污水污泥中重金属污染物的溶出过程研究

污水污泥中污染物尤其是重金属的水体浸出作为重要的二次污染途径备受关注。为了探讨污水污泥中重金属的溶出规律,对上海7个污水处理厂的污水污泥进行了重金属总量分析,并采用水平振荡法对上述污水污泥中重金属进行了溶出动力学研究。结果表明,污水污泥中Cu、Cr和Zn的含量均较高,之后依次是Pb、As、Cd和Hg;污水污泥中重金属溶出动力学过程分为快速反应和慢速反应两个过程,可以用Elovich方程进行模拟;污水污泥中各重金属的溶出负荷差异较大,Cu、Cr和Zn的溶出负荷较大,其他较小,但各重金属相对于污水污泥中重金属总量的溶出百分比差异不大,基本处于10%以下。     

调理剂对堆肥产品重金属生物有效性的影响

城市污泥中重金属含量及其生物有效性是限制污泥农用的主要因素,因此,研究污泥堆肥化处理过程中重金属生物有效性,对污泥的农用具有重要意义。实验以城市污泥为原料,以菌菇渣和秸秆为调理剂,设置4个处理:A(污泥∶菌菇渣∶秸秆=1∶0.4∶0.025)、B(污泥∶菌菇渣∶秸秆=1∶0.3∶0.025)、C(污泥∶秸秆=1∶0.12)和D(污泥∶秸秆=1∶0.09),进行好氧堆肥实验,采用BCR顺序提取法测定各种形态的重金属,研究堆肥前后重金属形态的变化规律。结果表明,城市污泥中Cu、Ni、Pb和Cr主要以可氧化态及残渣态存在,生物有效性较低,而Zn和Cd主要以酸溶态和可还原态存在,生物有效性较高;堆肥过程显著降低了Cu、Zn、Ni和Pb的生物有效性,并改变了Cu、Zn、Ni、Pb、Cr和Cd的形态分布,使污泥中的Cu、Zn、Ni、Pb和Cd向着更稳定的可氧化态或残渣态转变;污泥经过堆肥处理后,Cu、Zn和Ni 3种重金属生物有效性关系为:ABCD,与其他处理相比,处理A残渣态的Pb和Cr增加比例较多,综合来看,处理A对重金属生物有效性的降低最为明显,重金属钝化效果最佳。     

污泥与煤、木屑燃烧过程中重金属排放特性研究

为了考察燃料燃烧过程中重金属的迁移转化规律，对污泥、煤与木屑及其混合物在不同温度下氧气中燃烧灰渣中的重金属元素进行分析。结果表明，燃料中重金属在高温燃烧时表现出不同的挥发特性，大部分元素随着温度的升高挥发率增加，其中Cd、Pb和Zn元素挥发性较强，Cr、Cu和Ni挥发性较弱。污泥与木屑混合燃烧灰渣仍以污泥灰为主，重金属含量与污泥灰相近，污泥中混入煤后使灰中大部分重金属含量有所降低。燃烧过程会改变重金属存在形态，污泥与煤原料中以酸溶态和可还原态存在的重金属含量较高，具有较强的生物有效性和迁移性，而燃烧灰渣中酸溶态和可还原态含量显著下降，混合燃烧灰渣中除As外的其他重金属几乎全部以残渣态存在，其含量达到90％以上，焚烧过程有效降低了燃料灰渣中重金属的生物毒性。     

Emission characteristics for co-combustion of leather wastes,sewage sludge,and coal in a laboratory-scale entrained flow tube furnace

Four different mixed fuels consisted of leather waste, coal, and sewage sludge were combusted in a lab-scale entrained flow fluidized bed furnace. The influence of blending ratio on emission characteristics of SO₂, NO_x, HCl, particulate matter (PM), heavy metals, and polychlorinated dibenzo-p-dioxins and polychlorinated dibenzofurans (PCDD/Fs) was studied. Results showed that the mixing of coal with sewage sludge had a complex effect on the emission characteristics. On the one hand, with more sewage sludge blending in the mixed fuel, the acid gas pollutant (SO₂, NO_x) decreased a lot, and the recovery of volatile heavy metals (Cd, Pb) increased at the same time. Furthermore, the leaching toxicity of Cr in the fly ash and bottom ash went down below the national standard with the adding of sewage sludge. On the other hand, the mixing of sewage sludge which consisted of more ash content resulted in the increase of the PM emission. Moreover, the high content of Cu and chlorine in the sewage sludge can promote the formation of polychlorinated dibenzo-p-dioxins and polychlorinated dibenzofurans (PCDD/Fs) when the fuel 3 and 4 were combusted. Most importantly, the concentration of toxic PCDD/Fs in the flue gas produced from fuel 3 and fuel 4 was successfully controlled down below 0.20 ng I-TEQ/Nm³ by the active carbon.

     

蚯蚓直接处理城市剩余污泥的研究

以城市剩余污泥为饲料，根据蚯蚓的繁殖、生长时间，定时引出成蚓换料连续饲养，并改变留在原泥中蚓卵的生存环境来控制卵的发育之蚯蚓养殖方法，并对城市剩余污泥直接饲养蚯蚓的可行性及其重金属转移规律进行研究。结果表明，城市剩余污泥直接饲养蚯蚓是可行的；饲养过程中蚯蚓体内的重金属浓度随着饲养时间而上升，至4个月左右，蚯蚓体内重金属浓度达到极限，且该养殖法具有蚯蚓产量低，对蚯蚓具有易于处理和处置的优点。     

Digested sewage sludge solidification by converter slag for landfill cover

A new technology for solidification of digested sewage sludge referred to as converter slag solidification (CSS) has been developed using converter slag as the solidifying agent and quick lime as the solidifying aid. The CSS technology was investigated by analyzing the physicochemical properties of solidified sludge and determining its microstructural characteristics. The feasibility of using solidified sludge as a landfill cover material was considered in the context of the economical recycling of waste. Sludge solidified using the CSS technology exhibited geotechnical properties that are appropriate for replacing currently used cover soil. Microscopic analyses using XRD, SEM and EDS revealed that the main hydrated product of solidification was CSH (CaO . SiO2 . nH2O), which may play an important role in the effective setting process. Negligible leaching of heavy metals from the solidified sludge was observed. The solidification process of the hydrated sludge, slag and quicklime eliminated the coliform bacteria. Recycled sewage sludge solidified using CCS technology could be used as an effective landfill cover.     

Implications of rhizospheric heavy metals and nutrients for the growth of alfalfa in sludge amended soil

Rhizospheric distribution of nutrients and heavy metals in sludge amended soil was investigated using the rhizobag technique to give an indication of the release of metals from wastewater sludge. DTPA-extractable Zn, Cd, Ni and Mn, and available P, K and NH4+-N in the rhizosphere were markedly depleted when soil was amended with sludge. There was no conspicuous depletion or accumulation of DTPA-extractable Cu in the rhizosphere when the soil was amended with sewage sludge but DTPA-extractable Fe accumulated in the rhizosphere when the soil was amended with increasing amounts of sludge. The pH value in the rhizosphere increased with distance from the roots when soil was amended with larger amounts of sludge. The exchangeable fraction of Cu in the rhizosphere was depleted whether or not the soil was treated with sludge. Carbonate, oxide, organic and residual fractions of Cu and Zn were depleted in the rhizosphere at a distance of 0-2 mm from the roots when soil was amended with 50% sludge. Application of sewage sludge had a positive effect on alfalfa growth. With an increase in sludge amounts, the concentrations of Fe, Cu and Zn in alfalfa shoots did not change. Soil amendments with less than 25% sludge did not increase the availability or mobility of heavy metals. The depletion in rhizospheric DTPA-extractable Zn, Cd and Ni indicates that with the sole exception of Cu, release of metals from sludge amended soil was very limited.     

城市污水厂污泥替代营养盐培养海水小球藻的研究

为了城市污水厂污泥的资源化利用,对污泥替代F/2培养基培养海水小球藻(Chlorella pacifica)进行了研究。首先采用研磨-离心法制备污泥抽提液,将其与F/2培养基按体积比7∶3混合,接种微藻并在优化的条件下培养6 d,逐日测定混合液中无机氮、磷的浓度,培养结束后测定微藻生物量以及干藻中蛋白质、氨基酸和重金属含量。结果表明,将微藻在最佳条件下培养6 d后,混合液中PO34--P、NO2--N、NH4+-N和NO3--N的吸收率分别达到97.32%、96.72%、97.55%和78.13%;与F/2培养基对照组相比,混合液中微藻的生物量增加11.5%;蛋白质、必需氨基酸和非必需氨基酸的含量变化不大。另外,干藻中的重金属含量符合饲料行业标准的要求。     

Effects of phase separation on dewaterability promotion and heavy metal removal of sewage sludge during bioleaching

Environmental Science and Pollution Research - Bioleaching is of increasing interest because of its high efficiency in improving sludge dewaterability and removing heavy metals from sewage sludge....     

Change of PCBs and forms of heavy metals in sewage sludge during thermophilic anaerobic digestion

Determination of seven congeners of PCBs was carried out for sewage sludge before, during and after thermophilic digestion. The overall content of heavy metals (Zn, Cu, Ni, Cd, Pb, Cr) in sludge before and after digestion was determined. Moreover the concentration of heavy metals in particular chemical fractions of the sludge was analyzed. After the thermophilic digestion total concentration of seven PCBs was reduced by 47%, which suggests that thermophilic digestion affects PCB reduction positively. On the 10th d of the process, concentration of lower chlorinated PCBs increased, whereas those of higher chlorinated PCBs decreased. The thermophilic digestion process showed no accumulation of the studied heavy metals in the mobile fractions (exchangeable and carbonate) of the stabilized sewage sludge, except for nickel. The highest increase in zinc, copper, cadmium, and chromium concentration was observed in the organic-sulfide fraction, whereas the highest increase in lead was found in the residual fraction of the sludge. In case of nickel both fractions of organic-sulfide and exchangeable-carbonate fractions were enriched.     

城市污水污泥固结体重金属浸出毒性及路用性能研究

城市污水污泥的重金属离子Pb、Zn超过国家固体废弃物排放最高允许值,属于危险废物。污水污泥的最佳出路是无害化处理,资源化利用,产业化发展。研究了以上海市污水污泥为原料,加入一定比例的固化剂和矿物掺合料使之固结,经养护满足路用强度性能,测试其固结体重金属离子浸出质量浓度亦满足国家固体废弃物排放标准,即污泥中的重金属离子得到有效的束缚和稳定固化,既解决了环境问题,又为污泥产业化发展开辟了新的途径。     

Technology for recovering phosphorus from incinerated wastewater treatment sludge.

A bench-top study of phosphorus-recovering technology from ash associated with incinerated wastewater (sewage) treatment sludge was conducted by adding sulfuric acid to ashes for the elution of phosphorus. With the exception of lead, which is insoluble in sulfuric acid, when the pH of the ash fell below 2.0, phosphorus and various heavy metals in the ash were extracted. The study found that, when alkalis were added to adjust the pH of the ash extract to 4.0, phosphorus was subsequently recovered via filtration. Furthermore, when alkalis were added to adjust the pH to 10, the recovery of various heavy metals was observed. In addition, disposal of the remaining solution (wastewater), which consists of a relatively low concentration of salts, is not considered to be a significant issue since it is within wastewater discharge standards and has been found to be useful as an acid-treating substance.     

污泥中重金属的去除及回收试验

论述了利用离子交换技术循环使用柠檬酸去除污泥中重金属,并置换回收重金属的适宜工艺条件.经柠檬酸处理后,污泥中90%以上的重金属被去除;柠檬酸处理液中的重金属用离子交换法回收,考察了树脂种类、流速、操作方式等因素对离子交换、再生效果的影响;在适宜工艺条件下,重金属的交换率均为100%,而洗脱率均接近90%;柠檬酸及离子交换树脂循环使用,重金属也得到回收,降低了处理成本.     

Speciation of heavy metals during co-composting of sewage sludge with lime

During composting the humification of organic matter will have a significant effect on the physicochemical form of existence of heavy metals. Therefore the present study was conducted to investigate the effect of co-composting sewage sludge with lime on heavy metal speciation and the changes in DTPA extractable metals. Metal speciation was conducted to evaluate the redistribution of Cu, Mn, Ni, Pb and Zn in sewage sludge composted with lime. Sewage sludge was mixed with sawdust in 2:1 (w/w fresh weight) and then composted with lime at 0%, 0.63%, 1% or 1.63% (dry weight) for 100 days. The lime addition did not cause any changes in the different forms of Cu and Mn, but the composting process caused transformations of residual form of Cu and Mn into oxidizable and reducible form, respectively. For Ni, the reducible form was mainly transformed into residual form and lime addition decreased this transformation. Major transformation of different forms of Pb was not found, however the residual form of Pb increased with lime addition. The predominant residual form of Zn was mainly transformed into oxidizable form and the lime addition reduced this transformation. Addition of lime to sewage sludge during composting resulted in lower DTPA extractable metal contents. Therefore, lime is a suitable material to co-compost with sewage sludge to reduce the availability of heavy metals.     

氧化亚铁硫杆菌对电动力处理城市污泥中重金属影响研究

分析了氧化亚铁硫杆菌对污泥中重金属形态及对电动力处理污泥中重金属的去除率影响.氧化亚铁硫杆菌处理后的污泥,pH值降低,部分重金属从稳定态转化为可溶态.经氧化亚铁硫杆菌预处理后的泥样和未经预处理的泥样,在同样条件下用电动力处理,处理结果为:预处理后Cd的去除率从61.85%上升到72.54%,Cu从34.26%上升到63.51%,Zn从65.06%上升到7L 22%.预处理对Cu的影响比Cd、Zn大得多.用电动力处理Cu超标污泥中重金属时,将污泥先用氧化亚铁硫杆菌预处理,可有效地提高其去除效果,处理后的污泥有利于农用.     

Effects of sewage sludge amendment on heavy metal accumulation and consequent responses of Beta vulgaris plants

Use of sewage sludge, a biological residue produced from sewage treatment processes in agriculture is an alternative disposal technique of waste. To study the usefulness of sewage sludge amendment for palak (Beta vulgaris var. Allgreen H-1), a leafy vegetable and consequent heavy metal contamination, a pot experiment was conducted by mixing sewage sludge at 20% and 40% (w/w) amendment ratios to the agricultural soil. Soil pH decreased whereas electrical conductance, organic carbon, total N, available P and exchangeable Na, K and Ca increased in soil amended with sewage sludge in comparison to unamended soil. Sewage sludge amendment led to significant increase in Pb, Cr, Cd, Cu, Zn and Ni concentrations of soil. Cd concentration in soil was found above the Indian permissible limit in soil at both the amendment ratios.

The increased concentration of heavy metals in soil due to sewage sludge amendment led to increases in heavy metal uptake and shoot and root concentrations of Ni, Cd, Cu, Cr, Pb and Zn in plants as compared to those grown on unamended soil. Accumulation was more in roots than shoots for most of the heavy metals. Concentrations of Cd, Ni and Zn were more than the permissible limits of Indian standard in the edible portion of palak grown on different sewage sludge amendments ratios. Sewage sludge amendment in soil decreased root length, leaf area and root biomass of palak at both the amendment ratios, whereas shoot biomass and yield decreased significantly at 40% sludge amendment. Rate of photosynthesis, stomatal conductance and chlorophyll content decreased whereas lipid peroxidation, peroxidase activity and protein and proline contents, increased in plants grown in sewage sludge-amended soil as compared to those grown in unamended soil.

The study clearly shows that increase in heavy metal concentration in foliage of plants grown in sewage sludge-amended soil caused unfavorable changes in physiological and biochemical characteristics of plants leading to reductions in morphological characteristics, biomass accumulation and yield. The study concludes that sewage sludge amendment in soil for growing palak may not be a good option due to risk of contamination of Cd, Ni and Zn and also due to lowering of yield at higher mixing ratio.     

造纸工业污泥燃烧特性及动力学实验研究

在不同升温速率及与其他污泥不同混合比例条件下，利用热重法对造纸污泥和含工业污水污泥进行了实验研究。结果表明，造纸污泥与含工业污水污泥表现出不同的DTG曲线形式，其中造纸污泥固定碳燃烧峰失重较为明显。随着升温速率的提高，造纸污泥的燃烧速率加大，燃尽时间缩短，提高了其综合燃烧特性；加入含工业污水污泥后，造纸着火性能及燃尽性能均得到改善。采用积分法（Coats-Redfern方程）计算得到各阶段燃烧反应的机理方程及相应的活化能参数，表明活化能的大小与试样的燃烧阶段是相对应的。     

Distribution behavior of heavy metals investigated in a laboratory-scale incinerator

The distribution behavior of Pb, Cd, Fe, Cu, Mo and Zn was determined in a laboratory-scale incinerator. Points of interest were the influence of the temperature and combustion atmosphere on the emission rates of those metals, orientating at frequent combustion conditions of accidental fires. The experiments were carried out at 600 degrees C and 800 degrees C in N2, air, N2 + HCl and air + HCl atmospheres. Furthermore, the influence of the matrix (quartz, polyethylene and cellulose powder) on the distribution behavior of the heavy metals was investigated as well. It was determined whether the distribution behavior of Cu, Pb and Cd were affected by the other heavy metals. In conclusion, it was found that in air and N2 atmosphere a temperature increase from 600 degrees C to 800 degrees C and the addition of the matrix had no effect on the evaporation rates of the heavy metals, except for Cd. Addition of gaseous HCl led to increased evaporation of the heavy metals. The increase of the evaporation rates during the experiments with matrix was higher for Fe, remained the same for Pb, Cd, Zn, and lower for Mo and Cu compared to the experiments without matrix.     

Influence of ozone pre-treatment on sludge anaerobic digestion: removal of pharmaceutical and personal care products

The effect of an oxidative pre-treatment with ozone on the removal of Pharmaceutical and Personal Care Products (PPCPs) during the anaerobic digestion of sewage sludge has been investigated. Besides, the digested sludge characteristics in terms of pathogens content, dewatering properties, heavy metals content and linear alkylbenzene sulfonates (LAS) were determined. During ozonation (20mg O(3)/g TSS), about 8% of volatile solids (VS) and 60% of the chemical oxygen demand (COD) were solubilized. However, no mineralization was observed. The elimination of VS and total COD during anaerobic digestion were not affected by ozone treatment with efficiencies ranging from 60% to 65%. All PPCPs considered were removed during anaerobic treatment of sludge, with efficiencies ranging from 20% to 99%. No significant influence of ozone pre-treatment was observed on PPCPs elimination except for carbamazepine. Pathogens, heavy metals and LAS contents after conventional and pre-ozonation treatment of sewage sludge were below the legal requirements. However, the dewatering properties of sludge were deteriorated when the ozone pre-treatment was applied.     

PCDD/F, PAH and heavy metals in the sewage sludge from six wastewater treatment plants in Beijing, China

In order to better understand land application of sewage sludge, the characterization of heavy metals, PCDD/F and PAHs in sewage sludge was investigated from six different wastewater treatment plants (WWTP) in Beijing City, China. It was found that the total concentrations of Zn in Wujiacun (WJC) sewage sludge, and Cd and Hg in sewage sludge generated from all of the six different places are higher than Chinese regulation limit of pollutants for sludge to be used for agriculture (GB18918-2002). The levels of 16 PAHs that have been categorized as priority pollutants by US EPA in the sewage sludge samples varied from 2467 to 25923 microg/kg (dry weight), the highest values of 25923 microg/kg being found in WJC WWTP. The concentrations of Benzo[a]pyrene were as high as 6.1mg/kg dry weight in WJC sewage sludge, exceeding the maximum permitted content by GB18918-2002. Individual PAH content varies considerably with sewage samples. The ratios of anthracene to anthracene plus phenanthrene (An/178), benz[a]anthracene to benz[a]anthracene plus chrysene (BaA/228), indene[1,2,3-cd]pyrene to indene[1,2,3-cd]pyrene plus benzo[g,h,i]perylene (In/In+BP), and fluoranthene to fluoranthene plus pyrene (Fl/Fl+Py) suggest that petroleum and combustion of fossil fuel were the dominant contributions for the PAHs in sewage sludge. The concentrations of total PCDD/F in the sewage sludge ranged from 330 to 4245 pg/g d.w. The toxicity equivalent concentrations is between 3.47-88.24 pg I-TEQ according to NATO/CCMS, which is below Chinese legislation limit value proposed for land application. The PCDD/F congener/homologue profiles found in the Beijing samples indicated that the high chlorinated PCDD/F contamination might originate mainly from PCP-related source and depositional sources while the low chlorinated PCDD/F homologues could be originating from incineration or coal combustion. The major source of PCDD/Fs in Beijing sludge is still unclear.