羟基乙叉二膦酸镀铜废液的处理及Cu~(2+)的高附加值资源化回收

采用Na BH4还原法将羟基乙叉二膦酸(HEDP)镀铜废液中的Cu~(2+)制备成纳米铜粉,并采用聚丙烯酰胺(PAM)对还原反应后的废液进行絮凝处理。研究了n(Cu~(2+))∶n(Na BH4)、还原反应温度、还原反应时间及PAM添加量对废液中剩余Cu~(2+)质量浓度的影响,并对回收的纳米铜粉进行了XRD和TEM表征。实验结果表明:当n(Cu~(2+))∶n(Na BH4)=4∶6、还原反应温度为50℃、还原反应时间为2 h时,废液中剩余Cu~(2+)质量浓度降低至1.1 mg/L,Cu~(2+)还原率达99.99%;可获得粒径为20~45 nm的近球型、高纯度、由多晶组成的纳米铜粉;当PAM添加量为10 mg/L时,废液中剩余Cu~(2+)质量浓度降至0.35 mg/L以下,达到GB 21900—2008《电镀污染物排放标准》(小于0.5 mg/L)的要求。     

臭氧氧化6-APA制药厂生化处理出水的特性及动力学简

通过现场实验研究了6-APA制药厂生化处理出水的臭氧氧化特性及其动力学规律。结果表明，当臭氧浓度为27.5 mg/L，气水接触时间为80 min时，COD、UV₂₅₄、NH₃-N和色度的去除率分别可达72.95%、73.28%、72%和96.25%，达到《发酵类制药废水工业水污染物排放标准》（GB 21903-2008）排放控制要求。拟合结果表明，在0~10、10~30和30~90 min时段内，臭氧氧化过程遵循拟一级反应，但反应速率逐渐降低。当气水接触时间为30 min时，废水可生化性可由0.1提高至0.35，采用臭氧/生物处理的联合工艺也有望使出水达到相同的排放控制要求。     

Case study of landfill leachate recirculation using small-diameter vertical wells

A case study of landfill liquids addition using small diameter (5 cm) vertical wells is reported. More than 25,000 m³ of leachate was added via 134 vertical wells installed 3 m, 12 m, and 18 m deep over five years in a landfill in Florida, US. Liquids addition performance (flow rate per unit screen length per unit liquid head) ranged from 5.6 × 10^?8 to 3.6 × 10^?6 m³ s^?1 per m screen length per m liquid head. The estimated radial hydraulic conductivity ranged from 3.5 × 10^?6 to 4.2 × 10^?4 m s^?1. The extent of lateral moisture movement ranged from 8 to 10 m based on the responses of moisture sensors installed around vertical well clusters, and surface seeps were found to limit the achievable liquids addition rates, despite the use of concrete collars under a pressurized liquids addition scenario. The average moisture content before (51 samples) and after (272 samples) the recirculation experiments were 23% (wet weight basis) and 45% (wet weight basis), respectively, and biochemical methane potential measurements of excavated waste indicated significant (p < 0.025) decomposition.     

固定化微生物对渗滤液DTRO出水中氨氮降解的研究

采用固定化微生物技术处理渗滤液DTRO出水中氨氮,考察不同HRT、DO以及温度对反应体系脱氮的影响。结果表明:反应器驯化周期短,能够有效地去除反应体系中的氨氮和COD,其去除率分别为98.68%、78.19%。驯化后期,反应体系中出现轮虫、累枝虫、寡毛类动物。不同水力停留时间(HRT)、溶解氧(DO)、温度影响固定化微生物脱氮效果,通过试验得出最佳工艺条件为:HRT为5 d,ρ(DO)为4.0 mg/L,温度为25~30℃。在最佳工艺条件下,出水ρ(NH_4~+-N)为13.01~19.96 mg/L,ρ(COD)为6.78~12.07 mg/L,达GB 16889—2008《垃圾填埋场污染控制标准》。     

铁炭内电解垂直流人工湿地对污水厂尾水深度脱氮效果

针对污水厂尾水总氮(TN)含量偏高、微生物可利用碳源低的问题,构建铁炭内电解垂直流人工湿地(ICIE-VFCW)装置,研究了ICIE-VFCW对尾水的处理效果,并采用紫外-可见光光谱(UV-VIS)、凝胶过滤色谱(GFC),进一步探讨了ICIEVFCW强化脱氮机制.结果表明,ICIE-VFCW可提高系统对尾水中COD的去除,出水COD可稳定在30 mg·L~(-1)以下,全年、暖季、寒季COD平均去除率较普通垂直流人工湿地分别可提高10.16%、9.81%、11.22%.系统出水TN可维持在10 mg·L~(-1)以下,全年、暖季、寒季TN平均去除率较普通垂直流人工湿地分别提高13.72%、12.90%、16.17%.经过人工湿地处理后,污水中有机物的腐殖度、芳香度及相对分子质量(Mr)均有所下降,且ICIE-VFCW中Mr下降更为明显.湿地基质掺杂铁炭可促进尾水中大分子有机物转化为小分子,为微生物提供更多可利用碳源,从而提高脱氮效率.     

Removal of Cu(II) from acidic electroplating effluent by biochars generated from crop straws

The removal efficiency of copper(Cu(Ⅱ)) from an actual acidic electroplating effluent by biochars generated from canola,rice,soybean and peanut straws was investigated.The biochars simultaneously removed Cu(Ⅱ) from the effluent,mainly through the mechanisms of adsorption and precipitation,and neutralized its acidity.The removal efficiency of Cu(Ⅱ) by the biochars followed the order:peanut straw char > soybean straw char > canola straw char > rice straw char a commercial activated carbonaceous material,which is consistent with the alkalinity of the biochars.The pH of the effluent was a key factor determining the removal efficiency of Cu(Ⅱ) by biochars.Raising the initial pH of the effluent enhanced the removal of Cu(Ⅱ) from it.The optimum pyrolysis temperature was 400°C for producing biochar from crop straws for acidic wastewater treatment,and the optimum reaction time was 8 hr.     

Decolorization of oxygen-delignified bleaching effluent and biobleaching of oxygen-delignified kraft pulp by non-white-rot fungus Geotrichum candidum Dec 1

Decolorization of oxygen-delignified bleaching effluent (abbreviated as OBE) and biobleaching of oxygen-delignified kraft pulp (OKP) were conducted using a non-white rot fungus Geotrichum candidum Dec 1 (abbreviated as Dec 1) which has ability to decolorize various synthetic dyes and molasses. Dec 1 decolorized up to 77% of OBE for 6 days. In addition, Dec 1 increased the brightness of OKP from 47.8% to 51.2% and decreased the kappa value of OKP from 12.4 to 10.4 points during a 6-day incubation period at a 25% of pulp-concentration. At 2% pulp-concentration, the brightness of OKP increased by 13% and the kappa value of OKP decreased by 4 points only for a 3-day incubation period. When the decolorized OBE was used for bleaching of OKP, the brightness of OKP increased to 62.7% under the shaking culture to a 2% pulp-concentration using culture fluid of decolorized OBE. It was revealed that Dec 1 is a potential to apply for decolorization of wastewater and biobleaching of pulp in paper-mills.     

垃圾填埋场中真细菌群落16S rRNA基因的分析

回灌式垃圾填埋场渗滤液中真细菌群落的多样性同样通过不依赖于微生物培养的分析而获得。利用特异性的引物对,选择性地扩增渗滤液DNA中的真细菌16S rRNA基因片断(16S rDNA),并用于构建16S rDNA克隆文库。文库内真细菌16S rDNA的遗传多样性通过限制片断长度多态性分析(RFLP,限制性内切酶Hin PII和Msp I)而获得。初步的结果表明,随机选出的200个真细菌克隆子被分为147个不同的RFLP型(组),当中丰度最高的两个型均仅含有9个克隆子,两者共占所有被分析克隆子的不到10%;克隆子数≥2的型共有21个(包括以上2个丰度最高的型),它们共代表74个克隆子,占所有被分析克隆子的37%;而剩下的126个型均只含有1个克隆子,它们共占整个基因文库的63%。由此可见,李坑垃圾渗滤液中的真细菌具有非常复杂的群落结构。     

回流对陈垃圾生物反应器处理老年渗滤液污染物影响

为了研究回流对陈垃圾反应器处理老年渗滤液污染物的影响,构建了回流的陈垃圾生物反应器,试验了不同温度、负荷和回流比条件下反应器对污染物的去除效果。结果表明,在较低水力负荷12.8~25.5 L/(d.m2)的情况下,陈垃圾反应器对NH3-N、BOD5和COD等污染物的去除率分别达到90%、95%和70%以上。在不同温度下提高水力负荷,回流会抑制氨氮和COD的去除,但可显著提高TN的去除率,表明回流可作为提高老年渗滤液TN去除率的途径之一。利用氮同位素示踪技术发现反应器中有Anammox脱氮途径存在。但是可利用碳源的缺乏仍是提高老年渗滤液脱氮效率的限制因子。     

人工湿地净化海水养殖外排水影响因素与效果实验研究

以海水养殖外排水为处理对象,构建芦苇复合垂直流人工湿地模拟系统进行处理效果的影响因素(盐度,水力负荷,污染负荷)实验。植物选择芦苇,种植密度为48株/m2,基质填料选择细纱、蛭石、高炉矿渣、沸石和砾石。实验结果显示,随着盐度的升高,人工湿地对CODMn和NH4-N的去除率差异不显著(P>0.05),对PO4-P的去除率在逐渐降低,变化显著(P<0.05),但芦苇表现出较强的耐盐性,在盐度20时生长良好。随着水力负荷的增加,人工湿地对CODMn、NH4-N和PO4-P的去除率呈现出降低的趋势,变化显著(P<0.05);而当污染负荷增加时,去除率呈现出先增加后降低的趋势。综合考虑运行合理性及运行效果,得出合理工况为盐度20,水力负荷0.4 m3/(m2.d),污染负荷CODMn 10 mg/L,NH4-N 2 mg/L,PO4-P 0.5 mg/L。在此工况下,系统稳定运行2个月,显示人工湿地对海水养殖外排水中的污染物具有较好的去除效果。