湿法解毒还原工艺对铬渣中Cr(Ⅵ)的治理特性

以治理铬渣中的Cr(Ⅵ)污染为目的,提出了硫酸浸出-硫酸亚铁还原的铬渣湿法解毒工艺,在对铬渣处理前后的表面形貌进行表征的基础上,探究了不同处理条件下铬渣中Cr(Ⅵ)的处理效果及其修复机理。结果表明:铬渣湿法球磨时间为20 min时,铬渣颗粒98.68%过200目筛,水溶性Cr(Ⅵ)的浸出率可达40.96%;铬渣硫酸添加量为60%,液固比为4∶1,酸溶时间为2.5 h时,Cr(Ⅵ)浸出趋于饱和,此时浸出终点pH为5.8,水溶性和酸溶性Cr(Ⅵ)总浸出率为95.38%;硫酸亚铁添加量为40%时,铬渣中Cr(Ⅵ)含量下降为1.38 mg/kg。铬渣中Cr(Ⅵ)的去除主要与硫酸对含Cr(Ⅵ)矿物的溶解、SO₄2-和CrO₄2-的离子交换以及Fe(Ⅱ)对溶液中Cr(Ⅵ)的还原作用有关。     

铬渣浸出毒性试验研究

铬渣给环境带来的危害一直困扰着铬盐行业的发展 ,其浸出毒性研究有利于对铬渣危害的监测评估、治理及综合利用。本试验对新渣和陈渣的浸出毒性进行了探讨 ,同时对铬渣中Cr(Ⅵ )进行全量溶取 ,并分析铬渣中主要阴、阳离子的浸出行为。从而提出适宜于评价铬渣浸出毒性的试验方法 ,即 :液固比 2 0∶1,浸取时间 8h、提取剂为HAC NaAC(pH5 0± 0 2 ) ,粒径为 12 0目的浸出体系     

高温自蔓延还原解毒固化铬渣技术研究

采用高温自蔓延技术处置铬渣,探讨了高温自蔓延技术还原解毒固化铬渣的机制。以铝粉和三氧化二铁作铝热剂,与铬渣充分混合,用镁条点燃引发自蔓延反应,最终得到铬渣固化体。实验结果表明:高温自蔓延技术能有效固化铬渣,铬渣的掺渣率高达44.94%。浸出实验结果表明:A组(铬渣原样)铬渣固化体总铬浸出浓度未检出;B组(铬渣原样+重铬酸钾)铬渣固化体总铬浸出浓度为0.117 76 mg/L,远远低于国标(GB 5085.3-2007)限值15 mg/L,六价铬浸出浓度未检出。XRD分析表明:铬渣还原解毒固化机制主要是六价铬在自蔓延反应中被还原为三价铬,再与其他金属化合物在高温熔融状态下生成含铬尖晶石,铬以离子键Cr—O的形式参与尖晶石的晶格形成。     

“Achromobacter sp. CH-1-Cr(Ⅵ)-H2O”体系Cr(Ⅵ)还原的电化学行为

采用循环伏安法探明了"Achromobacter sp.CH-1-Cr(Ⅵ)-水"体系的电化学行为.结果表明:循环伏安曲线上-0.62V(相对于SCE)的电流峰对应的反应为Cr(Ⅵ)还原成Cr(Ⅲ)的反应,在电势为-0.82V时Cr(Ⅲ)开始还原为零价铬.体系中的电极反应为不可逆过程,阳极扫描时Cr(Ⅲ)不会被重新氧化为Cr(Ⅵ).细菌的存在使Cr(Ⅵ)的还原更容易进行,其还原峰电势正移约0.2 V,细菌对体系中的电化学反应起了催化作用.随细菌量的增加,氢气的析出、六价铬还原为三价铬及三价铬进一步还原为零价铬的电势均发生了正移,过高的细菌量主要影响三价铬还原沉积为金属铬的过程.铬浓度对细菌还原Cr(Ⅵ)溶液的循环伏安曲线的影响不大.初始pH值为10是细菌还原Cr(Ⅵ)的最佳pH值.     

米糠在微波条件下解毒铬渣中六价铬的研究

铬渣中含有毒性较强的六价铬化合物,其严重污染环境。为探讨米糠解毒铬渣的可行性,以米糠作为解毒铬渣的材料,在微波条件下对铬渣中的六价铬进行解毒实验研究。利用正交实验对铬渣中六价铬的去除条件进行了优化。在此基础上,开展单因素实验进一步研究确定了铬渣中六价铬去除的最佳条件,并对解毒后的含铬米糠是否具有危险废物的浸出毒性进行了探讨。实验结果表明,当米糠与铬渣质量比为2.5:1,微波作用时间为5min,微波功率为900W时铬渣中六价铬的去除率最大,为72.2%,且解毒后米糠中六价铬的浸出较小,低于国家最高允许浓度标准。     

两段式还原铬渣中Cr(Ⅵ)的试验研究

比对了多种还原剂处理六价铬的解毒效果,确定了焦亚硫酸钠、硫酸亚铁两段式还原处理铬渣浸出液中六价铬和总铬的还原剂投加顺序和投加量。结果表明,该技术能使解毒后铬渣中Cr6+浓度达到0.17 mg/L,满足HJ/T 301—2007《铬渣污染治理环境保护技术规范(暂行)》解毒后铬渣六价铬≤0.5 mg/的要求,且具有较好的长期稳定性,解毒彻底,可为该技术的工程应用提供理论依据。     

硫代硫酸钠、磷酸钠联合处理铬渣中的六价铬

以硫代硫酸钠为还原剂,将铬渣中的六价铬(Cr(VI))解毒转化为三价铬(Cr(III)),并加入磷酸盐作为稳定剂稳定解毒后的铬渣,考察不同反应时间和药剂用量对铬渣中Cr(VI)去除效果的影响.结果表明:硫代硫酸钠可以有效去除铬渣中的Cr(VI),当其与Cr(VI)的摩尔比为理论摩尔比的12倍、处理时间15d时铬渣中Cr(VI)的去除率达到最高(70%),继续增加还原剂用量或延长反应时间均不能有效提高Cr(VI)的去除率.随后加入磷酸钠作为稳定剂,当其物质的量为生成Cr(III)的4倍时,硫代硫酸钠与磷酸钠分步加入(两步法)比同时加入(一步法)处理铬渣的效果较好,处理效果最好时总铬浸出浓度为6.1mg/L,低于危险废物浸出鉴别的总铬标准(15mg/L),而且形成稳定的铬的化合物(CrPO4·6H2O).铬渣pH值变化、五态变化、XRD及XPS分析等结果表明,两步法的处理效果好于一步法.     

铬渣浸溶Cr(Ⅵ)溶解释放规律研究-以锦州堆场铬渣为例

通过锦州地区铬渣样品静态浸溶实验,测定不同固液比、浸出时间、浸取剂pH及组成、振荡速度、铬渣粒度大小、温度等因素对铬渣中Cr(VI)溶解释放的影响,揭示铬渣中Cr(VI)析出、释放机理。结果显示,稀释作用在不同固液比浸出中起主导作用,随固液比的降低,Cr(VI)浸出浓度逐渐降低,但是Cr(VI)浸出总量却在增加;随着浸出时间的增大,浸出Cr(VI)浓度随之增大;铬渣浸出液碱性很高,在铬渣溶解释放过程中,随酸性增强Cr(VI)溶解量相应增大,体现强的酸中和能力;随着振荡速度增加,Cr(VI)溶解释放速度明显加快;粒径越小,铬酸盐的溶解释放速度越快,溶解作用越充分;铬渣的浸出为吸热反应过程,铬渣溶解度随温度升高而增大。铬渣中Cr(Vl)溶解释放速率服从菲克(Fick)扩散定律。研究结果为铬渣危害的评价、监测及铬渣污染有效防治提供参考。     

电炉渣铬浸出行为及资源化利用风险分析

不锈钢电炉渣含有剧毒的CaCrO4,铬的浸出行为研究,对电炉渣的处置及资源化利用过程中的风险评估具有十分重要的意义。对电炉渣中铬的浸出特征进行了分析,标准浸出程序结果表明,电炉渣Cr和Cr(Ⅵ)浸出量分别为4.68 mg/L和1.74 mg/L,高于HJ/T 301—2007规定的限值,不宜直接应用于建材领域;电炉渣铬浸出受浸提剂pH影响显著,Cr在中性环境下浸出量最少,酸性和碱性环境都有利于Cr的浸出;Cr(Ⅵ)的浸出量随pH值增大而增加。     

AOD不锈钢渣中铬的酸性淋溶特性

基于AOD渣中铬的短期淋溶特性,采用静态淋溶实验方法研究了酸性淋溶液的初始pH值和固液比对AOD渣中铬淋溶特性的影响规律。实验结果表明,初始pH值为3.0和2.0时淋溶液的pH、E和DO的变化规律与中性淋溶液相似,AOD渣中铬的淋溶均呈现快速淋溶和慢速淋溶两个阶段,其中淋溶液初始pH值降至2.0时更为显著的增加了AOD渣中铬淋溶毒性;当固液比由10∶100提高1.5倍、2倍和4倍时,初始pH值为3.0的淋溶液中铬的淋溶浓度没有成比例倍增,初始pH值为2.0时,96 h内AOD渣中铬淋溶浓度分别增加了47.3%、56.7%和75.6%。由此可见,降低酸性淋溶液的初始pH值、延长淋溶时间和增加固液比都使得淋溶液中Cr3+浓度增加,考虑到淋溶液中Cr3+的沉淀反应,采用中性淋溶液毒性测试标准可能会过低评价AOD渣中铬的淋溶毒性。     

Distribution and ecological effect of mercury in Laogang landfill, Shanghai, China

Laogang landfill near Shanghai is the largest landfill in China, and receives about 10000 t of daily garbage per day, Samples of topsoil and plants were analyzed to evaluate mercury pollution from the landfill. For topsoil samples, there were significant correlations among total mercury （HgT）, combinative mercury （Hgc） and gaseous mercury （HgG）, and content of total organic carbon （TOC）, but, no significantly relationship was found between Hg content and filling time. Hg content changes in vertical profiles with time showed that the average Hgv of profiles 1992, 1996, and 2000 was similar, but their average HgG was quite different. HgT was significantly correlated with Hgc in profile 1992 and 2000, and Hgv was significantly correlated with Hg6 in profile 1996. HgG/Hgv ratio in profile samples decreased in the order of （HgG,/HgT）1992〉（HgG/HgT）1996〉〉（HgG/HgT）2000. A simple outline of Hg release in landfill could be drawn： with increasing of filling time, degradation undergoes different biodegradation, accordingly, gaseous mercury goes through small, more, and small proportion to total mercury. Distribution of Hg in plants was inhomogeneous, following the order of leaf〉root〉stem. The highest value of leaf may be associated with higher atmospheric Hg from landfill. Ligneous plants （e.g. Phyllostachys glanca, Prunus salicina and Ligustrum lucidum） are capable of enriching more Hg than herbaceous plants.     

EDTA-enhanced phytoremediation of lead contaminated soil by Bidens maximowicziana

Phytoremediation is a potential cleanup technology for the removal of heavy metals from contaminated soils.Bidens maximowicziana is a new Pb hyperaccumulator,which not only has remarkable tolerance to Pb but also extraordinary accumulation capacity for Pb.The maximum Pb concentration was 1509.3 mg/kg in roots and 2164.7 mg/kg in overground tissues.The Pb distribution order in the B. maximowicziana was:leaf>stem>root.The effect of amendments on phytoremediation was also studied.The mobility of soil Pb and the Pb concentrations in plants were both increased by EDTA application.Compared with CK(control check),EDTA application promoted translocation of Pb to overground parts of the plant.The Pb concentrations in overground parts of plants was increased from 24.23-680.56 mg/kg to 29.07-1905.57 mg/kg.This research demonstrated that B.maximowicziana appeared to be suitable for phytoremediation of Pb contaminated soil,especially,combination with EDTA.     

Decomposition of alachlor by ozonation and its mechanism

Decomposition and corresponding mechanism of alachlor, an endocrine disruptor in water by ozonation were investigated. Results showed that alachlor could not be completely mineralized by ozone alone. Many intermediates and final products were formed during the process, including aromatic compounds, aliphatic carboxylic acids, and inorganic ions. In evoluting these products, some of them with weak polarity were qualitatively identified by GC-MS. The information of inorganic ions suggested that the dechlorination was the first and the fastest step in the ozonation of alachlor.     

Enzymatic oxidation of aqueous pentachlorophenol

The influence of the nonionic surfactant Tween 80 on pentachlorophenol （PCP） oxidation catalyzed by horseradish peroxidase was studied. The surfactant was tested at concentrations below and above its critical micelle concentration （CMC）. Enhancement of PCP removal was observed at sub-CMCs. The presence of Tween 80 in the reaction mixture reduced enzyme inactivation which occurred through a combination of free radical attack and sorption by precipitated products. A simple first-order model was able to simulate time profiles for enzyme inactivation in the presence or absence of Tween 80. At supra-CMCs, the surfactant caused noticeable reductions in PCP removal, presumably through micelle partitioning of PCP which precluded the hydrophobic PCP molecule from interacting with the enzyme.     

基于综合水质标识指数和对应分析法的校园河道水质评价

以三峡大学的校园河道求索溪为研究对象,利用综合水质标识指数法确定求索溪水质类别,分析其水质时空变化规律,并利用对应分析法得出求索溪中不同监测点的主要污染因子.研究结果表明:求索溪整体的综合水质标识指数为7.423,整体水质为劣V类(地表水环境质量标准GB 3838-2002)且黑臭.从时间变化来看,求索溪4月份的水质最差,5月份次之,4、5月份所有监测点的水质都劣于V类且黑臭;8月份水质最好,水质为Ⅳ类;从空间分布来看,8个监测点综合水质标识指数均超过6.0,水质为劣V类,其中6号监测点的水质相对最好,监测点3号的水质相对最差;对应分析法得出求索溪的整体水体污染程度受总氮因子的影响最大,其次为总磷.该研究拟为求索溪及类似校园河道的水环境治理研究提供基础依据和参考.     

Effects of chitosan on growth of an aquatic plant (Hydrilla verticillata) in polluted waters with different chemical oxygen demands

Effects of chitosan on a submersed plant, Hydrilla verticillata, were investigated. Results indicated that H. venicillata could prevent ultrastructure phytotoxicities and oxidativereaction from polluted water with high chemical oxygen demand (COD). Superoxide dismutase (SOD) activity and malondialdehyde (MDA) contents in H. verticillata treated with 0.1% chitosan in wastewater increased with high COD (980 mg/L) and decreased with low COD (63 mg/L), respectively. Ultrastructural analysis showed that the stroma and grana of chloroplast basically remained normal. However, plant cells from the control experiment (untreated with chitosan) were vacuolated and the cell interval increased. The relict of protoplast moved to the center, with cells tending to disjoint. Our findings indicate that wastewater with high COD concentration can cause a substantial damage to submersed plant, nevertheless, chitosan probably could alleviate the membrane lipid peroxidization and ultrastructure phytotoxicities, and protect plant cells from stress of high COD concentration polluted water.     

Removal of cadmium using MnO2 loaded D301 resin

MnO2 loaded weak basic anion exchange resin D301 （Anion exchange resin, macroreticular weak basic styrene） as adsorbent has been prepared and applied to the removal of cadmium. The adsorption characteristics have been investigated with respect to effect of pH, equilibrium isotherms, removal kinetic data, and interference of the coexisting ions. The results indicated that the Cd^2＋ could be efficiently removed using MnO2 loaded D301 resin in the pH range of 3-8 from aqueous solutions with the co-existence of high concentration of alkali and alkaline-earth metals ions. The saturate adsorption capacity of the Cd^2＋ was 77.88 mg/g. The adsorption process followed the pseudo first-order kinetics. The equilibrium data obtained in this study accorded excellently with the Langmuir adsorption isotherm.     

Effect of coagulation pretreatment on the fouling of ultrafiltration membrane

The purpose of this study is to understand the effect and mechanism of preventing membrane fouling, by coagulation pretreatment, in terms of fractional component and molecular weight of natural organic matter （NOM）. A relatively higher molecular weight （MW） of hydrophobic compounds was responsible for a rapid decline in the ultrafiltration flux. Coagulation could effectively remove the hydrophobic organics, resulting in the increase of flux. It was found that a lower MW of neutral hydrophilic compounds, which could remove inadequately by coagulation, was responsible for the slow declining flux. The fluxes in the filtration of coagulated water and supernatant water were compared and the results showed that a lower MW of neutral hydrophilic compounds remained in the supernatant water after coagulation could be rejected by a membrane, resulting in fouling. It was also found that the coagulated flocs could absorb neutral hydrophilic compounds effectively. Therefore, with the coagulated flocs formed on the membrane surface, the flux decline could be improved.     

Penetration analysis of elements and bioleaching treatment of spent refractory for recycling

Acidithiobacillus ferrooxidans ATCC23270 and Acidithiobacillus thiooxidans TM-32 were used for bioleaching of spent refractories of aluminium and copper melting furnaces for their recycling.Firstly,penetration of elements into aluminium melting furnace refractory was investigated and it was found that up to 7 cm from surface was contaminated.Comparison on leaching efficiency by the strains ATCC23270 and TM-32 found that the strain ATCC23270 could treat larger amount of the refractories than the strain TM-32 could do.In the experiment of bioleaching of spent refractory aluminium melting furnace by the strain ATCC23270,high leaching efficiency were obtained on Al,Si,and Ca,and extremely low leaching performance was,however,shown on the rest of elements i.e.,Na,Mn,and Zn.Under the strain TM-32 use,relatively high leaching performance was recognized on Al,Si,Ca,Na,Mn,and Zn.In the experiment of bioleaching for spent refractory copper melting furnace,almost the same leaching trends were shown on Cu,Zn,Al,and Si under the strains ACTT23270 and TM-32 uses.     

Simultaneous removal of ammonium and phosphate by zeolite synthesized from coal fly ash as influenced by acid treatment

Zeolite synthesized from fly ash （ZFA） without modification is not efficient for the purification of NH4＋ and phosphate at low concentrations that occur in real effluents, despite the high potential removal capacity. To develop an effective technique to enhance the removal efficiency of ammonium and phosphate at low concentrations, ZFA was modified with acid treatment and the simultaneous removal of ammonium and phosphate in a wide range of concentration was investigated. It was seen that when compared with untreated ZFA, only the treatment by 0.01 mol/L of H2SO4 significantly improved the removal efficiency of ammonium at low initial concentrations. The behavior was well explained by the pH effect. Treatment by more concentrated H2SO4 led to the deterioration of the ZFA structure and a decrease in the cation exchange capacity. Treatment by 0.01 mol/L H2SO4 improved the removal efficiency of phosphate by ZFA at all initial P concentrations, while the treatment by concentrated H2SO4 （≥0.9 mol/L） resulted in a limited maximum phosphate immobilization capacity （PIC）. It was concluded that through a previous mild acid treatment （e.g. 0.01 mol/L of H2SO4）, ZFA can be used in the simultaneous removal of NH4＋ and P at low concentrations simulating real effluent.