Nitrification and denitrification in biological activated carbon filter for treating high ammonia source water

Since the ammonia in the effluent of the traditional water purification process could not meet the supply demand, the advanced treatment of a high concentration of NH₄ ⁺-N micro-polluted source water by biological activated carbon filter (BACF) was tested. The filter was operated in the downflow manner and the results showed that the removing rate of NH₄ ⁺-N was related to the influent concentration of NH₄ ⁺-N. Its removing rate could be higher than 95% when influent concentration was under 1.0 mg/L. It could also decrease with the increasing influent concentration when the NH₄ ⁺-N concentration was in the range from 1.5 to 4.9 mg/L and the dissolved oxygen (DO) in the influent was under 10 mg/L, and the minimum removing rate could be 30%. The key factor of restricting nitrification in BACF was the influent DO. When the influent NH₄ ⁺-N concentration was high, the DO in water was almost depleted entirely by the nitrifying and hetetrophic bacteria in the depth of 0.4 m filter and the filter layer was divided into aerobic and anoxic zones. The nitrification and degradation of organic matters existed in the aerobic zone, while the denitrification occurred in the anoxic zone. Due to the limited carbon source, the denitrification could not be carried out properly, which led to the accumulation of the denitrification intermediates such as NO₂ ^?. In addition to the denitrification bacteria, the nitrification and the heterotrophic bacteria existed in the anoxic zone.     

Advanced nitrogen removal using pilot-scale SBR with intelligent control system built on three layer network

Since eutrophication has become increasingly severe in China, nitrogen and phosphorous have been the concern of wastewater treatment, especially nitrogen removal. The stabilization of the intelligent control system and nitrogen removal efficiency were investigated in a pilot-scale aerobic-anoxic sequencing batch reactor (SBR) with a treatment capacity of 60 m³/d. Characteristic points on the profiles of dissolved oxygen (DO), pH, and oxidation reduction potential (ORP) could exactly reflect the process of nitrification and denitrification. Using the intelligent control system not only could save energy, but also could achieve advanced nitrogen removal. Applying the control strategy water quality of the effluent could stably meet the national first discharge standard during experiment of 10 months. Even at low temperature (t = 13°C), chemical oxygen demand (COD) and total nitrogen (TN) in the effluent were under 50 and 5 mg/L, respectively.     

Factors affecting simultaneous nitrification and denitrification in an SBBR treating domestic wastewater

An aerobic sequencing batch biofilm reactor (SBBR) packed with Bauer rings was used to treat real domestic wastewater for simultaneous nitrification and denitrification. The SBBR is advantageous for creating an anoxic condition, and the biofilm can absorb and store carbon for good nitrification and denitrification. An average concentration of oxygen ranging from 0.8 to 4.0 mg/L was proved very efficient for nitrification and denitrification. Volumetric loads of TN dropped dramatically and effluent TN concentration increased quickly when the concentration of average dissolved oxygen was more than 4.0 mg/L. The efficiency of simultaneous nitrification and denitrification (SND) increased with increasing thickness of the biofilm. The influent concentration hardly affected the TN removal efficiency, but the effluent TN increased with increasing influent concentration. It is suggested that a subsequence for denitrification be added or influent amount be decreased to meet effluent quality requirements. At optimum operating parameters, the TN removal efficiency of 74%–82% could be achieved.     

Circulating fluidized bed biological reactor for nutrients removal

A new biological nitrogen removal process, which is named herein “The circulating fluidized bed bioreactor (CFBBR)”, was developed for simultaneous removal of nitrogen and organic matter. This process was composed of an anaerobic bed (Riser), aerobic bed (Downer) and connecting device. Influent and nitrified liquid from the aerobic bed enters the anaerobic bed from the bottom of the anaerobic bed, completing the removal of nitrogen and organic matter. The system performance under the conditions of different inflow loadings and nitrified liquid recirculation rates ranging from 200% to 600% was examined. From a technical and economic point of view, the optimum nitrified liquid recirculation ratewas 400%. With a shortest total retention time of 2.5 h (0.8 h in the anaerobic bed and 1.5 h in the aerobic bed) and a nitrified liquid recirculation rate of 400% based on the influent flow rate, the average removal efficiencies of total nitrogen (TN) and soluble chemical oxygen demand (SCOD) were found to be 88% and 95%, respectively. The average effluent concentrations of TN and SCOD were 3.5 mg/L and 16 mg/L, respectively. The volatile suspended solid (VSS) concentration, nitrification rate and denitrification rate in the system were less than 1.0 g/L, 0.026-0.1 g NH₄ ⁺-N/g VSS·d, and 0.016–0.074 g NO_x ^?-N/g VSS·d, respectively.     

Effects of La3+, Ce3+ on nitrogen removal in sequencing batch reactor

Batch experiments were conducted to study the short-term biological effects of rare earth ions (La³⁺, Ce³⁺) and their mixture on the nitrogen removal in a sequencing batch reactor (SBR). The data showed that higher NH₄ ⁺-N removal rate, total inorganic nitrogen removal efficiency, and denitrification efficiency were achieved at lower concentrations of rare earth elements (REEs) (<1 mg/L). In the first hour of the aeration stage of SBR, the presence of REEs increased the total inorganic nitrogen removal efficiency and NH₄ ⁺-N removal efficiency by 15.7% and 10%–15%, respectively. When the concentrations of REEs were higher than 1 mg/L, the total inorganic nitrogen removal efficiency decreased, and nitrate was found to accumulate in the effluent. When the concentrations of REEs was up to 50.0 mg/L, the total inorganic nitrogen removal efficiency was less than 30% of the control efficiency with a high level of nitrate. Lower concentrations of REEs were found to accelerate the nitrogen conversion and removal in SBR.     

A/O-MBR处理某经济区市政污水的效能

采用A/O-MBR法处理某经济区市政污水,对其进、出水的水质进行连续监测,考察系统稳定性和处理效果。结果表明,在水力停留时间12小时,污泥龄30天,回流比75%,好氧段DO浓度1.3～8.5 mg/L的条件下,系统对COD、氨氮、总氮、总磷的平均去除率分别为92.04%、93.66%、78.04%、91.06%。反硝化...     

Advanced nitrogen removal by pulsed sequencing batch reactors (SBR) with real-time control

The feasibility of pH and oxidation reduction potential (ORP) as on-line control parameters to advance nitrogen removal in pulsed sequencing batch reactors (SBR) was evaluated. The pulsed SBR, a novel operational mode of SBR, was utilized to treat real municipal wastewater accompanied with adding ethanol as external carbon source. It was observed that the bending-point (apex and knee) of pH and ORP profiles can be used to control denitrification process at a low influent C/N ratio while dpH/dt can be used to control the nitrification and denitrification process at a high influent C/N ratio. The experimental results demonstrated that the effluent total nitrogen can be reduced to lower than 2 mg/L, and the average total nitrogen (TN) removal efficiency was higher than 98% by using real-time controll strategy.     

Advanced nitrogen and phosphorus removal in A2O-BAF system treating low carbon-to-nitrogen ratio domestic wastewater

A laboratory-scale anaerobic-anoxic-aerobic process (A²O) with a small aerobic zone and a bigger anoxic zone and biologic aerated filter (A²O-BAF) system was operated to treat low carbon-to-nitrogen ratio domestic wastewater. The A²O process was employed mainly for organic matter and phosphorus removal, and for denitrification. The BAF was only used for nitrification which coupled with a settling tank Compared with a conventional A²O process, the suspended activated sludge in this A²O-BAF process contained small quantities of nitrifier, but nitrification overwhelmingly conducted in BAF. So the system successfully avoided the contradiction in sludge retention time (SRT) between nitrifying bacteria and phosphorus accumulating organisms (PAOs). Denitrifying phosphorus accumulating organisms (DPAOs) played an important role in removing up to 91% of phosphorus along with nitrogen, which indicated that the suspended activated sludge process presented a good denitrifying phosphorus removal performance. The average removal efficiency of chemical oxygen demand (COD), total nitrogen (TN), total phosphorus (TP), and NH ₄ ⁺ -N were 85.56%, 92.07%, 81.24% and 98.7% respectively. The effluent quality consistently satisfied the national first level A effluent discharge standard of China. The average sludge volume index (SVI) was 85.4 mL·g^?1 additionally, the volume ratio of anaerobic, anoxic and aerobic zone in A²O process was also investigated, and the results demonstrated that the optimum value was 1:6:2.     

应用在线传感器实现前置反硝化工艺生物脱氮的过程控制

为了实现前置反硝化工艺硝化反硝化反应的过程控制,系统地研究了硝化反硝化过程中DO、pH和ORP的变化规律,并考察了它们作为硝化反硝化过程控制参数的可行性.结果表明,pH值在缺氧区的变化分为下降型和上升型,从而指示系统反硝化反应进行的程度以及内循环回流量是否充足;缺氧区末端ORP值和硝酸氮浓度具有较好的相关性;好氧区第1格室的DO浓度可以指示进水氨氮负荷高低;pH值在好氧区的变化也可分为下降型和上升型,可指示系统硝化反应进行的程度、曝气量和碱度是否充足;好氧区末端ORP值与出水氨氮、硝酸氮浓度具有很好的相关性.在此基础上建立了硝化反硝化反应在线控制系统,从而实现曝气量、内循环回流量和外碳源投加量的在线控制,提高系统出水水质、降低运行费用.图7表1参8     

序批式膜反应器处理高氨氮渗滤液同步硝化反硝化特性

应用序批式生物膜反应器(SBBR)处理实际垃圾渗滤液,在DO浓度分别为0.45mg.l-1和1.19mg.l-1条件下,研究了系统的有机物,氨氮和总氮去除特性以及游离氨(FA),DO对系统同步硝化反硝化(SND)类型的影响.250d试验研究表明:SBRR系统能够稳定高效地同步去除渗滤液内高浓度有机物和高浓度氨氮.在初始COD浓度为122—2385 mg.l-1的情况下,出水COD浓度为23—929 mg.l-1,有机物最大去除速率25.6 kgCOD.m-2载体.d-1.在初始NH4+-N浓度为40—396.5 mg.l-1的情况下,出水NH4+-N浓度为0—41.2 mg.l-1,最大硝化速率2.87 kgN.m-2载体.d-1.SBBR系统内发生了明显的同步硝化反硝化(SND)现象,TN平均去除率分别为73.8%(DO=0.45 mg.l-1)和30%(DO=1.19 mg.l-1)左右.当FA浓度在1.5—11.6 mg.l-1范围内时,系统中共存硝酸型SND和亚硝酸性SND.当FA从18.6 mg.l-1增加到56 mg.l-1,系统中形成稳定的亚硝酸SND.因此,FA是影响系统SND类型的主要因素,DO可促进亚硝酸性SND向硝酸型SND转化.     

Bioremediation of shrimp biofloc wastewater using clam,seaweed and fish

The aim of this study was to evaluate the bioremediation of effluents in the biofloc culture of shrimp juveniles using clams, seaweed and fish. Four treatments were considered: CLT – without bioremediating organisms; AB – using Anomalocardia brasiliana; GB – using Gracilaria birdiae and ON – using Oreochomis niloticus with 2.5?kg wet weight per m³ of shrimp effluent. In the AB treatment, significant differences were observed in the effluent at the end of the experiment (96?h) for values of nitrite-nitrogen, nitrate, alkalinity, TSS and orthophosphate. The ISS and VSS levels recorded for the AB treatment varied respectively from 336 to 127?mg?L^?1, and from 505 to 130?mg?L^?1, with a corresponding gradual reduction of approximately 62% and 74% at the end of the experiment. The use of a clam species to treat effluents in a biofloc system with salinity near 25?g?L^?1 reduced waste solids and increased the nitrification process from 72 to 96?h, indicating that this clam can be used as a bioremediator and contributes to effluent treatment in shrimp.     

不同进水有机物浓度下移动床生物膜反应器(SBMBBR)脱氮除磷特性

考察了不同进水有机物浓度下厌氧/好氧序批式移动床生物膜反应器（SBMBBR）污染物去除特性,实验结果表明,SBMBBR能够实现低碳源污水中氮和磷的同步去除,在进水TN和TP浓度分别为116.7 mg.L-1和11.5 mg.L-1、COD浓度为456 mg.L-1的条件下,TN和TP去除率分别达到94.3%和92.2%以上.反应器除磷是基于常规生物除磷和反硝化除磷过程实现的,脱氮主要是基于好氧段发生的同时硝化反硝化（SND）作用而完成.由于生物膜内部存在的DO扩散梯度,在好氧阶段混合液DO浓度不断提高的条件下反应器内具有良好SND反应的发生.进水COD浓度由149 mg.L-1提高至456 mg.L-1的过程中,反应器硝化效果不变,反硝化和除磷效果改善.反应器在好氧阶段pH值基本维持在7.0—7.1之间,为各类菌群的生长创造了条件.碱度变化较pH值更能反映硝化和反硝化反应发生的程度.反应器中微生物相丰富,生物膜以丝状菌为骨架,其上附着大量的球状菌和杆状菌,而悬浮活性污泥中丝状菌较少,形成了由细菌、真菌到原生动物和后生动物的复杂的生态体系,为系统取得稳定的污水处理效果提供了有效的保证.     

N2O emission from a sequencing batch reactor for biological N and P removal from wastewater

Nitrous oxide （N2O） is a greenhouse gas that can be released during biological nitrogen removal from wastewater. N2O emission from a sequencing batch reactor （SBR） for biological nitrogen and phosphorus removal from wastewater was investigated, and the aims were to examine which process, nitrification or denitrification, would contribute more to N2Oemission and to study the effects of heterotrophic activities on N2O emission during nitrification. The results showed that N2O emission was mainly attributed to nitrification rather than to denitrification. N2O emission during denitrification mainly occurred with stored organic carbon as the electron donor. During nitrification, NaO emission was increased with increasing initial ammonium or nitrite concentrations. The ratio of N2O emission to the removed ammonium nitrogen （N2O- N/NH4-N） was 2.5% in the SBR system with high heterotrophic activities, while this ratio was in the range from 0.14% to 1.06% in batch nitrification experiments with limited heterotrophic activities.     

不同结构生态滤池处理城镇污水研究

研究了不同结构生态滤池处理城镇污水的效果。复合床生态滤池采用初沉池出水作为进水，用中颗粒填料和粗颗粒填料作为惰性填料层，在不同水力负荷下(HLR)，CODCr、NH4^ -N去除率分别达74％-85％、30％-90％，出水浊度低。出水中NH4^ -N质量浓度下降，NO3^ -N质量浓度显著增加。氮的转化受HLR影响较大。中颗粒填料较粗颗粒填料的处理效果好，惰性层在硝化方面起着重要作用。进出水中碱度差与硝酸根质量浓度差、氨氮质量浓度差均呈显著相关性。介绍了生态滤池内的物质流、食物链及生态滤池的工作原理。     

Comparative experiment on treating digested piggery wastewater with a biofilm MBR and conventional MBR: simultaneous removal of nitrogen and antibiotics

A biofilm membrane bioreactor (BF-MBR) and a conventional membrane bioreactor (MBR) were parallelly operated for treating digested piggery wastewater. The removal performance of COD, TN, NH₄ ⁺-N, TP as well as antibiotics were simultaneously studied when the hydraulic retention time (HRT) was gradually shortened from 9 d to 1 d and when the ratio of influent COD to TN was changed. The results showed that the effluent quality in both reactors was poor and unstable at an influent COD/TN ratio of 1.0±0.2. The effluent quality was significantly improved as the influent COD/TN ratio was increased to 2.3±0.5. The averaged removal rates of COD, NH₄ ⁺-N, TN and TP were 92.1%, 97.1%, 35.6% and 54.2%, respectively, in the BF-MBR, significantly higher than the corresponding values of 91.7%, 90.9%, 17.4% and 31.9% in the MBR. Analysis of 11 typical veterinary antibiotics (from the tetracycline, sulfonamide, quinolone, and macrolide families) revealed that the BF-MBR removed more antibiotics than the MBR. Although the antibiotics removal decreased with a shortened HRT, high antibiotics removals of 86.8%, 80.2% and 45.3% were observed in the BF-MBR at HRTof 5–4 d, 3–2 d and 1 d, respectively, while the corresponding values were only 83.8%, 57.0% and 25.5% in the MBR. Moreover, the BF-MBR showed a 15% higher retention rate of antibiotics and consumed 40% less alkalinity than the MBR. Results above suggest that the BF-MBR was more suitable for digested piggery wastewater treatment.

Open image in new window

     

Respiratory quotient and calcification of Nautilus macromphalus (Cephalopoda: Nautiloidea)

Respiration and calcification were investigated in the ectocochleate cephalopod Nautilus macromphalus Sowerby. Specimens were collected off New Caledonia, in October 1991, and kept at the Nouméa Aquarium until December 1991. The respiratory quotient and calcification rate of 5 individuals were measured during 14 short term incubations (63 to 363 min). Oxygen uptake was recorded with a polarographic oxygen sensor. CO₂ flux and calcification were calculated from changes in pH and alkalinity (alkalinity-anomaly technique). Several methods were used to compute the respiratory quotient (RQ); a functional regression indicated an RQ of 0.74. CaCO₃ exchange rates were linearly related to respiratory quotient, calcification occurring in individuals with a low RQ. CaCO₃ uptake from the surrounding water was noncontinuous. From the highest CaCO₃ uptake, maximum growth rate was estimated as 7.1 mg shell wt h^- (=61 g yr^-1).     

Optimization of denitrifying phosphorus removal in a pre-denitrification anaerobic/anoxic/post-aeration + nitrification sequence batch reactor (pre-A<Subscript>2</Subscript>NSBR) system: Nitrate recycling,carbon/nitrogen ratio and carbon source type

Because the efficiency of biological nutrient removal is always limited by the deficient carbon source for the low carbon/nitrogen (C/N) ratio in real domestic sewage, the denitrifying phosphorus removal (DNPR) was developed as a simple and efficient method to remove nitrogen and phosphorous. In addition, this method has the advantage of saving aeration energy while reducing the sludge production. In this context, a pre-denitrification anaerobic/anoxic/post-aeration + nitrification sequence batch reactor (pre-A₂NSBR) system, which could also reduce high ammonia effluent concentration in the traditional two-sludge DNPR process, is proposed in this work. The pre-A₂NSBR process was mainly composed of a DNPR SBR and a nitrifying SBR, operating as alternating anaerobic/anoxic/post-aeration + nitrification sequence. Herein, the long-term performance of different nitrate recycling ratios (0–300%) and C/N ratios (2.5–8.8), carbon source type, and functional microbial community were studied. The results showed that the removal efficiency of total inorganic nitrogen (TIN, including NH₄⁺-N, NO₂^– -N, and NO₃^– -N) gradually increased with the nitrate recycling ratios, and the system reached the highest DNPR efficiency of 94.45% at the nitrate recycling ratio of 300%. The optimum C/N ratio was around 3.9–7.3 with a nitrogen and phosphorus removal efficiency of 80.15% and 93.57%, respectively. The acetate was proved to be a high-quality carbon source for DNPR process. The results of fluorescence in situ hybridization (FISH) analysis indicated that nitrifiers and phosphorus accumulating organisms (PAOs) were accumulated with a proportion of 19.41% and 26.48%, respectively.

Open image in new window

     

二级SBR法处理高浓度氨氮化工废水研究

用直接活性污泥法完成了各反应器的污泥驯化启动。二级ＳＢＲ工艺主要由硝化ＳＢＲ和反硝化ＳＢＲ反应器构成，其中硝化ＳＢＲ反应器采用悬浮生长法和固定生物膜法两种工艺作对比试验。结果表明，后者较前者具有更大的ＮＨ３－Ｎ容积负荷，最大可达７６６．５４ｍｇＬ＾－１ｄ＾－１；而且能节省碱的消耗量１１．０％～３８．７％和反硝化所需碳源量为３０％～４０％。在ｔＨＲ为２４ｈ的条件下，二级ＳＢＲ法能处理ρＩｎ（ＮＨ３－     

Nitrifying and denitrifying bacteria in aerobic granules formed in sequencing batch airlift reactors

The purpose of this study was to investigate nitrifying bacteria and denitrifying bacteria isolated from aerobic granules. Aerobic granules were formed in an internal-circulate sequencing batch airlift reactor (SBAR) and biodegradation of NH₃ ^?-N was analyzed in the reactor. Bacteria were isolated and determined from aerobic granules using selected media. The growth properties and morphology of bacteria colonies were observed by controlling aerobic or anaerobic conditions in the culture medium. It was found that bacteria in aerobic granules were diverse and some of them were facultative aerobes. The diversity of bacteria in aerobic granules was a premise of simultaneous nitrification and denitrification.     

Bioturbation effects of the amphipod Corophium volutator on microbial nitrogen transformations in marine sediments

Microcosms containing different densities of Corophium volutator, ranging from 0 to 6000 ind m^-2, were incubated in a flow-through system. Benthic fluxes of CO₂, O₂, NO₃ ^- and NH₄ ⁺ were measured regularly. Thirteen days after setup the microcosms were sacrificed and sediment characteristics, pore water NO₃ ^-, NH₄ ⁺ and exchangeable NH₄ ⁺ concentrations, and potential nitrification activity were measured. The presence of C. volutator increased overall mineralization processes due to burrow construction and irrigation. The amphipods increased the ratio CO₂/O₂ fluxes from 0.73 to 0.86 in microcosms inhabited by 0 and 6000 ind m^-2, respectively. Burrow ventilation removed NH₄ ⁺ from the sediment, which was nitrified in the oxic layer and transported NO₃ ^- to the burrow sediment, where denitrification potential was enhanced. Nitrification and total denitrification rates (denitrification of NO₃ ^- coming from the overlying water and of NO₃ ^- generated within the sediment) were calculated and discussed. Bioturbation by C. volutator increased both nitrification and denitrification, but denitrification was stimulated more than nitrification. Denitrification of NO₃ ^- coming from the overlying water was stimulated 1.2- and 1.7-fold in microcosms containing 3000 and 6000 ind m^-2 relative to control microcosms. The presence of C. volutator (6000 ind m^-2) stimulated nitrogen removal from the system, as dinitrogen, 1.5-fold relative to non-bioturbated microcosms. C. volutator individuals used in our study were collected from Norsminde Fjord, Denmark, in 1990.