碱渣用于模拟烟气湿式脱硫的研究

从脱硫率和脱硫饱和时间两个方面,对碱渣与电石渣的混合脱硫剂进行了实验研究,并采用添加有机酸的方法提高混合脱硫剂的脱硫能力。实验结果表明,碱渣粒度对脱硫率有一定的影响,碱渣粒度<60μm为宜;碱渣与电石渣配比为1∶1时,脱硫率接近纯氢氧化钙的脱硫能力;添加有机酸不仅能提高吸收浆液的脱硫能力,而且有缓冲浆液pH值的作用,二元有机酸的影响比一元酸的影响更为显著;添加了有机酸的吸收浆液的pH值可控制在4.5～5.0左右。     

废大理石粉湿法烟气脱硫工艺实验

实验研究了废大理石粉作为脱硫剂的湿法烟气脱硫工艺,分析了其吸收SO₂的传质反应机理.试验了不同液气比(L/G)、吸收浆液pH值和进气SO₂浓度等主要参数对脱硫率的影响,并对实验结果进行了分析.结果表明,选择以下操作条件较为适宜:pH₀=5.5～6.5,L/G=3L/m³,a=2%;以上工艺条件下,在进气SO₂浓度为1000ml/m³时,脱硫率达60%以上.本文还讨论了废大理石粉作为脱硫剂的工业应用前景.     

旋流板塔镁强化石灰脱硫过程研究

以旋流板塔为吸收器进行镁强化石灰脱硫的实验研究,测定了脱硫率、浆液pH值等随时间的变化情况,考察了硫酸镁浓度的影响,并利用实验数据计算了石灰利用率.与单用石灰脱硫对比,添加硫酸镁可明显提高脱硫率;对具有2块板的旋流板塔,硫酸镁浓度为0.2mol/L时,脱硫率从45%提高到60%以上.为保证较高的脱硫率,pH值宜控制在6.0～7.5.由于硫酸镁能促进石灰的溶解,减缓pH值的下降,因此又可提高石灰利用率;适宜条件下,0.2mol/L硫酸镁强化时可提高石灰利用率5%(所加石灰为基准)以上.     

水蒸气电晕放电下的烟气脱硫效果

采用多针-板式电极,在70 m³/h烟气流量范围内,研究了水蒸气浓度、烟气流量、电场强度等因素对不饱和水蒸气正直流电晕放电烟气脱硫率的影响以及水蒸气电晕放电对脉冲放电烟气脱硫率的提高.研究结果表明,实验范围内,按照NH₃∶SO₂摩尔比为2∶1添加NH3的条件下,增加水蒸气流量、增强电场强度、减少烟气流量,烟气脱硫率能提高10%,达到60%左右.同时,水蒸气电晕放电能使脉冲放电的烟气脱硫率提高5%左右,达到90%以上.     

石灰石湿法烟气脱硫添加剂的实验研究

利用双搅拌釜，作石灰石浆液脱硫的实验，测定添加剂强化前后石灰石浆液脱硫过程中气液两相传质系数的变化，对比气液两相传质系数的大小。并结合国内外脱硫技术现状，提出了以石灰石作为脱硫剂，以硫酸镁、硫酸钠、腐残酸钠为添加剂，应用双搅拌釜为主设备的湿法脱硫方法，对添加剂的脱硫机理进行了基础性研究。     

氧化镁添加剂对旋流板塔石灰湿法脱硫效果的影响分析

本文主要针对氧化镁对石灰湿法脱硫过程的影响进行了试验研究,详细分析了添加氧化镁前后浆液 pH 值、脱硫率随传质反应时间的变化规律,并就氧化镁的防腐阻垢性能进行试验,还从应用角度评价了氧化镁添加剂的作用效果。     

钙基湿法烟气脱硫主要参数的影响规律

以综合性能优越的旋流板塔为脱硫塔,研究了钙基湿法烟气脱硫的主要参数对脱硫率的影响规律,这些参数包括吸收剂、浆液pH值、气流量G、液流量L与气流量G同时增减等;由实验结果得出上要参数对脱硫率影响的回归关联式．同时对实验结果进行了分析,本研究为工业装置的设计、操作和运行提供了基础数据     

添加剂强化石灰石/石灰FGD过程的某些浆液特性

测定了不同浓度不同添加剂强化下的石灰石烟气脱硫浆液的固相沉降时间、上清液密度及滤饼固含量,实验结果表明:使用添加剂时,实验条件下滤饼固含量有所下降,但影响不大;浆液固相沉降时间的不同,可能与浆液中亚硫酸钙固相产物的含量及晶粒大小和晶型不同有关;添加剂不同,上清液密度也有差异.镁强化石灰脱硫浆液,沉降过程可分为快速沉降和慢速沉降两阶段;固相中亚硫酸钙的含量高则沉降速率较慢;与非强化石灰脱硫过程相比,滤饼固含量稍低.脱硫实验同时表明,使用添加剂有利于抑制设备结垢.      

几种碱性废渣脱硫性能的比较研究

以吸收瓶为实验装置研究了几种碱性废渣的脱硫容量。实验结果表明 ,电石渣、碱渣、废大理石和石灰石的脱硫容量分别为 0 85、0 75 ,0 6 2和 0 5 8gSO2 g脱硫剂。旋流板塔试验主要参数对脱硫率的影响结果表明 ,入塔浆液pH值越大 ,液气比L G越大 ,脱硫率η也越高 ;入塔SO2 浓度y0 越高 ,脱硫率η越低。模拟工业试验结果表明 ,对电石渣和碱渣 ,控制浆液pH >7,L G =2～ 3L m3时 ,η可达 6 5 %以上 ;对废大理石和石灰石 ,控制浆液pH为 6 5 ,L G =4～6L m3时 ,η可达 6 0 %以上。从以上结果来看 ,作为脱硫剂 ,电石渣脱硫效果最好 ,碱渣次之 ,最后是废大理石和石灰石。电石渣和碱渣显示了良好的应用前景     

石灰石湿式烟气脱硫工艺中添加剂的研究

石灰石湿式烟气脱硫工艺中使用添加剂 ,可提高脱硫率和石灰石利用率等。本研究应用旋流板塔处理模拟烟气 ,系统研究了几种无机及有机添加剂对湿式石灰石脱硫过程的影响 ,选出了适宜的添加剂及其添加浓度 ;得到了脱硫率与主要操作参数之间的关系 ,为工业设计和操作提供了参考数据。并对添加剂强化过程机理进行了讨论     

Effects of two sludge application on fractionation and phytotoxicity of zinc and copper in the soil

The potential harm of heavy metals is a primary concern in application of sludge to the agricultural land. A pot experiment was conducted to evaluate the effect of two sludges on fractionation of Zn and Cu in soil and their phytotoxicity to pakchoi. The loamy soil was mixed with 0%, 20%, 40%, 60% and 80% (by weight) of digested sewage sludge (SS) and composted sludge (SC). The additions of both sludges caused a significant raise in all fractions, resulting in that exchangeable (EXCH) and organic bound (OM) became predominance of Zn and organic bound Cu occupied the largest portion. There was more available amount of Zn and Cu in SS treatments than SC treatments. During the pot experiment, the concentration of Zn in EXCH, carbonate (CAR) and OM and Cu in EXCH and OM fractions decreased in all treatments, so their bioavailability reduced. Germination rate and plant biomass decreased when the addition rate was high and the best yield appeared in 20% mixtures at the harvest of pakchoi. The two sludges increased tissue contents of Zn and Cu especially in the SS treatments. Zn in pakchoi was not only in relationship to ΔEXCH and ΔCAR forms but also in ΔOM forms in the sludge-soil mixtures. Tissue content of Cu in pakchoi grown on SC-soils could not be predicted by ΔEXCH. These correlation rates between Zn and Cu accumulation in pakchoi and variation of different fractions increased with time, which might indicate that sludges represented stronger impacts on the plant in long-term land application.     

Intraspecific differences in effects of co-contamination of cadmium and

A hydroponic experiment was carried out to study intraspecific differences in the effects of different concentrations of cadmium (Cd)(0-10 mg/L) and arsenate (As(V)) (0-8 mg/L) on the growth parameters and accumulation of Cd and As in six wheat varieties Jing-9428, Duokang-1, Jingdong-11, Jing-411, Jingdong-8 and Zhongmai-8. The endpoints of wheat seedlings, including seed germination,biomass, root length and shoot height, decreased with increasing the Cd and As concentrations. Significant differences in seed germination, biomass, root length, shoot height and the accumulation of Cd and As were observed between the treatments and among the varieties (p ＜ 0.05). The lethal dosage 50% were about 20, 80, 60, 60, 80 and 20 mg As/L for Jing-9428, Duokang-1, Jingdong-11,Jing-411, Jingdong-8 and Zhongmai-8, respectively, and the corresponding values for Cd were about 30, 80, 20, 40, 60 and 10 mg Cd/L, respectively. Among the six varieties, Duokang-1 was found to be the most resistant to Cd and As toxicity, and Zhongmai-8 was the most sensitive to Cd and As co-contamination. The resistance of the six varieties was found dependant on the seedling uptake of Cd and As. Duokang-1 was the most suitable for cultivation in Cd and As co-contaminated soils.     

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

EDTA-enhanced phytoremediation of lead contaminated soil by Bidens maximowicziana

Phytoremediation is a potential cleanup technology for the removal of heavy metals from contaminated soils.Bidens maximowicziana is a new Pb hyperaccumulator,which not only has remarkable tolerance to Pb but also extraordinary accumulation capacity for Pb.The maximum Pb concentration was 1509.3 mg/kg in roots and 2164.7 mg/kg in overground tissues.The Pb distribution order in the B. maximowicziana was:leaf>stem>root.The effect of amendments on phytoremediation was also studied.The mobility of soil Pb and the Pb concentrations in plants were both increased by EDTA application.Compared with CK(control check),EDTA application promoted translocation of Pb to overground parts of the plant.The Pb concentrations in overground parts of plants was increased from 24.23-680.56 mg/kg to 29.07-1905.57 mg/kg.This research demonstrated that B.maximowicziana appeared to be suitable for phytoremediation of Pb contaminated soil,especially,combination with EDTA.     

Distribution and ecological effect of mercury in Laogang landfill, Shanghai, China

Laogang landfill near Shanghai is the largest landfill in China, and receives about 10000 t of daily garbage per day, Samples of topsoil and plants were analyzed to evaluate mercury pollution from the landfill. For topsoil samples, there were significant correlations among total mercury （HgT）, combinative mercury （Hgc） and gaseous mercury （HgG）, and content of total organic carbon （TOC）, but, no significantly relationship was found between Hg content and filling time. Hg content changes in vertical profiles with time showed that the average Hgv of profiles 1992, 1996, and 2000 was similar, but their average HgG was quite different. HgT was significantly correlated with Hgc in profile 1992 and 2000, and Hgv was significantly correlated with Hg6 in profile 1996. HgG/Hgv ratio in profile samples decreased in the order of （HgG,/HgT）1992〉（HgG/HgT）1996〉〉（HgG/HgT）2000. A simple outline of Hg release in landfill could be drawn： with increasing of filling time, degradation undergoes different biodegradation, accordingly, gaseous mercury goes through small, more, and small proportion to total mercury. Distribution of Hg in plants was inhomogeneous, following the order of leaf〉root〉stem. The highest value of leaf may be associated with higher atmospheric Hg from landfill. Ligneous plants （e.g. Phyllostachys glanca, Prunus salicina and Ligustrum lucidum） are capable of enriching more Hg than herbaceous plants.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Enzymatic oxidation of aqueous pentachlorophenol

The influence of the nonionic surfactant Tween 80 on pentachlorophenol （PCP） oxidation catalyzed by horseradish peroxidase was studied. The surfactant was tested at concentrations below and above its critical micelle concentration （CMC）. Enhancement of PCP removal was observed at sub-CMCs. The presence of Tween 80 in the reaction mixture reduced enzyme inactivation which occurred through a combination of free radical attack and sorption by precipitated products. A simple first-order model was able to simulate time profiles for enzyme inactivation in the presence or absence of Tween 80. At supra-CMCs, the surfactant caused noticeable reductions in PCP removal, presumably through micelle partitioning of PCP which precluded the hydrophobic PCP molecule from interacting with the enzyme.     

Decomposition of alachlor by ozonation and its mechanism

Decomposition and corresponding mechanism of alachlor, an endocrine disruptor in water by ozonation were investigated. Results showed that alachlor could not be completely mineralized by ozone alone. Many intermediates and final products were formed during the process, including aromatic compounds, aliphatic carboxylic acids, and inorganic ions. In evoluting these products, some of them with weak polarity were qualitatively identified by GC-MS. The information of inorganic ions suggested that the dechlorination was the first and the fastest step in the ozonation of alachlor.     

Degradation of metabolites accumulated of benzo[a]pyrene by coupling Penicillium Chrysogenum with KMnO4

Several main metabolites of benzo[a]pyrene （BaP） formed by Penicillium chrysogenum, Benzo[a]pyrene-1,6-quinone （BP 1,6- quinone）, trans-7,8-dihydroxy-7,8-dihydrobenzo[a]pyrene （BP 7,8-diol）, 3-hydroxybenzo[a]pyrene （3-OHBP）, were identified by high-performance liquid chromatography （HPLC）. The three metabolites were liable to be accumulated and were hardly further metabolized because of their toxicity to microorganisms. However, their further degradation was essential for the complete degradation of BaP. To enhance their degradation, two methods, degradation by coupling Penicillium chrysogenum with KMnO4 and degradation only by Penicillium chrysogenum, were compared; Meanwhile, the parameters of degradation in the superior method were optimized. The results showed that （1） the method of coupling Penicillium chrysogenum with KMnO4 was better and was the first method to be used in the degradation of BaP and its metabolites; （2） the metabolite, BP 1,6-quinone was the most liable to be accumulated in pure cultures; （3） the effect of degradation was the best when the concentration of KMnO4 in the cultures was 0.01% （w/v）, concentration of the three compounds was 5 mg/L and pH was 6.2. Based on the experimental results, a novel concept with regard to the bioremediation of BaP-contaminated environment was discussed, considering the influence on environmental toxicity of the accumulated metabolites.     

Impact of atrazine and nitrogen fertilizers on the sorption of chlorotoluron in soil and model sorbents

Sorption of chlorotoluron in ammonium sulfate, urea and atrazine multi-solutes system was investigated by batch experiments. The results showed application of nitrogen fertilizers to the soil could affect the behavior of chlorotoluron. At the same concentration of N, sorption of chlorotoluron decreased as the concentration of atrazine increased on the day 0 and 6 in soil, respectively. The sorption of chlorotoluron increased from 0 to 6 d when soils were preincubated with deionized water, ammonium sulfate and urea solution for 6 d. That indicated incubation time was one of the most important factors for the sorption of chlorotoluron in nitrogen fertilizers treatments. The individual sorption isotherms of chlorotoluron in rubbery polymer and silica were strictly linear in single solute system, but there were competition sorption between pesticides or between pesticides and nitrogen fertilizers. That indicated the sorption taken place by concurrent solid-phase dissolution mechanism and sorption on the interface of water-organic matter or water-mineral matter.