具有零频特性的隔振器设计与减振性能研究

目的 开展零刚度隔振器的结构设计与减振性能试验验证.方法 现有隔振器在超低频下很难具备良好的隔振特性和较宽的隔振频率.在准零刚度技术的基础上,通过仿真计算和试验分析相结合的方法对零刚度隔振器进行了深入研究.结果 首先,建立了零刚度隔振器的物理模型,对其进行了静力学计算,分析了系统的刚度特性,给出了系统的零刚度条件,从而完成了隔振器的结构设计.然后,通过Adams仿真软件对隔振器进行了动力学分析,得出了其在超低频振动环境下具有较好的隔振效果.最后,对零刚度隔振开展了静力压缩试验、正弦振动试验以及随机振动试验,通过试验验证了隔振器的零刚度特性和优良的隔振性能.结论 实现了零刚度隔振器的结构设计,且该隔振器在0.2～2000 Hz范围内都处于减振状态,传递率未出现大于1的情况.     

某涡桨发动机隔振安装系统弹性参数优化研究

目的降低某型涡桨发动机安装系统中存在的振动耦合。方法在ADAMS中建立该涡桨发动机安装系统的动力学模型,以发动机安装系统模态频率及侧向、垂向模态对应的振动解耦率为优化条件,通过ADAMS/insight模块对该动力学模型进行刚度优化。结果通过优化,发动机安装系统侧向模态频率为8.03 Hz,垂向模态频率为28.23Hz,满足隔振要求。侧向、偏航、俯仰模态实现了振动解耦,解耦率均在97%以上。由于主隔振器结构特点,垂向、航向、滚转模态仍存在振动耦合,可考虑改变主隔振器结构以降低该振动耦合。结论所述方法可提高涡桨发动机安装系统的振动解耦率,降低安装系统的刚度设计难度,进而提高涡桨发动机安装系统的隔振效率。     

考虑机翼柔性影响的发动机安装系统隔振设计研究

目的研究综合考虑安装系统的隔振效率、振型解耦、机翼柔性等因素影响的涡桨发动机安装系统隔振设计方法。方法首先对二自由度系统的动力学特性进行理论推导,得出机翼柔性在安装系统隔振分析中的重要性。进一步将弹性中心理论应用于发动机安装系统设计中,获得双平面五点式安装系统主要设计变量的优选参数。为分析柔性机翼对该设计过程的影响,利用有限元和多体动力学方法建立安装系统的刚柔混合计算模型,并进行分析。结果机翼阻尼对高频共振响应影响较大,垂向刚度比大于2时,安装系统取得较好的减振效果。结论综合考虑机翼柔性及振动解耦等因素的发动机安装系统隔振设计方法可以为航空发动机安装系统的工程设计提供参考。     

基于剪切增稠液体的变阻尼隔振器动力学特性研究

目的研究一种具有变阻尼特性的剪切增稠液体(STF)隔振器。方法首先采用二氧化硅纳米颗粒和聚乙二醇200为工作介质合成剪切增稠液体,通过试验研究剪切增稠液体的流变特性。之后以剪切增稠液体为工作介质,设计一种活塞液压式减振增稠液体隔振器,建立隔振器的动力学模型,并通过数值仿真研究了该隔振器的减振性能;最后,研究剪切增稠液体隔振器隔振性能影响因素。结果当远离共振频率时,隔振器具有小阻尼特性;在共振区附近,由于剪切增稠效应,隔振器阻尼骤然增加,实现对共振峰的有效抑制。结论剪切增稠液隔振器可有效抑制共振峰,同时不会对高频隔振性能产生不利影响,有效解决了传统隔振器线性阻尼的固有缺点。     

捷联惯导减振系统的耦合振动研究

目的研究耦合振动对捷联减振系统的影响。方法建立惯导减振系统动力学模型,并在有限元分析软件中对系统进行模态分析,然后通过扫频试验对比有无偏心情况下的响应。结果安装中心与弹性中心的不重合是导致线振动和角振动耦合的原因。结论对工程中减振器的安装提出了3个方面的要求,尽量保证弹性主轴与惯性主轴重合,避免偏心;增大安装半径,提高角振动与线振动频率比值;增加轴套等定位设备,增加寿命和精度。     

基于PAM-CRASH的飞机着舰拦阻系统动力学仿真分析

目的研究拦阻和着舰过程中拦阻钩的动态响应,为拦阻钩的多冲动力学分析提供依据。方法运用PAM-CRASH软件建立着舰拦阻冲击动力学的有限元模型,将整个过程分解为着舰和拦阻两个不同的阶段,考虑柔性体的建模方法。结果通过仿真分析,得到拦阻着舰过程中响应最大的位置,得到绳索拦阻的最大载荷。结论针对飞机拦阻钩结构动力学模型,就其啮合过程进行了动力学仿真,考虑飞机的航向及下沉速度综合作用下拦阻绳索的动态响应,探索了柔性拦阻绳索结构的动力学模拟方式。     

液-弹隔振器设计与试验分析

目的开展液-弹隔振器的设计及试验验证。方法基于反共振原理建立的液-弹隔振器动力学分析模型,推导了其动力学方程。结果建立了液弹隔振器隔振频率与相关参数的关系,依据相关参数完成了液-弹隔振器的设计,并进行了液-弹隔振器动力学性能相关试验,利用动刚度测试法和传递率测试法验证了液-弹隔振器性能,试验验证了液-弹隔振器高静态刚度和隔振频率点下的低动态刚度特点。结论实现了液-弹隔振器的设计,同时液弹隔振器在隔振频率点下达到60%的减振效果。     

响应面法对PBGA封装元器件的有限元模型修正

目的利用特殊设计夹具来模仿PCB板的典型插入式固定方式,通过响应面法对安装有PBGA的菊花链PCB板有限元模型进行修正。方法有限元模型经过三次响应面修正,每一个修正阶段都计算仿真前三阶频率与相对应的模态试验结果相对比,建立两个目标函数,并利用多目标遗传算法来缩小仿真分析与模态试验结果。结果有限元模型得到了有效的改善。结论响应面法可以从实际出发来提升有限元模型准确度。     

爆炸螺栓分离对热防护系统冲击响应分析

目的考察在爆炸螺栓分离过程中,作用在TPS(热防护系统)上的冲击响应是否会导致其破坏,从而影响航天器飞行安全,对过程进行数值仿真分析。方法提出四阶段仿真方案,基于MSC.Dytran软件,采用流固耦合方法对爆炸螺栓分离过程进行动力学仿真;根据单个爆炸螺栓地面分离试验的结构进行建模和分析,获取结构响应曲线;再根据实测的冲击响应数据,对爆炸过程中炸药及JWL方程的参数等设置进行调整,获取准确爆炸螺栓的分析模型;最后应用于对真实结构中TPS(热防护系统)在分离过程里受爆炸螺栓冲击响应的动力学分析与评估。结果通过参数调整,获得的仿真模型与爆炸螺栓地面分离试验实测结果一致,证明了仿真模型的有效性和四阶段仿真方案的可行性。结论提取的真实结构爆炸螺栓分离过程中作用在TPS(热防护结构)上的最大加速度响应曲线,可用于指导TPS(热防护系统)的设计。     

航炮炮舱结构的炮振响应分析

目的获得航炮发射时炮舱结构的动响应。方法依据火炮发射原理,使用化学爆炸模拟炮口冲击波,建立航炮发射时炮口冲击载荷的表达模型。利用ALE方法处理高压流动空气与炮舱表面的流固耦合问题,通过数值计算获得发射气流冲击载荷作用下炮舱结构的表面压力分布与动响应。利用试验结果,修正载荷与炮舱模型的有关参数。结果计算得到的炮舱动响应与试验结果相比较,误差在可接受范围内。结论建立了一种使用化爆模拟冲击波进行航炮炮舱结构炮振响应仿真计算的技术方法,初步确定了结构危险部位,为后续炮舱结构减振设计创造了条件。     

Effects of two sludge application on fractionation and phytotoxicity of zinc and copper in the soil

The potential harm of heavy metals is a primary concern in application of sludge to the agricultural land. A pot experiment was conducted to evaluate the effect of two sludges on fractionation of Zn and Cu in soil and their phytotoxicity to pakchoi. The loamy soil was mixed with 0%, 20%, 40%, 60% and 80% (by weight) of digested sewage sludge (SS) and composted sludge (SC). The additions of both sludges caused a significant raise in all fractions, resulting in that exchangeable (EXCH) and organic bound (OM) became predominance of Zn and organic bound Cu occupied the largest portion. There was more available amount of Zn and Cu in SS treatments than SC treatments. During the pot experiment, the concentration of Zn in EXCH, carbonate (CAR) and OM and Cu in EXCH and OM fractions decreased in all treatments, so their bioavailability reduced. Germination rate and plant biomass decreased when the addition rate was high and the best yield appeared in 20% mixtures at the harvest of pakchoi. The two sludges increased tissue contents of Zn and Cu especially in the SS treatments. Zn in pakchoi was not only in relationship to ΔEXCH and ΔCAR forms but also in ΔOM forms in the sludge-soil mixtures. Tissue content of Cu in pakchoi grown on SC-soils could not be predicted by ΔEXCH. These correlation rates between Zn and Cu accumulation in pakchoi and variation of different fractions increased with time, which might indicate that sludges represented stronger impacts on the plant in long-term land application.     

Intraspecific differences in effects of co-contamination of cadmium and

A hydroponic experiment was carried out to study intraspecific differences in the effects of different concentrations of cadmium (Cd)(0-10 mg/L) and arsenate (As(V)) (0-8 mg/L) on the growth parameters and accumulation of Cd and As in six wheat varieties Jing-9428, Duokang-1, Jingdong-11, Jing-411, Jingdong-8 and Zhongmai-8. The endpoints of wheat seedlings, including seed germination,biomass, root length and shoot height, decreased with increasing the Cd and As concentrations. Significant differences in seed germination, biomass, root length, shoot height and the accumulation of Cd and As were observed between the treatments and among the varieties (p ＜ 0.05). The lethal dosage 50% were about 20, 80, 60, 60, 80 and 20 mg As/L for Jing-9428, Duokang-1, Jingdong-11,Jing-411, Jingdong-8 and Zhongmai-8, respectively, and the corresponding values for Cd were about 30, 80, 20, 40, 60 and 10 mg Cd/L, respectively. Among the six varieties, Duokang-1 was found to be the most resistant to Cd and As toxicity, and Zhongmai-8 was the most sensitive to Cd and As co-contamination. The resistance of the six varieties was found dependant on the seedling uptake of Cd and As. Duokang-1 was the most suitable for cultivation in Cd and As co-contaminated soils.     

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

EDTA-enhanced phytoremediation of lead contaminated soil by Bidens maximowicziana

Phytoremediation is a potential cleanup technology for the removal of heavy metals from contaminated soils.Bidens maximowicziana is a new Pb hyperaccumulator,which not only has remarkable tolerance to Pb but also extraordinary accumulation capacity for Pb.The maximum Pb concentration was 1509.3 mg/kg in roots and 2164.7 mg/kg in overground tissues.The Pb distribution order in the B. maximowicziana was:leaf>stem>root.The effect of amendments on phytoremediation was also studied.The mobility of soil Pb and the Pb concentrations in plants were both increased by EDTA application.Compared with CK(control check),EDTA application promoted translocation of Pb to overground parts of the plant.The Pb concentrations in overground parts of plants was increased from 24.23-680.56 mg/kg to 29.07-1905.57 mg/kg.This research demonstrated that B.maximowicziana appeared to be suitable for phytoremediation of Pb contaminated soil,especially,combination with EDTA.     

Distribution and ecological effect of mercury in Laogang landfill, Shanghai, China

Laogang landfill near Shanghai is the largest landfill in China, and receives about 10000 t of daily garbage per day, Samples of topsoil and plants were analyzed to evaluate mercury pollution from the landfill. For topsoil samples, there were significant correlations among total mercury （HgT）, combinative mercury （Hgc） and gaseous mercury （HgG）, and content of total organic carbon （TOC）, but, no significantly relationship was found between Hg content and filling time. Hg content changes in vertical profiles with time showed that the average Hgv of profiles 1992, 1996, and 2000 was similar, but their average HgG was quite different. HgT was significantly correlated with Hgc in profile 1992 and 2000, and Hgv was significantly correlated with Hg6 in profile 1996. HgG/Hgv ratio in profile samples decreased in the order of （HgG,/HgT）1992〉（HgG/HgT）1996〉〉（HgG/HgT）2000. A simple outline of Hg release in landfill could be drawn： with increasing of filling time, degradation undergoes different biodegradation, accordingly, gaseous mercury goes through small, more, and small proportion to total mercury. Distribution of Hg in plants was inhomogeneous, following the order of leaf〉root〉stem. The highest value of leaf may be associated with higher atmospheric Hg from landfill. Ligneous plants （e.g. Phyllostachys glanca, Prunus salicina and Ligustrum lucidum） are capable of enriching more Hg than herbaceous plants.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Enzymatic oxidation of aqueous pentachlorophenol

The influence of the nonionic surfactant Tween 80 on pentachlorophenol （PCP） oxidation catalyzed by horseradish peroxidase was studied. The surfactant was tested at concentrations below and above its critical micelle concentration （CMC）. Enhancement of PCP removal was observed at sub-CMCs. The presence of Tween 80 in the reaction mixture reduced enzyme inactivation which occurred through a combination of free radical attack and sorption by precipitated products. A simple first-order model was able to simulate time profiles for enzyme inactivation in the presence or absence of Tween 80. At supra-CMCs, the surfactant caused noticeable reductions in PCP removal, presumably through micelle partitioning of PCP which precluded the hydrophobic PCP molecule from interacting with the enzyme.     

Decomposition of alachlor by ozonation and its mechanism

Decomposition and corresponding mechanism of alachlor, an endocrine disruptor in water by ozonation were investigated. Results showed that alachlor could not be completely mineralized by ozone alone. Many intermediates and final products were formed during the process, including aromatic compounds, aliphatic carboxylic acids, and inorganic ions. In evoluting these products, some of them with weak polarity were qualitatively identified by GC-MS. The information of inorganic ions suggested that the dechlorination was the first and the fastest step in the ozonation of alachlor.     

Degradation of metabolites accumulated of benzo[a]pyrene by coupling Penicillium Chrysogenum with KMnO4

Several main metabolites of benzo[a]pyrene （BaP） formed by Penicillium chrysogenum, Benzo[a]pyrene-1,6-quinone （BP 1,6- quinone）, trans-7,8-dihydroxy-7,8-dihydrobenzo[a]pyrene （BP 7,8-diol）, 3-hydroxybenzo[a]pyrene （3-OHBP）, were identified by high-performance liquid chromatography （HPLC）. The three metabolites were liable to be accumulated and were hardly further metabolized because of their toxicity to microorganisms. However, their further degradation was essential for the complete degradation of BaP. To enhance their degradation, two methods, degradation by coupling Penicillium chrysogenum with KMnO4 and degradation only by Penicillium chrysogenum, were compared; Meanwhile, the parameters of degradation in the superior method were optimized. The results showed that （1） the method of coupling Penicillium chrysogenum with KMnO4 was better and was the first method to be used in the degradation of BaP and its metabolites; （2） the metabolite, BP 1,6-quinone was the most liable to be accumulated in pure cultures; （3） the effect of degradation was the best when the concentration of KMnO4 in the cultures was 0.01% （w/v）, concentration of the three compounds was 5 mg/L and pH was 6.2. Based on the experimental results, a novel concept with regard to the bioremediation of BaP-contaminated environment was discussed, considering the influence on environmental toxicity of the accumulated metabolites.     

Impact of atrazine and nitrogen fertilizers on the sorption of chlorotoluron in soil and model sorbents

Sorption of chlorotoluron in ammonium sulfate, urea and atrazine multi-solutes system was investigated by batch experiments. The results showed application of nitrogen fertilizers to the soil could affect the behavior of chlorotoluron. At the same concentration of N, sorption of chlorotoluron decreased as the concentration of atrazine increased on the day 0 and 6 in soil, respectively. The sorption of chlorotoluron increased from 0 to 6 d when soils were preincubated with deionized water, ammonium sulfate and urea solution for 6 d. That indicated incubation time was one of the most important factors for the sorption of chlorotoluron in nitrogen fertilizers treatments. The individual sorption isotherms of chlorotoluron in rubbery polymer and silica were strictly linear in single solute system, but there were competition sorption between pesticides or between pesticides and nitrogen fertilizers. That indicated the sorption taken place by concurrent solid-phase dissolution mechanism and sorption on the interface of water-organic matter or water-mineral matter.