Relationships between anaerobic consortia and removal efficiencies in an UASB reactor degrading 2,4 dichlorophenol (DCP)

To gain more insight into the interactions between anaerobic bacteria and reactor performances (chemical oxygen demand-COD, 2,4 dichlorophenol-2,4 DCP removals, volatile fatty acid-VFA, and methane gas productions) and how they depended on operational conditions the microbial variations in the anaerobic granular sludge from an upflow anaerobic sludge blanket (UASB) reactor treating 2,4 DCP was studied. The study was composed of two parts. In the first part, the numbers of methanogens and acedogens in the anaerobic granular sludge were counted at different COD removal efficiencies. The relationships between the numbers of methanogens, the methane gas production and VFA production were investigated. The COD removal efficiencies increased to 74% from 30% while the number of total acedogens decreased to 10 from 30 cfu ml(-1). The number of total methanogens and acedogens varied between 11 x 10(3) and 10 x 10(9)MPN g(-1) and 10 and 30 cfu ml(-1) as the 2,4 DCP removal efficiencies were obtained between 60% and 99%, respectively. It was seen that, as the number of total acedogens decreased, the COD removal efficiencies increased. However, the number of total methanogens increased as the COD removal efficiencies increased. Correlations between the bacterial number and with the removal efficiencies obtained in different operational conditions were investigated. From the results presented in this paper a high correlation between the number of bacteria, COD removals, methane gas percentage, 2,4 DCP removals and VFA was observed. In the second part, methanogen bacteria in the anaerobic granular sludge were identified. Microbial observations and biochemical tests were applied to identify the anaerobic microorganisms from the anaerobic granular sludge. In the reactor treating 2,4 DCP, Methanobacterium bryantii, Methanobacterium formicicum, Methanobrevibacter smithii, Methanococcus voltae, Methanosarcina mazei, Methanosarcina acetivorans, Methanogenium bourgense and Methanospirillum hungatei were identified.     

厌氧序批式反应器内挥发性脂肪酸积累特性研究

小试规模的厌氧序批式反应器（ASBR），通过人工配水，研究了启动3个月时间以及一个运行周期内反应器内挥发性脂肪酸（VFA）的积累情况，并通过分析期间产甲烷活性的变化说明了控制VFA积累的重要性。经过近120 d的运行，乙酸和丙酸的最大比产甲烷活性分别提高了1.8和2.2倍，说明反应器的启动过程即是微生物群落的优化和选择的过程，ASBR的抗冲击的能力较强说明随启动的进行和种群的优化，活性污泥凝聚性能增强，对VFA的降解能力增强。     

Effects of free ammonia on volatile fatty acid accumulation and process performance in the anaerobic digestion of two typical bio-wastes

The effect of free ammonia on volatile fatty acid(VFA)accumulation and process instability was studied using a lab-scale anaerobic digester fed by two typical bio-wastes:fruit and vegetable waste(FVW)and food waste(FW)at 35°C with an organic loading rate(OLR)of 3.0 kg VS/(m~3·day). The inhibitory effects of free ammonia on methanogenesis were observed due to the low C/N ratio of each substrate(15.6 and 17.2,respectively). A high concentration of free ammonia inhibited methanogenesis resulting in the accumulation of VFAs and a low methane yield. In the inhibited state,acetate accumulated more quickly than propionate and was the main type of accumulated VFA. The co-accumulation of ammonia and VFAs led to an "inhibited steady state" and the ammonia was the main inhibitory substance that triggered the process perturbation. By statistical significance test and VFA fluctuation ratio analysis,the free ammonia inhibition threshold was identified as 45 mg/L. Moreover,propionate,iso-butyrate and valerate were determined to be the three most sensitive VFA parameters that were subject to ammonia inhibition.     

不同TS浓度互花米草沼渣二次发酵特性研究

中温（35±1）℃条件下,沼渣经6%的NaOH常温下处理48 h后,在TS含量8%、10%、12%的条件下沼气发酵.分析了发酵过程中日产气量、累积产气量、甲烷含量、pH值、挥发性脂肪酸（VFA）的变化,从不同角度考察TS含量负荷对沼渣二次发酵特性的影响.单位TS的日产气高峰分别达10、14、13 mL.g-1,累积产气率为217、227、228 mL.g-1,甲烷含量均在65%以上.发酵过程中最低pH为7.04.乙酸浓度最高分别为3 364、3 286、5 728 mg.L-1,丙酸和丁酸浓度均低于1 100 mg.L-1.结果表明,沼渣为难降解有机物,分解缓慢,不易出现酸化现象,但仍具有较强的产气潜力.     

COD/SO42-对硫酸盐有机废水处理效率的影响

以人工配制的含硫酸盐有机废水作为原水,研究不同COD/SO42-值下厌氧折流板反应器(ABR)处理含硫酸盐有机废水去除率.试验结果表明:当COD/SO42-＜14.8时COD的去除率可达95%,SO42-的去除率在86%～96%之间;当COD/SO42-在14.8～4.0之间时,COD的去除率有所下降但仍能保持在94%...     

气相色谱法测定废水中6种挥发性脂肪酸含量

挥发性脂肪酸(VFA)是厌氧消化过程的重要中间产物,在反应器运行中,出水VFA用作重要的控制指标。通过色谱条件探索将各种脂肪酸分离,同时研究了水样酸碱度,吸附等对测定的影响,进一步优化了废水中挥发性脂肪酸的测定。方法的检出限在0.99~1.77 mg/L,回收率在90.9%~102.7%之间,相对标准差(n=5)在1.3%~3.8%之间。     

VFAs、TOC及COD作为生物除磷能力指标的探讨

在实际生活污水的处理中,研究了通过A/O运行模式对生物除磷过程中磷的变化情况及在厌氧释磷过程中COD、TOC与VFAs变化之间的关系。结果表明,在厌氧释磷过程中VFAs的变化更能准确地反映系统内释磷进程,实际生活污水中能直接用于磷释放的有机物含量占COD的13.33%,并且释放1 mg P所需VFAs为1.401 mg,此值明显低于前期研究结果。通过对COD、TOC和VFAs 3种组分的分析,可将实际生活污水中的有机底物分为3类:易生物降解含碳有机物、难降解的含碳有机物和水中存在的无机性还原物质,含量分别占COD的13.33%、31.7%和54.97%,其中只有13.33%的含量对生物释磷有直接作用,并可对实际生活污水除磷有指导意义。     

污泥与秸秆共基质中温两相厌氧消化特性

以污泥和秸秆为共基质,以沼气产量、ρ（VFA）（VFA为挥发性脂肪酸）和COD_Cr去除率等为指标,探究污泥与秸秆配比（以COD_Cr计,质量比分别为1:0、1:1、2:1、3:1）对中温两相厌氧消化工艺运行效能的影响,以及最佳配比时SRT（污泥停留时间）对产甲烷相厌氧消化稳态特性的影响.结果表明:与污泥试验组相比,添加秸秆试验组的厌氧消化效能均较好;污泥与秸秆的最佳配比为2:1,该稳定状态下产酸相COD_Cr的去除率最高,为17.5%,ρ（VFA）为752 mg/L;产甲烷相COD_Cr的去除率为33.5%,ρ（VFA）为250 mg/L,产气量为47.7 mL/d,总体运行效能较高.在最佳污泥与秸秆配比（2:1）并设定产甲烷相反应器的SRT为20 d时,稳定状态下产甲烷相各组分的变化情况:COD_Cr去除率为41.20%,ρ（VFA）为238 mg/L,产气量为51.3 mL/d,沼气产率为8.4 mL/（d·g）.研究显示,当控制污泥与秸秆配比为2:1、SRT为20 d时,中温两相厌氧消化工艺运行效果良好.      

聚糖原菌富集实验及其内源过程探究

细胞衰减是微生物内源过程的一个重要组成部分,可分为由细胞死亡引起的数量衰减和由细胞活性降低引起的活性衰减两部分.通过挥发性脂肪酸（VFA）吸收速率(VFAUR)测定、荧光原位杂交技术（FISH）以及LIVE/DEAD细胞染色技术,研究了富集聚糖原菌（GAOs）在序批式反应器（SBR）系统中好氧环境下的衰减特征.结果表明,当T=30℃、进料中m(COD)∶m(P)=100时,SBR系统中GAOs富集比例达94%.测定和计算表明,SBR富集系统中GAOs衰减速率和死亡速率分别为0.132 d^-1和0.034 d^-1,其数量衰减和活性衰减占其细胞总衰减比例分别为26%和74%.可见,GAOs数量衰减只占其细胞总衰减中很小一部分,而绝大部分衰减由活性衰减所引起.     

ASBR工艺的研究现状与发展

厌氧序批式反应器(ASBR)由于生化推动力大、投资小、操作简单和运行灵活而倍受关注,但它存在压力波动、容易引起挥发性有机酸积累、颗粒污泥形成慢等不利因素,限制了该技术的推广应用.本文介绍了厌氧序批式反应器的操作模式、影响因素以及目前国内外最新的研究进展,并指出要推动这项技术的工业化应用所需要解决的问题.