褐煤地下气化过程汞析出规律的研究

在褐煤地下气化模型试验的基础上 ,研究了褐煤中汞的赋存形态 ,褐煤地下气化煤气中汞含量的变化及存在形态 ,以及气化工艺的影响 ;分析了地下气化过程中汞的析出及反应机理 .实验结果表明 ,汞在试验褐煤中主要以硫化物结合态和残渣态形式存在 ;褐煤地下气化煤气中汞含量随气化时间的变化而变化 ,且主要以Hg0 (g)的形态存在 ;水蒸汽的存在会降低Hg0 (g)被其它气体氧化为Hg2 (g)的趋势 ;与地面气化及燃煤过程不同 ,煤地下气化产物中 ,气态汞占总汞比例低于 2 0 % ,明显低于地面气化及燃煤     

温度对干化污泥水蒸气气化产气特性的影响

采用固定床气化装置,在水蒸气流量为0.32 kg/h条件下进行了污泥水蒸气气化实验。研究了温度对污泥气化气体产率、氢气产率、气体成分与低位热值、气体能源转化率的影响。结果表明:随着反应温度从700℃上升到1 000℃;气体产率从0.39 m3/kg升至0.61 m3/kg;氢气产率从0.18 m3/kg升至0.34 m3/kg;气体能源转化率从54%升至88%;产气的低位热值从10 688.1 kJ/m3提高至11 168.9 kJ/m3。同时产气中H2和CO含量随着温度的升高而增加,CH4、CO2和CnHm含量随温度的升高而减少。因此,为了获得更多的可燃气体,建议在污泥水蒸气气化工艺中,气化温度必须大于800℃。     

煤炭地下气化工艺危险有害因素的辨识与分析

本文在对煤炭地下气化原理、工艺流程进行分析的基础上,对煤炭地下气化工艺安全评价工作实施过程中危险有害因素的辨识与分析进行了论述,主要包括物料性质分析、厂址条件及总平面布置、地下气化过程、制氧过程、煤气净化及储存和输送过程以及生产工艺测控系统等方面的危险有害因素的辨识与分析,并对主要危险有害因素的分布情况进行了归纳.该研...     

矿业、冶金工业三废处理与综合利用

利用。」991年开始在徐州矿务局进行了煤炭地下气化半工业性试验。煤炭地下气化的科学理论主要是以煤化学与有机化学为基础。地下气化是多学科的联合体,建炉的方案分为无井式与有井式。建立地下气化燃烧的数学模型,在电脑上进行煤炭地下气化工艺理论的研究.以提高煤气的质量、数量与降低成本。地下煤气可用于联合循环发电、工业燃烧、城市民用及制造化工原料和冶金工业还原气等。总之煤炭地下气化在技术上可行、经济上合理、客观上需要,并能建立多种产品的联合企‘!肚。图3(同翔)X752.3 9503072煤矿酸性矿井水除铁研究/胡文容(山东矿业学院…     

污泥水蒸气气化焦油化学组分的分布特征

通过GC-MS分析,研究了气化温度和气料比S/B（水蒸气与污泥的质量比）对污泥气化焦油中芳香烃、含氮化合物、含氧化合物和含硫化合物分布特征的影响变化规律.结果表明：污泥气化焦油中芳香烃的化学组分主要为菲类、萘类、芴类和联苯类化合物,其中S/B值1.1、1.5和1.9时菲类和萘类化合物的产率在850℃均达到最大值,S/B值1.5和1.9时芴类产率随气化温度的升高而呈先升高后降低,而800℃时联苯类产率则随S/B值的增加而呈先升高后降低,其最高产率为1.284g/kg.含氮化合物以吲哚类化合物为主,其产率在S/B值为1.5和1.9时均随气化温度的升高而呈降低趋势;含氧化合物中主要为酚类化合物,其产率在750℃时随S/B值的升高而升高,其最高产率3.103g/kg;含硫化合物主要为4,4'-双（四氢噻喃）,且仅在850℃、S/B值为1.9气化条件下检出产率为0.263g/kg的萘并[1,2-b]噻吩.     

褐煤地下气化过程中铅和砷的迁移规律的研究

在煤炭地下气化模型试验的基础上,研究了褐煤原煤及其气化产物中的铅和砷的含量和分布,进行了铅和砷的质量平衡计算,并分析了其析出的反应机理.实验结果表明,铅在原煤中以残渣态23.07%、碳酸盐和铁锰氧化物结合态53.96%、硫化物结合态22.96%存在,而砷则以残渣态47.73%、有机结合态7.95%、硫化物结合态40.90%存在.在气化过程中63.65%的铅和56.23%的砷残存在地下煤灰中,1.15%的Pb和6.62%的As转化到煤气冷凝水中,35.20%的Pb和37.15%的As转化到煤气中.     

基于Aspen Plus的MSW气化熔融工艺全流程模拟研究

城市固体废物（MSW）气化熔融工艺能够减少二噁英的生成和熔融固化重金属,是一种清洁高效的固体废物处理方式。已有研究多针对MSW的热解特性以及污染物的生成与排放,而对气化熔融工艺系统模块之间的影响和各反应器间物质流、能量流的联动变化过程研究不足。利用Aspen Plus模拟平台,基于吉布斯自由能最小化原理,对MSW气化熔融工艺进行了全流程模拟研究,分析了垃圾干燥温度、垃圾含水率、气化温度、气化介质以及灰熔点对工艺流程节点参数、物质流和能量流的影响,并提出了优化的工艺流程和运行参数。结果表明：在垃圾热解模拟时,垃圾含水率为9%,通过烟气循环能达到能量自给;在相同条件下,以水蒸气作为气化介质的气化效率最高,且在气化温度为850℃,水蒸气当量比为50%时,达到最佳工艺效果;当气化后产生的焦炭在熔融炉内燃烧刚满足灰熔点温度时,灰熔点的升高使气化剂比例、气化气有效气体摩尔流量和碳转化率不断降低。不同工况下的物质流、能量流的变化对实际工程具有指导意义。     

城市生活垃圾催化气化制取富氢气体的研究

采用下吸式固定床气化炉,以煅烧白云石为催化剂水蒸气气化城市生活垃圾(MSW)有机组分,在气化温度为750~950℃,S/M(水蒸气和垃圾物料进料质量比)为0.57~1.28时,探讨了催化剂种类、气化温度和S/M等因素对富氢气体成分、产氢率、潜在产氢率、低位热值和碳转化率等的影响。较高气化温度有利于富氢气体的生成,增加碳转化率和产气率,但会降低富氢气体的热值;在实验条件下,富氢气体中H2体积分数最高达53.29%,产氢率达到7.13~46.52mol/kg,潜在产氢率为55.48~90.11mol/kg;镍基催化剂催化效果优于煅烧白云石,能大幅增加H2含量,使焦油在850℃以上完全分解。     

不同温度下污泥水蒸气气化合成气的生成特性

采用小型管式气化炉开展不同温度下污泥水蒸气气化实验,分析温度对污泥气化冷煤气效率η_l、污泥碳转化效率η_c、有机相转化效率η_v、以及气化合成气生成特性的影响规律。结果表明:气化温度对η_l、η_c、η_v均具有显著影响,提高温度有利于污泥蕴藏的化学能更多地转化为富氢合成气的化学能,促进污泥碳和有机组分气化反应发生,从而提高污泥能源转化率;气化温度从650℃提高至1 050℃,气相产物产率从38.5 g/100 g DSS(干污泥)增至57.9 g/100 g DSS,其中H_2和CO生成总量最高;另外,延长污泥高温气化停留时间,能够显著增加合成气中H_2生成量。     

垃圾RDF的气化特性

采用自制的气化装置对垃圾RDF进行了气化实验。垃圾RDF在200⁹00℃温度下气化时,瞬时产气量出现先升高、后下降、再升高又迅速下降的趋势,2个瞬时产气高峰分别为500℃和800℃。当气化温度在400℃以下时,除CO外,各种可燃气体的含量均很少。随着气化温度的升高,底渣含量逐渐降低,焦油的产率逐渐增加,产生的各可燃气体的体积分数和热值也增加,当热解温度达到900℃时,可燃气体的热值达到最高,为28MJ/m3,底渣含量最低,仅为12%左右。焦油在600900℃温度下气化时,瞬时产气量出现先升高、后下降、再升高又迅速下降的趋势,2个瞬时产气高峰分别为500℃和800℃。当气化温度在400℃以下时,除CO外,各种可燃气体的含量均很少。随着气化温度的升高,底渣含量逐渐降低,焦油的产率逐渐增加,产生的各可燃气体的体积分数和热值也增加,当热解温度达到900℃时,可燃气体的热值达到最高,为28MJ/m3,底渣含量最低,仅为12%左右。焦油在600⁷00℃达到最高值,为40%左右。     

Distribution and ecological effect of mercury in Laogang landfill, Shanghai, China

Laogang landfill near Shanghai is the largest landfill in China, and receives about 10000 t of daily garbage per day, Samples of topsoil and plants were analyzed to evaluate mercury pollution from the landfill. For topsoil samples, there were significant correlations among total mercury （HgT）, combinative mercury （Hgc） and gaseous mercury （HgG）, and content of total organic carbon （TOC）, but, no significantly relationship was found between Hg content and filling time. Hg content changes in vertical profiles with time showed that the average Hgv of profiles 1992, 1996, and 2000 was similar, but their average HgG was quite different. HgT was significantly correlated with Hgc in profile 1992 and 2000, and Hgv was significantly correlated with Hg6 in profile 1996. HgG/Hgv ratio in profile samples decreased in the order of （HgG,/HgT）1992〉（HgG/HgT）1996〉〉（HgG/HgT）2000. A simple outline of Hg release in landfill could be drawn： with increasing of filling time, degradation undergoes different biodegradation, accordingly, gaseous mercury goes through small, more, and small proportion to total mercury. Distribution of Hg in plants was inhomogeneous, following the order of leaf〉root〉stem. The highest value of leaf may be associated with higher atmospheric Hg from landfill. Ligneous plants （e.g. Phyllostachys glanca, Prunus salicina and Ligustrum lucidum） are capable of enriching more Hg than herbaceous plants.     

EDTA-enhanced phytoremediation of lead contaminated soil by Bidens maximowicziana

Phytoremediation is a potential cleanup technology for the removal of heavy metals from contaminated soils.Bidens maximowicziana is a new Pb hyperaccumulator,which not only has remarkable tolerance to Pb but also extraordinary accumulation capacity for Pb.The maximum Pb concentration was 1509.3 mg/kg in roots and 2164.7 mg/kg in overground tissues.The Pb distribution order in the B. maximowicziana was:leaf>stem>root.The effect of amendments on phytoremediation was also studied.The mobility of soil Pb and the Pb concentrations in plants were both increased by EDTA application.Compared with CK(control check),EDTA application promoted translocation of Pb to overground parts of the plant.The Pb concentrations in overground parts of plants was increased from 24.23-680.56 mg/kg to 29.07-1905.57 mg/kg.This research demonstrated that B.maximowicziana appeared to be suitable for phytoremediation of Pb contaminated soil,especially,combination with EDTA.     

Decomposition of alachlor by ozonation and its mechanism

Decomposition and corresponding mechanism of alachlor, an endocrine disruptor in water by ozonation were investigated. Results showed that alachlor could not be completely mineralized by ozone alone. Many intermediates and final products were formed during the process, including aromatic compounds, aliphatic carboxylic acids, and inorganic ions. In evoluting these products, some of them with weak polarity were qualitatively identified by GC-MS. The information of inorganic ions suggested that the dechlorination was the first and the fastest step in the ozonation of alachlor.     

Enzymatic oxidation of aqueous pentachlorophenol

The influence of the nonionic surfactant Tween 80 on pentachlorophenol （PCP） oxidation catalyzed by horseradish peroxidase was studied. The surfactant was tested at concentrations below and above its critical micelle concentration （CMC）. Enhancement of PCP removal was observed at sub-CMCs. The presence of Tween 80 in the reaction mixture reduced enzyme inactivation which occurred through a combination of free radical attack and sorption by precipitated products. A simple first-order model was able to simulate time profiles for enzyme inactivation in the presence or absence of Tween 80. At supra-CMCs, the surfactant caused noticeable reductions in PCP removal, presumably through micelle partitioning of PCP which precluded the hydrophobic PCP molecule from interacting with the enzyme.     

基于综合水质标识指数和对应分析法的校园河道水质评价

以三峡大学的校园河道求索溪为研究对象,利用综合水质标识指数法确定求索溪水质类别,分析其水质时空变化规律,并利用对应分析法得出求索溪中不同监测点的主要污染因子.研究结果表明:求索溪整体的综合水质标识指数为7.423,整体水质为劣V类(地表水环境质量标准GB 3838-2002)且黑臭.从时间变化来看,求索溪4月份的水质最差,5月份次之,4、5月份所有监测点的水质都劣于V类且黑臭;8月份水质最好,水质为Ⅳ类;从空间分布来看,8个监测点综合水质标识指数均超过6.0,水质为劣V类,其中6号监测点的水质相对最好,监测点3号的水质相对最差;对应分析法得出求索溪的整体水体污染程度受总氮因子的影响最大,其次为总磷.该研究拟为求索溪及类似校园河道的水环境治理研究提供基础依据和参考.     

Effects of chitosan on growth of an aquatic plant (Hydrilla verticillata) in polluted waters with different chemical oxygen demands

Effects of chitosan on a submersed plant, Hydrilla verticillata, were investigated. Results indicated that H. venicillata could prevent ultrastructure phytotoxicities and oxidativereaction from polluted water with high chemical oxygen demand (COD). Superoxide dismutase (SOD) activity and malondialdehyde (MDA) contents in H. verticillata treated with 0.1% chitosan in wastewater increased with high COD (980 mg/L) and decreased with low COD (63 mg/L), respectively. Ultrastructural analysis showed that the stroma and grana of chloroplast basically remained normal. However, plant cells from the control experiment (untreated with chitosan) were vacuolated and the cell interval increased. The relict of protoplast moved to the center, with cells tending to disjoint. Our findings indicate that wastewater with high COD concentration can cause a substantial damage to submersed plant, nevertheless, chitosan probably could alleviate the membrane lipid peroxidization and ultrastructure phytotoxicities, and protect plant cells from stress of high COD concentration polluted water.     

Removal of cadmium using MnO2 loaded D301 resin

MnO2 loaded weak basic anion exchange resin D301 （Anion exchange resin, macroreticular weak basic styrene） as adsorbent has been prepared and applied to the removal of cadmium. The adsorption characteristics have been investigated with respect to effect of pH, equilibrium isotherms, removal kinetic data, and interference of the coexisting ions. The results indicated that the Cd^2＋ could be efficiently removed using MnO2 loaded D301 resin in the pH range of 3-8 from aqueous solutions with the co-existence of high concentration of alkali and alkaline-earth metals ions. The saturate adsorption capacity of the Cd^2＋ was 77.88 mg/g. The adsorption process followed the pseudo first-order kinetics. The equilibrium data obtained in this study accorded excellently with the Langmuir adsorption isotherm.     

Effect of coagulation pretreatment on the fouling of ultrafiltration membrane

The purpose of this study is to understand the effect and mechanism of preventing membrane fouling, by coagulation pretreatment, in terms of fractional component and molecular weight of natural organic matter （NOM）. A relatively higher molecular weight （MW） of hydrophobic compounds was responsible for a rapid decline in the ultrafiltration flux. Coagulation could effectively remove the hydrophobic organics, resulting in the increase of flux. It was found that a lower MW of neutral hydrophilic compounds, which could remove inadequately by coagulation, was responsible for the slow declining flux. The fluxes in the filtration of coagulated water and supernatant water were compared and the results showed that a lower MW of neutral hydrophilic compounds remained in the supernatant water after coagulation could be rejected by a membrane, resulting in fouling. It was also found that the coagulated flocs could absorb neutral hydrophilic compounds effectively. Therefore, with the coagulated flocs formed on the membrane surface, the flux decline could be improved.     

Penetration analysis of elements and bioleaching treatment of spent refractory for recycling

Acidithiobacillus ferrooxidans ATCC23270 and Acidithiobacillus thiooxidans TM-32 were used for bioleaching of spent refractories of aluminium and copper melting furnaces for their recycling.Firstly,penetration of elements into aluminium melting furnace refractory was investigated and it was found that up to 7 cm from surface was contaminated.Comparison on leaching efficiency by the strains ATCC23270 and TM-32 found that the strain ATCC23270 could treat larger amount of the refractories than the strain TM-32 could do.In the experiment of bioleaching of spent refractory aluminium melting furnace by the strain ATCC23270,high leaching efficiency were obtained on Al,Si,and Ca,and extremely low leaching performance was,however,shown on the rest of elements i.e.,Na,Mn,and Zn.Under the strain TM-32 use,relatively high leaching performance was recognized on Al,Si,Ca,Na,Mn,and Zn.In the experiment of bioleaching for spent refractory copper melting furnace,almost the same leaching trends were shown on Cu,Zn,Al,and Si under the strains ACTT23270 and TM-32 uses.     

Simultaneous removal of ammonium and phosphate by zeolite synthesized from coal fly ash as influenced by acid treatment

Zeolite synthesized from fly ash （ZFA） without modification is not efficient for the purification of NH4＋ and phosphate at low concentrations that occur in real effluents, despite the high potential removal capacity. To develop an effective technique to enhance the removal efficiency of ammonium and phosphate at low concentrations, ZFA was modified with acid treatment and the simultaneous removal of ammonium and phosphate in a wide range of concentration was investigated. It was seen that when compared with untreated ZFA, only the treatment by 0.01 mol/L of H2SO4 significantly improved the removal efficiency of ammonium at low initial concentrations. The behavior was well explained by the pH effect. Treatment by more concentrated H2SO4 led to the deterioration of the ZFA structure and a decrease in the cation exchange capacity. Treatment by 0.01 mol/L H2SO4 improved the removal efficiency of phosphate by ZFA at all initial P concentrations, while the treatment by concentrated H2SO4 （≥0.9 mol/L） resulted in a limited maximum phosphate immobilization capacity （PIC）. It was concluded that through a previous mild acid treatment （e.g. 0.01 mol/L of H2SO4）, ZFA can be used in the simultaneous removal of NH4＋ and P at low concentrations simulating real effluent.