糠醇生产中铜铬废触媒资源化研究

对已有的糠醇生产中产生的废渣回收工艺进行了改进。将糠醛液相加氢生产糠醇产生的废渣于130℃真空蒸馏回收废渣中的有机混合物，经过精馏获得糠醇与糠醛；剩余的固体废触媒与纯碱混合，经反射炉焙烧、水浸取、掺加石灰除硅、过滤得到铬酸钠水溶液；剩下的粗氧化铜经碱溶除铬、溶于硝酸得到硝酸铜溶液；将铬酸钠溶液、硝酸铜溶液按一定比例混合，加氨水搅拌，分离出的沉淀经传统方法焙烧活化、造粒制得新催化剂，回用于糠醛液相加氢生产糠醇。有机物、铬组分和铜组分的回收率均在90％以上。     

糠醛加氢废催化剂的回收再利用

以糠醛液相加氢生产糠醇所用的废铜铬氧化物催化剂为原料，通过与纯碱氧化——钠化焙烧、浸取分离铜铬离子，分别制得铬酸钠和硝酸铜，并以此为原料进一步制得新催化剂，回用于糠醛液相加氢制糠醇。Cr(Ⅲ)与Cu(Ⅱ)的转化率均在90％以上，制得的新催化剂回收率大于85％，使用效果好。研究了铬转化率与焙烧温度、时间、返渣量等条件的关系。     

铜铬氧化物废催化剂中铜铬的回收

以糠醛加氢制糠醇用的废铜铬氧化物催化剂为原料,通过焙烧、酸化、过滤、重结晶制取硫酸铜,再将所得沉淀加纯碱,焙烧,浸取,制取铬矾。该方法工艺简单、成本低且可同时回收铜铬两种离子．铜离子回收率92％,铬离子回收率达60％以上。     

糠醛废渣的处置

我国每年约有30～40万吨糠醛废渣产生。糠醛废渣具有广阔的应用前景。本文较详细地介绍了利用糠醛废渣生产活性炭,改良土壤、作燃料以及其他方面的经验。     

钢铁厂冷轧废水污泥中铬回收实验研究

钢铁厂冷轧废水污泥中含有10%以上的铬、20%以上的铁和1.5%以上的锌(均以质量分数计).为了从污泥中回收铬,首先研究了污泥中铬的形态,确定为Cr(Ⅲ);然后以碳酸钠为氧化助剂,将污泥与碳酸钠按一定比例混合后焙烧,再用水浸取.研究了碳酸钠的添加量、焙烧温度和时间、浸取时间和浸取方式对铬回收率的影响.研究表明,每克干污泥中添加0.6 g或以上碳酸钠,在固定床上700 ℃焙烧4 h以上,可实现60%以上的总铬浸出率,残渣为Fe2O3基脱硫剂原料.     

砷华生产废渣中硫的回收利用研究

高温下氧化焙烧细磨后的砷华生产废渣,利用软锰矿浆吸收产生的SO2气体,吸收液经净化除杂、浓缩结晶等工序可制备工业产品硫酸锰.适宜的焙烧条件如下:焙烧温度为650℃,焙烧时间为60 min,废渣粒度为-97μm.选择合适的吸收工艺,Mn的浸出率可达96.20%,此时SO2脱除率为87.20%.     

电镀污泥中无定型铝的选择性浸出

针对电镀污泥加碱、石灰焙烧灰渣水浸过程铝浸出率较低的问题,在分析电镀废水处理工艺的基础上,根据污泥中铝、铬、锌、铜等金属的存在相态以及焚烧过程所发生的化学反应,拟采用低浓度氢氧化钠溶液先选择性浸出污泥中的铝。研究了稀氢氧化钠溶液浸出铝的工艺条件,结果表明,电镀污泥用2 mol·L~(-1)氢氧化钠在90℃浸出60 min,铝的浸出率可达95%以上,而铬、锌和铜等金属则大部分进入浸出渣,基本上达到铝与其他金属的初步分离的目的。研究结果为混合电镀污泥中铝的回收以及铝及其他金属的选择性分步分离工艺流程的选择提供理论与技术支持。     

砷华生产废渣中硫的回收利用研究

高温下氧化焙烧细磨后的砷华生产废渣，利用软锰矿浆吸收产生的SO2气体，吸收液经净化除杂、浓缩结晶等工序可制备工业产品硫酸锰。适宜的焙烧条件如下：焙烧温度为650℃，焙烧时间为60min，废渣粒度为-97μm。选择合适的吸收工艺，Mn的浸出率可达96．20％，此时SO2脱除率为87．20％。     

庆云中学电镀设备厂产品介绍

浙江省海宁县庆云中学电镀设备厂地处沪杭线庆云钲,生产各种电解环保设备和硅整流、硅可控制整流器。各种产品结构合理,保护系统完善;环保设备容量大、效率高,操作费用小;价格优惠,服务周到,产品行销华东各地,深受用户欢迎。 一、隔膜电解设备 本厂生产的以素烧陶瓷为隔膜的隔膜电解处理设备可以用于含三价铬浓度高的各种废铬酸溶液的再生,例如塑料电镀前处理铬酸粗化废液的处理。在塑料粗化处理时,铬酸粗化液     

中温焙烧/钠化氧化法回收电镀污泥中的铬

采用中温焙烧/钠化氧化法从电镀污泥中回收铬.结果表明,影响铬浸出率的最主要因素为焙烧温度.电镀污泥与碳酸钠质量比、焙烧时间、水浸时间对铬浸出率的影响较接近,在水浸水固比为10.0 ; 1.0(质量比)、室温、焙烧温度为650℃、焙烧时间为2.0h、电镀污泥与碳酸钠质量比为1:1、水浸时间为60 min的最佳浸出条件下,铬浸出率为99.3%;去除氢氧化铝、氢氧化锌的最佳反应温度和pH分别为90～95℃和7.5;去除硫酸钠晶体的最佳pH为4.0,在最佳试验条件下,铬回收率为90.57%.     

Evaluation of trichloroethene recovery processes in heterogeneous aquifer cells flushed with biodegradable surfactants

The ability of two biodegradable surfactants, polyoxyethylene (20) sorbitan monooleate (Tween 80) and sodium dihexyl sulfosuccinate (Aerosol MA), to recover a representative dense non-aqueous-phase liquid (DNAPL), trichloroethene (TCE), from heterogeneous porous media was evaluated through a combination of batch and aquifer cell experiments. An aqueous solution containing 3.3% Aerosol MA, 8% 2-propanol and 6 g/l CaCl(2) yielded a weight solubilization ratio (WSR) of 1.21 g TCE/g surfactant, with a corresponding liquid-liquid interfacial tension (IFT) of 0.19 dyn/cm. Flushing of aquifer cells containing a TCE-DNAPL source zone with approximately two pore volumes of the AMA formulation resulted in substantial (>30%) mobilization of TCE-DNAPL. However, a TCE mass recovery of 81% was achieved when the aqueous-phase flow rate was sufficient to displace the mobile TCE-DNAPL toward the effluent well. Aqueous solutions of Tween 80 exhibited a greater capacity to solubilize TCE (WSR=1.74 g TCE/g surfactant) and exerted markedly less reduction in IFT (10.4 dyn/cm). These data contradict an accepted empirical correlation used to estimate IFT values from solubilization capacity, and indicate a unique capacity of T80 to form concentrated TCE emulsions. Flushing of aquifer cells with less than 2.5 pore volumes of a 4% T80 solution achieved TCE mass recoveries ranging from 66 to 85%, with only slight TCE-DNAPL mobilization (<5%) occurring when the total trapping number exceeded 2 x 10(-5). These findings demonstrate the ability of Tween 80 and Aerosol MA solutions to efficiently recover TCE from a heterogeneous DNAPL source zone, and the utility of the total trapping number as a design parameter for a priori prediction of DNAPL mobilization and bank angle formation when flushing with low-IFT solutions. Given their potential to stimulate microbial reductive dechlorination at low concentrations, these surfactants are well-suited for remedial action plans that couple aggressive mass removal followed by enhanced bioremediation to treat chlorinated solvent source zones.     

The variation of street air levels of PAH and other mutagenic PAC in relation to regulations of traffic emissions and the impact of atmospheric processes

The occurrence of particle associated PAH and other mutagenic PAC was determined in 1996 in the street air of Copenhagen. In addition, particle extracts were tested for mutagenicity. The measurements were compared with previous measurements in 1992/1993. The levels had decreased in this period. The decrease was caused by an implementation of light diesel fuels for buses and the exchange of older petrol-driven passenger cars with catalystequipped new ones. About 65% of the reduction was caused by the application of the light diesel fuels. Under special conditions, chemical processes in the atmosphere produced many more mutagens than the direct emissions. The concentrations of S-PAC and N-PAC were 10 times lower than those of PAH, while the levels of oxy-PAH were in the same order of magnitude as those of PAH. Benzanthrone, an oxy-PAH, is proposed to be formed in the atmosphere in addition to direct emissions. Benzo(a)pyrene, often applied as an air quality criteria indicator, was photochemically degraded in the atmosphere. A strong increase in the mutagenic activities was observed to coincide with a depletion of benzo(a)pyrene.     

Chloroaromatic pollutants in mussels incubated in two finnish watercourses polluted by industry

Concentrations of different chlorinated compounds were measured in mussels incubated in two polluted watercourses, a river (the River Kymijoki) and a lake (Lake Vanaja) for four weeks in summer 1995. The sum concentrations of polychlorinated phenols (PCP) and biphenyls (PCB) were both about 1 μg/g lipid weight (lw) in Lake Vanaja mussels, while in the River Kymijoki mussels PCPs were non-detectable and PCBs were measured 120 ng/g lIw. The concentrations of toxic polychlorinated dibenzo-p-dioxin (PCDD) and dibenzofuran (PCDF) congeners ranged between <17 and 370 pg/g Iw in Lake Vanaja mussels and between <38 and 11,000 pg/g lw in the River Kymijoki mussels. Polychlorinated diphenyl ethers (PCDE) were detected in the mussels incubated in the River Kymijoki (0.4–1.1 ng/g Iw), but not in those incubated in Lake Vanaja. Polychlorinated phenoxyanisoles (PCPA) were measured 33 ng/g lw and polychlorinated phenoxyphenols (PCPP) 300 ng/g lw in the mussels incubated in the River Kymijoki. PCPAs were also detected in reference samples, which were sediment and pike from the River Kymijoki and Baltic salmon, seal and white-tailed sea eagle.     

Teratological effects of pesticides in vertebrates: a review

Abstract

In the last decades, the use and misuse of pesticides in the agriculture have increased, having a severe impact on ecosystems and their fauna. Although the various effects of pesticides on biodiversity have been already documented in several studies, to our knowledge no consistent overview of the impact of pesticides in vertebrates, both terrestrial and aquatic, is available. In this review, we try to present a concise compilation of the teratogenic effects of pesticides on the different classes of vertebrates – mammals, birds, reptiles, amphibians and fish.     

Book review

The Pesticide Manual ‐ A World Compendium, 8th Edition, C.R. Worthing, Editor and S.B. Walker, Assistant Editor, British Crop Protection Council, BCPC Publications Sales, Bear Farm, Binfield, Bracknell, Berkshire RG12 5QE, England. 1987, 1100 pp., UK £50; Overseas £56. ISBN 0–948404–01–9.     

Patterns of volatile metabolites and nonvolatile trichothecenes produced by isolates of <Emphasis Type="Italic">Stachybotrys,Fusarium, Trichoderma,Trichothecium</Emphasis> and <Emphasis Type="Italic">Memnoniella</Emphasis>

We reported previously that trichodiene, a volatile trichothecene derivative, was produced by a Stachybotrys isolate, also known to produce highly cytotoxic, non-volatile, macrocyclic trichothecenes (satrotoxins). We investigated the relationship between the production of trichodiene and various non-volatile trichothecenes for several molds. Volatile metabolites were concentrated by adsorption on Tenax TA and analyzed by GC/MS, while non-volatile metabolites were separated by HPLC, derivatized and analyzed by GC/MS. Stachybotrys chartarum isolates producing macrocyclic trichothecenes secreted significantly larger amounts of trichodiene and other sesquiterpenes than isolates which only produced simple trichothecenes. The amounts of secreted trichodiene were relatively small in all cases. With the exception of Memnoniella, which excreted small amounts of sesquiterpenes, the other isolates produced varying amounts of sesquiterpenes, including trichodiene, as well as simple tricothecenes, no detectable trichodiene, but large amounts of griseofulvin derivatives. In Stachybotrys there is apparently a correlation between trichodiene and macrocyclic trichothecene production. In the remaining isolates, there was no simple relationship between trichodiene and non-volatile trichothecene synthesis. Trichodiene is produced in larger amounts by Stachybotrys isolates, which also produce satratoxins, but it will be difficult to utilize this metabolite to detect toxic isolates in buildings due to the relatively small amounts excreted.     

Observations on the influence of water and soil pH on the persistence of insecticides

Abstract

The pH‐disappearance rate profiles were determined at ca. 25°C for 24 insecticides at 4 or 5 pH values over the range 4.5 to 8.0 in sterile phosphate buffers prepared in water‐ethanol (99: 1 v/v). Half‐lives measured at pH 8 were generally smaller than at lower pH values. Changes in half lives between pH 8.0 and 4.5 were largest (>1000x) for the aryl carbamates, carbofuran and carbaryl, the oxime carbamate, oxamyl, and the organophosphorus insecticide, trichlorfon. In contrast, half lives of phorate, terbufos, heptachlor, fensulfothion and aldicarb were affected only slightly by pH changes. Under the experimental conditions described half lives at pH8 varied from 1–2 days for trichlorfon and oxamyl to >1 year for fensulfothion and cyper‐methrin. Insecticide persistence on alumina (acid, neutral and basic), mineral soils amended with aluminum sulfate or calcium hydroxide to different pH values and four natural soils of different pH was examined. No correlation was observed between the measured pH of these solids and the rate of disappearance of selected insecticides applied to them. These observations demonstrate the difficulty of extrapolating the pH dependent disappearance behaviour observed in homogeneous solution to partially solid heterogeneous systems such as soil.     

Knowledge transfer initiative between molecular biologists and environmental researchers and regulators

A Natural Environment Research Council (NERC) funded Knowledge Transfer (KT) workshop was held in the United Kingdom (UK) to identify the needs and opportunities in the application of molecular biology and ‘omics’ techniques to environmental monitoring and risk assessment. Attendees highlighted a lack of effective communication between end-users and researchers as well as difficulties with data interpretation as reasons behind the slow uptake of molecular biology and omics techniques. A number of promising areas in which new techniques could be implemented at a practical level in the very near future were identified, thereby raising the profile of these recent technologies and providing vital proof of concept work. Molecular taxonomy, bacterial source tracking and pre-screening of chemicals for potential toxicities were all viewed as areas in which omics and molecular techniques could have immediate value, with the aim of reducing cost, increasing efficiency and providing more comprehensive data of improved quality.     

The chemical stability of formulations of some hydrolyzable insecticides in aqueous mixtures with hydrolysis catalysts

Abstract

The active ingredients in commercial formulations of malathion, oxamyl, carbaryl, diazinon, and chlorpyrifos diluted to “spray tank”; concentrations with buffered distilled or natural water of pH 4–9 were stable for at least 24 hr. Formulations of trichlorfon were not stable at pH 7 or above but disappearance rates were slower than for the pure chemical in homogeneous solution. Cupric ion was observed to be an effective catalyst for the hydrolysis of a variety of pure organophosphorus insecticides but did not catalyze hydrolysis of the active ingredients of the formulations examined. Increasing the dilution of the formulation increased the susceptibility of malathion, oxamyl, and carbaryl to hydrolysis.     

Organochlorine compounds in a three-step terrestrial food chain

The concentrations of 15 organochlorine chemicals (PCBs and pesticides) were studied in a Central European oak wood food chain system: Great tit (Parus major), caterpillars (Tortrix viridana, Operophtera brumata, Erannis defoliaria), and oak-leaves (Quercus robur). Juvenile tits receive organochlorines from the mother via egg transfer and, eventually to a greater extent, from the caterpillar food source during nestling period. The concentrations of PCB 153 (2,2′,4,4′,5,5′-hexachlorobiphenyl, the most abundant in this study) was found in leaf material at ca. 1 ng/g, in caterpillars 10 ng/g, and in bird eggs 170 ng/g on an average and on a dry mass basis.