化肥厂爆炸事故的不安全动作分析

为了分析化肥厂爆炸事故背后的不安全动作。本文选取了2009-2018年间国内外发生的52起典型化肥厂爆炸事故。从发生时间的角度分析事故特性,发现白昼期间的事故发生概率相对较高。同时文章分析了运输卸料、车间操作、特种作业和管理人员4种作业类型的不安全动作,从发生频率和风险等级两个方面评估了不安全动作的综合危险度。结果表明13项不安全动作的综合危险度较高,需要重点预控。     

氢氧化钽对水体中磷酸盐的吸附去除作用

采用氢氧化钽为吸附剂,对水中磷酸盐的吸附性能进行了研究,考察了吸附时间、pH值、磷酸盐的初始浓度、反应温度对吸附量的影响。实验结果表明:pH值越小,氢氧化钽对磷酸盐的吸附量越大,当pH值为2时氢氧化钽对磷酸盐的吸附性能优,并且pH值对磷酸盐的吸附量影响较大;磷酸盐的初始浓度越大,吸附量越大,吸附平衡时间越短;氢氧化钽对磷酸盐的吸附量和吸附速率都随着温度的升高而增加。在25℃、pH=2、初始浓度为200 mg/L、吸附30 min时达到平衡时最大吸附量为76.69 mg/g。吸附后的氢氧化钽红外谱图在1066 cm-1处出现特征峰,该峰恰好是吸附磷酸盐的伸缩振动峰,并且在638 cm-1与670 cm-1之间Ta-O键由于磷酸盐的吸附发生了蓝移。采用6 mol/L的NaOH对吸附了磷酸盐的氢氧化钽进行解吸,当pH=12时解吸率为52.45%。研究结果表明,氢氧化钽能够有效的去除水溶液中磷酸盐的吸附剂。     

营养条件对污水中小球藻生长及产能效应的影响

以过滤的富营养化的鱼塘废水为培养液,添加外源的碳、氮、磷元素,考察污水中不同的外源无机碳浓度、总氮浓度、总磷浓度对小球藻(Chlorella vulgaris)的生长、油脂含量和烃类含量的影响。在25℃、光照强度为4 500 Lux、光暗比为12L:12D的条件下培养10 d。单因子方差分析和多重比较结果表明:(1)以Na2CO3做碳源,小球藻生物量和烃类含量在外源无机碳浓度为6 mg/L时最高,油脂含量在外源无机碳浓度为12 mg/L最高。(2)以KNO3做氮源,小球藻生物量在总氮浓度为25 mg/L时最高,油脂含量在总氮浓度为15 mg/L时最高,烃含量在总氮浓度为20 mg/L时最高。(3)以KH2PO4做磷源,小球藻生物量和烃类含量在总磷浓度为2 mg/L时最高,油脂含量在总磷浓度为1.5 mg/L时最高。     

Mechanism of lead immobilization by oxalic acid-activated phosphate rocks

Lead (Pb) chemical fixation is an important environmental aspect for human health. Phosphate rocks (PRs) were utilized as an adsorbent to remove Pb from aqueous solution. Raw PRs and oxalic acid-activated PRs (APRs) were used to investigate the effect of chemical modification on the Pb-binding capacity in the pH range 2.0-5.0. The Pb adsorption rate of all treatments above pH 3.0 reached 90%. The Pb binding on PRs and APRs was pH-independent, except at pH 2.0 in activated treatments. The X-ray diffraction analysis confirmed that the raw PRs formed cerussite after reacting with the Pb solution, whereas the APRs formed pyromorphite. The Fourier Transform Infrared spectroscopy analysis indicated that carbonate (CO₃^2-) in raw PRs and phosphate (PO₄^3-) groups in APRs played an important role in the Pb-binding process. After adsorption, anomalous block-shaped particles were observed by scanning electron microscopy with energy dispersive spectroscopy. The X-ray photoelectron spectroscopy data further indicated that both chemical and physical reactions occurred during the adsorption process according to the binding energy. Because of lower solubility of pyromorphite compared to cerussite, the APRs are more effective in immobilizing Pb than that of PRs.     

鸟粪石法回收养猪废水中磷时pH对沉淀物组分的影响

采用鸟粪石沉淀法对养猪废水中的磷进行回收,应用红外光谱和X射线衍射法,并结合物料衡算研究pH变化对沉淀物组分的影响.结果表明,当pH由8.0升至9.0时,磷去除率从85%增加到94%;pH在9.0～11.0范围,磷去除率稳定在94%左右;当pH升高至12.0,磷去除率急剧下降至70％.沉淀物组分为鸟粪石(MgNH₄PO₄·6H₂O)、 钾型鸟粪石(MgKPO₄·6H₂O)、 Ca₃(PO₄)₂·xH₂O和Mg(OH)₂,不含有硫酸盐和碳酸盐.当pH<9.0,沉淀物组分主要为鸟粪石;pH在9.0～10.0范围时,鸟粪石含量降低,钾型鸟粪石、 Ca₃(PO₄)₂·xH₂O含量呈逐渐增加趋势;pH由10.0升至12.0时,鸟粪石含量急剧下降,Ca₃(PO₄)₂·xH₂O和Mg(OH)₂含量快速增加,而钾型鸟粪石快速增加并在pH 11.0达到最大后急剧下降.因此,回收养猪废水中的磷时要获得纯度高的鸟粪石产品,pH值应控制在8.0～9.0.     

Co-transport of dissolved organic matter and heavy metals in soils induced by excessive phosphorus applications

To evaluate the e ects of long-term applications of phosphorus fertilizers on mobility of dissolved organic matter (DOM) and heavy metals in agricultural soils, a sandy soil and a loamy soil were spiked with ammonium phosphate at application rates of 0, 25, 50, 100, 250, and 500 mg P per kilogram of soil. A series of 15-cm long soil columns were constructed by packing incubated soils of varying concentrations of P. The soil columns were consecutively leached by simulated rainfalls for six cycles. The contents of water extractable organic carbon in both sandy and loamy soils increased significantly with increasing rates of P applications. Relatively high rates of P applications could induce a marked increase in DOM concentrations in the leachates, the e ects were larger with the sandy soil rather than with the loamy soil. Applications of P changed the partitioning of trace metals in the soil solids and the soil solutions. The increased P application rates also seemed to elevate the leaching of Cu, Cd, and Zn from soils. The concentrations of Cu, Cd, and Zn in the leachates were positively correlated with DOM, probably due to the formation of metal-DOM complexes. In contrast, Pb concentrations in the leachates were negatively correlated with DOM, and decreased with increasing rates of P applications. The boosted leaching of DOM induced by high rates of P applications was probably due to the added phosphate ions competing for adsorption sites in the soil solids with the indigenous DOM.     

Releases of phosphate fertilizer industry in the surrounding environment: Investigation on heavy metals and polonium-210 in soil

Distribution of Cu,Zn,Pb,Cr,Ni,Mn concentrations and the activity of polonium-210 in the surrounding area of a phosphate fertilizer industry located on the eastern coast of the Mediterranean Sea has been determined.Nineteen sampling sites were distributed around the industrial zone on a surface area of about 100,000 m2.Atomic absorption spectroscopy and Alpha spectroscopy were used to quantify the heavy elements and polonium-210,respectively.Investigation on a particle scale was conducted by TEM and SEM coupled to EDX and X-ray cartography to determine the nature of heavy elements carriers and their distribution.Heavy elements were mainly concentrated inside the particle size fraction 50 μm.Their levels decreased with distance increasing from the industry.According to the reference soil,enrichment factors were about 10,15,32 and 100 times for Zn,Pb,Cu,and Cr,respectively inside the particle size fraction 50 μm on the closest sites to the industry.The main contaminant sources were transport and storage of row materials and the free release of phosphogypsum waste.Heavy elements were entrapped inside agglomerates of sulfates,phosphates and iron oxihydroxides in a di used shape.Polonium-210 with an enrichment factor of about 56,showed the same behavior of the spatial distribution of the trace elements.     

萃取-反萃法综合回收磷矿浮选尾矿中磷和镁

针对某磷矿浮选尾矿的资源特点,将其作为高镁低品位磷矿进行处理,用萃取-反萃法分离酸浸液中的镁和磷。选择正丁醇作为萃取剂,在磷酸浓度为30%、萃取相比为1:1,温度为常温,萃取时间为5min的均衡搅拌条件下,五氧化二磷萃取率可达68%以上;用水作为反萃剂,在其加入量为反萃前有机相体积的30%,反萃时间为3min,常温条件下进行反萃,反萃率可达90%以上。该研究为综合回收磷矿浮选尾矿提供了基础性资料,     

不同水分管理方式下水稻生长季N_2O排放量估算:模型验证和输入参数检验

利用2005～2007年我国稻田N2O排放通量的田间原位测定资料和国际上其它地区稻田N2O报道结果,对作者建立的不同水分管理方式下水稻生长季N2O排放估算模型进行了验证.结果表明,持续淹水稻田N2O排放的拟合结果与其他地区淹水稻田N2O通量值相一致.淹水-烤田-淹水的水分管理方式下,稻田N2O排放的拟合值接近于国际上同类研究结果.淹水-烤田-淹水-湿润灌溉的水分管理方式下,稻田N2O排放的估算模型对田间原位测定资料有很好的适切性.为了检验模型输入参数的可信度,将本研究建立的有关我国水稻生产的相关资料数据库与以往研究报道结果进行了比较,结果表明,两者具有高度的一致性.数据库资料表明,在20世纪50～70年代间,持续淹水稻田占20%～25%,大约75%～80%的稻田采用淹水-烤田-淹水的水分管理方式.在20世纪80～90年代间,采用持续淹水,淹水-烤田-淹水和淹水-烤田-淹水-湿润灌溉水分管理方式的稻田分别约占12%～16%、77%和7%～12%.20世纪50年代水稻生长季平均每季总施氮量为87.49 kg·hm-2,而90年代平均为224.64 kg·hm-2.其中,化学氮肥的施用量从20世纪50年代的37.4 kg·hm-2增加到了90年代的198.8 kg·hm-2,分别占水稻生长季氮输入总量的43%和88%.在20世纪50～70年代间有机氮的输入量相对比较稳定,平均变幅在45.2～48.2 kg·hm-2之间,随后逐步降低,有机肥料氮占氮输入总量的比例从20世纪50年代的52%降低到了90年代的9%.作物残体N输入量从20世纪50年代的4.9 kg·hm-2增加到了80年代的6.3 kg·hm-2.20世纪50～70年代水稻生长季氮肥施用量具明显的空间变异性,而80～90年代间其空间变异较小.模型验证和输入参数检验的结果表明,该模型能较好地模拟我国不同水分管理方式下的稻田N2O直接排放量.     

活化赤泥去除猪场废水生化处理出水中的磷和重金属

以铝矿工业废渣赤泥为原材料,采用焙烧活化方法进行活化处理,并将其用于畜禽废水生化处理出水中磷和重金属的吸附去除.同时,研究考察了吸附剂除磷、除重金属的能力以及投加量、pH值和反应时间对去除效果的影响.结果表明,赤泥和活化赤泥对磷、铜、锌、砷吸附规律符合Langmuir吸附等温方程;焙烧改性后,赤泥对磷、铜、锌、砷的去除能力显著提高,900℃焙烧活化饱和吸附量可分别由46.26、18.18 、15.45、18.83 mg·g-1提高至149.00、65.17、99.20、27.51 mg·g-1;pH显著影响除磷、除重金属的效果,高pH条件有利于磷、铜、锌、砷的去除;赤泥和活化赤泥除磷、铜、锌、砷的作用机理包含金属氧化物表面的表面络合作用机理,其对砷和磷的去除机理还包括共沉淀作用.