Effects of feed solutions on refuse hydrolysis and landfill leachate characteristics

Tap water, aerobically pre-treated leachate, and anaerobically pre-treated leachate, were each fed into the top of a series of three simulated landfills columns, filled with municipal solid waste collected in Shanghai, China. Changes in leachate, including pH, total organic carbon (TOC), and volatile fatty acids (VFAs), and the produced biogas were monitored over time. The tap-water-fed columns had a low hydrolysis rate that yielded an acidic environment (pH 4.8-5.4) in the leachate that inhibited methanogenesis reaction in the refuse. When aerobically pre-treated leachate was fed into the columns, the hydrolysis rate of total organic carbon fluctuated between 200 and 400 mg d-1 and methanogenesis in the refuse column was only partly activated. The hydrolysis rate of refuse fed with anaerobically pre-treated leachate was the highest among the three solutions. The high alkaline levels of the anaerobically pre-treated leachate and its methanogenic bacteria led to an early activation of methanogenesis in the refuse columns. The VFAs contributed approximately 40-60% of TOC in tap-water-fed columns, 60-80% of TOC in the columns fed aerobically pre-treated leachate, and up to 70-90% of TOC in columns fed with anaerobically pre-treated leachate. The feed solution had considerably affected leachate characteristics, and then the build-up of the methanogenesis in the refuse column and the composition of fermentation products in the leachate. The success of a bioreactor landfill depends on whether the recycled leachate could yield a favorable methanogenic environment in the top refuse layer, or whether an appropriate pre-treatment is adopted to modify the leachate characteristics.     

厌氧发酵系统中回流沼液的产甲烷活性研究

为确定两阶段厌氧发酵系统合理的污泥回流时段,对厌氧发酵系统排出沼液产甲烷活性进行了研究。通过对这些沼液在后储罐放置的不同天数(0~5 d)测定其不同的活性,用间歇实验方法测定最大比产甲烷活性(Um ax.CH4)作为厌氧污泥的产甲烷活性指标。结果表明,排出的沼液产甲烷活性在不同的时间段有所不同,经实验得出沼液放置第2 d时的产甲烷活性最高,从而确定该两阶段厌氧发酵系统排出污泥合理的回流时段应该是沼液进入后储罐的第2 d。进而为在线活性污泥与后储罐最佳活性时段污泥混合的污泥回流工艺提供理论依据。     

An activated sludge process to reduce the pollution load of a dye-industry waste

A laboratory-scale activated sludge process was developed to reduce the pollution load of a dye-industry waste, containing aniline, phenol, methyl violet and rhodamine B as its major components. The waste exerted an organic load of 5576 mg litre(-1) as the chemical oxygen demand (COD), of 896 mg litre(-1) as total organic carbon (TOC), and had a 31.5 mg litre(-1) phenol content. A microbial sludge, capable of growing on the waste, was developed from cattle dung, adapted to the waste and used as a bioinoculum for the process. This resulted in reductions of 60% in COD, 37% in TOC, and 92% in phenol content, and a decrease in optical density of the colour of the waste from an initial 0.915 to 0.360 at 580 nm. Microorganisms isolated from sludge were identified as Pseudomonas alcaligenes and P. mendocina.     

Biodegradation of phthalate esters during the mesophilic anaerobic digestion of sludge

Phthalic acid esters (PAE) are commonly found in the sludge generated in the wastewater treatment plants. Anaerobic digestion followed by land application is a common treatment and disposal practice of sludge. To date, many studies exist on the anaerobic biodegradation rates of PAE, especially of the easily biodegradable ones, whereas the higher molecular weight PAE have reported to be non-biodegradable under methanogenic conditions. Furthermore, there is no information on the effect of the PAE on the performance of the anaerobic digesters treating sludge. In this study, the anaerobic biodegradation of di-n-butyl phthalate (DBP), di-ethyl phthalate (DEP) and di-ethylhexyl phthalate (DEHP) was investigated and their relative rates of anaerobic degradation were calculated. Also, the biological removal of PAE during the anaerobic digestion of sludge in bench-scale digesters was investigated using DBP and DEHP as model compounds of one biodegradable and one recalcitrant PAE respectively. The degradation of all the PAE tested in this study (DEP, DBP and DEHP) is adequately described by first-order kinetics. Batch and continuous experiments showed that DEP and DBP present in sludge are rapidly degraded under mesophilic anaerobic conditions (a first-order kinetic constant of 8.04 x 10(-2) and 13.69 x 10(-2)-4.35 day(-1) respectively) while DEHP is degraded at a rate between one to two orders of magnitude lower (0.35 x 10(-2)-3.59 x 10(-2) day(-1)). It is of high significance that experiments with anaerobic sludge of different origin (US and Europe) showed that degradation of DEHP occurs under methanogenic conditions. Accumulation of high levels of DEHP (more than 60 mg/l) in the anaerobic digester has a negative effect on DBP and DEHP removal rates as well as on the biogas production.     

Influence of ultrasonication on anaerobic bioconversion of sludge.

The influence of ultrasonication on hydrolysis, acidogenesis, and methanogenesis in anaerobic decomposition of sludge was investigated. The sonicated sludge exhibited prehydrolysis and preacidogenesis effects in the anaerobic decomposition process. First-order hydrolysis rates increased from 0.0384 day(-1) in the control digester to 0.0672 day(-1) in the digester fed, with sludge sonicated at 0.52 W/mL. The sonication appeared to be ineffective in relation to acidogenesis reaction rates, but it provided a better buffering capacity to diminish the adverse effect of acidification. Digesters fed with sonicated sludge demonstrated enhanced methanogenesis over the control unit. Determination by coenzyme F420 verified that sonication is able to promote the growth of methanogenic biomass and facilitate a positive methanogenic microbial development in suppressing the initial methanogenesis limitation. The results suggest that ultrasonication could enhance anaerobic decomposition of sludge, resulting in an accelerated bioconversion, improved organics degradation, improved biogas production, and increased methane content.     

Effects of sludge recirculation rate and mixing time on performance of a prototype single-stage anaerobic digester for conversion of food wastes to biogas and energy recovery

Food wastes have been recognized as the largest waste stream and accounts for 39.25 % of total municipal solid waste in Thailand. Chulalongkorn University has participated in the program of in situ energy recovery from food wastes under the Ministry of Energy (MOE), Thailand. This research aims to develop a prototype single-stage anaerobic digestion system for biogas production and energy recovery from food wastes inside Chulalongkorn University. Here, the effects of sludge recirculation rate and mixing time were investigated as the main key parameters for the system design and operation. From the results obtained in this study, it was found that the sludge recirculation rate of 100 % and the mixing time of 60 min per day were the most suitable design parameters to achieve high efficiencies in terms of chemical oxygen demand (COD), total solids (TS), and total volatile solid (TVS) removal and also biogas production by this prototype anaerobic digester. The obtained biogas production was found to be 0.71 m³/kg COD and the composition of methane was 61.6 %. Moreover, the efficiencies of COD removal were as high as 82.9 % and TVS removal could reach 83.9 % at the optimal condition. Therefore, the developed prototype single-stage anaerobic digester can be highly promising for university canteen application to recover energy from food wastes via biogas production.     

接种比对餐厨垃圾干式厌氧发酵启动的影响

针对不同接种比对餐厨垃圾干式厌氧发酵启动的影响,对比分析了VS接种比分别为0.36和0.90两种情况下,餐厨垃圾干式厌氧发酵启动过程中pH、NH4-N、COD、VFA、甲烷含量等指标的变化。实验结果表明,启动初期2组样品pH分别快速降至4.74和5.68,均呈酸化状态,经碱液调整后,接种比为0.36的处理仍无法正常产气,接种比为0.90的处理,pH逐步提高,系统正常运行,经72 d的发酵实验,COD去除率达90.29%,甲烷含量高于60%的沼气产量达255.4 L,分析可见,VS接种比是干式厌氧发酵处理的重要参数;此外,与传统湿式厌氧发酵处理相比,餐厨垃圾干式厌氧发酵在较高的VFA和氨氮浓度下,仍能正常运行,采用干式厌氧发酵技术处理餐厨垃圾是可行的。     

Biogas production from anaerobic digestion of food waste and relevant air quality implications

Biopower can diversify energy supply and improve energy resiliency. Increases in biopower production from sustainable biomass can provide many economic and environmental benefits. For example, increasing biogas production through anaerobic digestion of food waste would increase the use of renewable fuels throughout California and add to its renewables portfolio. Although a biopower project will produce renewable energy, the process of producing bioenergy should harmonize with the goal of protecting public health. Meeting air emission requirements is paramount to the successful implementation of any biopower project. A case study was conducted by collecting field data from a wastewater treatment plant that employs anaerobic codigestion of fats, oils, and grease (FOG), food waste, and wastewater sludge, and also uses an internal combustion (IC) engine to generate biopower using the biogas. This research project generated scientific information on (a) quality and quantity of biogas from anaerobic codigestion of food waste and municipal wastewater sludge, (b) levels of contaminants in raw biogas that may affect beneficial uses of the biogas, (c) removal of the contaminants by the biogas conditioning systems, (d) emissions of NO_x, SO₂, CO, CO₂, and methane, and (e) types and levels of air toxics present in the exhausts of the IC engine fueled by the biogas. The information is valuable to those who consider similar operations (i.e., co-digestion of food waste with municipal wastewater sludge and power generation using the produced biogas) and to support rulemaking decisions with regards to air quality issues for such applications.

Implications: Full-scale operation of anaerobic codigestion of food waste with municipal sludge is viable, but it is still new. There is a lack of readily available scientific information on the quality of raw biogas, as well as on potential emissions from power generation using this biogas. This research developed scientific information with regard to quality and quantity of biogas from anaerobic co-digestion of food waste and municipal wastewater sludge, as well as impacts on air quality from biopower generation using this biogas. The need and performance of conditioning/pretreatment systems for biopower generation were also assessed.     

空速和二氧化碳对沼气脱硫剂硫容确定的影响

为了弄清空速与二氧化碳含量对氧化铁脱硫剂硫容确定的影响,分别在实验气源为纯硫化氢,空速为40、80、120和160 h-1以及实验气源为二氧化碳含量分别在0%、20%、40%和80%,其余为硫化氢,空速为80 h-1条件下,对T502(粗脱硫剂)和HXT-2(精脱硫剂)2种氧化铁脱硫剂进行了不同测试条件对氧化铁硫容确定影响的研究。研究结果表明,T502和HXT-2氧化铁脱硫剂硫容测试结果随着空速和二氧化碳含量增加而减少,结果显示了在空速较低条件下(120h-1),二氧化碳含量在40%以下时对氧化铁脱硫剂硫容测试结果影响不大,但二氧化碳含量在40%以上时,对氧化铁脱硫剂硫容测试结果影响显著。     

低强度超声波预处理对厨余垃圾厌氧消化的影响

以厨余垃圾为研究对象,实验研究产气效率、pH、SCOD、甲烷浓度及生物降解率5个参数的变化趋势,比较低强度超声波处理对厨余垃圾厌氧消化产气特性的影响,结果表明:(1)低强度超声波处理对厨余垃圾厌氧消化产生明显效果,在不同的超声波强度(100、175和250 W)或处理时间(20和40 min)下,产气效率、累计产气量、pH下降幅度、SCOD增加幅度随处理时间和超声功率增加而增加;在超声波强度250 W和处理时间60 min下出现抑制作用;(2)在超声波强度250 W和处理时间40 min条件下,超声波对厨余垃圾厌氧消化增强效果最明显,累计产气量由未处理的3 513 mL提高至5 007 mL,提高42.6%,甲烷气体浓度由51.25%提高至58.8%,生物降解率由58.11%提高至73.5%.     

UASB处理硫酸盐有机废水的启动

为了考察上流式厌氧污泥床反应器(UASB)处理含硫酸盐有机废水的特性,采用有效容积为10 L的UASB,研究了启动运行过程中COD和SO2-4降解情况、出水VFA和pH值、产气量及颗粒污泥比产甲烷活性(SMA)变化状况。结果表明,接种厌氧颗粒污泥,保持进水COD为1 500 mg/L,SO2-4浓度为100 mg/L,将HRT由24 h缩短至12 h以提高负荷,经历55 d成功启动了UASB反应器;当HRT为12 h,进水COD和SO2-4负荷为3.0 kg/(m3·d)和0.20 kg/(m3·d),COD和SO2-4的去除率分别达到80%和89%,出水VFA为3 mmol/L,产气量达9.5 L/d,颗粒污泥的SMA为86.4 mL/(g VSS·d)。     

Enhancement of batch waste activated sludge digestion by microwave pretreatment.

Batch anaerobic digesters were used to stabilize microwave (MW)-irradiated waste activated sludge (WAS). A low temperature range (50-96 degrees C) MW irradiation was applied. Effects of pretreatment temperature (T) and intensity (I), concentration (C) and percentage of sludge pretreated (PT) were investigated in a multilevel factorial statistical design containing 54 mesophilic batch reactors by monitoring cumulative biogas production (CBP). Variance analysis (ANOVA) determined that the most important factors affecting WAS solubilization were temperature, intensity, and sludge concentration. Improvements in CBP from WAS were significantly affected by sludge percentage pretreated, temperature, and concentration. Pretreatment resulted in 3.6 +/- 0.6 and 3.2 +/- 0.1 fold increases in soluble to total chemical oxygen demand (SCOD/TCOD) at high and low sludge concentrations, respectively. WAS, microwaved to 96 degrees C, produced the greatest improvement in CBP with 15 +/- 0.5 and 20 +/- 0.3% increases over controls after 19 d of digestion at low and high WAS concentrations. Dewaterability of microwaved sludge was enhanced after anaerobic digestion.     

Estimate of the Pollution Removed by Leaching of Standard Domestic Waste: Mass Assessments Carried Out in Batches and Columns

Abstract

Batch and column tests allowed estimation of the mobilization of pollution of standard domestic waste in leachate and biogas. Three laboratory tests (biochemical methane potential (BMP), tank leaching test (TLT), and column tests) have been applied to evaluate the emission of pollutants in liquid and/or gas phase from reconstituted municipal solid waste (MSW) on the basis of French waste. In the case of the batch tests (BMP and TLT), BMP tests indicated a maximum organic carbon share produced by waste (biogas potential) equal to 59% of the initial carbon. The maximum quantity of carbon likely to be leached by the waste (TLT) corresponded to 6% of the carbon contained in the waste. On the other hand, during column tests, 3.3% of carbon was leached and 8% of carbon was evacuated in biogas at the end of a 440-day follow-up. It thus appears that the test conditions have a great in?uence on the remobilization of pollution. In particular it has been proven than the greater the optimization of the liquid/solid ratio, the agitation, the sowing, and the temperature, the greater the pollutant is leached. This study highlights the possible use of batch and column tests to evaluate the pollution risk of a landfill.     

Steam-explosion pretreatment for enhancing anaerobic digestion of municipal wastewater sludge.

This study evaluated the use of steam explosion as a pretreatment for municipal wastewater treatment sludges and biosolids as a technique for enhancing biogas generation during anaerobic digestion. Samples of dewatered anaerobic digester effluent (biosolids) and a mixture of thickened waste activated sludge (TWAS) and biosolids were steam-exploded under differing levels of intensity in this study. The results indicate that steam explosion can solublize components of these sludge streams. Increasing the intensity of the steam-explosion pressure and temperature resulted in increased solublization. The steam-explosion pretreatment also increased the bioavailability of sludge components under anaerobic digestion conditions. Increasing the steam-explosion intensity increased the ultimate yield of methane during anaerobic digestion. Batch anaerobic digestion tests suggested that pretreatment at 300 psi was the most optimal condition for enhanced biogas generation while minimizing energy input. Semicontinuous anaerobic digestion revealed that the results that were observed in the batch tests were sustainable in prolonged operation. Semicontinuous digestion of the TWAS/biosolids mixture that was pretreated at 300 psi generated approximately 50% more biogas than the controls. Semicontinuous digestion of the pretreated biosolids resulted in a 3-fold increase in biogas compared with the controls. Based on capillary suction test results, steam-explosion pretreatment at 300 psi improved the dewaterability of the final digested sludge by 32 and 45% for the TWAS/ biosolids mixture and biosolids, respectively, compared with controls. The energy requirements of the nonoptimized steam-explosion process were substantially higher than the additional energy produced from enhanced digestion of the pretreated sludge. Substantial improvements in energy efficiency will be required to make the process viable from an energy perspective.     

超声与次氯酸钠耦合预处理剩余污泥的中温厌氧消化效果

以某城市污水处理厂剩余污泥为对象,通过实验研究了超声与次氯酸钠预处理对污泥的溶胞效果,以及对后续厌氧消化的影响。结果表明,超声与次氯酸钠耦合作用最优操作条件为超声声能密度1.0 W/mL,作用时间50 min。在此条件下,次氯酸钠投加量为4.023 mg/g SS时,对污泥厌氧消化改善效果最明显,剩余污泥产气率及甲烷含量较对照组分别提高了69.73%和10%。同时污泥VSS去除率由11.11%提高到21.24%,在一定程度上实现了污泥减量。     

Co-composting of fresh tobacco leaves and soil: an exploration on the utilization of fresh tobacco waste in farmland

Environmental Science and Pollution Research - A large amount of fresh tobacco waste with high water content are produced in farmland, and it may cause environmental pollution if it is not properly...     

Microalgae growth using high-strength wastewater followed by anaerobic co-digestion

Integration of algal biofuel production to wastewater anaerobic digestion infrastructure has the potential to increase biogas production, decrease high and variable internal nitrogen loads, and improve sludge digestibility and dewaterability. In this research, two species of microalgae, Spirulina platensis and Chlorella sp., were grown on sludge centrate and a centrate and nitrified wastewater effluent mixture. Harvested algae were co-digested with waste activated sludge (WAS) at varying ratios. High-growth (6.8 g m(-2) x d(-1)), nitrogen (36.5 g m(-3) x d(-1)), and phosphorus (6.5 g m(-3) x d(-1)) uptake rates were achieved with Chlorella on centrate. No growth was observed with S. platensis under the same conditions; however, both organisms grew well on the centrate and effluent mixture. Co-digestion of algae with WAS improved volatile solids reduction. Although co-digestion with S. platensis improved biosolids dewaterability, Chlorella had a slight negative effect on dewaterability compared to WAS alone. The efficiency of energy conversion from photons to biogas generated from Chlorella was estimated at 1.4%.     

不同混合比牛粪玉米秸中温干发酵产沼性能

设置5组牛粪和玉米秸的混合物(干物质比为0∶1、1∶0、1∶1、1∶2、2∶1),研究其在中温35℃下干发酵产沼性能,以产沼性能最好实验组的实验数据为基础,对比研究了两类产气模型。研究结果显示:玉米秸与牛粪的混合干发酵运行效果较好;其中,牛粪和玉米秸干物质比为2∶1时产沼效果最好,产气量最高为81 209 mL,干物质产气率为0.312 m3/kg,整个发酵过程中产气量和甲烷的含量比较稳定,CH4含量最高达56.59%,总固体、挥发性固体的去除率相对较高,分别为26.11%和34.27%。一级动力学模型与多项式函数方程2个产气模型拟合检验结果显示,应用简单的多项式函数即可对产气情况进行相对准确的预测。     

挥发性脂肪酸对厌氧干式发酵产甲烷的影响

为了提高中温干式厌氧间歇发酵效率,研究了发酵过程中间产物———挥发性脂肪酸对产甲烷的影响。实验分2批进行,第1批在牛粪发酵过程中分别添加乙酸、丙酸和丁酸,第2批发酵添加易产生挥发酸的厨余垃圾混合发酵。结果显示,添加单一挥发酸的发酵过程中,添加丙酸的产甲烷速度较慢,因为丙酸降解生成乙酸的速度较慢,减慢了甲烷的形成;混合发酵过程厨余垃圾产甲烷速度比牛粪快,发酵过程产生2个产气高峰;牛粪和厨余垃圾固体物质含量比在11∶1到5∶1范围内较好,比牛粪单独发酵产气多,产酸高但不酸败,产生的挥发酸主要是乙酸和丙酸,其中比例为7∶1混合发酵的产甲烷速率最大,为4.89 mL/(g VS·d)。实验表明,牛粪厌氧干式发酵过程添加一定量的厨余垃圾可加快挥发酸的产生并提高挥发酸产量,从而提高甲烷的产量,但是总挥发酸长时间超过10 000 mg/L,pH降到不适于产甲烷菌生长的范围时,将抑制甲烷的生成,挥发酸积累导致厌氧发酵酸败。     

Valorization of spent coffee grounds recycling as a potential alternative fuel resource in Turkey: An experimental study

In this study, recycling of spent coffee grounds (SCG) as a potential feedstock for alternative fuel production and compounds of added value in Turkey was assessed. The average oil content was found (≈ 13% w/w). All samples (before and after extraction) were tested for scanning electron microscopy (SEM), differential scanning calorimetry (DSC), thermogravimetric analysis (TGA), X-ray diffraction (XRD), calorific value, surface analysis and porosity, Fourier transform infrared (FT-IR), and elemental analysis to assess their potential towards fuel properties. Elemental analysis indicated that carbon represents the highest percentages (49.59% and 46.42%, respectively), followed by nitrogen (16.7% and 15.5%), hydrogen (6.74% and 6.04%), and sulfur (0.851% and 0.561%). These results indicate that SCG can be utilized as compost, as it is rich in nitrogen. Properties of the extracted oil were examined, followed by biodiesel production. The quality of biodiesel was compared with American Society for Testing and Materials (ASTM) D6751 standards, and all the properties complied with standard specifications. The fatty acid compositions were analyzed by gas chromatography. It was observed that coffee waste methyl ester (CWME) is mainly composed of palmitic (35.8%) and arachidic (44.6%) acids, which are saturated fatty acids. The low degree of unsaturation provides an excellent oxidation stability (10.4 hr). CWME has also excellent cetane number, higher heating value, and iodine value with poor cold flow properties. The studies also investigated blending of biodiesel with Euro diesel and butanol. Following this, a remarkable improvement in cloud and pour points of biodiesel was obtained. Spent coffee grounds after oil extraction is an ideal material for garden fertilizer, feedstock for ethanol, biogas production, and as fuel pellets. The outcome of such research work produces valuable insights on the recycling importance of SCG in Turkey.

Implications: Coffee is a huge industry, and coffee has been widely used due to its refreshing properties. This industry generates large quantities of waste. Therefore, recycling of spent coffee grounds for producing alternative fuels and compounds of added value is crucial. Elemental analysis indicated that coffee waste can be utilized as compost, as it is rich in nitrogen. Coffee waste after oil extraction is an ideal feedstock for ethanol and biogas production, garden fertilizer, and as fuel pellets. The low degree of unsaturation provides excellent oxidation stability. Its biodiesel has also excellent cetane number, higher heating value, and lower iodine value.