制备方法对MgAl水滑石衍生氧化物负载钯催化剂丙烷完全氧化活性的影响

以沉积沉淀法(DP)、浸渍法(IM)和共沉淀法(CP)制备MgAl水滑石衍生氧化物负载钯催化剂,用ICP、XRD、SEM、TEM、EDS、TPR以及比表面测定等手段对催化剂进行了表征.ICP和XRD数据表明用上述3种方法均可成功制备水滑石为前体载钯催化剂.SEM、TEM、EDS数据表明不同方法制备的样品具有不同的形貌以及钯在其中的分散度.综合各类表征数据可知Pd在催化剂中暴露的活性位是影响其活性的主要因素.     

环氧丙烷储罐空气泡沫灭火试验研究

环氧丙烷为低沸点水溶性可燃液体,由于其饱和蒸汽压大,灭火困难,此前,国内外未对环氧丙烷进行过大型工程应用灭火试验研究。为研究空气泡沫对环氧丙烷储罐的灭火性能,分别对环氧丙烷进行了0．25m^2油盘探索性试验、1．73m^2油盘泡沫灭火剂选型试验和直径3．5m储罐工程应用灭火试验。试验结果表明,空气泡沫难以扑灭环氧丙烷储罐火灾,在直径3．5m储罐上,虽然采用了灭火性能较好的泡沫液,且使用了较大的供给强度和较长的供给时问,但仍难灭火。在试验基础上,对环氧丙烷储罐的消防要求提出了建议。     

Propane oxidation and steam reforming over Pd/LaFe(0.8) Co(0.2) O3 catalyst: effects of the reactant composition and steam

The effects of reactant composition and steam on propane combustion over Pd/LaFe0.8Co0.2O3 catalyst were investigated.Propane conversion and the oxidation state of palladium were strongly affected by the redox ration of reactants.Higher propane conversion could be obtained under rich conditions and explained as a complex balance between oxidation and steam reforming.Water produced in the oxidation could promote the propane conversion by steam reforming.However,the presence of excess steam would bring about inhibition.     

活性污泥法+接触氧化法工艺处理高盐度环氧丙烷生产废水的试验研究

采用活性污泥法和接触氧化两段工艺对高含盐的环氧丙烷生产废水进行处理，同时研究了不同水力停留时间的处理效果和不同的盐度对处理效果的影响。试验结果表明CODcr的去除率可以达84．38％，出水CODcr＜160mg／L，pH＜8。     

An investigation of a heat pump system using CO2/propane mixture as a working fluid

In order to decrease the heat rejection pressure of heat pump using pure working fluid, CO₂ or R744, other natural component including hydrocarbons (R290, R600a, R600, R1270, R170, R601) and dimethyl ether (RE170) is added to CO₂, respectively, and then six binary mixtures are achieved. By environmental and thermodynamic comparisons, R290 is selected to be the most appropriate component candidate to mix with CO₂, and meanwhile to weaken the flammability and explosivity for pure R290. Then, the system performances of heat pump using mixture of CO₂ and R290 were experimentally studied when R290 is added to CO₂ with a small fraction, and compared with that of the pure CO₂. The experimental test rig is designed and set up for the transcritical heat pump system. When the refrigerant charge is variable, the heating coefficient performance, optimum heat rejection pressure, compressor power, mass flow rate of refrigerant, and total heat coefficient of gas cooler were researched. The variation ratios of heating coefficient performance and heating capacity with deviation from the optimum refrigerant charge were also investigated. The optimum refrigerant charge of CO₂/R290 is obtained and the research results show that the addition of R290 to CO₂ can efficiently reduce the heat rejection pressure and improve the system performance. The results in the present work could provide useful guidelines for the design and operation of heat pump system using CO₂-based mixture.     

氯醇化法环氧丙烷生产中的循环经济探索

从传统的氯醇化法环氧丙烷生产工艺和存在的环保问题入手,结合国内外对环氧丙烷循环经济和清洁生产新技术的研究,对循环经济的新技术进行清洁性分析,提出该技术可以从源头削减污染物产量,提高物料的循环利用率、水的综合利用率,符合清洁生产原则。     

Effects of tungsten oxide on the activity and thermal stability of a sulfate-derived titania supported platinum catalyst for propane oxidation

A Pt/WO₃/TiO₂ catalyst for propane oxidation was prepared by a stepwise wet impregnation method, and was aged at 800℃ for 5 hr. Compared to the sulfate-derived titania supported catalyst, the introduction of tungsten oxide as stable Bronsted acid sites led to the formation of more metallic platinum active sites at the Pt/WO₃ interface. The dissociation of surface intermediates for propane oxidation was promoted on the WO₃-modified catalyst. This, as well as the inhibition effects of tungsten oxide on the sintering of anatase and the phase transformation to rutile, resulting in a high activity and thermal stability for the Pt/WO₃/TiO₂ catalyst.     

丙烷扩散火焰燃烧光谱特性研究*

为实现烃类火灾事故的光谱辨识,对丙烷火焰燃烧初期过程中的光谱特性进行实验研究,利用拉曼光谱仪等设备采集、提取丙烷扩散火焰光谱数据。分析燃烧初期OH*,C2*,CH*,H2O分子谱带范围及特征峰值分布特性,揭示谱带光谱特征强弱的主要原因,阐述沿火焰轴向与径向C2*,CH*以及H2O分子光谱峰值强度的分布特性。研究结果表明:丙烷火焰特征光谱主要分布在可见光与近红外波段,250~380 nm的近紫外波段光谱强度较弱。C2*的509.4,512.8,810.5 nm特征谱带,CH*的431.4 nm谱带以及H2O分子的586.2,652.2 nm处振动-转动谱带可作为丙烷火焰燃烧的关键特征光谱,为烃类火灾的早期识别与防控提供光谱实验依据。     

处理环氧氯丙烷废水工程实践

采用调节-中和-沉淀-稀释的预处理,好氧水解-接触氧化生物法处理环氧氯丙烷高含盐生产废水,实际调试运行情况表明,稀释后控制生化池Cl-浓度4~6g/L,环氧氯丙烷废水处理能够达到出水COD≤300mg/L、PH 6~9、SS≤200mg/L的排放标准。     

室内丙烷连续泄漏扩散浓度变化的数值模拟

探究室内气体燃料泄漏后的扩散特性及危害范围的影响,采用CFD软件FLUENT对室内丙烷连续泄漏扩散浓度变化过程进行数值模拟,研究丙烷的浓度场分布和爆炸浓度范围的变化规律。结果表明:水平射流运动和重力对气体的扩散有显著的影响;墙壁对气体的扩散有阻碍作用,在近壁面处形成高浓度区域;爆炸危险区随泄漏时间的增加而先增大后减小。