPP on nitrogen leaching, nitrifying organisms, and enzyme activities in a rice-oilseed rape cropping system

DMPP （3,4-dimethylpyrazole phosphate） has been used to reduce nitrogen （N） loss from leaching or denitrification and to improve N supply in agricultural land. However, its impact on soil nitrifying organisms and enzyme activities involved in N cycling is largely unknown. Therefore, an on-farm experiment, for two years, has been conducted, to elucidate the effects of DMPP on mineral N （NH4^＋- N and NO3^--N） leaching, nitrifying organisms, and denitrifying enzymes in a rice-oilseed rape cropping system. Three treatments including urea alone （UA）, urea ＋ 1% DMPP （DP）, and no fertilizer （CK）, have been carded out. The results showed that DP enhanced the mean NH4^＋-N concentrations by 19.1%-24.3%, but reduced the mean NO3^--N concentrations by 44.9%-56.6% in the leachate, under a two-year rice-rape rotation, compared to the UA treatment. The population of ammonia oxidizing bacteria, the activity of nitrate reductase, and nitrite reductase in the DP treatment decreased about 24.5%-30.9%, 14.9%-43.5%, and 14.7%-31.6%, respectively, as compared to the UA treatment. However, nitrite oxidizing bacteria and hydroxylamine reductase remained almost unaffected by DMPP. It is proposed that DMPP has the potential to either reduce NO3^--N leaching by inhibiting ammonia oxidization or N losses from denitrification, which is in favor of the N conversations in the rice-oilseed rape cropping system.     

硝化抑制剂的加量对生化需氧量值影响的探讨

BOD作为衡量水体受有机污染程度的重要指标,其反映的可生化降解性是其他参数无法替代的。在5日生化培养时间内,硝化作用的耗氧量取决于是否存在足够数量的能进行此种氧化作用的微生物,许多二级生化处理的出水和受污染较久的水体中,往往含有大量硝化微生物,因此测定这种水样时应抑制其硝化反应。通过对特定水体硝化抑制剂添加与否及加量多少对BOD5测定结果的影响,分析并探讨抑制特定水体硝化过程的最佳条件。在严格质量控制的基础上,对特定行业和环境水体的实际样品进行硝化抑制剂添加与否和加量及时间培养曲线等对比实验,通过所得到的比对数据以化学需氧量值与BOD5之间关系为基准,对硝化抑制剂的加量进行了探究。     

40吨转炉除尘水循环使用技术

承钢炼钢一厂4座40吨转炉采用湿法除尘,产量由20吨转炉改造扩产,但除尘水系统没有进行相应改造,系统能力一直不足,系统结垢严重。通过优化冷却水系统,进行适宜的水质稳定处理,解决了除尘水系统结垢问题。     

蜂窝陶瓷催化臭氧化降解水中痕量硝基苯的机理研究

实验考察了HCO3-、CO32-、HPO42-、H2PO4-和叔丁醇等羟基自由基抑制剂存在条件下,单独臭氧氧化和臭氧/蜂窝陶瓷氧化对水中硝基苯降解效果的影响规律,初步推测了反应机理.结果表明,2种工艺对硝基苯的去除率都随着HCO3-浓度的增加(0～200 mg·L-1)先增高再降低,在浓度为50 mg·L-1时去除率达到最大值;单独臭氧氧化和臭氧/蜂窝陶瓷对硝基苯的去除率随着CO32-浓度的增加(0～20 mg·L-1)分别降低了16.57%和27.52%,随着HPO42-浓度的增加(0～12 mg·L-1)分别降低了13.61%和17.52%,随着H2PO4-浓度的增加(0～120 mg·L-1)分别降低了6.61%和12.52%,随着叔丁醇浓度的增加(0～10mg·L-1)硝基苯去除率降低了30.06%和46.09%.证明单独臭氧氧化和臭氧/蜂窝陶瓷氧化对硝基苯的降解遵循·OH氧化机理,叔丁醇更适合作为自由基抑制剂用来推断单独臭氧氧化和臭氧/蜂窝陶瓷氧化降解硝基苯的反应机理.单独臭氧氧化对硝基苯的去除率随着pH值的升高(3.02～10.96)而增大,臭氧/蜂窝陶瓷氧化对硝基苯的去除率在pH=9.23时达到最大值.     

The human serum paraoxonase—Polymorphism and specificity

Human serum contains EDTA‐sensitive (Ca⁺⁺‐dependent) and EDTA‐stable (albumin) paraoxonases which hydrolyse paraoxon, 0,0‐diethyl,0–4‐nitrophenyl phosphate.

In Caucasians the EDTA‐sensitive enzyme shows a genetically determined polymorphism which is governed by two alleles. In typical Mongoloid or Negro populations this polymorphism is expressed to a lesser degree, and in a few samples (e.g. Aborigines) it cannot be observed at all. The distribution of the activity of the EDTA‐stable (albumin) paraoxonase is unimodal.

Many authors supposed that paraoxonase is an arylesterase (EC 3.1.1.2) which means that it is also able to hydrolyse phenylacetate or β‐naphthylacetate. New investigations have shown that the human serum fractions splitting paraoxon can be separated from those hydrolysing phenylacetate and related substrates.

The polymorphism of the EDTA‐sensitive human serum paraoxonase can be applied to investigations concerning specificity. From this it becomes evident that this enzyme is rather specific. Already slight changes of the paraoxon molecule lead to a decrease of activity. On the other hand the enzyme seems to hydrolyse also phosphonic acid esters and 4‐nitrophenylacetate in the same way like paraoxon (polymorphism).

There is a linkage relationship of paraoxonase with cystic fibrosis and DNA markers. According to these results the (EDTA‐sensitive) paraoxonase locus is on the human chromosome 7.

A high serum paraoxonase level actually protects serum cholinesterase (EC 3.1.1.8) and has to be considered in biological monitoring of workers exposed to parathion.     

可燃物爆炸抑制的研究现状及发展

从实验研究、数值模拟和微观反应机理三个方面概括总结了近年来可燃物爆炸抑制的研究现状,总结了现阶段的研究成果,指出了研究中存在的不足。实验研究主要涉及卤代烃、水、干粉这三种抑制剂,研究了这三种抑制剂的制效果及优缺点;理论计算主要阐述爆炸及其抑制的反应特性、反应机理,现阶段的理论研究以宏观反应机理为主,缺乏对爆炸及其抑制的微观机理的研究,对爆炸及其抑制的本质认识不够。基于以上原因,对今后的研究方向进行了展望。     

腐殖酸和产甲烷抑制剂对厌氧污泥发酵产氢效能的影响

为提高厌氧污泥的发酵产氢能力,采用间歇培养方式考察了不同产甲烷抑制剂与腐殖酸联合作用对厌氧污泥发酵葡萄糖产氢效能的影响,并通过Illumina MiSeq测序揭示了微生物群落结构的变化规律.结果表明,在葡萄糖初始浓度为500 mg·L^-1条件下,经过120 h的连续培养后,对照的累计产氢量为1.2 mL,存在明显的耗氢现象.当加入0.02%氯仿（V/V）、0.04%氯仿（V/V）或2-溴乙酸磺酸钠（10 mmol·L^-1）后,耗氢现象得到有效控制,它们的累计产氢量分别为15.7、13.2和9.4 mL.当向发酵系统同时加入产甲烷抑制剂和腐殖酸后,可以显著提高厌氧污泥的产氢效能.其中,0.02%氯仿和腐殖酸联合作用的促进效果最佳,其累计产氢量和最大产氢速率（R_max）分别达到了17.4 mL和0.24 mL·L^-1.相反,当替硝唑作为产甲烷抑制剂时,仍然存在耗氢现象.Illumina MiSeq测序结果表明,发酵系统中优势菌群的相对丰度存在显著差异.在对照系统中,Ottowia、Ignavibacterium、Nitrospira、Saccharibacteria_genera_incertae_sedis和Terrimona为优势菌群,其相对丰度为2.2%~4.2%.当0.02%氯仿和腐殖酸加入发酵系统后,Ottowia和Saccharibacteria_genera_incertae_sedis的相对丰度较对照分别增加了11.9%和31.8%,而Nitrospira的含量显著减少.     

新型膦磺酸阻垢缓蚀剂SEDMP的性能评定

对自制的新型膦磺酸阻垢缓蚀剂SEDMP对CaCO3和Ca3(PO4)2的阻垢性能进行评定。在SEDMP加入量为4 mg/L、浓缩至水溶液中Ca2+质量浓度为500 mg/L时,SEDMP对CaCO3的阻垢率为90.6%,对CaCO3的阻垢效果大大优于其他有机膦类阻垢剂。当SEDMP加入量为10 mg/L时,对Ca3(PO4)2的阻垢率为96.0%。SEDMP作为缓蚀剂单独使用时具有一定的缓蚀效果,与磺酸盐共聚物、锌盐复配后效果更佳。SEDMP与常用杀菌剂同时使用时仍可保持良好的对CaCO3的阻垢性能,且不影响杀菌剂的杀菌率。     

硬膜缓蚀剂对钛合金紧固件电偶腐蚀的防护作用研究

目的 研究YTF-3硬膜缓蚀剂对由TC4螺栓、不锈钢螺母、7050铝合金及TC4钛合金夹层板组成的组件电偶腐蚀的影响作用。方法 利用硬膜缓蚀剂对钛合金紧固件和夹层板进行整体腐蚀防护处理,并通过盐雾加速腐蚀试验。将齿轮槽螺栓与无耳托板自锁螺母安装连接后,进行自然环境加速腐蚀试验,腐蚀后对螺栓螺母以及夹层板的腐蚀情况进行拍照检查,采用图像处理方式对腐蚀情况进行评价,并通过室温拉伸试验对钛合金螺栓腐蚀前后的力学性能情况进行对比分析。结果 经过腐蚀试验后,TC4螺栓和铝合金组件刷涂缓蚀剂区域比未刷涂缓蚀剂区域的平均腐蚀面积要小。不锈钢螺母与TC4钛合金组件刷涂缓蚀剂区域出现明显褶皱和破损现象。对比了试验前后钛合金螺栓的最大拉断载荷,发现降幅仅为0.5%。结论 铝合金夹层板会遭受电偶腐蚀,而YTF-3缓蚀剂可以有效隔绝腐蚀介质渗入固定间隙,大幅缓解电偶腐蚀,而钛合金螺栓在加速腐蚀试验中并未发生明显的腐蚀,并且力学性能无明显改变。