Advanced nitrogen removal by pulsed sequencing batch reactors (SBR) with real-time control

The feasibility of pH and oxidation reduction potential (ORP) as on-line control parameters to advance nitrogen removal in pulsed sequencing batch reactors (SBR) was evaluated. The pulsed SBR, a novel operational mode of SBR, was utilized to treat real municipal wastewater accompanied with adding ethanol as external carbon source. It was observed that the bending-point (apex and knee) of pH and ORP profiles can be used to control denitrification process at a low influent C/N ratio while dpH/dt can be used to control the nitrification and denitrification process at a high influent C/N ratio. The experimental results demonstrated that the effluent total nitrogen can be reduced to lower than 2 mg/L, and the average total nitrogen (TN) removal efficiency was higher than 98% by using real-time controll strategy.     

复合自养反硝化材料处理低碳氮比硝酸盐污水

作为一种典型的硝酸盐污水,低碳氮比硝酸盐污水的存在具有广泛性,且对生态环境和居民健康带来的危害日益突出.本研究构建了复合硫自养反硝化(CSAD)体系,基于硫-碳酸钙型复合材料与微生物,进行低碳氮比硝酸盐污水的深度处理,分析了材料投加量、粒径以及进水硝酸盐浓度对CSAD的影响,并探究了硝酸盐去除的动力学行为.结果 表明,...     

应用在线传感器实现前置反硝化工艺生物脱氮的过程控制

为了实现前置反硝化工艺硝化反硝化反应的过程控制,系统地研究了硝化反硝化过程中DO、pH和ORP的变化规律,并考察了它们作为硝化反硝化过程控制参数的可行性.结果表明,pH值在缺氧区的变化分为下降型和上升型,从而指示系统反硝化反应进行的程度以及内循环回流量是否充足;缺氧区末端ORP值和硝酸氮浓度具有较好的相关性;好氧区第1格室的DO浓度可以指示进水氨氮负荷高低;pH值在好氧区的变化也可分为下降型和上升型,可指示系统硝化反应进行的程度、曝气量和碱度是否充足;好氧区末端ORP值与出水氨氮、硝酸氮浓度具有很好的相关性.在此基础上建立了硝化反硝化反应在线控制系统,从而实现曝气量、内循环回流量和外碳源投加量的在线控制,提高系统出水水质、降低运行费用.图7表1参8     

Scrap Iron Filings assisted nitrate and phosphate removal in low C/N waters using mixed microbial culture

• Microbes enhance denitrification under varying DO concentrations and SIF dosages. • Abiotic nitrate reduction rates are proportional to SIF age and dosage. • Over 80% of the simultaneously loaded NO₃⁻-N and PO₄³⁻ is removed biologically. This study focuses on identifying the factors under which mixed microbial seeds assist bio-chemical denitrification when Scrap Iron Filings (SIF) are used as electron donors and adsorbents in low C/N ratio waters. Batch studies were conducted in abiotic and biotic reactors containing fresh and aged SIF under different dissolved oxygen concentrations with NO₃⁻-N and/or PO₄^3- influent(s) and their nitrate/phosphate removal and by-product formations were studied. Batch reactors were seeded with a homogenized mixed microbial inoculum procured from natural sludges which were enriched over 6 months under denitrifying conditions in the presence of SIF. Results indicated that when influent containing 40 mg/L of NO₃⁻-N was treated with 5 g SIF, 79.9% nitrate reduction was observed in 8 days abiotically and 100% removal was accomplished in 20 days when the reactor was seeded. Both abiotic and seeded reactors removed more than 92% PO₄³⁻ under high DO conditions in 12 days. Abiotic and biochemical removal of NO₃⁻-N and abiotic removal of PO₄³⁻ were higher under independent NO₃⁻-N/PO₄³⁻ loading, while 99% PO₄^3- was removed biochemically under combined NO₃⁻-N and PO₄³⁻ loading. This study furthers the understandings of nitrate and phosphate removal in Zero Valent Iron (ZVI) assisted mixed microbial systems to encourage the application of SIF-supported bio-chemical processes in the simultaneous removals of these pollutants.     

Preliminary study of groundwater denitrification using a composite membrane bioreactor

A composite membrane bioreactor (CMBR) integrating the immobilized cell technique and the membrane separation technology was developed for groundwater denitrification. The CMBR had two well mixed compartments with one filled with the nitrate- containing influent and the other with a dilute ethanol solution; the compartments were separated by the composite membrane consisting of a microporous membrane facing the influent and an immobilized cell membrane facing the ethanol solution. Nitrate and ethanol molecules diffused from the respective compartments into the immobilized cell membrane where nitrate was reduced to gaseous nitrogen by the denitrifying bacteria present there with ethanol as the carbon source. The microporous membrane was attached to one side of the immobilized cell membrane for retention of the disaggregated bacteria. Relative to the single dose of external ethanol, the two-dose supplementation produced better treatment results as evidenced by the lower concentrations of NO3--N and ethanol (as measured by total organic carbon) of the effluent. The batch treatment in CMBR removed most of the nitrate in the influent and attained a stable denitrification rate of 0.1 g·m^-2·h^-1 for most of the 96-h cycles during the 30-cycle study. The effluent was essentially free of ethanol and nitrite nitrogen.     

Process evaluation of an alternating aerobic-anoxic process applied in a sequencing batch reactor for nitrogen removal

In order to improve the nitrogen removal efficiency and save operational cost, the feasibility of the alternating aerobic-anoxic process (AAA process) applied in a sequencing batch reactor (SBR) system for nitrogen removal was investigated. Under sufficient influent alkalinity, the AAA process did not have an advantage over one aerobicanoxic (OAA) cycle on treatment efficiency because microorganisms had an adaptive stage at the alternating aerobic-anoxic transition, which would prolong the total cycling time. On the contrary, the AAA process made the system control more complicated. Under deficient influent alkalinity, when compared to OAA, the AAA process improved treatment efficiency and effluent quality with NH₄ ⁺-N in the effluent below the detection limit. In the nitrification, the average stoichiometric ratio between alkalinity consumption and ammonia oxidation is calculated to be 7.07 mg CaCO₃/mg NH₄ ⁺-N. In the denitrification, the average stoichiometric ratio between alkalinity production and NO₃ ^?-N reduction is about 3.57 mg CaCO₃/mg NO₃ ^?-N. As a result, half of the alkalinity previously consumed during the aerobic nitrification was recovered during the subsequent anoxic denitrification period. That was why the higher treatment efficiency in the AAA process was achieved without the supplement of bicarbonate alkalinity. If the lack of alkalinity in the influent was less than 1/3 of that needed, there is no need for external alkalinity addition and treatment efficiency was the same as that under sufficient influent alkalinity. Even if the lack of alkalinity in the influent was more than 1/3 of that needed, the AAA process was an optimal strategy because it reduced the external alkalinity addition and saved on operational cost.     

两种电化学-硫自养集成脱硝工艺的对比

研究了两种电化学 硫自养集成脱硝工艺去除饮用水中的硝酸盐 ,结果表明 ,在同样的条件下 ,当无石灰石反应器的最小电流高于石灰石反应器约 2mA时 ,两种反应器均能取得 90 %以上的NO-3 N去除率 ,并且反应器出水中不存在NO-2 N的积累 .同时 ,无石灰石反应器硫段出水中Ca2 的浓度没有增加 ,避免了出水中的硬度问题 ;而石灰石反应器硫段出水中Ca2 的浓度有所增加 ,造成电化学段的除垢负担 .在同样水力停留时间下 ,无石灰石反应器出水中SO2 -4 的浓度低于石灰石反应器约 1 5mg·l- 1 ;电流高于 3mA时 ,两种反应器出水的pH值均维持在 7左右 .另外 ,无石灰石反应器的出水指标优于石灰石反应器 ,表明在两种集成工艺中 ,硫自养段不填充石灰石的集成工艺优于硫段装填石灰石的集成工艺 .     

Nitrification and denitrification in biological activated carbon filter for treating high ammonia source water

Since the ammonia in the effluent of the traditional water purification process could not meet the supply demand, the advanced treatment of a high concentration of NH₄ ⁺-N micro-polluted source water by biological activated carbon filter (BACF) was tested. The filter was operated in the downflow manner and the results showed that the removing rate of NH₄ ⁺-N was related to the influent concentration of NH₄ ⁺-N. Its removing rate could be higher than 95% when influent concentration was under 1.0 mg/L. It could also decrease with the increasing influent concentration when the NH₄ ⁺-N concentration was in the range from 1.5 to 4.9 mg/L and the dissolved oxygen (DO) in the influent was under 10 mg/L, and the minimum removing rate could be 30%. The key factor of restricting nitrification in BACF was the influent DO. When the influent NH₄ ⁺-N concentration was high, the DO in water was almost depleted entirely by the nitrifying and hetetrophic bacteria in the depth of 0.4 m filter and the filter layer was divided into aerobic and anoxic zones. The nitrification and degradation of organic matters existed in the aerobic zone, while the denitrification occurred in the anoxic zone. Due to the limited carbon source, the denitrification could not be carried out properly, which led to the accumulation of the denitrification intermediates such as NO₂ ^?. In addition to the denitrification bacteria, the nitrification and the heterotrophic bacteria existed in the anoxic zone.     

Feedforward control for nitrogen removal in a pilot-scale anaerobic-anoxic-oxic plant for municipal wastewater treatment

To improve the efficiency of nitrogen removal with lower energy consumption, the study of feedforward control was carried out on a pilot-scale anaerobic-anoxic-oxic (AAO) plant for the treatment of municipal wastewater. The effluent qualities of the pilot plant under different control strategies were investigated. The results indicated that the change of external recycle was not a suitable approach to regulate the sludge concentration of plug-flow reactors; adjusting the aeration valve and dissolved oxygen set-point according to ammonia load could overcome the impact of influent fluctuation; and the denitrification potential could be estimated based on the transit time of anoxic zone and the relative content of carbon resource entering the anoxic zone. Simple feedforward control strategies for aeration and internal recycle were subsequently proposed and validated. The nitrogen removal was successfully improved in the pilot plant. The effluent total nitrogen had decreased by 29.9% and was steadily controlled below 15 mg·L^-1. Furthermore, approximately 38% of the energy for aeration had been saved.     

Factors affecting simultaneous nitrification and denitrification in an SBBR treating domestic wastewater

An aerobic sequencing batch biofilm reactor (SBBR) packed with Bauer rings was used to treat real domestic wastewater for simultaneous nitrification and denitrification. The SBBR is advantageous for creating an anoxic condition, and the biofilm can absorb and store carbon for good nitrification and denitrification. An average concentration of oxygen ranging from 0.8 to 4.0 mg/L was proved very efficient for nitrification and denitrification. Volumetric loads of TN dropped dramatically and effluent TN concentration increased quickly when the concentration of average dissolved oxygen was more than 4.0 mg/L. The efficiency of simultaneous nitrification and denitrification (SND) increased with increasing thickness of the biofilm. The influent concentration hardly affected the TN removal efficiency, but the effluent TN increased with increasing influent concentration. It is suggested that a subsequence for denitrification be added or influent amount be decreased to meet effluent quality requirements. At optimum operating parameters, the TN removal efficiency of 74%–82% could be achieved.     

不同进水有机物浓度下移动床生物膜反应器(SBMBBR)脱氮除磷特性

考察了不同进水有机物浓度下厌氧/好氧序批式移动床生物膜反应器（SBMBBR）污染物去除特性,实验结果表明,SBMBBR能够实现低碳源污水中氮和磷的同步去除,在进水TN和TP浓度分别为116.7 mg.L-1和11.5 mg.L-1、COD浓度为456 mg.L-1的条件下,TN和TP去除率分别达到94.3%和92.2%以上.反应器除磷是基于常规生物除磷和反硝化除磷过程实现的,脱氮主要是基于好氧段发生的同时硝化反硝化（SND）作用而完成.由于生物膜内部存在的DO扩散梯度,在好氧阶段混合液DO浓度不断提高的条件下反应器内具有良好SND反应的发生.进水COD浓度由149 mg.L-1提高至456 mg.L-1的过程中,反应器硝化效果不变,反硝化和除磷效果改善.反应器在好氧阶段pH值基本维持在7.0—7.1之间,为各类菌群的生长创造了条件.碱度变化较pH值更能反映硝化和反硝化反应发生的程度.反应器中微生物相丰富,生物膜以丝状菌为骨架,其上附着大量的球状菌和杆状菌,而悬浮活性污泥中丝状菌较少,形成了由细菌、真菌到原生动物和后生动物的复杂的生态体系,为系统取得稳定的污水处理效果提供了有效的保证.     

Combined process of biofiltration and ozone oxidation as an advanced treatment process for wastewater reuse

The effluent of a wastewater treatment plant was treated in a pilot plant for reclaimed water production through the denitrification biofilter (DNBF) process, ozonation (O₃), and biologic aerated filtration (BAF). The combined process demonstrated good removal performance of conventional pollutants, including concentrations of chemical oxygen demand (27.8 mg·L⁻¹) and total nitrogen (9.9 mg·L⁻¹) in the final effluent, which met the local discharge standards and water reuse purposes. Micropollutants (e.g., antibiotics and endocrine-disrupting chemicals) were also significantly removed during the proposed process. Ozonation exhibited high antibiotic removal efficiencies, especially for tetracycline (94%). However, micropollutant removal efficiency was negatively affected by the nitrite produced by DNBF. Acute toxicity variations of the combined process were estimated by utilizing luminescent bacteria. Inhibition rate increased from 9% to 15% during ozonation. Carbonyl compound concentrations (e.g., aldehydes and ketones) also increased by 58% as by-products, which consequently increased toxicity. However, toxicity eventually became as low as that of the influent because the by-products were effectively removed by BAF. The combined DNBF/O₃/BAF process is suitable for the advanced treatment of reclaimed water because it can thoroughly remove pollutants and toxicity.     

1株贫营养好氧反硝化菌的分离鉴定及其脱氮特性

从水库底泥样品中,以硝酸盐为唯一氮源进行驯化、分离筛选出1株能在贫营养及好氧条件下进行高效反硝化的菌株PY8,经过电镜形态学观察、生理生化和16S rDNA序列分析,并基于16SrDNA序列结果,构建了该菌株的系统发育树,最终确定菌株PY8为根瘤菌Rhizobiumsp.。考察了初始pH值、温度、C/N、初始硝酸钠质量浓度、投菌量对菌株PY8硝酸盐还原活性的影响,以及该菌株的异养硝化性能。结果表明,在pH6.0～10.0,温度25～30℃,C/N1.0～9.0,初始硝酸钠质量浓度0.01～0.50g·L-1,投菌量1%～15%时,菌株PY8培养72h后的硝氮去除率可达到95%以上。另外,该菌株具有同时硝化-反硝化作用,在培养过程中氨氮去除率可达到58%左右。实验结果表明,菌株PY8在微污染水体生物脱氮领域中具有很大的应用潜力。     

二级SBR法处理高浓度氨氮化工废水研究

用直接活性污泥法完成了各反应器的污泥驯化启动。二级ＳＢＲ工艺主要由硝化ＳＢＲ和反硝化ＳＢＲ反应器构成，其中硝化ＳＢＲ反应器采用悬浮生长法和固定生物膜法两种工艺作对比试验。结果表明，后者较前者具有更大的ＮＨ３－Ｎ容积负荷，最大可达７６６．５４ｍｇＬ＾－１ｄ＾－１；而且能节省碱的消耗量１１．０％～３８．７％和反硝化所需碳源量为３０％～４０％。在ｔＨＲ为２４ｈ的条件下，二级ＳＢＲ法能处理ρＩｎ（ＮＨ３－     

Effect of denitrifying bacteria on the electrochemical reaction of activated carbon fiber in electrochemical biofilm system

An electrochemical-activated denitrifying biofilm system consisting of activated carbon fiber electrodes immobilized with denitrifying bacteria film as cathode was studied. A revised model for an electrochemical-activated denitrifying biofilm was developed and validated by electrochemical analysis of cathodal polarization curves and nitrate consumption rate. The cathodal polarization curve and nitrate consumption rate were introduced to verify the rate of electrochemical reaction and the activity of denitrifying bacteria, respectively. It was shown that the denitrification process effectively strengthened the electrochemical reaction while the electron also intensified denitrification activity. Electron was transferred between electrochemical process and biological process not only by hydrogen molecule but also by new produced active hydrogen atom. Additionally, a parameter of apparent exchange current density was deprived from the cathodal polarization curve with high overpotential, and a new bio-effect current density was defined through statistical analysis, which was linearly dependent to the activity of denitrification bacteria. Activated carbon fiber (ACF) electrode was also found to be more suitable to the electrochemical denitrifying system compared with graphite and platinum.     

A/O-MBR处理某经济区市政污水的效能

采用A/O-MBR法处理某经济区市政污水,对其进、出水的水质进行连续监测,考察系统稳定性和处理效果。结果表明,在水力停留时间12小时,污泥龄30天,回流比75%,好氧段DO浓度1.3～8.5 mg/L的条件下,系统对COD、氨氮、总氮、总磷的平均去除率分别为92.04%、93.66%、78.04%、91.06%。反硝化...     

Effects of restoration and reflooding on soil denitrification in a leveed Midwestern floodplain.

River floodplains have the potential to remove nitrate from water through denitrification, the anaerobic microbial conversion of nitrate to nitrogen gas. An important factor in this process is the interaction of river water with floodplain soil; however, many rivers have been disconnected from their historic floodplains by levees. To test the effect of reflooding a degraded floodplain on nitrate removal, we studied changes in soil denitrification rates on the Baraboo River floodplain in Wisconsin, USA, as it underwent restoration. Prior to this study, the site had been leveed, drained, and farmed for more than 50 years. In late fall 2002, the field drainage system was removed, and a gate structure was installed to allow controlled flooding of this site with river water. Soil moisture was extremely variable among zones and months and reflected local weather. Soil organic matter was stable over the study period with differences occurring along the elevation gradient. High soil nitrate concentrations occurred in dry, relatively organic-poor soil samples and, conversely, all samples with high moisture soils characterized by low nitrate. We measured denitrification in static cores and potential denitrification in bulk samples amended with carbon and nitrogen, one year before and two years following the manipulation. Denitrification rates showed high temporal and spatial variability. Static core rates of individual sites ranged widely (from 0.00 to 16.7 microg N2O-N x [kg soil](-1) x h(-1), mean +/- SD = 1.10 +/- 3.02), and denitrification enzyme activity (DEA) rates were similar with a slightly higher mean (from 0.00 to 15.0 microg N2O-N x [kg soil](-1) x h(-1), 1.41 +/- 1.98). Denitrification was not well-correlated with soil nitrate, organic matter content, or moisture levels, the three parameters typically thought to control denitrification. Static core denitrification rates were not significantly different across years, and DEA rates decreased slightly the second year after restoration. These results demonstrate that restored agricultural soil has the potential for denitrification, but that floodplain restoration did not immediately improve this potential. Future floodplain restorations should be designed to test alternative methods of increasing denitrification.     

硫／石灰石滤柱的自养反硝化动力学模型

本文对用硫作为电子供体，硝酸盐作为电子受体，由脱氮硫杆菌进行的自养反硝化过程的动力学模型进行了研究。结果表明，硝酸盐在滤料表面生物膜中的扩散过程对硫／石灰石滤柱的反硝化动力学影响很大。若扩散速率慢，硝酸盐只能穿过生物膜的一部分，则滤柱的反硝化速率遵循１／２级反应动力学；若扩散速率快，硝酸盐能穿过整个生物膜，则滤柱的反硝化速率遵循零级反应动力学。     

三种生物除磷工艺的比较

比较了Ａ／Ｏ法、Ａ＾２／Ｏ法和ＳＢＲ法生物除磷工艺。结果表明，它们的除磷效果好；污染含磷量达６％以上、除磷系数达０．０４左右，是常规好氧生物处理的３倍。在系统除磷系数相同的条件下，Ａ＾２／Ｏ法取好，是常规好氧法的３倍；ＳＢＲ法次之，高速率Ａ／Ｏ法因不能经反硝化作用脱氮，去氮效果与常规好氧法相同。     

低溶解氧条件下生物脱氮研究中的新现象

活性污泥法中 ,曝气主要起供氧和扰动混合的作用 ,曝气提供的氧被微生物用来氧化有机物并合成细胞 .反应器中的溶解氧 (DO)浓度是重要的运行参数 ,曝气池中DO偏低 ,好氧微生物不能正常生长和代谢 ;DO过高 ,不仅能耗增加 ,而且细菌的活力也会降低 .一般要求曝气池中DO不低于 2mgL-1的水平 ,但在实践中常常会出现曝气强度过高的情况 .因而有必要通过有效手段将DO控制在适当的水平 ,既不影响微生物的正常生长和有机物的去除 ,同时又避免过多能耗 .传统观点认为 ,低DO条件会促进丝状菌生长 ,破坏污泥絮体的沉降性能 ;使胞外多聚物的产生量…