纳米TiO_2-Al_2O_3负载CuMnO_x对甲苯的催化燃烧

研究采用改进的溶胶-凝胶法制备了TiO2-Al2O3复合载体,并用浸渍法制备CuMnOX/TiO2-Al2O3催化剂,通过对甲苯废气催化燃烧的实验,分别考察了Cu-Mn负载量、Cu/Mn摩尔比、焙烧温度及载体对催化剂制备过程及催化剂活性的影响。实验结果表明:活性组分负载量25%,铜锰活性组分的配比Cu:Mn=1:2,焙烧温度500℃是浸渍法制备CuMnOX/TiO2-Al2O3催化剂较佳的工艺条件;XRD衍射图谱表明,500℃下铜锰尖晶石的存在是催化剂催化活性优良的主要原因;由复合载体制备的CuMnOX/TiO2-Al2O3催化剂比单一载体制备的CuMnOX/Al2O3催化剂具有更高的甲苯转化率,其T99比单一载体要低20℃以上。     

V-W/TiO_2/γ-Al_2O_3催化剂催化还原NO的研究

掺杂15%TiO2对γ-Al2O3改性制备了TiO2/γ-Al2O3复合氧化物载体,以此复合氧化物及TiO2、γ-Al2O3为载体用浸渍法负载钒钨制备了一系列催化剂,采用比表面积和孔结构分析、X射线衍射(XRD)、高分辨电镜(HRTEM)、原位红外(in situ FT-IR)等技术对载体和催化剂进行宏观-微观表征,同时在模拟氨气选择性催化还原NO(NH3-SCR)的反应条件下对催化剂的脱硝反应活性进行考察,比较研究TiO2掺杂对V2O5-WO3/TiO2和V2O5-WO3/γ-Al2O3催化剂的改性作用。结果发现,少量TiO2掺杂制得的TiO2/γ-Al2O3复合载体中,TiO2和γ-Al2O3之间的协同作用使得V2O5-WO3/TiO2/γ-Al2O3催化剂的选择性催化还原脱硝效率及活性窗口明显优于单一载体制备的催化剂,并表现出了良好的热稳定性;各种表征结果表明,TiO2/γ-Al2O3复合载体中TiO2高度分散在γ-Al2O3上,复合载体具有较大的比表面积,载体表面存在大量的Br?nsted酸位和较多的活性中间产物,这些可能是TiO2/γ-Al2O3复合载体催化剂具有较好SCR活性的原因。     

二氧化钛复合型催化剂制备及其微波辅助催化氧化甲苯性能

实验采用溶胶凝胶法和传统浸渍法制备了TiO2-分子筛复合载体及复合载体负载过渡金属与稀土元素催化剂,通过微波辅助催化氧化甲苯的性能实验考察其催化活性.结果表明,复合TiO2明显提高了载体结构的稳定性与耐温性,并使过渡金属铜(Cu)、锰(Mn)和稀土元素铈(Ce)等活性组分在催化剂表面的分散更均匀;在复合载体吸附、吸波性能与多相活性组分催化的共同作用下,Cu-Mn-Ce/TiO2-分子筛催化剂微波辅助催化氧化甲苯的完全燃烧温度仅为175℃,此时甲苯去除率可达99％;15 h的连续性实验表明,TiO2复合型催化剂具有良好的催化活性与稳定性.由催化剂表征分析结果可知,活性组分颗粒的均匀分布与铜、锰氧化物及铜锰尖晶石固溶物等活性相的存在促进了甲苯的催化氧化,锐钛矿型TiO2较高的电子迁移速率与催化剂孔径的增大均有助于甲苯的氧化降解.     

Catalytic performance of copper and cerium oxides-based γ-Al_2O_3 on combustion of toluene

以γ-Al2O3为载体,以复合氧化物CuxCe1-xO2为活性组分,其中,x=0.1,0.2,0.4,0.6,0.8,通过浸渍法制备了一系列CuxCe1-xO2/γ-Al2O3催化剂.在固定床反应器中评价了催化剂对甲苯的催化活性,通过XRD、SEM对催化剂进行表征,并运用ICP-MS分析并计算Cu、Ce的摩尔比以及活性组分的负载量.结果表明,在CuxCe1-xO2/γ-Al2O3催化剂中Cu、Ce摩尔比的实际值与理论值相近,活性组分的负载量在19%以上,而且对甲苯都有较好的低温催化活性,其中当x=0.2时,即Cu0.2Ce0.8O2/γ-Al2O3催化剂对甲苯的催化活性最高,其中T10=160℃,T90=265℃;当甲苯的进口浓度在700～3000mg·m-3时,进口浓度对Cu0.2Ce0.8O2/γ-Al2O3催化剂的催化活性影响较小,且经过连续80h的稳定性操作后转化率仍然保持在90%以上.     

CuMnO_x/γ-Al_2O_3对含甲苯废气催化燃烧的性能研究

利用浸渍法制备催化剂CuO/γ-Al2O3、MnOx/γ-Al2O3、CuMnOx/γ-Al2O3,通过实验研究表明:CuMnOx/γ-Al2O3具有更高的催化活性,其T99比其他两种催化剂要低50℃以上。在焙烧温度300、400、500、600℃下制备CuMnOx/γ-Al2O3,比较其催化活性,发现在600℃制备的催化剂要比其他温度下制备的同等催化剂的催化活性高,证明了尖晶石结构在催化燃烧中起着很大的作用。     

锰铜复合氧化物催化氧化甲苯的性能研究

利用水热法制备了一系列锰铜摩尔比例不同的锰铜复合氧化物催化材料,借助场发射扫描电镜(FE-SEM)和X-射线粉末衍射(XRD)对催化剂进行表征,研究了复合物催化剂在催化降解甲苯反应中的催化活性,筛选出最佳锰铜比例的复合氧化物,并考察了其重复使用性能。结果表明:Mn∶Cu(摩尔比)=1∶4时催化剂的活性最高,甲苯转化率达90%时的温度为190℃,其选择性最好,连续使用5次催化活性变化不大,重复使用性能好。     

TiO_2对In-Ag-O/γ-Al_2O_3催化剂上CO选择性还原NO的改性研究

以Ti O2、γ-Al2O3及Ti O2-γ-Al2O3复合氧化物为载体,以In-Ag-O基为活性组分,采用等体积浸渍法制备了一系列In/Ag催化剂,通过XRD、BET、SEM、H2-TPR等技术手段对催化剂表面形态进行分析,并考察了催化剂对CO选择性还原NO的反应活性和载体中Ti O2含量对催化性能的影响.结果表明,Ti O2的添加促进了活性组分铟和银物种的分散,当Ti O2的含量为载体的15%时制备的催化剂活性最高,合适的Ti O2与γ-Al2O3配比使活性组分与载体之间发生了强烈的相互作用,由此提高了CO选择性还原NO的活性.     

稀土/Y分子筛多相催化电解氧化深度去除渗滤液中难降解有机物

采用浸渍和焙烧法制备了以Y分子筛为载体的几种稀土催化剂,并用玻璃纤维包埋催化剂形成反应床体,构建稀土多相催化电解氧化体系,探索这一体系对垃圾渗滤液中难降解有机物的去除效果.同时,以COD值为控制指标,考察了焙烧温度、浸渍液金属离子浓度、稀土元素种类对电催化活性的影响.最后,用SEM和XRD等手段对催化剂的微观结构、表面形貌进行了表征,并与稀土/γ-Al2O3催化剂的电催化活性和结构进行了比较.结果表明,Y分子筛中引入稀土元素后没有破坏Y分子筛的晶体结构,稀土/Y分子筛催化剂的表面并没有检测到稀土氧化物的物相,稀土/γ-Al2O3催化剂的表面形成了明显的稀土氧化物衍射峰;稀土/Y分子筛催化剂的最佳制备条件为焙烧温度400℃,浸渍液中金属离子质量分数1%～3%,负载金属为铈;所制备的稀土/Y分子筛催化剂具有良好的电催化活性和稳定性,其活性高于稀土/γ-Al2O3催化剂.     

铁路行业喷漆工艺中VOCs废气净化的研究

本文拟采用烧结金属粉末微孔过滤材料为吸附材料,催化剂为CuMn/γ-Al2O3来净化铁路行业喷漆过程中产生的VOCs废气。试验结果：VOCs中甲苯和二甲苯在温度高于260℃条件下转化率大于99%。在温度高于290℃,苯的转化率同样可以超过99%。经过现场试验验证：VOCs在温度300℃时经过烧结金属粉末过滤器处理后,以上三种废气的去除率均大于99%,排放浓度低于北京市《大气污染物综合排放标准》DB11/501-2007中的排放限值。     

整体式分子筛基催化剂制备及其微波催化燃烧VOCs

以整体式蜂窝状分子筛为载体,制备铜锰铈负载型催化剂,研究其微波辐照下对VOCs （甲苯、丙酮、乙酸乙酯）的催化活性及其稳定性,探究影响催化剂活性的因素,并通过测试床层温度分布进行分析.研究表明,微波功率1.3kW、催化剂体积300mm×300mm×300mm,固定床温度>300℃条件下,催化剂对初始浓度200~2000mg/m³的5m³/h VOCs气体的降解效率为80%~92%.温度是VOCs氧化降解的条件,但当床层温度超过了300℃（VOCs完全燃烧温度）之后,升温对VOCs降解效率的影响不再明显.表征可知,尖晶石态铜锰铈单金属氧化物及其复合氧化物是主要的催化活性组分.VOCs在催化剂表面进行准一级反应而被催化氧化;高温对催化剂结构有一定影响,但重复性试验证实了催化剂的高活性和良好的稳定性.     

Distribution and ecological effect of mercury in Laogang landfill, Shanghai, China

Laogang landfill near Shanghai is the largest landfill in China, and receives about 10000 t of daily garbage per day, Samples of topsoil and plants were analyzed to evaluate mercury pollution from the landfill. For topsoil samples, there were significant correlations among total mercury （HgT）, combinative mercury （Hgc） and gaseous mercury （HgG）, and content of total organic carbon （TOC）, but, no significantly relationship was found between Hg content and filling time. Hg content changes in vertical profiles with time showed that the average Hgv of profiles 1992, 1996, and 2000 was similar, but their average HgG was quite different. HgT was significantly correlated with Hgc in profile 1992 and 2000, and Hgv was significantly correlated with Hg6 in profile 1996. HgG/Hgv ratio in profile samples decreased in the order of （HgG,/HgT）1992〉（HgG/HgT）1996〉〉（HgG/HgT）2000. A simple outline of Hg release in landfill could be drawn： with increasing of filling time, degradation undergoes different biodegradation, accordingly, gaseous mercury goes through small, more, and small proportion to total mercury. Distribution of Hg in plants was inhomogeneous, following the order of leaf〉root〉stem. The highest value of leaf may be associated with higher atmospheric Hg from landfill. Ligneous plants （e.g. Phyllostachys glanca, Prunus salicina and Ligustrum lucidum） are capable of enriching more Hg than herbaceous plants.     

EDTA-enhanced phytoremediation of lead contaminated soil by Bidens maximowicziana

Phytoremediation is a potential cleanup technology for the removal of heavy metals from contaminated soils.Bidens maximowicziana is a new Pb hyperaccumulator,which not only has remarkable tolerance to Pb but also extraordinary accumulation capacity for Pb.The maximum Pb concentration was 1509.3 mg/kg in roots and 2164.7 mg/kg in overground tissues.The Pb distribution order in the B. maximowicziana was:leaf>stem>root.The effect of amendments on phytoremediation was also studied.The mobility of soil Pb and the Pb concentrations in plants were both increased by EDTA application.Compared with CK(control check),EDTA application promoted translocation of Pb to overground parts of the plant.The Pb concentrations in overground parts of plants was increased from 24.23-680.56 mg/kg to 29.07-1905.57 mg/kg.This research demonstrated that B.maximowicziana appeared to be suitable for phytoremediation of Pb contaminated soil,especially,combination with EDTA.     

Decomposition of alachlor by ozonation and its mechanism

Decomposition and corresponding mechanism of alachlor, an endocrine disruptor in water by ozonation were investigated. Results showed that alachlor could not be completely mineralized by ozone alone. Many intermediates and final products were formed during the process, including aromatic compounds, aliphatic carboxylic acids, and inorganic ions. In evoluting these products, some of them with weak polarity were qualitatively identified by GC-MS. The information of inorganic ions suggested that the dechlorination was the first and the fastest step in the ozonation of alachlor.     

Enzymatic oxidation of aqueous pentachlorophenol

The influence of the nonionic surfactant Tween 80 on pentachlorophenol （PCP） oxidation catalyzed by horseradish peroxidase was studied. The surfactant was tested at concentrations below and above its critical micelle concentration （CMC）. Enhancement of PCP removal was observed at sub-CMCs. The presence of Tween 80 in the reaction mixture reduced enzyme inactivation which occurred through a combination of free radical attack and sorption by precipitated products. A simple first-order model was able to simulate time profiles for enzyme inactivation in the presence or absence of Tween 80. At supra-CMCs, the surfactant caused noticeable reductions in PCP removal, presumably through micelle partitioning of PCP which precluded the hydrophobic PCP molecule from interacting with the enzyme.     

基于综合水质标识指数和对应分析法的校园河道水质评价

以三峡大学的校园河道求索溪为研究对象,利用综合水质标识指数法确定求索溪水质类别,分析其水质时空变化规律,并利用对应分析法得出求索溪中不同监测点的主要污染因子.研究结果表明:求索溪整体的综合水质标识指数为7.423,整体水质为劣V类(地表水环境质量标准GB 3838-2002)且黑臭.从时间变化来看,求索溪4月份的水质最差,5月份次之,4、5月份所有监测点的水质都劣于V类且黑臭;8月份水质最好,水质为Ⅳ类;从空间分布来看,8个监测点综合水质标识指数均超过6.0,水质为劣V类,其中6号监测点的水质相对最好,监测点3号的水质相对最差;对应分析法得出求索溪的整体水体污染程度受总氮因子的影响最大,其次为总磷.该研究拟为求索溪及类似校园河道的水环境治理研究提供基础依据和参考.     

Effects of chitosan on growth of an aquatic plant (Hydrilla verticillata) in polluted waters with different chemical oxygen demands

Effects of chitosan on a submersed plant, Hydrilla verticillata, were investigated. Results indicated that H. venicillata could prevent ultrastructure phytotoxicities and oxidativereaction from polluted water with high chemical oxygen demand (COD). Superoxide dismutase (SOD) activity and malondialdehyde (MDA) contents in H. verticillata treated with 0.1% chitosan in wastewater increased with high COD (980 mg/L) and decreased with low COD (63 mg/L), respectively. Ultrastructural analysis showed that the stroma and grana of chloroplast basically remained normal. However, plant cells from the control experiment (untreated with chitosan) were vacuolated and the cell interval increased. The relict of protoplast moved to the center, with cells tending to disjoint. Our findings indicate that wastewater with high COD concentration can cause a substantial damage to submersed plant, nevertheless, chitosan probably could alleviate the membrane lipid peroxidization and ultrastructure phytotoxicities, and protect plant cells from stress of high COD concentration polluted water.     

Removal of cadmium using MnO2 loaded D301 resin

MnO2 loaded weak basic anion exchange resin D301 （Anion exchange resin, macroreticular weak basic styrene） as adsorbent has been prepared and applied to the removal of cadmium. The adsorption characteristics have been investigated with respect to effect of pH, equilibrium isotherms, removal kinetic data, and interference of the coexisting ions. The results indicated that the Cd^2＋ could be efficiently removed using MnO2 loaded D301 resin in the pH range of 3-8 from aqueous solutions with the co-existence of high concentration of alkali and alkaline-earth metals ions. The saturate adsorption capacity of the Cd^2＋ was 77.88 mg/g. The adsorption process followed the pseudo first-order kinetics. The equilibrium data obtained in this study accorded excellently with the Langmuir adsorption isotherm.     

Evaluation of phytoextracting cadmium and lead by sunflower, ricinus, alfalfa and mustard in hydroponic culture

Soil contaminated with heavy metals cadmium(Cd)and lead(Pb)is hard to be remediated.Phytoremediation may be a feasible method to remove toxic metals from soil,but there are few suitable plants which can hyperaccumulate metals.In this study,Cd and Pb accumulation by four plants including sunflower(Helianthus annuus L.),mustard(Brassica juncea L.),alfalfa(Medicago sativa L.), ricinus(Ricinus communis L.)in hydroponic cultures was compared.Results showed that these plants could phytocxtract heavy metals, the ability of accumulation differed with species,concentrations and categories of heavy metals.Values of BCF(bioconcentration factor)and TF(translocation factor)indicated that four species had dissimilar abilities of phytoextraction and transportation of heavy metals.Changes on the biomass of plants,pH and Eh at different treatments revealed that these four plants had distinct responses to Cd and Pb in cultures.Measurements should be taken to improve the phytoremediation of sites contaminated with heavy metals,such as pH and Eh regulations,and so forth.     

Effect of coagulation pretreatment on the fouling of ultrafiltration membrane

The purpose of this study is to understand the effect and mechanism of preventing membrane fouling, by coagulation pretreatment, in terms of fractional component and molecular weight of natural organic matter （NOM）. A relatively higher molecular weight （MW） of hydrophobic compounds was responsible for a rapid decline in the ultrafiltration flux. Coagulation could effectively remove the hydrophobic organics, resulting in the increase of flux. It was found that a lower MW of neutral hydrophilic compounds, which could remove inadequately by coagulation, was responsible for the slow declining flux. The fluxes in the filtration of coagulated water and supernatant water were compared and the results showed that a lower MW of neutral hydrophilic compounds remained in the supernatant water after coagulation could be rejected by a membrane, resulting in fouling. It was also found that the coagulated flocs could absorb neutral hydrophilic compounds effectively. Therefore, with the coagulated flocs formed on the membrane surface, the flux decline could be improved.     

Penetration analysis of elements and bioleaching treatment of spent refractory for recycling

Acidithiobacillus ferrooxidans ATCC23270 and Acidithiobacillus thiooxidans TM-32 were used for bioleaching of spent refractories of aluminium and copper melting furnaces for their recycling.Firstly,penetration of elements into aluminium melting furnace refractory was investigated and it was found that up to 7 cm from surface was contaminated.Comparison on leaching efficiency by the strains ATCC23270 and TM-32 found that the strain ATCC23270 could treat larger amount of the refractories than the strain TM-32 could do.In the experiment of bioleaching of spent refractory aluminium melting furnace by the strain ATCC23270,high leaching efficiency were obtained on Al,Si,and Ca,and extremely low leaching performance was,however,shown on the rest of elements i.e.,Na,Mn,and Zn.Under the strain TM-32 use,relatively high leaching performance was recognized on Al,Si,Ca,Na,Mn,and Zn.In the experiment of bioleaching for spent refractory copper melting furnace,almost the same leaching trends were shown on Cu,Zn,Al,and Si under the strains ACTT23270 and TM-32 uses.