过硫酸钠氧化脱色罗丹明B——影响因素和机理

采用过硫酸钠(PDS)直接氧化和催化活化氧化脱色罗丹明B(RhB),分别考察了PDS剂量、pH、催化剂、Cl-浓度对RhB脱色的影响.结果表明,PDS在无外加催化剂下能够有效脱色RhB,pH越低,脱色率越高;当pH 2.4,PDS用量为3.5 g·L^-1,在120 min内RhB的脱色率可达92%;自由基淬灭实验表明,酸性条件下主要为PDS直接氧化脱色RhB,并存在小部分硫酸根自由基(SO₄4·-)作用.在pH 5.6、pH 8.0条件下,外加活性炭纤维(ACF)、四氧化三铁(Fe₃O₄4)、Fe₃O₄4负载型催化剂(ACF/Fe3O₄4)可促进PDS对RhB脱色;在pH 2.4条件下,外加ACF对RhB脱色的促进作用较小,Fe₃O₄4、ACF/Fe₃O₄4对RhB脱色有一定抑制作用.不同pH和催化剂处理下,低浓度Cl-(0.01、0.04 mO₄l·L^-1)对RhB脱色速率都呈现抑制作用,高浓度Cl-(0.08 mO₄l·L^-1)相对于低浓度Cl-处理都呈促进作用.不同浓度Cl-处理在反应前60 min RhB脱色速率差异较大,而反应120 min后脱色率差异较小.提出Cl-通过调控SO₄4·-脱色RhB途径来影响RhB脱色速率的机理,Cl-竞争消耗SO₄4·-降低RhB脱色速率,但经一系列反应生成的Cl2·-能与RhB快速反应而提高RhB脱色速率;Cl-对RhB的脱色反应速率的影响存在抑制-促进双重机制,且与Cl-浓度相关.研究结果为基于PDS直接氧化和催化氧化处理含盐染料废水的研究和应用提供了一定的理论依据.     

Enterobacter sp. CV-v对甲基橙的脱色特性与条件优化

从浙江温州分离筛选到1株甲基橙高效脱色菌株CV-v,经16S rRNA基因序列分析表明,该菌株属于Enterobacter sp.属.单因素实验结果表明:当pH值在5.0~9.0之间时,培养48h以后,该菌株对甲基橙的脱色率均在80%以上;脱色的最适温度范围为30~40℃之间;所测碳源中的葡萄糖和麦芽糖、氮源中的牛肉膏和酵母粉对脱色的促进效果最为显著,且Ca2+和Mg2+也对脱色有显著的促进效应;此外,当接种量达到7%(V:V)以后,48h的脱色率即可达近100%.响应面设计实验结果显示,该菌株对甲基橙脱色的最优操作条件为:pH 8.0,葡萄糖1.7g/L,酵母粉3.0g/L,氯化镁3.0mmol/L及培养温度35.9℃.验证实验结果表明在最优条件下,该菌株在10h内对甲基橙的脱色率可达88.0%.总体而言,该菌株在偶氮染料脱色中的应用潜能较大.     

Decolorization and degradation of acid dyes mediated by salt fractionated turnip ( Brassica rapa ) peroxidases

Peroxidases from turnip roots (524?U?g^?1 of vegetable) were highly effective in decolorizing acid dyes having wide spectrum chemical groups. Dye solutions, containing 40–170?mg?dye?L^?1, were treated by turnip peroxidases (TP) (specific activity of 122.0?U?mg^?1 proteins). These enzymes were able to decolorize most of the acid dyes in the presence of 2.0?mM 1-hydroxybenzotriazole (HOBT). Increasing concentration of enzyme and time in the absence of HOBT did not influence dye decolorization. The rate of decolorization was significantly enhanced when HOBT was added to the decolorizing solutions. The decolorization of all the used dyes was maximum at pH 5.0 and 40°C. Complex mixtures of dyes were significantly decolorized when treated with enzyme in the presence of HOBT (2.0?mM). Phytotoxicity test based on Allium cepa root growth inhibition has shown that majority of the TP-treated dye product were not more toxic than their parent dye. Kinetic parameters of the TP with various dyes showed that this enzyme has highest affinity for Acid Yellow 42. This study demonstrates that the peroxidase/mediator system was an effective biocatalyst for the treatment of industrial effluents from textile, dye manufacturing, dyeing and printing industries or complex mixtures of dyes.     

Removal of Remazol Brilliant Violet-5R dye using periwinkle shells

The purpose of this research is to obtain optimal processing conditions for the adsorption of Remazol Brilliant Violet-5R (RBV-5R) dye onto activated carbon prepared from periwinkle shells (PSAC) by chemical activation with KOH using response surface methodology. Central composite design (CCD) was used to determine the effects of three preparation variables; CO₂ activation temperature, CO₂ activation time and KOH:char impregnation ratio (IR) on two responses; percentage RBV-5R dye removal and PSAC yield. Based on the CCD, two quadratic models were developed for percentage RBV-5R dye removal and PSAC yield, respectively. The most influential factor on each experimental design response was identified from the analysis of variance (ANOVA). The optimum conditions for the adsorption of RBV-5R dye onto PSAC were CO₂ activation temperature of 811 °C, CO₂ activation time of 1.70 h and IR of 3.0, resulting in 81.28% RBV-5R dye removal and 28.18% PSAC yield. PSAC prepared under optimum conditions was mesoporous with a Brunauer–Emmett–Teller surface area of 1894 m²·g^?1, total pore volume of 1.107 cm³·g^?1 and average pore diameter of 2.32 nm. The surface morphology and functional groups of the activated carbon were respectively determined from the scanning electron microscopy and Fourier transform infrared analysis.     

Fe-C-H_2O_2协同催化氧化处理印染废水

用Fe-C-H2O2协同催化氧化体系对印染工业废水的降解脱色处理进行了研究。对影响印染废水降解的几种因素如铁屑/碳粒质量比、双氧水的质量分数、废水pH等进行考察。试验结果表明,对于色度为650度和ρ（COD）为468mg·L-1的印染废水,在废水pH=4.8的情况下,当铁屑/碳粒质量比为25∶1、H2O2用量为150mg·L-1、催化反应30min时,印染废水的脱色率达98%以上,CODCr去除率可达78%。与Fe-C微电解法相比,Fe-C-H2O2协同催化氧化方法对印染废水的脱色能力和去除COD,表现出了更好的处理效果。     

真菌产漆酶对蒽醌类染料脱色的研究

以香菇发酵获得漆酶粗酶液,用该酶液对蒽醌类染料进行脱色研究,分别考察了反应温度、pH值、时峰、漆酶浓度和不同染料的脱色影响.结果表明,香菇产漆酶粗酶液对蒽醌类染料具有良好的脱色效果,脱色最佳条件为：温度在30℃左右、pH3-4、反应8h、酶单位在20-30U/L的脱色率达85％.     

Effects of glucose on the decolorization of Reactive Black 5 by yeast isolates

The cometabolic roles of glucose were investigated in decolorization of an azo dye, Reactive Black 5, by yeast isolates, Debaryomyces polymorphus and Candida tropicalis. The results indicated that the dye degradation by the two yeasts was highly associated with the yeast growth process and glucose presence in the medium. Color removal of 200 mg dye/L was increased from 76.4% to 92.7% within 60 h to 100% within 18-24 h with the increase of glucose from 5 to 10 g/L, although the activity of manganese dependent peroxidase （MnP） decreased by 2-8 times in this case. Hydrogen peroxide of 233.3 μg/L was detected in 6 h in D. polymorphus culture. The cometabolic functions of glucose and hydrogen peroxide could be also confirmed by the further color removals of 95.8% or 78,9% in the second cycle of decolorization tests in which 7 g glucose/L or 250 μg H202/L was superadded respectively together with 200 mg dye/L.     

活性炭多维电极法处理活性染料模拟废水的机理研究

以活性嫩黄K-4G染料模拟废水为处理对象,探讨了多维电极系统处理活性染料废水时色度、COD降解的效果和机理。结果表明,活性炭多维电极法对染料废水的处理效果优于单纯电解法和单纯活性炭吸附法;氧化和还原作用对染料的色度和COD去除效果相差不大;增大处理系统中溶液的循环流量可显著改善活性炭多维电极系统对COD和色度的去除效果。     

电化学催化氧化法降解水中甲基橙的研究

采用电沉积-热解氧化法制备了含有中间层SnO2+Sb2O3的钛基体二氧化铅电极(Ti/SnO2+Sb2O3/PbO2),以甲基橙水溶液为模拟废水,研究了所制备的电极对其所具有的电催化氧化脱色性能。考察了电极制备条件对电极催化性能的影响,同时对甲基橙脱色降解实验条件进行了优化。用该电极对含60mg/L甲基橙的模拟废水处理2h,脱色率可达到82.21%,COD去除率为76.75%。     

直接染料在兼氧条件下的生物降解性能研究

实验分析了6大类14种直接染料在兼氧条件下的降解性能和脱色效果。在未加葡萄糖的实验中,采用不同温度（20℃与35℃）和不同停留时间来测定染料的降解性能。结果表明,35℃下的最佳停留时间为48h,此时的COD。的去除率及脱色均有较好的效果,而在72h的停留时间下,降解效果无明显提升。20℃下最佳停留时间则为72h,此时的COD。去除率及脱色效果与35℃下的结果很接近。在添加葡萄糖的实验中得到结果证实了葡萄糖作为在共代谢作用中的碳源对促进染料的降解起到非常积极的作用。