Oxidation inhibition of sulfite in dual alkali FGD system

A laboratory-scale well-mixed thermostatic reactor with continuously blasting air was used to investigate the oxidation inhibition of sulfite in dual alkali flue gas desulfurization （FGD） system. The effects of operating parameters such as pH value and catalyst concentration on the oxidation were studied. Sodium thiosulfate was used in the system, and was found that it significantly inhabited the sulfite oxidation. In the absence of catalyst, sodium thiosulfate at 12.67 mmol/L had an inhibition efficiency of approximately 98%. While in the presence of catalyst, sodium thiosulfate at 26.72 mmol/L had an inhibition efficiency less than 85.0%. The oxidation reaction order of sulfite in the sodium thiosulfate was determined to be -1.90 and 4）.55 in the absence and presence of the catalyst, respectively. Apparent activation energy of oxidation inhibition was calculated to be 53.9 kJ/mol. Pilot tests showed that the consumption rate of thiosulfate agreed well with the laboratory-scale experimental results.     

膨润土对复合污染中表面活性剂的吸附及机理

选取阳离子表面活性剂氯化十六烷基吡啶(CPC)、阴离子表面活性剂十二烷基苯磺酸钠(SDBS)及非离子表面活性剂Triton X-100(TX-100)为代表,研究了其在膨润土上的吸附行为,探讨了膨润土阳离子交换容量(CEC)、温度、盐度对CPC吸附的影响.结果表明,Na基膨润土对CPC的吸附性能最好,对SDBS基本无吸附,对TX-100的吸附介于两者之间.Na基膨润土对CPC的吸附是阳离子交换和疏水键缔合共同作用的结果,对TX-100的吸附主要是通过其与膨润土硅氧表面间的氢键作用,同时通过疏水键作用形成吸附双分子层;SDBS在Ca基膨润土上的吸附损失量先增大后减小,在1.5倍临界胶束浓度 (CMC)时达到极大值,主要机理是SDBS与膨润土中的Ca²⁺产生沉淀作用,而胶束具有再溶解沉淀的作用.膨润土对CPC的吸附量随着温度升高而降低,随着CEC的增大而增大,一定浓度NaCl的加入有利于其在膨润土上的吸附.     

Effects of seed aerosols on the growth of secondary organic aerosols from the photooxidation of toluene

Hydroxyl radical （.OH）-initiated photooxidation reaction of toluene was carried out in a self-made smog chamber. Four individual seed aerosols such as ammonium sulfate, ammonium nitrate, sodium silicate and calcium chloride, were introduced into the chamber to assess their influence on the growth of secondary organic aerosols （SOA）. It was found that the low concentration of seed aerosols might lead to high concentration of SOA particles. Seed aerosols would promote rates of SOA formation at the start of the reaction and inhibit its formation rate with prolonging the reaction time. In the case of ca. 9000 pt/cm^3 seed aerosol load, the addition of sodium silicate induced a same effect on the SOA formation as ammonium nitrate. The influence of the four individual seed aerosols on the generation of SOA decreased in the order of calcium chloride〉sodium silicate and ammonium nitrate〉ammonium sulfate.     

火焰原子吸收法测定地表水中钾钠钙镁的方法改进

用空气—乙炔火焰原子吸收测定地表水中钾钠钙镁时,将测钾钠用的消电离剂和测钙镁用的释放剂配成混合溶液,加入待测试样中,便可连续测定其中的钾钠钙镁。与现在常用的火焰原子吸收方法测得的结果一致,精密度和准确度符合规范要求,且方法简单快速。     

氟硅酸钠废水处理与循环利用探讨

从芒硝法（Na2SO4）氟硅酸钠生产工艺过程分析了氟硅酸钠母液废水的来源和主要成分,剖析了现有污水处理工艺过程存在的三个方面缺陷,并从实施清洁生产、节能减排和完善治理设施两方面提出了改进对策,全面实现了废水的循环利用。     

Effects of metal and acidic sites on the reaction by-products of butyl acetate oxidation over palladium-based catalysts

Catalytic oxidation is widely used in pollution control technology to remove volatile organic compounds. In this study, Pd/ZSM-5 catalysts with different Pd contents and acidic sites were prepared via the impregnation method. All the catalysts were characterized by means of N2 adsorption- desorption, X-ray fluorescence （XRF）, HE temperature programmed reduction （H2-TPR）, and NH3 temperature programmed desorption （NH3-TPD）. Their catalytic performance was investigated in the oxidation of butyl acetate experiments. The by-products of the reaction were collected in thermal desorption tubes and identified by gas chromatography/mass spectrometry. It was found that the increase of Pd content slightly changed the catalytic activity of butyl acetate oxidation according to the yield of CO2 achieved at 90%, but decreased the cracking by-products, whereas the enhancement of strong acidity over Pd-based catalysts enriched the by-product species. The butyl acetate oxidation process involves a series of reaction steps including protolysis, dehydrogenation, dehydration, cracking, and isomerization. Generally, butyl acetate was cracked to acetic acid and 2- methylpropene and the latter was an intermediate of the other by-products, and the oxidation routes of typical by-products were proposed. Trace amounts of 3-methylpentane, hexane, 2-methylpentane, pentane, and 2-methylbutane originated from iso4merization and protolysis reactions.     

UV/SPS降解水中三氯生的效能及动力学

采用短波紫外光激活过硫酸钠(UV/SPS)对水中三氯生(TCS)的去除进行了研究,考察了紫外光波长、紫外光强、过硫酸钠(SPS)投加量、pH值和腐殖酸(HA)等因素对TCS去除的影响,计算了自由基(·OH、SO_4~(·-))与TCS的二级反应速率常数及其对TCS去除的贡献值,鉴定了反应中主导自由基,对比了UV254/SPS和UV254/H_2O_2对天然水体中TCS的去除效果,GC/MS分析了TCS降解的中间产物及可能的降解路径.结果表明UV/SPS能有效去除TCS,紫外光波长为254nm,光强为11.5μW·cm-2,SPS浓度为1 mmol·L~(-1)时,100s后初始浓度为275μg·L~(-1)的TCS去除率可达98.15%,TCS降解过程符合拟一级反应动力学方程,其动力学常数K=0.039 2 s~(-1).实验范围内TCS去除的速率常数随紫外光强(I)和SPS投加量的增加而增大,波长对TCS去除影响不显著,中性条件不利于TCS降解,HA对TCS去除具有抑制作用.·OH和SO_4~(·-)与TCS反应速率常数分别为7.62×109L·mol~(-1)·s~(-1)、9.86×109L·mol~(-1)·s~(-1),UV254/SPS中主导自由基为SO_4~(·-),其对TCS去除贡献率为97.63%.UV254/SPS工艺更能有效地去除TCS,其拟一级动力学常数K值是UV254/H_2O_2工艺的4.13倍.TCS降解过程中主要生成了2,4-二氯苯酚(2,4-DCP)、苯酚等中间产物.     

吐温80与氢氧化钠耦合强化剩余污泥溶胞效果的研究

利用吐温80的润湿、渗透作用,将其与氢氧化钠耦合应用于剩余污泥的溶胞。结果表明,吐温80的存在能有效提高氢氧化钠对剩余污泥的溶胞效果;而同样的溶胞效果下,吐温80的存在能降低溶胞的环境温度。吐温80与氢氧化钠耦合剩余污泥溶胞工艺的最佳工艺条件为：吐温80投加量100 mg/L、作用时间15 min,先加吐温80再加氢氧...     

不同载体对淀粉酶固定化的比较研究

采用海藻酸钠微胶囊法和壳聚糖交联法对淀粉酶进行固定化，比较两种淀粉酶固定化方法的优劣。结果表明，两种固定化酶的活力回收分别为33．2％、26．6％，比活力分别为27．1U／mg蛋白、24．2U／mg蛋白，最适pH分别为5．0、8．0。海藻酸钠微胶囊法热稳定性、pH稳定性、操作稳定性、贮存稳定性明显高于壳聚糖交联法，因此海藻酸钠微胶囊法较佳，具有一定应用价值。     

旋转填料床/柠檬酸盐法吸收-解吸SO2

提出采用旋转填料床结合柠檬酸盐法脱除烟气中SO2的方法,考察了旋转填料床转子转速、液气比、初始柠檬酸根浓度和初始pH值等因素对脱硫效率的影响。结果表明,采用超重力法超重机转子转速为1 000 r/min、液气比为7L/m3、初始柠檬酸根浓度为1.5 mol/L、吸收液的初始pH值为5.0,脱硫效率稳定在99%左右。研究了水蒸气汽提法解吸SO2时初始柠檬酸根浓度、初始pH值、SO2浓度、富液流量和水蒸气流量对解吸效率的影响,得出了影响SO2解吸率的基本规律,并进行了分析。通过实验证明该方法在技术上是可行的,具有良好的应用前景。