氢安全研究现状及面临的挑战

氢能具有储运便捷、来源多样、洁净环保等突出优点,许多国家把发展氢能作为重要的能源战略。氢安全是氢能大规模商业化应用的重要保障。在分析国内外氢安全领域近年来最新研究进展的基础上,依次从氢泄漏与扩散、氢燃烧与爆炸、氢与金属材料相容性及氢风险评价等方面,系统总结了国内外氢安全研究面临的挑战,并对我国氢安全的发展提出了建议。     

Research on different venting performance between flat and curved bursting panels

There is a noticeable discrepancy in the ability to control reduced explosion overpressure between flat bursting panels and curved bursting panels with the same static activation overpressure. Flat bursting plates were observed to leak at approximately 80% of the static activation overpressure lower than curved bursting plates. A new experimental technique is proposed in our paper. Three different vent areas of flat and curved bursting panels were tested, there was significant difference in structural stiffness between flat bursting panels and curved bursting panels, which is the reason the discrepancy in the ability to control reduced explosion overpressure. The structural stiffness of the flat bursting panels is poorer than that of the other, and a greater deformation of the flat bursting panels occurs under the same load. The membrane stress caused by the explosion overpressure therefore produces a larger value in the flat bursting panels which causes it to open prematurely. Moreover, the smaller the vent area that is, the more significant discrepancy in controlling the reduced explosion overpressure between both bursting panels is. This experimental and theoretical result in our paper provides some useful experience for the method of explosion venting.     

Investigation of multiple domino scenarios caused by fragments

A model of multiple domino scenarios and the risk of the domino effect, which is a sequential chain escalating from the primary unit to the last unit, is presented in this paper. The trajectories of fragments from all units, the ground distribution of projectiles, and the risk of the sequential chain of the domino effect were calculated using Monte Carlo simulations. The results showed that the range affected by the fragments from each tank included the other tanks, meaning that fragments from one tank could hit the other tanks and cause multiple accidents, and that the sequential chain of the domino effect could indeed happen. The distributions of ground impacts showed that tank fragments were projected over long distances, up to 1200 m from the source. The spatial distribution of the kinetic energy at ground impact for tank fragments was also obtained. Moreover, the magnitudes of the probabilities of the primary, secondary, third, and fourth accidents in the domino chain were respectively about 10⁻⁷, 10⁻¹¹, 10⁻¹⁵, and 10⁻¹⁹. These results showed that for neighboring domino effect units in the same accident chain, the risk of the most recent domino effect was 10⁴ times that of the following domino effect.     

高铁网络可达性测度及经济潜力分析——以安徽省为例

高速铁路的开通给沿线城市的建设带来了重大影响。基于可达性测度以及修正的经济潜力模型,利用GIS对安徽省高铁可达性以及经济潜力进行深入分析。研究表明:(1)高铁开通后安徽省可达性显著提高,但总体格局保持不变,呈现出以合肥为中心,淮南、芜湖等地为副中心的"多核心"模式。池州、铜陵两城市可达性上升幅度最大,黄山紧随其后,芜湖、滁州变化最小。高铁开通后,滁州可达性排名下降5名,下降幅度最大,合肥、淮南、黄山最为稳定,其他城市均有小幅变化。(2)可达性的提升对城市经济潜力造成了一定影响,总体呈现出以合肥为中心的外围扩展模式。池州、铜陵经济潜力增长最为显著,黄山位列第3,可达性的提升直接影响了池州、铜陵、黄山三市的经济发展。高铁开通后,合肥、芜湖经济潜力排名始终位于前二,传统经济中心地位不变。马鞍山排名上升4名,幅度最大,池州、黄山两市处于末端,经济潜力仍然较为薄弱。(3)高铁开通后,时空收敛效应明显,可达性的提升令城市经济潜力增长显著,但受多方面因素影响,可达性与经济潜力呈现不完全契合关系。     

Liquefaction process for a hydrothermally treated waste mixture containing plastics

Most landfilled plastic waste is a mixture or is in the form of composites with incombustible wastes such as glass, metals, and ceramics. After hydrothermal treatment, including a steam-explosion process, the separation of mixed waste (MW) into organic and inorganic substances becomes easy. However, the effect of hydrothermal pretreatment on the subsequent liquefaction of organic substances from MW is not obvious. In this study, the effects on the liquefaction of polystyrene and high-density polyethylene are discussed. Moreover, optimum conditions for the liquefaction of organic substances from hydrothermally treated MW are identified. By means of this hydrothermal pretreatment, including the steam-explosion process, polystyrene and high-density polyethylene can be significantly converted to oil by liquefaction at 300°–400°C. In comparison with liquefaction of hydrothermally pretreated mixed waste (HMW) at 300°–400°C with a batch type reactor, the yield of oil increases significantly on liquefaction using a semi-batch type reactor. It is considered that the radical chain and termination reactions among the radicals from HMW were inhibited in the semi-batch type reactor. On liquefaction of HMW in a semi-batch reactor, the conversion of HMW to oil was enhanced on increasing the liquefaction temperature to 350°C and the holding time to 60 min. Chemical Feedstock Recycling & Other Innovative Recycling Techniques 6     

爆炸空气冲击波在巷道转弯处的传播特性

为了探索爆炸空气冲击波在巷道内的传播规律,进行了数值计算和理论分析,讨论了爆炸冲击波通过45°弯曲巷道后的压力变化过程.研究结果表明: 爆炸空气冲击波通过45°弯曲巷道后的压力分布复杂,空气冲击波逐渐恢复为平面波需经过4倍等效巷道直径的距离传播.在该4倍等效距离内,冲击波反射叠加,在巷道外侧壁面Mach反射点取得超压最大值,恢复平面波以后超压随距离呈单调衰减.     

从一起爆炸事故谈作业安全票证(单)的管理

从一起爆炸事故的原因--没有办理设备检修许可证,分析了使用作业安全票证(单)存在的问题,提出了加强作业安全票证(单)管理措施.     

氯碱企业生产过程中的重大危害分析及对策

分析了氯碱企业生产过程中的重大危害为中毒和火灾爆炸,提出了相应的对策.     

一起甲苯爆炸事故的调查与分析

分析了利用压缩空气压送甲苯混合物时发生爆炸事故的直接原因和间接原因,提出了相应的对策.     

管式法高压聚乙烯装置的道化学火灾爆炸危险指数评价

运用道化学火灾爆炸危险指数评价方法,对Quantum管式法高压聚乙烯装置中多次出现泄漏火灾的聚合单元进行评价。对照装置实际分析了防火防爆缺陷因子,提出完善聚合单元的防火防爆措施。