火电厂脱硫石膏和粉煤灰综合利用的实验研究

对火电厂两大固体废物烟气脱硫石膏和粉煤灰在空气自然条件下的固结反应进行了实验研究。结果表明,粉煤灰与脱硫石膏的最佳质量比为3∶2;少量添加剂有助于固结材强度增加,其中硫酸盐类以1%Na2SO4效果最好,碱性添加剂以1%石灰为佳,添加1%*的盐酸可大幅增加固结材强度;此外,粉煤灰的含碳量和粒径对固结材强度有显著影响。粉煤灰-脱硫石膏固结材以电厂两大固废为原料,可利用工业废渣作添加剂,在空气自然养护条件下具有良好固结性能,可广泛应用于填埋、铺路等对固结性要求不高的领域。     

火电厂脱硫石膏和粉煤灰综合利用的实验研究

对火电厂两大固体废物烟气脱硫石膏和粉煤灰在空气自然条件下的固结反应进行了实验研究。结果表明,粉煤灰与脱硫石膏的最佳质量比为3∶2;少量添加剂有助于固结材强度增加,其中硫酸盐类以1%Na2SO4效果最好,碱性添加剂以1%石灰为佳,添加1%*的盐酸可大幅增加固结材强度;此外,粉煤灰的含碳量和粒径对固结材强度有显著影响。粉煤灰-脱硫石膏固结材以电厂两大固废为原料,可利用工业废渣作添加剂,在空气自然养护条件下具有良好固结性能,可广泛应用于填埋、铺路等对固结性要求不高的领域。     

火电厂脱硫石膏和粉煤灰综合利用的实验研究

对火电厂两大固体废物烟气脱硫石膏和粉煤灰在空气自然条件下的固结反应进行了实验研究。结果表明,粉煤灰与脱硫石膏的最佳质量比为3∶2;少量添加剂有助于固结材强度增加,其中硫酸盐类以1%Na2SO4效果最好,碱性添加剂以1%石灰为佳,添加1%*的盐酸可大幅增加固结材强度;此外,粉煤灰的含碳量和粒径对固结材强度有显著影响。粉煤灰-脱硫石膏固结材以电厂两大固废为原料,可利用工业废渣作添加剂,在空气自然养护条件下具有良好固结性能,可广泛应用于填埋、铺路等对固结性要求不高的领域。     

尾矿添加量对加气混凝土性能的影响

通过实验,以金尾矿、石膏、水泥、石灰、铝粉等为原料,研究金尾矿添加量对加气混凝土性能的影响。分析认为,不同的配合比,不仅关系到产品的经济效益,还会对产品的性能有显著影响。实验得出能提高尾矿利用率的最优尾矿添加量为64.8%,最佳配比为:金尾矿64.8%、石灰16.2%、水泥14.2%、石膏4.7%、铝粉0.1%。     

非烧结磷石膏砖的制备研究

以磷石膏为主要原料,辅以粉煤灰、生石灰、河砂等制备非烧结磷石膏砖,探索较优的物料配比及操作条件;设定操作条件为砖坯成型压力20 MPa、105℃下干燥12 h,通过120℃,0.105 MPa的蒸汽养护4 h;最优物料配比为m(磷石膏量)∶m(粉煤灰量)∶m(河砂量)∶m(生石灰量)∶m(成型水量)=1∶0.5∶0.2∶0.15∶0.25。制品强度可达MU10级;制品无浸出毒性风险。     

典型燃煤电厂汞的分布、迁移及释放特征研究

采集安徽不同地区两典型燃煤电厂火力发电中使用的原煤及其产生的3类固体副产物(飞灰,炉渣及脱硫石膏样品),对4类样品中汞含量分别进行测定,以此揭示电厂燃煤过程中汞的分布、迁移及转化规律。此外,采用质量平衡及二次排放模型分别初步估算了电厂燃煤及燃煤固体副产物再利用过程中汞的两次释放特征。结果显示,汞在原煤、飞灰、炉渣及脱硫石膏样品中的含量分别为174~321μg/kg、421~316μg/kg、6~3 143μg/kg和2 988~4 694μg/kg;燃煤过程中有20.9%~23.6%的汞转移到飞灰中,32.6%~59.9%的汞赋存于脱硫石膏中,16.5%~37.4%的汞通过烟囱首次排入大气,仅有0.02%~9.2%的汞残留在炉渣中。二次排放模拟结果显示,燃煤电厂1#和2#中飞灰和脱硫石膏的高温再利用过程将向大气二次释放汞量96.0 kg/a和165.8 kg/a,两次年排放总量分别为189.5 kg和640.8 kg。本研究可为燃煤电厂汞的污染过程控制提供参考依据。     

粉煤灰不同配比基质对黑麦草生长的影响

粉煤灰是燃煤电厂排出的固体废弃物,主要成分有SiO2,Al2O3,Fe2O3,CaO等。采用盆栽试验将粉煤灰分别与粘土、砂土、秸秆按3:1的比例混合作为基质种植黑麦草,并用纯粉煤灰基质做对照,研究黑麦草在粉煤灰不同配比基质上的生长状况,结果表明,粉煤灰+粘土为黑麦草的最佳生长基质。     

新疆地区电厂脱硫石膏增强的水泥基污泥固化剂的制备及性能分析

利用水泥基和电厂废弃脱硫石膏研制适用于新疆地区经济高效污泥固化剂,采用单因素多水平和响应面分析的方法研究硅酸盐水泥、脱硫石膏、粉煤灰、过硫酸钾(KPS)的掺比和固化时间对污泥固化体无侧限抗压强度的影响,运用Design-expert优化污泥固化体的无侧限抗压强度,并利用扫描电镜分析污泥固化体的微观结构。实验表明:水泥基和电厂废弃的脱硫石膏能够有效改善污泥固化体的抗压强度;当工程应用中,需要抗压强度最佳时的掺比为m(污泥)∶m(水泥)∶m(脱硫石膏)∶m(粉煤灰)∶m(KPS)=100∶3∶1∶1∶0. 5、固化时间为3 d;而需要经济最优时的掺比为m(污泥)∶m(水泥)∶m(脱硫石膏)=100∶1∶1、固化时间为7 d,处理每吨污泥的药剂成本为5～6元。     

中国燃煤电厂汞的物质流向与汞排放研究

为研究中国燃煤电厂中汞的去向,基于2010年中国各省份燃煤中的汞含量、燃煤消耗量、燃煤电厂大气污染控制设备的安装比例以及粉煤灰、脱硫石膏的二次利用方式,计算了我国燃煤电厂2010年向大气、水体、土壤中排放汞的量.2010年我国电厂燃煤共输入汞271.7t (147.1~403.6t).煤炭在电厂燃烧一次排放到大气中的汞为101.3t (44.0~167.1t),进入燃煤副产物、水体的汞分别为167.4t (84.3~266.3t),3.0t (1.2~5.0t).燃煤副产物二次利用过程向大气排放的汞为32.7t (12.5~56.1t),进入土壤中的汞为58.6t (33.6~103.9t),还有76.1t (30.3~108.6t)汞留在了产品中.结果表明,粉煤灰用于水泥生产和粉煤灰制砖是副产物向大气中二次排放的重要源,分别占总二次排放量的81.7%和15.3%.     

废石膏用于道路回填材料的处理工艺及性能研究

讨论了化工废石膏在矿物掺合物、粉煤灰、激发剂、外加剂等存在时，在不同配比下的力学性能、凝结时间、溶蚀率、软化系数和体积稳定性，并分析了该材料水化、硬化规律，硬化体结构及与性能的关系，试验结果表明，化工废石膏掺加量的多少将直接影响到各项性能指标，采用复合早强减水剂，对于粉煤灰活性激发，及加速胶结材料凝结水化、降低用量，有显著效果。     

Distribution and ecological effect of mercury in Laogang landfill, Shanghai, China

Laogang landfill near Shanghai is the largest landfill in China, and receives about 10000 t of daily garbage per day, Samples of topsoil and plants were analyzed to evaluate mercury pollution from the landfill. For topsoil samples, there were significant correlations among total mercury （HgT）, combinative mercury （Hgc） and gaseous mercury （HgG）, and content of total organic carbon （TOC）, but, no significantly relationship was found between Hg content and filling time. Hg content changes in vertical profiles with time showed that the average Hgv of profiles 1992, 1996, and 2000 was similar, but their average HgG was quite different. HgT was significantly correlated with Hgc in profile 1992 and 2000, and Hgv was significantly correlated with Hg6 in profile 1996. HgG/Hgv ratio in profile samples decreased in the order of （HgG,/HgT）1992〉（HgG/HgT）1996〉〉（HgG/HgT）2000. A simple outline of Hg release in landfill could be drawn： with increasing of filling time, degradation undergoes different biodegradation, accordingly, gaseous mercury goes through small, more, and small proportion to total mercury. Distribution of Hg in plants was inhomogeneous, following the order of leaf〉root〉stem. The highest value of leaf may be associated with higher atmospheric Hg from landfill. Ligneous plants （e.g. Phyllostachys glanca, Prunus salicina and Ligustrum lucidum） are capable of enriching more Hg than herbaceous plants.     

EDTA-enhanced phytoremediation of lead contaminated soil by Bidens maximowicziana

Phytoremediation is a potential cleanup technology for the removal of heavy metals from contaminated soils.Bidens maximowicziana is a new Pb hyperaccumulator,which not only has remarkable tolerance to Pb but also extraordinary accumulation capacity for Pb.The maximum Pb concentration was 1509.3 mg/kg in roots and 2164.7 mg/kg in overground tissues.The Pb distribution order in the B. maximowicziana was:leaf>stem>root.The effect of amendments on phytoremediation was also studied.The mobility of soil Pb and the Pb concentrations in plants were both increased by EDTA application.Compared with CK(control check),EDTA application promoted translocation of Pb to overground parts of the plant.The Pb concentrations in overground parts of plants was increased from 24.23-680.56 mg/kg to 29.07-1905.57 mg/kg.This research demonstrated that B.maximowicziana appeared to be suitable for phytoremediation of Pb contaminated soil,especially,combination with EDTA.     

Decomposition of alachlor by ozonation and its mechanism

Decomposition and corresponding mechanism of alachlor, an endocrine disruptor in water by ozonation were investigated. Results showed that alachlor could not be completely mineralized by ozone alone. Many intermediates and final products were formed during the process, including aromatic compounds, aliphatic carboxylic acids, and inorganic ions. In evoluting these products, some of them with weak polarity were qualitatively identified by GC-MS. The information of inorganic ions suggested that the dechlorination was the first and the fastest step in the ozonation of alachlor.     

Enzymatic oxidation of aqueous pentachlorophenol

The influence of the nonionic surfactant Tween 80 on pentachlorophenol （PCP） oxidation catalyzed by horseradish peroxidase was studied. The surfactant was tested at concentrations below and above its critical micelle concentration （CMC）. Enhancement of PCP removal was observed at sub-CMCs. The presence of Tween 80 in the reaction mixture reduced enzyme inactivation which occurred through a combination of free radical attack and sorption by precipitated products. A simple first-order model was able to simulate time profiles for enzyme inactivation in the presence or absence of Tween 80. At supra-CMCs, the surfactant caused noticeable reductions in PCP removal, presumably through micelle partitioning of PCP which precluded the hydrophobic PCP molecule from interacting with the enzyme.     

基于综合水质标识指数和对应分析法的校园河道水质评价

以三峡大学的校园河道求索溪为研究对象,利用综合水质标识指数法确定求索溪水质类别,分析其水质时空变化规律,并利用对应分析法得出求索溪中不同监测点的主要污染因子.研究结果表明:求索溪整体的综合水质标识指数为7.423,整体水质为劣V类(地表水环境质量标准GB 3838-2002)且黑臭.从时间变化来看,求索溪4月份的水质最差,5月份次之,4、5月份所有监测点的水质都劣于V类且黑臭;8月份水质最好,水质为Ⅳ类;从空间分布来看,8个监测点综合水质标识指数均超过6.0,水质为劣V类,其中6号监测点的水质相对最好,监测点3号的水质相对最差;对应分析法得出求索溪的整体水体污染程度受总氮因子的影响最大,其次为总磷.该研究拟为求索溪及类似校园河道的水环境治理研究提供基础依据和参考.     

Effects of chitosan on growth of an aquatic plant (Hydrilla verticillata) in polluted waters with different chemical oxygen demands

Effects of chitosan on a submersed plant, Hydrilla verticillata, were investigated. Results indicated that H. venicillata could prevent ultrastructure phytotoxicities and oxidativereaction from polluted water with high chemical oxygen demand (COD). Superoxide dismutase (SOD) activity and malondialdehyde (MDA) contents in H. verticillata treated with 0.1% chitosan in wastewater increased with high COD (980 mg/L) and decreased with low COD (63 mg/L), respectively. Ultrastructural analysis showed that the stroma and grana of chloroplast basically remained normal. However, plant cells from the control experiment (untreated with chitosan) were vacuolated and the cell interval increased. The relict of protoplast moved to the center, with cells tending to disjoint. Our findings indicate that wastewater with high COD concentration can cause a substantial damage to submersed plant, nevertheless, chitosan probably could alleviate the membrane lipid peroxidization and ultrastructure phytotoxicities, and protect plant cells from stress of high COD concentration polluted water.     

Removal of cadmium using MnO2 loaded D301 resin

MnO2 loaded weak basic anion exchange resin D301 （Anion exchange resin, macroreticular weak basic styrene） as adsorbent has been prepared and applied to the removal of cadmium. The adsorption characteristics have been investigated with respect to effect of pH, equilibrium isotherms, removal kinetic data, and interference of the coexisting ions. The results indicated that the Cd^2＋ could be efficiently removed using MnO2 loaded D301 resin in the pH range of 3-8 from aqueous solutions with the co-existence of high concentration of alkali and alkaline-earth metals ions. The saturate adsorption capacity of the Cd^2＋ was 77.88 mg/g. The adsorption process followed the pseudo first-order kinetics. The equilibrium data obtained in this study accorded excellently with the Langmuir adsorption isotherm.     

Effect of coagulation pretreatment on the fouling of ultrafiltration membrane

The purpose of this study is to understand the effect and mechanism of preventing membrane fouling, by coagulation pretreatment, in terms of fractional component and molecular weight of natural organic matter （NOM）. A relatively higher molecular weight （MW） of hydrophobic compounds was responsible for a rapid decline in the ultrafiltration flux. Coagulation could effectively remove the hydrophobic organics, resulting in the increase of flux. It was found that a lower MW of neutral hydrophilic compounds, which could remove inadequately by coagulation, was responsible for the slow declining flux. The fluxes in the filtration of coagulated water and supernatant water were compared and the results showed that a lower MW of neutral hydrophilic compounds remained in the supernatant water after coagulation could be rejected by a membrane, resulting in fouling. It was also found that the coagulated flocs could absorb neutral hydrophilic compounds effectively. Therefore, with the coagulated flocs formed on the membrane surface, the flux decline could be improved.     

Penetration analysis of elements and bioleaching treatment of spent refractory for recycling

Acidithiobacillus ferrooxidans ATCC23270 and Acidithiobacillus thiooxidans TM-32 were used for bioleaching of spent refractories of aluminium and copper melting furnaces for their recycling.Firstly,penetration of elements into aluminium melting furnace refractory was investigated and it was found that up to 7 cm from surface was contaminated.Comparison on leaching efficiency by the strains ATCC23270 and TM-32 found that the strain ATCC23270 could treat larger amount of the refractories than the strain TM-32 could do.In the experiment of bioleaching of spent refractory aluminium melting furnace by the strain ATCC23270,high leaching efficiency were obtained on Al,Si,and Ca,and extremely low leaching performance was,however,shown on the rest of elements i.e.,Na,Mn,and Zn.Under the strain TM-32 use,relatively high leaching performance was recognized on Al,Si,Ca,Na,Mn,and Zn.In the experiment of bioleaching for spent refractory copper melting furnace,almost the same leaching trends were shown on Cu,Zn,Al,and Si under the strains ACTT23270 and TM-32 uses.     

Simultaneous removal of ammonium and phosphate by zeolite synthesized from coal fly ash as influenced by acid treatment

Zeolite synthesized from fly ash （ZFA） without modification is not efficient for the purification of NH4＋ and phosphate at low concentrations that occur in real effluents, despite the high potential removal capacity. To develop an effective technique to enhance the removal efficiency of ammonium and phosphate at low concentrations, ZFA was modified with acid treatment and the simultaneous removal of ammonium and phosphate in a wide range of concentration was investigated. It was seen that when compared with untreated ZFA, only the treatment by 0.01 mol/L of H2SO4 significantly improved the removal efficiency of ammonium at low initial concentrations. The behavior was well explained by the pH effect. Treatment by more concentrated H2SO4 led to the deterioration of the ZFA structure and a decrease in the cation exchange capacity. Treatment by 0.01 mol/L H2SO4 improved the removal efficiency of phosphate by ZFA at all initial P concentrations, while the treatment by concentrated H2SO4 （≥0.9 mol/L） resulted in a limited maximum phosphate immobilization capacity （PIC）. It was concluded that through a previous mild acid treatment （e.g. 0.01 mol/L of H2SO4）, ZFA can be used in the simultaneous removal of NH4＋ and P at low concentrations simulating real effluent.