用高效染料脱色菌和PVA降解菌混合培养液处理印染废水

在厌气－好气－活性碳三级串联工艺系统中，用７株高效染料脱色降解菌在厌气池中接种，在好气池中用聚乙烯醇降解菌富集培养液接种挂膜处理含ＰＶＡ和ＢＯＤ５／ＣＯＤｃｒ＜０．２的印染废水，经日处理１７ｔ废水的中试表明，当进水ＣＯＤｃｒ，ＢＯＤ５，ＰＶＡ，洗涤剂和色度含量分别为６８０ｐｐｍ，１１０ｐｐｍ，１３４ｐｐｍ，２．９４ｐｐｍ和６５倍时，在厌气池，好气池和活性碳池中的水力负荷分别为３．１７，３．０，１４     

硫酸根对颗粒铁去除铬动力学影响研究

铁渗透反应格栅是铬污染地下水的有效去除技术,但地下水中SO42-对铁格栅长期运行性能影响还不清楚。文章采用批实验和柱实验的方法,分别研究了硫酸根离子浓度对颗粒铁从液相去除常量C(rVI)(20mg/L)的动力学影响及这种影响随时间的变化。批试验表明,随SO42-浓度的增加,C(rVI)的面积标准化速率系数kSA增加。柱试验采用三个平行柱实验系统连续输入含20mg/LC(rVI)的模拟地下水(含或不含SO42(-1000mg/L))。柱实验表明,运行100PV以前,SO42-显著增大颗粒铁对C(rVI)的面积标准化速率常数kSA,随后SO42-增强作用逐渐减弱,运行337PV时,SO42-没有明显的影响。硫酸根离子通过在铁表面形成配合物而加速铁的溶解,增加颗粒铁的表面活性,从而增强颗粒铁对C(rVI)的去除,生物作用不强时可以不考虑硫酸根对铁格栅长期运行性能的影响。     

Weak magnetic field accelerates chromate removal by zero-valent iron

Weak magnetic field(WMF) was employed to improve the removal of Cr(VI) by zero-valent iron(ZVI) for the first time. The removal rate of Cr(VI) was elevated by a factor of 1.12–5.89 due to the application of a WMF, and the WMF-induced improvement was more remarkable at higher Cr(VI) concentration and higher p H. Fe2+was not detected until Cr(VI) was exhausted, and there was a positive correlation between the WMF-induced promotion factor of Cr(VI) removal rate and that of Fe2+release rate in the absence of Cr(VI) at pH 4.0–5.5. These phenomena imply that ZVI corrosion with Fe2+release was the limiting step in the process of Cr(VI) removal. The superimposed WMF had negligible influence on the apparent activation energy of Cr(VI) removal by ZVI, indicating that WMF accelerated Cr(VI)removal by ZVI but did not change the mechanism. The passive layer formed with WMF was much more porous than without WMF, thereby facilitating mass transport. Therefore,WMF could accelerate ZVI corrosion and alleviate the detrimental effects of the passive layer, resulting in more rapid removal of Cr(VI) by ZVI. Exploiting the magnetic memory of ZVI, a two-stage process consisting of a small reactor with WMF for ZVI magnetization and a large reactor for removing contaminants by magnetized ZVI can be employed as a new method of ZVI-mediated remediation.     

Bio-immobilization and recovery of chromium using a denitrifying biofilm system: Identification of reaction zone, binding forms and end products

Chromium is an important resource in strategic metals. Different from most studies focusing on the bio-reduction of hexavalent chromium [Cr(VI)], this study aims to achieve the immobilization and recovery of chromium using a sequencing batch biofilm reactor. Results showed that Cr(VI) removal efficiency remained more than 99%, and 97% of reduced Cr(III) was immobilized in the biofilm. Immobilization zone, chromium forms and extracellular polymeric substances composition changes were combined to reveal the mechanism of Cr(VI) reduction and immobilization. The chromium distribution in biofilm demonstrated that intercellular layer was the main active zone with an immobilization amount of 891.70±126.32 mg/g-VSS. The reduced products analysis confirmed that trivalent chromium [Cr(III)] chelated with carboxyl, amino and other functional groups and immobilized in the form of organic Cr(III). The digestion method realized a chromium recovery efficiency of 74.59%. This study provides an alternative method for the bioremediation and resources recovery in chromium polluted wastewater.     

Virus Type-Specific Removal in a Full-Scale Membrane Bioreactor Treatment Process

We investigated removal of noroviruses, sapoviruses, and rotaviruses in a full-scale membrane bioreactor (MBR) plant by monitoring virus concentrations in wastewater samples during two gastroenteritis seasons and evaluating the adsorption of viruses to mixed liquor suspended solids (MLSS). Sapoviruses and rotaviruses were detected in 25% of MBR effluent samples with log reduction values of 3- and 2-logs in geometric mean concentrations, respectively, while noroviruses were detected in only 6% of the samples. We found that norovirus and sapovirus concentrations in the solid phase of mixed liquor samples were significantly higher than in the liquid phase (P < 0.01, t test), while the concentration of rotaviruses was similar in both phases. The efficiency of adsorption of the rotavirus G1P[8] strain to MLSS was significantly less than norovirus GI.1 and GII.4 and sapovirus GI.2 strains (P < 0.01, t test). Differences in the adsorption of viruses to MLSS may cause virus type-specific removal during the MBR treatment process as shown by this study.     

Synthesis, characterization and application of Lagerstroemia speciosa embedded magnetic nanoparticle for Cr(VI) adsorption from aqueous solution

Lagerstroemia speciosa bark (LB) embedded magnetic nanoparticles were prepared by co-precipitation of Fe²⁺ and Fe³⁺ salt solution with ammonia and LB for Cr(VI) removal from aqueous solution. The native LB, magnetic nanoparticle (MNP), L. speciosa embedded magnetic nanoparticle (MNPLB) and Cr(VI) adsorbed MNPLB particles were characterized by SEM–EDX, TEM, BET-surface area, FT-IR, XRD and TGA methods. TEM analysis confirmed nearly spherical shape of MNP with an average diameter of 8.76 nm and the surface modification did not result in the phase change of MNP as established by XRD analysis, while led to the formation of secondary particles of MNPLB with diameter of 18.54 nm. Characterization results revealed covalent binding between the hydroxyl group of MNP and carboxyl group of LB particles and further confirmed its physico-chemical nature favorable for Cr(VI) adsorption. The Cr(VI) adsorption on to MNPLB particle as an adsorbent was tested under different contact time, initial Cr(VI) concentration, adsorbent dose, initial pH, temperature and agitation speed. The results of the equilibrium and kinetics of adsorption were well described by Langmuir isotherm and pseudo-second-order model, respectively. The thermodynamic parameters suggest spontaneous and endothermic nature of Cr(VI) adsorption onto MNPLB. The maximum adsorption capacity for MNPLB was calculated to be 434.78 mg/g and these particles even after Cr(VI) adsorption were collected effortlessly from the aqueous solution by a magnet. The desorption of Cr(VI)-adsorbed MNPLB was found to be more than 93.72% with spent MNPLB depicting eleven successive adsorption–desorption cycles.     

γ-射线辐照法去除水中的六价铬

以人工配制的含Cr水溶液[Cr(VI)=42mg/L]为研究对象,从动力学的角度考察了不同实验条件对γ-射线辐照还原Cr(VI)的影响.结果表明,初始pH值对Cr(VI)还原影响较大,酸性条件有利于Cr(VI)的还原,在15kGy的辐照强度下,pH2时,Cr(VI)的去除率达86.2%,而pH5和pH7时,Cr(VI)的去除率仅分别为36.3%和22.2%.乙醇的存在提高了Cr(VI)的辐照还原动力学常数.在乙醇添加量为0.1%(体积比),pH2的条件下,在较低的辐照强度(5kGy)下就可获得较高的Cr(VI)去除率(99.9%).中性条件下(pH7),添加1mmol/L的碳酸钠对Cr(VI)的还原有一定促进作用,而酸性条件下(pH2)则效果不明显.试验还考察了充N₂或充O₂对Cr(VI)辐照还原效果的影响,充N₂气可增强Cr(VI)的还原效果,而充O₂则抑制Cr(VI)的还原.     

零价铁PRB修复硝酸盐和铬复合污染地下水

通过连续流动试验研究了Fe0(零价铁)-PRB(渗透反应格栅)修复受NO₃--N、Cr(Ⅵ)以及NO₃--N和Cr(Ⅵ)复合污染模拟地下水的反应特性,分析了Fe0对NO₃--N和Cr(Ⅵ)的氧化还原产物,并且对NO₃--N和Cr(Ⅵ)的相互影响进行了研究. 采用粒径为0.15～0.42 mm的Fe0和粒径为0.15 mm的活性炭作为PRB反应介质,二者的质量比为1∶1. 结果表明,Fe0单独与NO₃--N反应情况下,当进水中ρ(NO₃--N)为20 mg/L时,去除率达95%,NO₂-为还原过渡状态,NH₄+是主要产物,出水pH从原水的7.1升至9.0左右,出水中ρ(TFe)<0.60 mg/L. Fe0处理Cr(Ⅵ)情况下,对Cr(Ⅵ)有较高的去除效果,进水中ρ〔Cr(Ⅵ)〕为10 mg/L时,去除率达96%,反应产物Fe3+和Cr(Ⅲ)可以形成沉淀附着在反应介质上,不会迁移到“下游”水体中,出水pH从原水的7.0升至8.0左右,出水中ρ(TFe)<0.30 mg/L. Fe0去除NO₃--N和Cr(Ⅵ)复合污染时,共存的NO₃--N对Cr(Ⅵ)的去除效果没有影响,Cr(Ⅵ)的存在降低了NO₃--N的去除效果.      

热活化过硫酸钠耦合甲酸技术研究——处理水溶液中四氯化碳与六价铬污染

以甲酸为活化剂,耦合热活化过硫酸钠技术产生还原性二氧化碳阴离子自由基（CO₂^·-）,从而还原去除水溶液中四氯化碳（CT）和Cr（VI）,考察过硫酸钠和甲酸初始浓度的影响以及复合污染处理效果.结果表明：当过硫酸钠与甲酸浓度均为100mmol/L时,单独CT或Cr（VI）分别在120min、60min内基本完全去除（50℃）,且污染物去除效率随过硫酸钠及甲酸浓度升高而增强.在CT和Cr（VI）复合污染体系中,Cr（VI）的存在能够抑制CT降解,且抑制程度随Cr（VI）初始浓度升高而提高,但Cr（VI）去除率随CT初始浓度增大而升高.加入CO₂^·-猝灭剂（甲基紫精）能够抑制CT降解,但促进Cr（VI）去除,表明有机物的存在能够增强Cr（VI）去除效率.     

Electrochemical reduction of Cr(VI) in the presence of sodium alginate and its application in water purification

Chromium (Cr) is used in many manufacturing processes, and its release into natural waters is a major environmental problem today. Low concentrations of Cr(VI) are toxic to human health and living organisms due to the carcinogenic and mutagenic nature of this mineral. This work examined the conversion of Cr(VI) to Cr(III) via electrochemical reduction using gold electrode in an acidic sodium alginate (SA) solution and subsequent removal of the produced Cr(III)-SA by the polymer-enhanced ultrafiltration (PEUF) technique. A solution of SA in nitric acid was used both as an electrolytic medium during the voltammetric measurements and bulk electrolysis and as an extracting agent during the PEUF technique. The electroanalysis of Cr(VI) was performed by linear sweep voltammetry in the presence of acidic SA solution to study its voltammetric behavior as a function of the Cr(VI) concentration, pH, presence of Cr(III), SA concentration and scan rate. In addition, the quantitative reduction of Cr(VI) to Cr(III) was studied through the bulk electrolysis technique.The results showed efficient reduction with well-defined peaks at approximately 0.3 V vs. Ag/AgCl, using a gold working electrode. As the pH increased, the reduction signal strongly decreased until its disappearance. The optimum SA concentration was 10 mmol/L, and it was observed that the presence of Cr(III) did not interfere in the Cr(VI) electroanalysis. Through the quantitative reduction by bulk electrolysis in the presence of acidic SA solution, it was possible to reduce all Cr(VI) to Cr(III) followed by its removal via PEUF.     

Study on activated carbon in chromium-containingwastewater treatment by XPS

Ｓｔｕｄｙｏｎａｃｔｉｖａｔｅｄｃａｒｂｏｎｉｎｃｈｒｏｍｉｕｍ－ｃｏｎｔａｉｎｉｎｇｗａｓｔｅｗａｔｅｒｔｒｅａｔｍｅｎｔｂｙＸＰＳＹａｎｇＪｕｎ；ＷａｎｇＹｕｎｘｉｕ（ＳｈａｎｄｏｎｇＵｎｉｖｅｒｓｉｔｙｏｆＴｅｃｈｎｏｌｏｇｙ，Ｊｉｎａｎ２５０...     

乙酰螺旋霉素废水生物处理的试验研究

采用相同体积 (6 2L)的升流厌氧污泥床和厌氧复合床处理乙酰螺旋霉素废水 ,当容积负荷为 6 0kg(COD) (m3 ·d)时 ,升流厌氧污泥床和厌氧复合床反应器对SS、COD、BOD5的去除率分别为 6 7 4 %、85 1%、91 2 %和 75 6 %、91 7%、96 1%,结果表明厌氧复合床是高效实用的厌氧生物反应器 ;厌氧出水采用相同体积 (6 4L)的生物接触氧化工艺和周期循环活性污泥系统进行处理 ,当容积负荷为 1 6kg(COD) (m3 ·d)时 ,生物接触氧化反应器和周期循环活性污泥系统对SS、COD、BOD5的去除率分别为 87 9%、85 1%、92 8%和 91 6 %、88 7%、95 4 %,结果表明周期循环活性污泥系统是高效实用的好氧生物反应器 .     

生物硫铁复合材料处理含铬废水及铬资源化研究

研究了由硫酸盐还原菌(SRB)与其原位生成的纳米硫铁化合物组成的生物硫铁复合材料(生物硫铁)的耐铬性能和再生性能,并利用其再生特性,设计了处理高浓度含铬废水及铬资源化的还原-再生循环处理工艺.结果表明,生物硫铁处理含铬废水后,污泥中的SRB仍具有活性,能以反应产物Fe3+和S单质为电子受体,重新生成生物硫铁;而且SRB在Cr(VI)浓度600mg/L的废水中仍能存活并逐渐将Cr(VI)去除.还原-再生循环处理工艺处理含铬废水结果表明,出水Cr(VI)低于0.019mg/L,总Cr低于0.929mg/L,能达标排放.经10个循环处理后污泥中铬(Cr2O3)含量达到40.47%,铬铁比达到6.98,污泥达到冶金级(湿法冶炼铬)铬矿标准和化工级铬矿标准,可资源化利用.     

不同生物反应器中基因工程菌生物强化处理阿特拉津研究

在膜-生物反应器(MBR)和复合生物反应器中,考察基因工程菌生物强化处理阿特拉津去除效果,并对基因工程菌浓度和降解基因atzA基因丰度变化进行检测.结果表明,阿特拉津对COD和氨氮的生物去除活性具有一定的抑制作用;基因工程菌生物强化后,COD及氨氮的去除效率得到恢复.MBR对COD和氨氮的去除效果优于复合生物反应器.基...     

Thermal stabilization of chromium slag by sewage sludge: Effects of sludge quantity and temperature

To investigate the feasibility of detoxifying chromium slag by sewage sludge,synthetic chromium slag containing 3% of Cr(VI) was mixed with sewage sludge followed by thermal treatment in nitrogen gas for stabilizing chromium.The effects of slag to sludge ratio(0.5,1 and 2) and temperature(200,300,500,700 and 900°C) on treatment efficiency were investigated.During the mixing process before thermal treatment,59.8%-99.7% of Cr(VI) was reduced,but Cr could be easily leached from the reduction product.Increasing heating temperature and decreasing slag to sludge ratio strengthened the reduction and stabilization of Cr(VI).When the slag to sludge ratio was 0.5 and thermal treatment temperature was 300°C,the total leached Cr and Cr(VI) declined to 0.55 mg/L and 0.17 mg/L respectively,and 45.5% of Cr in the thermally treated residue existed as residual fraction.A two-stage mechanism was proposed for the reduction and stabilization of Cr.     

Shewanella oneidensis MR-1对Cr(VI)的还原及其影响因素

在实验室纯培养条件下,探讨厌氧体系中Shewanella oneidensis MR-1对Cr（VI）的还原能力,采用扫描电镜（SEM）-能谱（EDS）、X射线光电子能谱（XPS）等方法进行表征.结果表明,S.oneidensis MR-1介导下不同浓度Cr（VI）的生物转化与微生物对铬的耐受特性密切相关,低浓度Cr（VI）对其生长影响不大,高浓度时细菌生长则受到抑制,进而抑制Cr（VI）的还原率;菌株对Cr（VI）的还原作用随着接种菌悬液量的增加而增强;菌株最适生长pH值为中性,弱碱性环境比酸性环境更有利于菌株对Cr（VI）的还原;增加Fe（Ⅲ）的量会加快Cr（VI）完全还原的速率.通过SEM-EDS和XPS分析,在对Cr（VI）进行处理5d后,菌体表面有Cr（VI）和Cr（Ⅲ）两种形态存在,证实S.oneidensis MR-1在对Cr（VI）进行还原的同时也伴有少量的吸附作用.微生物还原为环境中Cr（VI）的去除以及解毒提供了一种有效的方法.     

铬渣浸溶Cr(Ⅵ)溶解释放规律研究-以锦州堆场铬渣为例

通过锦州地区铬渣样品静态浸溶实验,测定不同固液比、浸出时间、浸取剂pH及组成、振荡速度、铬渣粒度大小、温度等因素对铬渣中Cr(VI)溶解释放的影响,揭示铬渣中Cr(VI)析出、释放机理。结果显示,稀释作用在不同固液比浸出中起主导作用,随固液比的降低,Cr(VI)浸出浓度逐渐降低,但是Cr(VI)浸出总量却在增加;随着浸出时间的增大,浸出Cr(VI)浓度随之增大;铬渣浸出液碱性很高,在铬渣溶解释放过程中,随酸性增强Cr(VI)溶解量相应增大,体现强的酸中和能力;随着振荡速度增加,Cr(VI)溶解释放速度明显加快;粒径越小,铬酸盐的溶解释放速度越快,溶解作用越充分;铬渣的浸出为吸热反应过程,铬渣溶解度随温度升高而增大。铬渣中Cr(Vl)溶解释放速率服从菲克(Fick)扩散定律。研究结果为铬渣危害的评价、监测及铬渣污染有效防治提供参考。     

Preparation of cross-linked magnetic chitosan with quaternary ammonium and its application for Cr(VI) and P(V) removal

Pollutants that exist in anionic species are issues of concern in water treatment. Compared to cationic pollutants, the removal of anionic pollutants by adsorption is more difficult because most adsorbents carry predominantly negative charges in neutral and alkaline environments. In this study, a cross-linked chitosan derivative with quaternary ammonium and magnetic properties（QM-chitosan） was prepared and employed to remove chromium（VI） and phosphorus（V）（Cr（VI） and P（V）） from aqueous environments. The QM-chitosan was characterized by Fourier transform infrared spectrometry（FT-IR）,thermogravimetric analysis（TGA）, energy dispersive X-ray（SEM-EDX） and zeta potential.Batch experiments show that QM-chitosan can effectively remove Cr（VI） and P（V）, and the main mechanism was believed to be electrostatic interaction. A pseudosecond-order model was fitted to describe the kinetic processes of Cr（VI） and P（V） removal. The adsorption isotherms of both Cr（VI） and P（V） on the QM-chitosan were well fitted by the Langmuir isotherm equation. The saturated adsorption capacity of P（V）（2.783 mmol/g） was found to be higher than that of Cr（VI）（2.323 mmol/g）, resulting from the size of the H2PO-4ions being smaller than that of the HCr O-4ions. However, the theoretical calculation and experimental results showed that QM-chitosan had a stronger affinity for Cr（VI） than P（V）. The adsorption–desorption of the QM-chitosan was evaluated, and high regeneration rates were demonstrated.     

土柱淋洗法修复铬污染土壤的水力梯度优化试验

针对重金属污染土壤的修复,淋洗法是一种比较成熟的方式,但目前研究主要聚焦于淋洗剂的选择,而关于水力停留时间对淋洗效果影响的研究相对较少.水力梯度是影响水力停留时间的重要因素,优化水力梯度能够缩短修复周期,降低淋洗成本,有效提高淋洗效率,为现场淋洗修复工程应用提供参考.本文针对人工制备的不同质地的铬污染土壤进行了土柱淋洗试验,探究了土柱淋洗过程中不同水力梯度条件下淋出液的pH值、淋洗液渗流速度和淋洗前后不同类型土壤中Cr（VI）及总Cr含量的变化情况,并根据土壤中Cr（VI）、总Cr去除情况对水力梯度进行了优化,研究结果表明淋洗铬污染土壤的最佳柠檬酸浓度为0.15 mol·L^-1,淋洗铬污染壤土、砂质壤土和砂土的最佳水力梯度分别为7.2、3.6和1.2,总Cr去除率分别达到82.86%、77.27%和82.15%.     

Kinetics and mechanism of hexavalent chromium removal by basic oxygen furnace slag

Basic oxygen furnace slag(BOFS) has the potential to remove hexavalent chromium(Cr(VI))from wastewater by a redox process due to the presence of minerals containing Fe2+. The effects of the solution p H, initial Cr(VI) concentration, BOFS dosage, BOFS particle size, and temperature on the removal of Cr(VI) was investigated in detail through batch tests. The chemical and mineral compositions of fresh and reacted BOFS were characterized using scanning electron microscope(SEM) equipped with an energy dispersive spectrometer(EDS)system and X-ray diffractometer(XRD). The results show that Cr(VI) in wastewater can be efficiently removed by Fe2+released from BOFS under appropriate acidic conditions. The removal of Cr(VI) by BOFS significantly depended on the parameters mentioned above. The reaction of Cr(VI) with BOFS followed the pseudo-second-order kinetic model. Fe2+responsible for Cr(VI) removal was primarily derived from the dissolution of Fe O and Fe3O4 in BOFS. When H2SO4 was used to adjust the solution acidity, gypsum(Ca SO4·2H2O)could be formed and become an armoring precipitate layer on the BOFS surface, hindering the release of Fe2+and the removal of Cr(VI). Finally, the main mechanism of Cr(VI) removal by BOFS was described using several consecutive reaction steps.