纳米零价铁耦合黏土修复污染土壤的研究进展

黏土负载型nZVI具有低成本、易制备、环境相容性好、综合性能优越的特点.本文在归纳nZVI改性策略的基础上,比较了黏土种类对nZVI形貌和性能的影响,提出了理想黏土载体的优选顺序,分析了复合材料的铁含量、比表面积、nZVI尺寸等与去除性能之间的关系,对nZVI耦合黏土在修复土壤重金属、卤代有机物、硝酸盐、新型污染物等方面的研究进行了总结,并概述了nZVI技术在土壤修复中的负面效应,最后对nZVI耦合黏土修复污染土壤的未来方向进行了展望.     

包埋硫铁生物填料的制备及自养反硝化性能

采用包埋固定化技术制备了包埋硫铁生物填料(ESI Filler),基于升流式自养反硝化反应器开展动态实验研究,通过改变水力停留时间(HRT)、pH值、溶解氧(DO)等运行条件,探究ESI Filler反应器的脱氮效果及微生物群落结构组成。结果表明,当进水硝酸盐氮(NO₃^--N)浓度为30mg/L,HRT为10h时,NO₃^--N去除率不断上升至99.80%。当HRT缩短为2.5h时,NO₃^--N去除率降至61.35%。ESI Filler反应器对pH值和DO的改变具有较高的稳定性,NO₃^--N平去除率可维持在82.5%以上。但对低温的耐受性较差,当温度从35℃降低至15℃时,NO₃^--N平均去除率由90.12%降低至68.80%。运行164d后,球体未出现破裂散落的现象,表现出较长的使用寿命。通过扫描电镜发现,填料表面疏松多孔,附着大量杆状细菌,已成为微生物的良好载体。高通量测序结果表明,包埋颗粒中优势菌属为典型的自养反硝化功能菌Thiobacillus,丰度为80.79%。     

Dosing low-level ferrous iron in coagulation enhances the removal of micropollutants, chlorite and chlorate during advanced water treatment

Drinking water utilities are interested in upgrading their treatment facilities to enhance micropollutant removal and byproduct control. Pre-oxidation by chlorine dioxide (ClO₂) followed by coagulation-flocculation-sedimentation and advanced oxidation processes (AOPs) is one of the promising solutions. However, the chlorite (ClO₂^–) formed from the ClO₂ pre-oxidation stage cannot be removed by the conventional coagulation process using aluminum sulfate. ClO₂^– negatively affects the post-UV/chlorine process due to its strong radical scavenging effect, and it also enhances the formation of chlorate (ClO₃^–). In this study, dosing micromolar-level ferrous iron (Fe(II)) into aluminum-based coagulants was proposed to eliminate the ClO₂^– generated from ClO₂ pre-oxidation and benefit the post-UV/chlorine process in radical production and ClO₃^– reduction. Results showed that the addition of 52.1-µmol/L FeSO₄ effectively eliminated the ClO₂^– generated from the pre-oxidation using 1.0 mg/L (14.8 µmol/L) of ClO₂. Reduction of ClO₂^– increased the degradation rate constant of a model micropollutant (carbamazepine) by 55.0% in the post-UV/chlorine process. The enhanced degradation was verified to be attributed to the increased steady-state concentrations of HO^· and ClO^· by Fe(II) addition. Moreover, Fe(II) addition also decreased the ClO₃^– formation by 53.8% in the UV/chlorine process and its impact on the formation of chloro-organic byproducts was rather minor. The findings demonstrated a promising strategy to improve the drinking water quality and safety by adding low-level Fe(II) in coagulation in an advanced drinking water treatment train.     

高炉出铁场除尘方案研究

某钢铁企业高炉炼铁车间的出铁场在生产过程中产生大量高浓度的烟尘,对厂区的大气环境及周边的环境造成严重污染,同时直接危害了职工的身体健康。通过对整个出铁场除尘工艺系统及通风状况的分析及实际应用情况,总结出了适合该场合的系统除尘方案。     

纳米零价铁在应用中存在的问题及提高反应活性的方法

纳米零价铁对多种污染物质均有较好的去除效果,在污染的水体、土壤及底泥中被广泛研究与应用。前人对纳米零价铁的制备、在污染治理各方面的应用、作用的机理等方面进行了较为详细的总结,针对纳米零价铁在应用中存在的问题虽有提及,但少有人集中进行整理。本文主要针对纳米零价铁在环境治理方面存在的问题进行论述并对提高其反应活性的常用方法进行了总结,以期为纳米零价铁实际应用领域的深入研究提供借鉴并拓展新的思路。     

电感耦合等离子体原子发射光谱法(ICP-AES)测定磷生铁中的Mn、P、Si

建立了电感耦合等离子体原子发射光谱（ICP-AES）法测定磷生铁中3种元素Mn、P、Si的定量分析方法.通过试验选择257.610nm、185.942nm、212.412nm分别作为Mn、P、Si的分析谱线,无需进行光谱干扰校正.实验结果表明,各元素分析谱线线性相关系数大于0.9990.方法用于高磷铸铁标准物质分析,测定值与认定值相符,测定结果的相对标准偏差在0.21％ （Mn） ～1.8％ （P）范围.     

Steady performance of a zero valent iron packed anaerobic reactor for azo dye wastewater treatment under variable influent quality

Zero valent iron (ZVI) is expected to help create an enhanced anaerobic environment that might improve the performance of anaerobic treatment. Based on this idea, a novel ZVI packed upflow anaerobic sludge blanket (ZVI-UASB) reactor was developed to treat azo dye wastewater with variable influent quality. The results showed that the reactor was less influenced by increases of Reactive Brilliant Red X-3B concentration from 50 to 1000 mg/L and chemical oxygen demand (COD) from 1000 to 7000 mg/L in the feed than a reference UASB reactor without the ZVI. The ZVI decreased oxidation-reduction potential in the reactor by about 80 mV. Iron ion dissolution from the ZVI could buffer acidity in the reactor, the amount of which was related to the COD concentration. Fluorescence in situ hybridization test showed the abundance of methanogens in the sludge of the ZVI-UASB reactor was significantly greater than that of the reference one. Denaturing gradient gel electrophoresis showed that the ZVI increased the diversity of microbial strains responsible for high efficiency.     

Rapid decolorization of Acid Orange II aqueous solution by amorphous zero-valent iron

Some problems including low treatment capacity, agglomeration and clogging phenomena, and short working life, limit the application of pre-treatment methods involving zero-valent iron (ZVI). In this article, ZVI was frozen in an amorphous state through a melt-spinning technique, and the decolorization effect of amorphous ZVI on Acid Orange II solution was investigated under varied conditions of experimental variables such as reaction temperature, ribbon dosage, and initial pH. Batch experiments suggested that the decolorization rate was enhanced with the increase of reaction temperature and ribbon dosage, but decreased with increasing initial solution pH. Kinetic analyses indicated that the decolorization process followed a first order exponential kinetic model, and the surface-normalized decolorization rate could reach 2.09 L/(m². min) at room temperature, which was about ten times larger than any previously reported under similar conditions. Recycling experiments also proved that the ribbons could be reused at least four times without obvious decay of decolorization rate and efficiency. This study suggests a tremendous application potential for amorphous ZVI in remediation of groundwater or wastewater contaminated with azo dyes.     

Shellac-coated iron oxide nanoparticles for removal of cadmium(II) ions from aqueous solution

This study describes a new effective adsorbent for cadmium removal from aqueous solution synthesized by coating a shellac layer, a natural biodegradable and renewable resin with abundant hydroxyl and carboxylic groups, on the surface of iron oxide magnetic nanoparticles. Transmission Electron Microscopy (TEM) imaging showed shellac-coated magnetic nanoparticle (SCMN) adsorbents had a core-shell structure with a core of 20 nm and shell of 5 nm. Fourier Transform Infrared Spectroscopic analysis suggested the occurrence of reaction between carboxyl groups on the SCMN adsorbent surface and cadmium ions in aqueous solution. Kinetic data were well described by pseudo second-order model and adsorption isotherms were fitted with both Langmuir and Freundlich models with maximum adsorption capacity of 18.80 mg/g. SCMN adsorbents provided a favorable adsorption capacity under high salinity conditions, and cadmium could easily be desorbed using mild organic acid solutions at low concentration.     

pH值对纳米零价铁吸附降解2,4-二氯苯酚的影响

在不同pH条件下,对纳米铁(颗粒粒径为30～40 nm)及其降解2,4-二氯苯酚反应体系进行取样,并进行透射电子显微镜(TEM)、扫描电子显微镜-能谱联用(SEM-EDX)以及电感耦合等离子体发射光谱(ICP-OES)等形貌观测与分析表征,以考察pH值在纳米零价铁降解氯酚反应过程中的影响和作用.结果表明,在降解2,4-二氯苯酚的过程中纳米铁由分散的颗粒逐渐团聚,其表面逐渐氧化,并最终被呈针状结晶的碱式氧化亚铁(FeOOH)覆盖,从而阻碍了降解反应的进一步进行.在酸性体系中,纳米零价铁的氧化和团聚现象有所缓解,尽管会造成一部分铁量的损失,但反应产生大量的亚铁离子参与并促进了脱氯降解反应的进行,反应过程中溶液pH值有逐渐升高的趋势.不同pH条件下,纳米铁对氯酚的去除率随pH值的降低而升高,酸性条件有利于提高氯酚的还原降解速率,当pH=3时,24 h内氯酚的去除率可达到90%以上.