A mathematical model for a hybrid anaerobic reactor

A mathematical model for a hybrid anaerobic reactor (HAR), which uses self-immobilized anaerobic bacterial granules under completely fluidized condition, has been developed. Stoichiometry of glucose fermentation into methane has been considered in this model. The model includes: (1) a biofilm model which describes substrate conversion kinetics within a single granule; (2) a bed fluidization model which describes the distribution of biogranules within the fluidized bed and (3) a reactor model which links the above two to predict the substrate and products concentration profile along the reactor height. Product and pH inhibition for each group of bacteria has been considered in the kinetic model. The spatial distribution of each group of anaerobic bacteria within granules has been found to play a vital role in bringing about the conversion. Experiments were conducted in the reactor using a synthetic effluent containing glucose as the carbon source to study the treatment efficiency. The model was simulated first assuming a 3-layered distribution [MacLeod, F.A., Guiot, S.R., Costerton, J.W., 1990. Layered structure of bacterial aggregates produced in an upflow anaerobic sludge bed and filter reactor. Applied and Environmental Microbiology 56, 1598-1607.] of anaerobic bacteria within granules and then homogeneous distribution [Grotenhuis, J.T.C., Smit, M., Plugge, C.M., Yuansheng, X., van Lammeren, A.A.M., Stams, A.J.M., Zehnder, A.J.B., 1991. Bacterial composition and structure of granular sludge adapted to different substrates. Applied and Environmental Microbiology 57, 1942-1949.] of anaerobic bacteria. The predictions of model simulation with the assumption of layered structure closely represented the experimental data.     

Sorption of phenol and 4-chlorophenol onto pumice treated with cationic surfactant

The anaerobic digestion rate for flocculated sludge has been considered to be lower than that of original sludge, particularly in the later stages of digestion; attributed this relatively slower rate to the increased mass transfer resistance for reactants through the large flocs after flocculation. This study confirmed that methane production was retarded by flocculation. The structure of the floc was identified with fluorescence in situ hybridization (FISH) and a confocal laser scanning microscope (CLSM) technique. To verify the mass transfer resistance induced by flocculation, microsensors were applied to assess the response of oxygen concentration distribution inside the flocs that are subjected to sudden changes in ambient oxygen levels. Response time for the electrode at a floc's center was five times greater than the response time in original sludge flocs. Although the effective diffusivity of oxygen in the floc increased by 2.3 times after flocculation, the increased size of the flocculated floc was the major contributor to the total mass transfer resistance to oxygen.     

溶解氧对好氧颗粒污泥影响的研究进展

好氧颗粒污泥技术是一种新颖废水处理技术。溶解氧(DO)是好氧颗粒污泥形成和稳定运行的一个重要参数。好氧颗粒污泥需要的曝气量大,能耗高。高曝气量带来的高DO浓度不利于氨氮通过SND去除。当DO扩散在颗粒内部受到限制时,颗粒中心形成的厌氧层不利于颗粒污泥的长期稳定运行。本文系统分析了DO浓度对好氧颗粒污泥影响的国内外研究现状,对好氧颗粒污泥中DO浓度这一重要参数的研究进行了总结。研究在低DO浓度下保持好氧颗粒污泥的稳定性有利于降低运行成本,采取合适的方法降低颗粒内部的扩散限制有利于增强颗粒的稳定性能。     

硫酸盐生物还原的限制性生态因子的影响研究

利用厌氧颗粒污泥对烟气中SO2吸收生成的硫酸盐或亚硫酸盐废水进行处理，考察起始SO4^2-质量浓度、初始COD／SO4^2-、初始pH、接种污泥质量、亚铁离子等限制性生态因子对硫酸盐还原的影响。结果表明：在起始SO4^2-质量浓度800mg／L，初始COD／SO4^2-为3．0，pH值为7．0，接种污泥质量为31．10gVSS／L，添加亚铁离子的条件下，进行半连续试验，硫酸根去除率可迭70％。表明在COD／SO4^2-较低的条件下，各生态因子综合作用下，硫酸盐还原可得较好效果。     

Studies on the toxic effects of pentachlorophenol on the biological activity of anaerobic granular sludge

In order to explore the pathway of the anaerobic biotreatment of the wastewater containing pentachlorophenol (PCP) and ensure the normal operation of Upflow Anaerobic Sludge Blanket (UASB) reactor, the anaerobic sludge under different acclimation conditions were selected to seed and start up UASB reactors. Anaerobic toxicity assays were employed to study the biological activity, the tolerance and the capacity to degrade PCP of different anaerobic granular sludge from UASB reactors. Results showed that the anaerobic granular sludge acclimated to chlorophenols (CPs) could degrade PCP more quickly (up to 9.50mg-PCPg(-1)TVSd(-1)). And the anaerobic granular sludge without acclimation to CPs had only a little activity of degrading PCP (less than 0.07mg-PCPg(-1)TVSd(-1)). Different PCP concentrations (2, 4, 6, 8mgL(-1)) had different inhibition effects on glucose utilization, volatile fatted acidity (VFA)-degrading and methanogens activity of PCP degradation anaerobic granular sludge, and the biological activity declined with the increase in PCP concentration. The methanogens activity suffered inhibition from PCP more easily. The different acclimation patterns of seeded sludge had distinctly different effects on biological activity of the degradation of PCP of anaerobic granular sludge from UASB reactors. The biological activity of the anaerobic granular sludge acclimated to PCP only was also inhibited. This inhibition was weak compared to that of anaerobic granular sludge acclimated to CPs, further, the activity could recover more quickly in this case. In the same reactor, the anaerobic granular sludge from the mid and base layers showed higher tolerance to PCP than that from super layer or if the sludge is unacclimated to CPs, and the corresponding recovery time of the biological activity in the mid and base layers were short. Acetate-utilizing methanogens and syntrophic propinate degraders were sensitive to PCP, compared to syntrophic butyrate degraders.     

油田含油污泥深度调剖技术研究

针对目前油田联合站中含油污泥处理难的问题,提出了利用含油污泥开展深度调剖技术,通过对含油污泥组分和颗粒粒径分布测试分析,研制出合适的含油污泥深度调剖剂,室内评价结果表明:该调剖剂抗剪切能力强,热稳定性好,适用于80℃以下油藏,可提高驱油效率31.8%,不仅提高了注水开发效果,而且为解决油田含油污泥污染环境问题提供了一个途径。     

Relationships between anaerobic consortia and removal efficiencies in an UASB reactor degrading 2,4 dichlorophenol (DCP)

To gain more insight into the interactions between anaerobic bacteria and reactor performances (chemical oxygen demand-COD, 2,4 dichlorophenol-2,4 DCP removals, volatile fatty acid-VFA, and methane gas productions) and how they depended on operational conditions the microbial variations in the anaerobic granular sludge from an upflow anaerobic sludge blanket (UASB) reactor treating 2,4 DCP was studied. The study was composed of two parts. In the first part, the numbers of methanogens and acedogens in the anaerobic granular sludge were counted at different COD removal efficiencies. The relationships between the numbers of methanogens, the methane gas production and VFA production were investigated. The COD removal efficiencies increased to 74% from 30% while the number of total acedogens decreased to 10 from 30 cfu ml(-1). The number of total methanogens and acedogens varied between 11 x 10(3) and 10 x 10(9)MPN g(-1) and 10 and 30 cfu ml(-1) as the 2,4 DCP removal efficiencies were obtained between 60% and 99%, respectively. It was seen that, as the number of total acedogens decreased, the COD removal efficiencies increased. However, the number of total methanogens increased as the COD removal efficiencies increased. Correlations between the bacterial number and with the removal efficiencies obtained in different operational conditions were investigated. From the results presented in this paper a high correlation between the number of bacteria, COD removals, methane gas percentage, 2,4 DCP removals and VFA was observed. In the second part, methanogen bacteria in the anaerobic granular sludge were identified. Microbial observations and biochemical tests were applied to identify the anaerobic microorganisms from the anaerobic granular sludge. In the reactor treating 2,4 DCP, Methanobacterium bryantii, Methanobacterium formicicum, Methanobrevibacter smithii, Methanococcus voltae, Methanosarcina mazei, Methanosarcina acetivorans, Methanogenium bourgense and Methanospirillum hungatei were identified.     

Treatment and reuse of sewage sludge

Sewage sludge was treated using composting, fixed-bed and stirred anaerobic digesters. The treatment performance in terms of the physico chemical parameters, bacterial indicators and pathogenic forms were assessed. In addition, the biogas production rate was recorded in the case of anaerobic digesters. Composting of the sewage sludge increased its total solids from 39 to 93% after 6 weeks, while the reduction in organic matter was 40% and the total nitrogen and phosphorus contents increased by 22 and 30%, respectively. Complete removal of salmonellae and faecal coliforms occurred, so that the composted sludge could be used as a soil conditioner and fertilizer. The results of the anaerobic treatment indicated that an organic load of 4.8kg COD m–3 per day achieved the best operating conditions for either the stirred or fixed-bed digester. The mean percentage removals of COD, BOD, faecal coliforms, faecal streptococci and the biogas production rate for the stirred digester were 53, 53, 24 and 29% and 259 L kg–1 COD per day, respectively. The corresponding mean percentage removals and production rate for the experiments with a fixed-bed digester were 61, 62, 33 and 35% and 328 L kg–1 COD per day, respectively. Improvements in the BOD and faecal coliform reductions and the gas production rate of 17, 38 and 21%, respectively, were achieved due to the presence of media (Berl saddles) in the fixed-bed digester. The microbial content of the anaerobically treated sludge is too high to be used as a fertilizer, while that of the composted sludge is low enough for such use.     

国外厌氧颗粒污泥培养研究简介

本文荟萃了荷兰、美国、德国、法国许多学者对厌氧颗粒污泥培养的研究，强调了颗粒化的机理仍是一个较为复杂而尚存在许多未知数的领域，并介绍了颗粒污泥的贮存。     

Performance of sequential anaerobic/aerobic digestion applied to municipal sewage sludge

A promising alternative to conventional single phase processing, the use of sequential anaerobic-aerobic digestion, was extensively investigated on municipal sewage sludge from a full scale wastewater treatment plant. The objective of the work was to evaluate sequential digestion performance by testing the characteristics of the digested sludge in terms of volatile solids (VS), Chemical Oxygen Demand (COD) and nitrogen reduction, biogas production, dewaterability and the content of proteins and polysaccharides. VS removal efficiencies of 32% in the anaerobic phase and 17% in the aerobic one were obtained, and similar COD removal efficiencies (29% anaerobic and 21% aerobic) were also observed. The aerobic stage was also efficient in nitrogen removal providing a decrease of the nitrogen content in the supernatant attributable to nitrification and simultaneous denitrification. Moreover, in the aerobic phase an additional marked removal of proteins and polysaccharides produced in the anaerobic phase was achieved. The sludge dewaterability was evaluated by determining the Optimal Polymer Dose (OPD) and the Capillary Suction Time (CST) and a significant positive effect due to the aerobic stage was observed. Biogas production was close to the upper limit of the range of values reported in the literature in spite of the low anaerobic sludge retention time of 15 days. From a preliminary analysis it was found that the energy demand of the aerobic phase was significantly lower than the recovered energy in the anaerobic phase and the associated additional cost was negligible in comparison to the saving derived from the reduced amount of sludge to be disposed.     

Modeling of real scale waste activated sludge anaerobic digestion process by Anaerobic Digestion Model 1 (ADM1)

In this study, real-scale wastewater treatment plant (Hurma WWTP) sludge anaerobic digestion process was modeled by Anaerobic Digestion Model (ADM1) with the purpose of generating the data to understand the process better by contributing to the prediction of the process operational conditions and process performance, which will be a base for future anaerobic sludge stabilization process investments.

Real-scale anaerobic sludge digestion process data was evaluated in terms of known process and state variables and also process yields. Average VS removal yield, methane production yield, and methane production rate values of the anaerobic sludge digestion unit were calculated as 46.4%, 0.49 m³CH₄/kg VS_removed, and 0.33 m³ CH₄/m³day, respectively. In this study, ADM1 was intended to predict the behavior of real-scale anaerobic digester processing sewage sludge under dynamic conditions. To estimate the variables of real-scale sludge anaerobic digestion process with high accuracy and to provide high model prediction performance, values of the four parameters (disintegration rate constant, carbohydrate hydrolysis rate constant, protein hydrolysis rate constant, and lipid hydrolysis rate constant) that have strong effects on structured ADM1 were estimated by using the parameter estimation module in Aquasim program and their values were found as 0.101, 10, 10, and 9.99, respectively. When the numbers of kinetic parameters with the processes included in ADM1 along with the dynamic and non-linear structure of the real scale anaerobic digestion were taken into consideration, model simulations were in good agreement with measured results of the biogas flow rate, methane flow rate, pH, total alkalinity, and volatile fatty acids.     

一种厌氧颗粒污泥的微生物与化学组成研究初探

本文研究UASB反应器处理石灰法制浆的草浆蒸煮黑液,在较短时间内培养出首育良好沉淀性能和较高活性的厌氧颗粒污泥。并对其形态、结构和化学组份及不同生理类群的厌氧微生物特性等进行了观察和测试,结果表明厌氧颗粒污泥高活性的原因。为进一步探索厌氧颗粒污泥的形成机理提供了依据。     

市政污泥与高浓度废弃物的厌氧共消化：一种生物质能源净产生的途径

厌氧共消化是一种绿色、实用的回收废弃物中能源的技术。本文介绍了厌氧共消化技术的原理，并介绍了美国佐治亚州F. Wayne Hil水资源处理中心采用油脂废弃物（FOG）和含糖工业废水与市政污泥进行连续流厌氧共消化的实际应用案例。结果表明，厌氧共消化可显著提高甲烷产量达2倍以上，甲烷产量随着高浓度有机废弃物负荷率及厌氧消化反应器停留时间的延长而增加，且COD和VS降解率可保持在合理范围内，经济效益显著。     

Evaluation of water treatment sludge for ameliorating acid mine waste

This study investigated the liming effect of water treatment sludge on acid mine spoils. The study was conducted with sludge from a water purification plant along the Vaal River catchments in South Africa. The optimum application rate for liming acid spoils and the speed and depth with which the sludge reacted with the mine waste were investigated. Chemical analysis indicated that the sludge is suitable as a liming agent because of its alkaline pH (8.08), high bicarbonate concentration (183.03 mg L(-1)), and low salinity (electrical conductivity = 76 mS m(-1)). The high cation exchange capacity of 15.47 cmol(c) kg(-1) and elevated nitrate concentration (73.16 mg L(-1)) also increase its value as an ameliorative material. The soluble concentrations for manganese, aluminum, lead, and selenium were high at a pH of 5 although only selenium (0.83 mg L(-1)) warranted some concern. According to experimental results, the application of 10 Mg ha(-1) of sludge to acid gold tailings increased the leach water pH from 4.5 to more than 7.5 and also increased the medium pH from 2.4 to 7.5. The addition of sludge further reduced the solubility of iron, manganese, copper, and zinc in the ameliorated gold tailings, but increased the electrical conductivity. The liming tempo was highest in the coal discard profile that had a coarse particle size distribution and took the longest to move through the gold tailings that had a fine particle size distribution. Results from this study indicate that the water treatment sludge investigated is suitable as a liming agent for rehabilitation of acid mine waste.     

An overview on biogas generation from anaerobic digestion of food waste

Food waste is an inevitable type of waste in every city, and its treatment technology evolves with time. Due to the high organic content and high biodegradability of food waste, anaerobic digestion becomes a commonly accepted treatment method to deal with it. This review article summarizes key factors for anaerobic digestion and provides useful information for successful anaerobic digestions. Reasonable temperature and pH are essential for a successful and productive anaerobic digestion process. A good inoculum to substrate ratio triggers a profitable food waste digestion. Good mixing and small particle sizes are important factors too. In addition, the pros and cons of different reactors to food waste digestion are highlighted. Moreover, co-digestion of food waste with animal manures, sewage sludge, and green waste were introduced.     

Evaluation of Optically Acquired Zooplankton Size-Spectrum Data as a Potential Tool for Assessment of Condition in the Great Lakes

An optical plankton counter (OPC) potentially provides an assessment tool for zooplankton condition in ecosystems that is rapid, economical, and spatially extensive. We collected zooplankton data with an OPC in 20 near-shore regions of 4 of the Laurentian Great Lakes. The zooplankton size information was used to compute mean size, biomass density, and size-spectra parameters for each location. The resulting metrics were analyzed for their ability to discriminate among the Great Lakes. Biomass density provided discrimination among lakes, as did several parameters describing spectra shape and distribution. A proposed zooplankton indicator, mean size (determined with OPC measurements in this study), was found to provide discrimination among lakes. Size-spectra-related parameters added increased ability to discriminate in conjunction with the biomass density (or mean size) metric. A discriminant function analysis of the multiple metrics (mean size, biomass density, and distribution parameters) suggests that a multi metric size-based approach might be used to classify communities among lakes improving a mean-size metric. The feasibility OPCs and size-based metrics for zooplankton assessment was found to have potential for further development as assessment tools for the biological condition of zooplankton communities in the Great Lakes.     

污水厂污泥与厨余垃圾厌氧/混合厌氧消化研究进展

本文主要对国内外城市污水厂污泥与厨余垃圾混合厌氧消化的研究进行了综述,介绍了厌氧消化技术在污水厂污泥和厨余垃圾处理处置中的应用,对两种废物单独厌氧消化和混合厌氧消化技术进行了比较,分析了城市污水厂污泥与厨余垃圾混合厌氧消化的可行性以及工艺参数对混合厌氧消化的影响,并对城市污水厂污泥与厨余垃圾的混合厌氧消化技术的研究和应用提出了展望。     

Thermophilic adaptation of a mesophilic anaerobic sludge for food waste treatment

As opposed to mesophilic, thermophilic anaerobic digestion of food waste can increase the biogas output of reactors. To facilitate the transition of anaerobic digesters, this paper investigated the impact of adapting mesophilic sludge to thermophilic conditions. A 5L bench scale reactor was seeded with mesophilic granular sludge obtained from an up-flow anaerobic sludge blanket digester. After 13 days of operation at 35 degrees C, the reactor temperature was instantaneously increased to 55 degrees C and operated at this temperature until day 21. The biomass was then fed food waste on days 21, 42 and 63, each time with an F/M (Food/Microorganism) ratio increasing from 0.12 to 4.43 gVS/gVSS. Sludge samples were collected on days 0, 21, 42 and 63 to conduct substrate activity tests, and reactor biogas production was monitored during the full experimental period. The sludge collected on day 21 demonstrated that the abrupt temperature change had no pasteurization effect, but rather lead to a biomass with a fermentative activity of 3.58 g Glucose/gVSS/d and a methanogenic activity of 0.47 and 0.26 g Substrate/gVSS/d, related respectively, to acetoclastic and hydrogenophilic microorganisms. At 55 degrees C, an ultimate gas production (Go) and a biodegradation potential (Bo) of 0.2-1.4 L(STP)/gVS(fed) and of 0.1-0.84 L(STP) CH(4)/gVS(fed) were obtained, respectively. For the treatment of food waste, a fully adapted inoculum was developed by eliminating the initial time-consuming acclimatization stage from mesophilic to thermophilic conditions. The feeding stage was initiated within 20 days, but to increase the population of thermophilic methanogenic microorganisms, a substrate supply program must be carefully observed.     

污泥厌氧消化预处理技术综述

全球环境问题已成为国际社会关注的焦点,围绕全球气候变化,降低温室气体排放,寻求再生能源,节能减排已成为目前国际科技发展的方向。通过"十一五"污水处理厂的建设,每年污泥产量已接近3000万吨(含水率80%脱水污泥计)以上,且以每年10%的速度递增。其处理与处置是制约社会经济发展的重要问题。但是,城市污泥蕴含有大量生物质能,通过借鉴国外先进技术与经验,开发城市污泥生物质能提取和利用技术,对我国节能减排具有重要战略意义。由于细胞壁的存在,使得污泥水解成为限制厌氧消化效率的重要瓶颈,而污泥强化预处理可有效提高污泥细胞壁的破坏,溶出胞内有机物,最大化回收剩余污泥中的有机能源。目前,预处理技术较多,如超声波预处理、热处理、微波预处理、碱解处理、臭氧预处理等,本文从物理、化学等角度分析了不同预处理对厌氧消化技术的影响。     

焦化废水BOD5接种质量控制

接种是BOD5质量控制关键。为了提高生物毒性较大的焦化废水BOD5测定结果的精密度和准确度,本文采用焦化废水活性污泥制备接种液,考察了接种底质和接种量对测定结果的影响。接种量为3～5mL/L时,BOD5值达到了GB 7488-1987质控要求。2个月的稳定性考察实验以及对随机水样的测定结果表明,该方法制备的接种液活性高、稳定性好,对改进焦化废水BOD5的监测有一定的现实指导意义。