Practical performance and its efficiency of arsenic removal from groundwater using Fe-Mn binary oxide

A treatment unit packed by granular adsorbent of Fe-Mn binary oxide incorporated into diatomite (FMBO(1:1)-diatomite) was studied to remove arsenic from anaerobic groundwater without any pre-treatment or post-treatment. The raw anaerobic groundwater containing 35-45 μg/L of arsenic was collected from suburb of Beijing. Arsenic(III) constituted roughly 60%-80% of the total arsenic content. Approximately 7,000 bed volumes (ratio of efluent volume to adsorbent volume) treated water with arsenic concentration below 10 μg/L were produced in the operation period of four months. The regeneration of FMBO(1:1)-diatomite had been operated for 15 times. In the first stage, the regeneration process significantly improved the adsorption capacity of FMBO(1:1)-diatomite. With increased loading amount of Fe-Mn binary oxide, the adsorption capacity for arsenic decreased 20%-40%. Iron and manganese in anaerobic groundwater were oxidized and adsorptive filtrated by FMBO(1:1)-diatomite efficiently. The final concentrations of iron and manganese in efluents were nearly zero. The continued safe performance of the treatment units proved that adsorbent FMBO(1:1)-diatomite had high oxidation ability and exhibited strong adsorptive filtration.     

铁锰复合氧化物吸附去除五价锑性能研究

对比研究了铁锰复合氧化物(FMBO)、羟基氧化铁(FeOOH)和二氧化锰(MnO₂)吸附去除五价锑(Sb(V))的性能.结果表明FMBO对Sb(V)具有很好的吸附性能,在pH=5.0的条件下,最大吸附容量达到1.05 mmol·g^-1,略高于FeOOH (0.82 mmol·g^-1)及远高于MnO₂ (0.43 mmol·g^-1);采用Freundlich模型可以很好地描述Sb(V)在FMBO的吸附行为(R² = 0.98).就吸附动力学而言,假二级动力学可很好地描述Sb(V)在FMBO (R² = 0.93)和MnO₂表面的吸附过程(R² = 0.96),而Sb(V)在FeOOH表面的吸附过程可用Elovich模型拟合 (R² = 0.94).Sb(V)的吸附量随着pH值的升高而降低;磷酸盐显著抑制了Sb(V)的吸附,而硫酸盐和碳酸盐影响不大.提高体系离子强度可促进Sb(V)在FMBO表面的吸附,推断Sb(V)在FMBO表面形成内层络合物后被吸附去除.     

载铁(β-FeOOH)球形棉纤维素吸附剂去除地下水As(Ⅴ)的研究

制备了一种载铁(β- FeOOH)球形棉纤维素吸附剂,球珠孔隙度大,强度好,活性成分铁的载入量可高达360mg/mL ,(质量分数达50%) ,活性好.研究表明,当铁含量为220mg/mL时,该吸附剂对As(V)的最大吸附量为15.6mg/mL(33.2mg/g) ,Langmuir和Freundlich方程能很好地描述吸附等温线.吸附速度较快,10h可达到吸附平衡,吸附动力学符合Lagergren二级方程.SiO₃^2- ,SO₄^2-,Cl^-干扰离子均不影响砷的去除.柱吸附实验表明,空床停留时间为5.9min ,进水As(V)浓度为500μg/L时,As(V)的穿透体积为5000BV .吸附剂可以用1.5mol·L^-1 NaOH再生,洗脱和再生效率可达90%以上.活性成分β-FeOOH形态稳定,柱操作和再生时铁无溶出.吸附剂制备方法简单,新颖,对地下水和饮用水砷去除具有较好的应用前景.     

铁锰双金属材料对砷和重金属复合污染土壤的稳定化研究

由于矿产资源的共生、伴生现象及历史上采选冶技术的相对落后,我国矿区附近的重金属污染场地多存在复合污染的情况,而稳定化技术是解决该问题的有效措施.本文通过室内模拟培养实验和静态吸附试验,研究了人工合成的铁锰双金属材料(FMBO)对矿区复合污染土壤中As、Pb、Cd等重金属的稳定化作用和机制.毒性浸出实验结果表明,在3种不同的As和重金属复合污染土壤中,FMBO材料能够对As和Pb等重金属起到较好的稳定化作用,在5%的最大添加量下,FMBO对As、Pb的稳定化效率分别能够达到95.2%~100%和95.5%~97.5%,同时不会引起Cd、Zn和Cu等重金属的活化.由连续提取实验结果可知,FMBO能够使土壤中As和Pb由酸可提取态向可还原态转变,稳定性增强.微观特征分析结果表明,FMBO材料对As的稳定化主要通过表面羟基(—OH)基团的吸附作用,而对Pb、Cd等金属离子则通过吸附、沉淀等多种方式起作用.总体看来,FMBO材料适用于As、Pb等重金属复合污染土壤的治理.     

铁锰双金属材料在不同pH条件下对土壤As和重金属的稳定化作用

pH是影响土壤As和重金属赋存形态及稳定化过程的重要因素,本文以人工合成的铁锰双金属材料(FMBO)为研究对象,研究了其在不同pH条件下对3种As和重金属复合污染土壤的稳定化作用,同时探讨了材料添加对土壤pH和酸碱缓冲性的影响.结果表明,As、Pb元素分别在土壤pH 3~9的中性偏酸性条件、pH 5~10的中性偏碱性条件下较为稳定,Cd、Zn、Cu在pH为7~11的碱性条件下浸出浓度较低.在碱性条件下,FMBO材料自身稳定性及稳定化作用均优于酸性条件,在As和重金属稳定的最适pH范围内,随着材料添加量增加,稳定化效率逐渐升高,其对As、Pb、Cd、Zn、Cu的稳定化效率最高分别能达到92.7%、100%、97.0%、88.7%、82.7%.添加FMBO材料可使土壤pH值升高,并能够提高土壤的酸缓冲能力,对As和重金属的长期稳定性有促进作用,而对土壤碱缓冲作用影响较小.从浸出元素的相关关系可以看出,Fe元素对土壤中As的稳定性有重要作用,Pb、Cd、Zn、Cu的稳定性受土壤pH影响较大.     

三种氧化铁吸附水环境中砷的试验研究

采用两种人工合成的氧化铁(针铁矿、水铁矿)和赤铁矿作为吸附剂,对含砷(三价砷及三价五价砷混合液)水进行了吸附试验。结果表明,在初始浓度为1200μg/L的As(Ⅲ)溶液中,水铁矿的吸附效果最好,针铁矿和赤铁矿吸附效果较差;在初始pH为7,As(Ⅲ)和As(Ⅴ)摩尔比为1:1的混合液中时,三种铁矿对总砷的吸附效果均随着As/Fe摩尔比的增大而减小;在A(sⅢ)和As(Ⅴ)摩尔比为1:1的混合液中,吸附总砷效果最好的是针铁矿,水铁矿次之,赤铁矿的吸附效果最差;A(sⅤ)的存在对除砷效果有一定的影响,三价砷和五价砷共存时,三种铁矿对其吸附具有一定的选择性。     

水固液微界面氧化还原反应过程与污染物控制研究

本文介绍了3个反应体系,包括铁锰复合氧化物氧化吸附除砷体系、铁氧化物包覆零价铁光芬顿催化和负载型多价态锰氧化物臭氧催化体系,通过固液微界面不同的氧化还原反应,实现了对水中砷和难降解有机污染物的高效去除.重点介绍了不同氧化还原反应对污染物转移转化的作用机制,说明了水体中固液微界面氧化还原反应,对污染物的转移转化起着重要作用.     

Migration of manganese and iron during the adsorption-regeneration cycles for arsenic removal

Fe-Mn binary oxide incorporated into porous diatomite (FMBO-diatomite) was prepared in situ and regenerated in a fixed-bed column for arsenite [As(III)] and arsenate [As(V)] removal. Four consecutive adsorption cycles were operated under the following conditions: Initial arsenic concentration of 0.1 mg·L⁻¹, empty bed contact time of 5 min, and pH 7.0. About 3000, 3300, 3800, and 4500 bed volumes of eligible effluent (arsenic concentration ⩽ 0.01 mg·L⁻¹) were obtained in four As (III) adsorption cycles; while about 2000, 2300, 2500, and 3100 bed volumes of eligible effluent were obtained in four As(V) adsorption cycles. The dissection results of FMBO-diatomite fixed-bed exhibited that small amounts of manganese and iron were transferred from the top of the fixed-bed to the bottom of the fixed-bed during As(III) removal process. Compared to the extremely low concentration of iron (<0.01 mg·L⁻¹), the fluctuation concentration of Mn²⁺ in effluent of the As(III) removal column was in a range of 0.01–0.08 mg·L⁻¹. The release of manganese suggested that manganese oxides played an important role in As(III) oxidation. Determined with the US EPA toxicity characteristic leaching procedure (TCLP), the leaching risk of As(III) on exhausted FMBO-diatomite was lower than that of As(V).     

磁性吸附材料CuFe2O4吸附砷的性能

根据Cu(Ⅱ)和Fe(Ⅲ)都对砷有较强的亲和性,制备了同时含有Cu(Ⅱ)和Fe(Ⅲ)的、可用磁分离方法进行分离回收的磁性吸附材料CuFe₂O₄,并对其进行了表征及吸附砷的性能研究.结果表明,该吸附剂对砷的吸附能力与溶液pH有关,在弱酸性及中性条件下,吸附砷的能力最强,而对As(V)的吸附能力比对As(Ⅲ)更强些,在平衡浓度为10μg/L时,其吸附容量可达10mg/g左右,可以很容易地将水中浓度为1～20mg/L的As(V)降到10μg/L以下.实验考察了几种无机阴离子对吸附砷的影响,表明较高浓度(砷浓度的20倍)的硫酸盐对As(Ⅲ)和As(V)的吸附均有一定影响,盐酸盐及磷酸盐则影响不明显;负载的As(V)可较容易地用0.1mol/L NaOH洗脱下来,使吸附剂再生,而As(Ⅲ)则难以洗脱,这与2种价态砷的吸附机理不同有关.     

氧化锰改性活性炭的优化制备及其对Cd(Ⅱ)的吸附研究

采用浸渍焙烧法制备了活性炭负载氧化锰的除镉(Cd(Ⅱ))吸附剂,通过L_9(3~4)正交试验确定最优制备条件如下:浸渍时间7 h,KMnO_4质量分数2.7%,焙烧温度470℃,焙烧时间2.5 h。通过BET、SEM、FTIR、XRD对改性活性炭(MOAC)进行表征,研究了pH值、吸附时间、初始浓度、吸附温度等对Cd(Ⅱ)吸附效果的影响。结果表明:MOAC表面烃基含氧官能团增多,氧化锰以MnO_2的形式负载到其表面;当MOAC的投加量为0.5 g/L,Cd(Ⅱ)的初始浓度为50 mg/L,溶液pH值为6.0,温度为298 K,吸附时间为12 h时,MOAC对Cd(Ⅱ)的吸附量高达84.15 mg/g,吸附过程符合准二级动力学方程和Langmuir等温吸附方程,热力学参数表明该吸附过程为放热、自发的过程。     

天然菱铁矿改性及强化除砷研究

我国高砷地下水分布广泛,经济、高效地饮用水除砷技术受到广泛关注.静态批实验采用资源丰富、价格便宜的天然菱铁矿为主要原材料,考虑灼烧温度、时间及添加黏合剂等因素确定最优改性条件使除砷效果达到最佳.结果表明,在加铝量为10 mg.g-1、350℃下恒温灼烧90 min后造粒达到强度要求并除砷效果较优.25℃、固液比为0.5 g∶50 mL、As(Ⅲ)和As(Ⅴ)初始浓度为5 mg.L-1时,吸附后溶液中残留As浓度均<10μg.L-1.静态吸附批实验结果表明,25℃时,接触反应时间为12 h可达到吸附平衡,吸附过程较好地符合Lagergren假二级吸附速率方程;最优改性天然菱铁矿对砷的吸附规律可用Langmuir和Freundlich等温吸附模型很好地描述,As(Ⅲ)、As(Ⅴ)饱和吸附容量分别可以达到1 039、1 026μg.g-1.结合XRD、SEM等研究方法和比表面及孔结构分析初步探讨天然菱铁矿改性以及除砷的主要机制.分析表明,改性后天然菱铁矿比表面积大幅度增大,孔径减小,且在表面活化生成一层圆球状的含Fe(Ⅱ)和Fe(Ⅲ)的化合物.改性天然菱铁矿是一种值得进一步研究并实际应用的除砷材料.     

两种铁氧化物对土壤有效态汞的吸附作用研究

利用氧化物对土壤中汞的吸附特性,研究了汞污染土壤中添加铁锰和铁铝复合氧化物对土壤汞有效性的影响.结果表明,在土壤中添加氧化物后,土壤中有效态汞的含量明显降低,在相同添加量下铁铝复合氧化物比铁锰复合氧化物的吸附效果好.14 d时间内,添加铁铝氧化物后,两种土壤中有效态汞的含量分别降低了94.60%和93.11%;添加铁锰氧化物后,两种土样中有效态汞的含量分别降低了88.69%和87.85%,可见两种氧化物是土壤中有效态汞的有效吸附剂.通过方程拟合研究了氧化物对土壤中有效态汞吸附的规律,其中,铁铝氧化物对土壤中有效态汞的吸附规律以Elovich方程和权函数方程拟合度较好,铁锰氧化对土壤中有效态汞的吸附规律以Elovich方程拟合效果最好,零级速率方程及指数方程的拟合效果则相对较差.     

Removal of tetracycline from water by Fe-Mn binary oxide

Significant concerns have been raised over the presence of antibiotics including tetracyclines in aquatic environments. A series of Fe-Mn binary oxide with different Fe:Mn molar ratios was synthesized by a simultaneous oxidation and coprecipitation process for TC removal. Results showed that Fe-Mn binary oxide had higher removal efficiency than that of hydrous iron oxide and hydrous manganese oxide, and that the oxide with a Fe:Mn molar ratio of 5:1 was the best in removal than other molar ratios. The tetracycline removal was highly pH dependent. The removal of tetracycline decreased with the increase of initial concentration, but the absolute removal quantity was more at high concentration. The presence of cations and anions such as Ca²⁺, Mg²⁺, CO₃^2- and SO₄^2- had no significant effect on the tetracycline removal in our experimental conditions, while SiO₃^2- and PO₄^3- had hindered the adsorption of tetracycline. The mechanism investigation found that tetracycline removal was mainly achieved by the replacement of surface hydroxyl groups by the tetracycline species and formation of surface complexes at the water/oxide interface. This primary study suggests that Fe-Mn binary oxide with a proper Fe:Mn molar ratio will be a very promising material for the removal of tetracycline from aqueous solutions.     

CTAC改性活性炭去除水中砷(V)的柱实验吸附和再生研究

为了开发一种能有效去除水中砷的吸附材料, 研究了十六烷基三甲基氯化铵(CTAC)改性活性炭后, 活性炭对水中五价砷As(V)的去除效果.研究中利用动态小柱实验(Rapid small-scale column test, RSSCT)探讨了CTAC改性后活性炭对砷的吸附能力、影响吸附能力的因素和活性炭再生方法.结果表明, CTAC改性能有效提高活性炭对As(V)的吸附.活性炭对As(V)的吸附受溶液pH、空床接触时间、进水中砷浓度及水中其他离子存在的影响.另外, 1 mol·L^-1的盐酸能有效对吸附穿透后的活性炭进行再生,再生后的活性炭可以重复使用.同时,柱实验中对出水CTAC的检测结果表明, CTAC和活性炭的结合非常稳定.     

Polyphenylene sulfide based anion exchange fiber: Synthesis, characterization and adsorption of Cr(VI)

A fibrous strong base anion exchanger (QAPPS) was prepared for the first time via chloromethylation and quaternary amination reaction of polyphenylene sulfide fiber (PPS), and its physical-chemical structure and adsorption behavior for Cr(VI) were characterized by FT-IR, Energy Dispersive Spectrometry, TG-DTG, elemental analysis and batch adsorptive technique, respectively. The novel fibrous adsorbent could effectively adsorb Cr(VI) over the pH range 1-12, the maximum adsorption capacity was 166.39 mg/g at pH 3.5, and the adsorption behavior could be described well by Langmuir isotherm equation model. The adsorption kinetics was studied using pseudo first-order and pseudo second-order models, and the t_1/2 and equilibrium adsorption time were 5 and 20 min respectively when initial Cr(VI) concentration was 100 mg/L. The saturated fibers could be regenerated rapidly by a mixed solution of 0.5 mol/L NaOH and 0.5 mol/L NaCl, and the adsorption capacity was well maintained after six adsorption-desorption cycles.     

两种铁基材料对污染农田土壤砷、铅、镉的钝化修复

制备得到了铁钙（FeCa）和铁锰（FMBO）两种铁基材料,用于钝化修复As、Pb和Cd污染土壤.研究采集了来自绍兴上虞（SY）、广东佛山（FS）、广东韶关（SG）、湖南浏阳（LY）、江西赣州（GZ）、贵州独山（DS）和安徽马鞍山（MAS）的7种重金属污染水稻土（潮泥土）,通过土壤培养试验,研究铁钙材料（FeCa）和铁锰材料（FMBO）对各类土壤溶液中As、Pb和Cd浓度动态变化的影响,对土壤中有效态As、Pb和Cd钝化效果的影响,以及在不同种类土壤中有效态As、Pb和Cd钝化效果差异及影响因素.结果表明,培养过程中,铁基材料处理下土壤溶液中As、Pb和Cd浓度均低于对照处理.研究发现,两铁基材料均能对土壤中As、Pb和Cd起到较好的钝化作用,相同添加量下,铁钙材料对土壤As的钝化效率优于铁锰材料,而材料之间对土壤Pb和Cd钝化效率无显著差异.铁钙材料处理下各种土壤As钝化效果表现为GZ > SG > DS和MAS,土壤铅钝化效果表现为FS>SY、LY和SG>MAS,土壤镉钝化效果表现为SY、GZ和DS>MAS;铁锰材料处理下各种土壤As钝化效果表现为SY、LY和GZ > DS > FS,土壤Pb钝化效果表现为FS > GZ > SY,土壤Cd钝化效果表现为DS > LY > MAS.各种土壤As钝化效率在两铁基材料处理下均与土壤黏土含量呈显著负相关,各种土壤Pb钝化效率在两铁基材料处理下均与土壤pH呈显著正相关,各种土壤Cd钝化效率在铁钙材料处理下与土壤黏土含量显著负相关.总体来看,两铁基材料均适用于各不同种类As、Pb和Cd污染土壤的治理.     

运用涂铁砂粒进行分散式饮水除砷的效果

采用铁盐处理普通河砂研制成涂铁砂粒(IOCS),通过静态和动态吸附试验观察其分散式饮水除砷效果,并选取地砷病现场进行了验证.结果表明,IOCS性质较为稳定,扫描电镜下可见铁氧化物呈片状分散的覆盖在砂粒表层;IOCS无需活化处理,其对砷的最大吸附发生在30min～60min;pH5～9时,五价砷的去除率随着pH值的升高而下降,三价砷的去除率变化不明显.IOCS对砷的吸附符合朗格缪尔(Langmuir)吸附方程;5次滤柱循环中,75g(50ml)的IOCS分别处理含砷1.0mg·L^-1的水样408～426床(三价砷),390～412床(五价砷),用0.2 mol·L^-1NaOH进行再生处理,砷回收率均在94%以上.充填IOCS 3.0kg的家庭用模拟装置处理含1.0mg·L^-1的五价砷209L和198L,三价砷196L和185L,并在现场实验期间,连续处理含砷0.202～1.733mg·L^-1的水样200L,对水质亦无不良影响.无论是经济上还是技术上,IOCS均是适合于分散式饮水除砷的一种新型除砷剂.     

Modified activated carbon with interconnected fibrils of iron-oxyhydroxides using Mn2 + as morphology regulator, for a superior arsenic removal from water

The arsenic removal efficiency of iron-modified activated carbons depends greatly on the number of available iron oxide surface sites, which are given by the surface area of the anchored particles. In this sense, aiming the generation of an adsorbent with superior arsenic adsorption capacity, we developed a protocol to anchor interconnected fibrils of iron oxyhydroxides, using Mn^2 + as a morphology regulator. The protocol was based on a microwave-assisted hydrothermal method, using bituminous based activated carbon and both Fe^2 + and Mn^2 + ions in the hydrolysis solution. The elemental analysis of modified carbons revealed that Mn does not anchor to the carbon. However, when Mn is included in the hydrolysis solution, the iron content in the activated carbon increased up to 3.5?wt%, without considerable decreasing the adsorbent surface area. Under specific hydrothermal conditions, the Mn^2 + promoted the formation of iron oxide nanoparticles shaped as interconnected fibrils. This material showed a superior arsenic adsorption capacity in comparison to similar iron modified activated carbons (5?mg As/g carbon, at 2?mg As/L), attributed to the increase in quantity and availability of active sites located on the novel interconnected fibrils of iron oxyhydroxides nanostructures.     

巯基棉纤维对多种微量元素吸附性能的研究

本文研究了自制的巯基棉纤维对十六种微量元素的定量吸附条件、吸附速度、吸附量、吸附强弱顺序和解脱条件。讨论了巯基棉纤维的制备、保存、稳定性、再生使用及吸附时共存物的干扰与消除等问题。 实验得知,巯基棉纤维是一种良好的固体吸附剂,它可以定量吸附水溶液中多种微量重金属离子和某些非金属离子,具有富集倍数大、吸附率高、吸附速度快、选择性强、解脱性能好等优点,且制备简单、操作方便、易于推广。     

场地土壤中有效态砷的稳定化处理及机理研究

分别以生石灰和亚铁盐作为辅助剂与稳定剂对2种砷污染的土壤进行稳定化处理,通过化学浸出、形态及结构研究,揭示土壤中有效砷的稳定效率和机理.结果表明,外源铁添加量与土壤砷含量(Fe/As)的物质的量比达到6:1~8:1,CaO投加比例为0.05%~0.1%(w/w)时,土壤中有效态砷的稳定效率超过85%.土壤有效砷的稳定化处理主要是将砷从非专性吸附态和专性吸附态转化为弱结晶的铁铝或铁锰水化氧化物结合态、结晶铁铝或铁锰水化氧化物结合态.稳定处理后2种污染土均有新物相羟砷铜矿(As2Cu5H4O12)生成.