Landfill leachate treatment using a rotating biological contactor and an upward-flow anaerobic sludge bed reactor

This paper describes the feasibility of an aerobic system (rotating biological contactor, RBC) and a biological anaerobic system (upward-flow anaerobic sludge bed reactor) at small scale for the treatment of a landfill leachate. In the first phase of the aerobic system study, a cyclic-batch RBC system was used to select perforated acetate discs among three different acetate disc configurations. These discs were chosen on the basis of high COD removal (65%) and biological stability. In the second phase, the RBC system (using four stages) was operated continuously at different hydraulic retention times (HRT), at different rotational speeds, and with varying organic concentrations of the influent leachate (2500-9000mgL(-1)). Forty percent of the total surface area of each perforated disc was submerged in the leachate. A COD removal of about 52% was obtained at an HRT of 24h and a rotational speed of 6rpm. For the anaerobic system, the reactor was evaluated with a volumetric organic load of 3273g-COD m(-3) day(-1) at an HRT of 54, 44, 39, 24 and 17h. At these conditions, the system reached COD removal efficiencies of 62%, 61%, 59%, 44% and 24%, respectively.     

炼油外排废水回用试验

针对某炼油厂的废水场二沉池出水,先后采用曝气生物滤池和超滤工艺进行深度处理.试验结果表明,在曝气生物滤池中投加专性微生物菌种、曝气生物滤池HRT为2h、COD去除负荷为0.36 kg/( m3·d)、超滤膜通量为50L/(m2·h)的条件下,出水中的ρ(油)为0.8 mg/L、COD为57 mg/L、ρ(氨氮)为0.2 mg/L.出水水质达到Q/SH0104-2007《炼化企业节水减排考核指标与回用水质控制指标》,可回用于循环水的补水.     

两种接触氧化填料处理洗涤剂废水的比较

以某日化企业在生产过程中产生的洗涤剂废水为处理对象,以接触氧化法为核心工艺,比较了悬挂式组合填料和移动床生物膜反应器(MBBR)悬浮填料对洗涤剂废水的处理效果。实验结果表明:悬挂式组合填料和MBBR悬浮填料的挂膜启动时间分别为13,25 d;当悬挂式组合填料反应器的DO为4.0 mg/L时,COD和LAS的去除率分别为84.33%和89.06%;当MBBR悬浮填料反应器的DO为3.0 mg/L时,COD和LAS的去除率分别为82.54%和90.31%;当MBBR悬浮填料反应器的COD容积负荷为0.5~1.3 kg/(m3·d)时,平均COD去除率为83.91%,继续增大COD容积负荷,COD去除率仍能保持在80%以上;MBBR悬浮填料在COD的高效降解及高浓度有机废水的处理方面优于悬挂式组合填料。     

气升式环流生物反应器处理废水厌氧过程研究

采用气升式环流生物反应器处理模拟废水。周期性通入空气和氮气来实现厌氧一好氧交替过程。对厌氧一好氧过程和普通好氧过程进行了对比,研究了厌氧处理时间和曝气速率对生物除磷效果的影响。结果表明,厌氧过程可以显著地增强生物除磷效果,与普通好氧过程相比,在进水总磷质量浓度为10mg／L时,磷的去除率可以提高30％,而COD的去除基本不受影响;适当延长厌氧处理时间和适当增大厌氧过程曝气速率可以改善厌氧环境及活性污泥性能,提高磷的去除率。     

移动床生物膜反应器预处理含酚废水

采用两级移动床生物膜反应器（MBBR）预处理高挥发酚含量的石化厂汽提净化水，考察了HRT和DO对废水中挥发酚和COD去除效果的影响。实验结果表明：在两级MBBR总HRT为10 h、MBBR中部废水DO 为1~3 mg/L的条件下， 装置连续运行处理ρ（挥发酚）=110~201 mg/L、COD=644~1 827 mg/L、BOD₅/COD=0.15~0.69的废水，两级MBBR处理后出水平均ρ（挥发酚）为17.6 mg/L，挥发酚去除率达87.9%;平均COD为745 mg/L，COD去除率为32.7%;出水BOD₅/COD平均为0.68，表明经过两级MBBR处理后，废水的可生化性有所提高，有利于废水的后续生化处理。     

Anaerobic treatment of effluents from an industrial polymers synthesis plant

The feasibility of the anaerobic treatment of an industrial polymer synthesis plant effluent was evaluated. The composition of the wastewater includes acrylates, styrene, detergents, a minor amount of silicates and a significant amount of ferric chloride. The average chemical oxygen demand (COD) corresponding is about 2000 mg/l. The anaerobic biodegradability of the effluent is shown and the toxicity effect on the populations of anaerobic bacteria is evaluated. The results of the anaerobic biodegradation assays show that 62% of the wastewater compounds, measured as COD, could be consumed. An upflow anaerobic sludge blanket (UASB) reactor was used in the evaluation, it has a diameter–height ratio of 1:7, and 4-liter volume. The inoculum was obtained from a UASB pilot plant that treats brewery wastewaters. At the beginning of the operation, the biomass showed an anaerobic activity of 0.58 gCOD/(gVSS×d), it decreased only 2.5% in the subsequent 4 months. After 35 days of continuous operation, the reactor was operated at different steady states for 140 days. The COD was maintained at 2200 mg/l in the feed. The results were: organic loading rate (OLR): 4.3 kg COD/(m³×d), hydraulic retention time: 12 h, superficial velocity: 1 m/h, average biogas productivity: 290 L CH₄/kg COD fed, biogas composition: 70–75% methane and a COD removal percentage >75%. ©     

厌氧氨氧化-反硝化协同脱氮研究

采用厌氧氨氧化（ANAMMOX）工艺的上流式厌氧污泥床（UASB）-生物膜反应器（简称反应器）处理高浓度含氮废水，启动并稳定运行630d后，进行进水浓度负荷实验分析。当进水ρ（NH3-N），ρ（NO2--N），ρ（TN）分别为340．0，448．8，788．8mg／L时，其去除率分别为84．0％，93．0％，85．0％。在反应器中连续加入有机物（葡萄糖），进水ρ（NH3-N）和ρ（NO2--N）分别为240．0，316．8mg／L，进水COD为330．0—380．0mg／L，COD去除率达92．0％。仅用23d，在同一反应器系统中成功实现了ANAMMOX与反硝化协同作用脱氮。葡萄糖的存在对系统去除NH3-N和NO2--N的能力影响不大。     

好氧颗粒污泥处理增塑剂生产废水

以SBR为反应器，利用好氧颗粒污泥处理增塑剂生产废水。实验结果表明:通过培养驯化后，好氧颗粒污泥对该废水具有较好的处理效果;好氧颗粒污泥对增塑剂生产废水中COD的去除率为78%，出水COD为62mg/L，接近于GB18918－2002《城镇污水处理厂污染物排放标准》中的一级B标准;出水中NH3-N未检出，TP为0.03mg/L，去除率分别达到100%和90%。     

高效降解菌处理高浓度焦化废水

为了解决高浓度焦化废水不经稀释无法直接处理的问题,将HENGJIE高效混合菌制剂和粉末活性炭加入O1AO2废水处理系统中,进行焦化废水的中试试验。试验结果表明,该方法可对未经稀释的高浓度焦化废水直接进行处理,且系统启动快,菌种对污染物的降解效率较高。在O1段水力停留时间为20h、A段水力停留时间为35h、O2段水力停留时间为25h的条件下,经过20d的连续运行后,使进水COD由5435．7mg／L（平均值）降至出水COD369．3mg／L（平均值）,COD去除率为93．17％;使进水中NH3-N平均质量浓度由67．80mg／L降至出水中NH3-N平均质量浓度1．04mg／L,NH3-N去除率为98．18％,废水色度为100～200。除废水COD与色度外,其他检测项目均可达到废水一级排放标准。     

两相厌氧工艺处理高浓度丙烯酸生产废水

利用两相厌氧工艺处理高浓度丙烯酸生产废水。实验结果表明：在较高进水COD和容积负荷的条件下，系统具有良好、稳定的处理效果;在负荷提高及稳定运行阶段，将生活污水与丙烯酸生产废水的体积比调整为5∶1，容积负荷最大提高至12.3 kg/（m3·d），两相厌氧反应器可长期稳定运行，总COD去除率基本维持在90%以上，出水COD小于323 mg/L;当进水甲醛质量浓度为800~1 733 mg/L时，总甲醛去除率基本稳定在95.6%~99.3%;在负荷提高及稳定运行阶段，水解酸化相反应器和产甲烷相反应器的出水pH分别为6.2~7.6和7.6~8.1，出水总碱度分别为1 220~1 820 mg/L和1 800~2 620 mg/L。     

曝气-过滤一体化装置脱氮除磷的研究

曝气-过滤一体化装置将生物反应器与过滤机理有机结合，较好地维持了反应器中的高污泥浓度，实现了水力停留时间（HRT）与污泥停留时间的分离。采用连续流间歇曝气工艺对该装置的脱氮除磷效果进行了研究。实验结果表明：在HRT为8h，运行方式为曝气2h、停曝2h的条件下，COD去除率为95．55％，NH3-N未检出，TN为84．90％，TP为93．69％，出水各项指标都达到了GB8978-1996（污水综合排放标准》一级排放标准要求。     

A pilot plant two-phase anaerobic digestion system for bioenergy recovery from swine wastes and garbage

A pilot plant bioenergy recovery system from swine waste and garbage was constructed. A series of experiments was performed using swine feces (SF); a mixture of swine feces and urine (MSFU); a mixture of swine feces, urine and garbage (MSFUG); garbage and a mixture of urine and garbage (AUG). The system performed well for treating the source materials at a high organic loading rate (OLR) and short hydraulic retention time (HRT). In particular, the biogas production for the MSFUG was the highest, accounting for approximately 865-930Lkg(-1)-VS added at the OLR of 5.0-5.3kg-VSm(-3)day(-1) and the HRT of 9 days. The removal of VS was 67-75%, and that of COD was 73-74%. Therefore, co-digestion is a promising method for the recovery of bioenergy from swine waste and garbage. Furthermore, the results obtained from this study provide fundamental information for scaling up a high-performance anaerobic system in the future.     

两相厌氧+A/O工艺处理腈纶和丙烯酰胺混合废水

采用两相厌氧+A/O工艺处理腈纶和丙烯酰胺混合废水。实验结果表明：在混合进水中V（腈纶废水）∶V（丙烯酰胺废水）=1、产酸反应器HRT为20 h、产甲烷反应器HRT为36 h、A/O池HRT为24 h、DO为4~5 mg/L、混凝池进水COD为（4 000±300） mg/L的条件下，总COD去除率为87%~89%，A/O池出水COD低于500 mg/L，出水达到GB 8978—1996《污水综合排放标准》中的三级标准;在混凝池进水BOD₅/COD为0.20~0.30的条件下，产甲烷反应器出水BOD₅/COD为0.55~0.65，说明两相厌氧可明显提高废水的可生化性。     

“二级厌氧-微氧-好氧”组合工艺处理模拟碳纤维生产废水

对模拟碳纤维生产废水进行“厌氧-好氧”静态小试,根据COD的去除效果确定该碳纤维废水的可生化性。采用“二级厌氧-微氧-好氧”组合工艺进行动态中试,考察废水的处理效果及系统的抗冲击性能。试验结果表明：该工艺对碳纤维生产废水的处理效果较好;系统具有厌氧池出水pH增大的特点,且抗冲击能力较强;在厌氧池水温为28~38 ℃、好氧池水温不低于15 ℃、废水流量为100 L/h、进水COD为660 mg/L、进水ρ（氨氮）为4.9 mg/L的条件下,出水COD稳定在50 mg/L以下,ρ（氨氮）稳定在5 mg/L以下,能够满足GB 8978-1996《污水综合排放标准》的要求。     

SMBBR-AF-SMBBR组合工艺处理高氨氮农药废水

采用特异性移动床生物膜反应器(SMBBR)和厌氧生物滤池(AF)组合工艺处理高氨氮农药废水。考察了HRT、pH和DO等工艺条件对SMBBR-AF-SMBBR组合工艺运行稳定期COD和氨氮去除率的影响。试验结果表明,在进水COD为2 408~7 440 mg/L、ρ(NH_4~+-N)为160.21~433.84 mg/L、TN为208.27~537.65 mg/L、HRT为8d、pH为8.0、DO为4 mg/L的条件下,处理后出水平均COD为342 mg/L,COD去除率达92.3%;ρ(NH_4~+-N)小于4.0mg/L,氨氮平均去除率为89.2%;TN小于50 mg/L,平均TN去除达83.0%。出水各指标均优于原A2O工艺出水。     

UASB反应器反硝化处理工业废水

采用絮状污泥成功启动升流式厌氧污泥床(UASB)反应器处理含甲酸、苯胺、环已酮、NO3-等的工业废水。UASB反应器以低负荷启动,10天后逐渐提高进水COD,出水COD保持在710~770 mg/L,COD去除率为40%~60%;出水TOC保持在115~314 mg/L,TOC去除率由60.3%逐渐升高至87.2%,最终维持在81%左右;出水中ρ(NO3-)维持在134~176 mg/L,NO3-去除率为90%左右,系统稳定后NO3-去除率几乎为100%。在进水COD容积负荷不超过5.00 kg/(m3·d)的条件下,实际COD容积负荷稳定在2.00 kg/(m3·d)左右,实际TOC容积负荷稳定在1.00 kg/(m3·d)以上。当进水COD容积负荷不大于4.48 kg/(m3·d)时,COD去除率为55%~74%,TOC去除率为63%~87%,NO3-去除率大于95%。     

Continuous high-solids anaerobic co-digestion of organic solid wastes under mesophilic conditions

With increasing concerns over the limited capacity of landfills, conservation of resources, and reduction of CO(2) emissions, high-solids (dry) anaerobic digestion of organic solid waste (OSW) is attracting a great deal of attention these days. In the present work, two dry anaerobic co-digestion systems fed with different mixtures of OSW were continuously operated under mesophilic conditions. Dewatered sludge cake was used as a main seeding source. In reactor (I), which was fed with food waste (FW) and paper waste (PW), hydraulic retention time (HRT) and solid content were controlled to find the maximum treatability. At a fixed solid content of 30% total solids (TS), stable performance was maintained up to an HRT decrease to 40 d. However, the stable performance was not sustained at 30 d HRT, and hence, HRT was increased to 40 d again. In further operation, instead of decreasing HRT, solid content was increased to 40% TS, which was found to be a better option to increase the treatability. The biogas production rate (BPR), CH(4) production yield (MPY) and VS reduction achieved in this condition were 5.0m(3)/m(3)/d, 0.25 m(3) CH(4)/g COD(added), and 80%, respectively. Reactor (II) was fed with FW and livestock waste (LW), and LW content was increased during the operation. Until a 40% LW content increase, reactor (II) exhibited a stable performance. A BPR of 1.7 m(3)/m(3)/d, MPY of 0.26 m(3) CH(4)/g COD(added), and VS reduction of 72% was achieved at 40% LW content. However, when the LW content was increased to 60%, there was a significant performance drop, which was attributed to free ammonia inhibition. The performances in these two reactors were comparable to the ones achieved in the conventional wet digestion and thermophilic dry digestion processes.     

好氧颗粒污泥脱氮性能研究

研究了序批式反应器的污泥沉降时间、曝气速率、水力停留时间、进水方式等参数对好氧颗粒污泥的性能以及COD,NH4^*—N,TN去除率的影响。研究结果表明,在一个运行周期内,反应器运行工艺参数,如DO质量浓度和pH,具有一定的变化规律,并且其变化与反应器内各物质的转化存在严格的对应关系。因此,参照反应器运行工艺参数的特征点,对反应过程进行必要的控制,可达到较理想的处理效果。     

High rate mesophilic, thermophilic, and temperature phased anaerobic digestion of waste activated sludge: a pilot scale study

The paper reports the findings of a two-year pilot scale experimental trial for the mesophilic (35°C), thermophilic (55°C) and temperature phased (65+55°C) anaerobic digestion of waste activated sludge. During the mesophilic and thermophilic runs, the reactor operated at an organic loading rate of 2.2 kgVS/m(3)d and a hydraulic retention time of 20 days. In the temperature phased run, the first reactor operated at an organic loading rate of 15 kgVS/m(3)d and a hydraulic retention time of 2 days while the second reactor operated at an organic loading rate of 2.2 kgVS/m(3)d and a hydraulic retention time of 18 days (20 days for the whole temperature phased system). The performance of the reactor improved with increases in temperature. The COD removal increased from 35% in mesophilic conditions, to 45% in thermophilic conditions, and 55% in the two stage temperature phased system. As a consequence, the specific biogas production increased from 0.33 to 0.45 and to 0.49 m(3)/kgVS(fed) at 35, 55, and 65+55°C, respectively. The extreme thermophilic reactor working at 65°C showed a high hydrolytic capability and a specific yield of 0.33 g COD (soluble) per gVS(fed). The effluent of the extreme thermophilic reactor showed an average concentration of soluble COD and volatile fatty acids of 20 and 9 g/l, respectively. Acetic and propionic acids were the main compounds found in the acids mixture. Because of the improved digestion efficiency, organic nitrogen and phosphorus were solubilised in the bulk. Their concentration, however, did not increase as expected because of the formation of salts of hydroxyapatite and struvite inside the reactor.     

高氨氮化工废水MBBR—AMBBR—MBBR组合工艺处理

采用移动床生物膜反应器（MBBR）—厌氧移动床生物膜反应器（AMBBR）—MBBR组合工艺处理高氨氮化工废水。反应器采用几何构型优化、比表面积大的新型YD-25生物载体和DNF-203硝化细菌,实现了同步硝化和反硝化,强化了脱氮能力。采用投加菌种和排泥的方式,经27 d的驯化培养即完成了反应器的挂膜启动。试验结果表明：最佳操作条件为HRT 8 d、MBBR中DO 3 mg/L、进水pH 8.0;在进水COD 2 840~7 437 mg/L、ρ（氨氮）92~179 mg/L、TN 148~258 mg/L、pH 6~8的条件下,出水指标均值为COD 352 mg/L、ρ（氨氮）21.2 mg/L、TN 36 mg/L、pH 7.4,满足排放要求。