超声处理对提取苦杏仁挥发油的研究

研究了超声处理对提取苦杏仁挥发油的影响。结果表明,超声处理有利于提高苦杏仁挥发油的得率,在所选取的范围内随功率和时间的增加而提高;通过正交实验确定影响挥发油得率的因素从大到小依次为超声功率、物料细度、pH和处理时间,确定最优工艺组合是物料细度为80目;在pH值为5的提取液中浸泡后,超声功率为100W处理30min。经分析,超声处理得到挥发油样品的主要成分是苯甲醛。     

蜈蚣草总黄酮提取工艺的优选

采用水浴法提取总黄酮,以蜈蚣草为原料、总黄酮得率为考察指标,通过正交试验研究乙醇浓度、提取时间、提取温度及料液比对提取蜈蚣草总黄酮得率的影响。结果表明,各因素对总黄酮提取率的影响程度为∶乙醇浓度提取时间提取温度料液比;最佳的提取工艺条件为:乙醇浓度60%,料液比1∶15,提取温度60℃,每次3h,提取3次,在此条件下提取的总黄酮得率为6.15%。     

响应面法优化西兰花总黄酮提取工艺的研究

利用响应面法优化西兰花总黄酮的提取工艺条件。在预试验的基础上,以乙醇为溶剂,提取西兰花总黄酮。选取提取温度、提取时间及液固比、乙醇浓度4个因素进行Box-Benhnken中心组合设计,利用响应面分析法对提取工艺参数进行优化。结果表明,西兰花总黄酮的提取工艺为:乙醇浓度90%,液固比30∶1,提取温度85.28℃,提取时间1.82h;预测值为0.887%,实际得率为0.853%,两者较接近,说明Box-Behnken设计结合响应面分析法可很好地对西兰花总黄酮提取工艺进行优化。     

长梗黄精主根与须根多糖的提取工艺研究

对长梗黄精主根与须根多糖的提取工艺进行了研究.在对乙醇浓度、浸提温度、浸提时间和粉碎粒度等进行单因素试验的基础上,通过正交试验确定了长梗黄精主根与须根多糖提取的最佳工艺条件,即对长梗黄精主根多糖的提取最佳条件为乙醇浓度80％、浸提温度80℃、浸提时间50min、颗粒大小40目,此时多糖提取率为18.754％;而对长梗黄精须根多糖的提取最佳条件为乙醇浓度70％、浸提温度60℃、浸提时间30min、颗粒大小80目,此时多糖提取率为16.652％.须根多糖含量与主根含量差异性不显著,故须根的利用价值也很高,有待开发利用.     

花生壳中黄酮物质的提取及对油脂的抗氧化作用

对花生壳中黄酮物质的提取工艺进行了优化研究，并对提取物的抗氧化性进行了初步研究。用单因素试验分别对提取溶剂乙醇体积分数、料液比、提取时间及提取温度进行了研究。在此基础上，通过正交试验确定上述4个因素的最佳组合。优化后花生壳中黄酮的最大提取率为92．32％，花生壳中黄酮类化合物的适宜提取条件为乙醇体积分数60％、料液比1：30、提取时间150min、提取温度60℃。花生壳中黄酮类化合物对猪油有明显的抗氧化作用，当添加量为0．2％时抗氧化效果与0．2％BHT接近。     

屯绿陈茶有效成分提取及茶多酚提纯工艺研究

探讨了从陈茶中提取有效成分和茶多酚的提纯工艺。采用不同物料比、浸提温度、浸提时间的正交实验，通过热水煮提从茶叶中获取水溶性物质。结果表明，当料液比为1：20、90℃、120min时，测得的水提取物固化物量最多可达31％；茶叶水提物固化物、水配比为13：400时与乙酸乙酯萃取茶多酚的得率达23％，茶多糖从总量中提取的得率达2．5％。屯绿陈茶有效成分保留效果良好，具有较好的综合利用价值。     

利用超声波辅助提取苦杏仁精油的工艺研究

在超声波作用下,通过使用不同溶剂,研究了苦杏仁中精油的提取方法。结果表明,超声处理有利于提高苦杏仁精油的提取率。通过正交实验确定影响其收率的因素,从大到小依次为料液比、提取温度和提取时间,确定最优工艺为:乙酸乙酯和四氢呋喃的混合溶剂(1∶1,V/V)为提取剂,料液比1∶20,提取温度20°C,提取时间30min,此条件下提取率为16.20%。本研究结果为纯天然苦杏仁精油的提取工艺提供了技术参数。     

超声波辅助提取杜仲籽油的工艺优化

以杜仲籽为原料,应用超声波辅助法提取杜仲籽油.在单因素试验的基础上,通过正交试验确定了超声波辅助提取杜仲籽油的较佳工艺条件.结果表明,杜仲籽油的较佳提取工艺条件为料液比12ml/g,提取温度50℃,提取时间15min,超声波功率225W,在该条件下杜仲籽油得率27.24%.     

柑橘皮中果胶提取条件的研究

利用酸性水解乙醇沉淀法提取果胶,分别测定了不同的浸泡时间、酸碱度及水解温度对果胶产率的影响.结果表明:浸泡时间与水解时间过长或过短,酸碱度及水解温度过高或过低,果胶的产率均不高,只有浸泡时间在2h左右、水解时间在2～2.5h、pH在2～3之间、水解温度在80～95℃时果胶的得率最大.     

银杏叶中有效成分的提取

通过使用不同溶剂比较了两种装置提取银杏叶中有效成分的优缺点。结果表明，简易装置所用时间较短、收率较高且操作简单方便；利用95％乙醇作为提取剂在使用简易装置时，银杏叶粗提物得率最高。     

黄曲霉侵染对不同品种花生生理特性的影响

以高抗黄曲霉花生品种J11、中抗品种HY22和敏感性品种JH1012为材料进行黄曲霉侵染,在不同时间段取样测定各品种花生种皮和籽仁的毒素含量,并同时测定籽仁中脂肪酸和亚油酸、油酸含量。结果表明,各花生品种的种皮内毒素含量随侵染时间增加而升高,到最大值后保持稳定;而籽仁中的毒素含量较低,不同品种花生受侵染后毒素含量大小表现为高抗品种〈普通品种〈高感品种。亚油酸和脂肪含量与黄曲霉毒素含量呈显著正相关,而油酸呈显著负相关,说明高油酸含量和低脂肪、亚油酸含量的花生品种对黄曲霉毒素的侵染有一定抵抗作用。     

Free-air carbon dioxide enrichment of soybean: influence of crop variety on residue decomposition

Elevated atmospheric CO2 can result in larger plants returning greater amounts of residue to the soil. However, the effects of elevated CO2 on carbon (C) and nitrogen (N) cycling for different soybean varieties have not been examined. Aboveground residue of eight soybean [Glycine max (L.) Merr.] varieties was collected from a field study where crops had been grown under two different atmospheric CO2 levels [370 micromol mol(-1) (ambient) and 550 micromol mol(-1) (free-air carbon dioxide enrichment, FACE)]. Senesced residue material was used in a 60-d laboratory incubation study to evaluate potential C and N mineralization. In addition to assessing the overall effects of CO2 level and variety, a few specific variety comparisons were also made. Across varieties, overall residue N concentration was increased by FACE, but residue C concentration was only slightly increased. Overall residue C to N ratio was lower under FACE and total mineralized N was increased by FACE, suggesting that increased N2 fixation impacted residue decomposition; total mineralized C was also slightly increased by FACE. Across CO2 levels, varietal differences were also observed with the oldest variety having the lowest residue N concentration and highest residue C to N ratio; mineralized N was lowest in the oldest variety, illustrating the influence of high residue C to N ratio. It appears (based on our few specific varietal comparisons) that the breeding selection process may have resulted in some varietal differences in residue quality which can result in increased N or C mineralization under elevated CO2 conditions. This limited number of varietal comparisons indicated that more work investigating varietal influences on soil C and N cycling under elevated CO2 conditions is required.     

Validation of procedures to quantify nonextractable polycyclic aromatic hydrocarbon residues in soil

This study was conducted to optimize butanol solvent shake extraction, dichloromethane soxtec extraction, and methanolic saponification extraction for the selective extraction of aged polycyclic aromatic hydrocarbons from soil. Extraction kinetics for these methods was established to determine the optimal time necessary to achieve exhaustive compound extraction. This resulted in times of 12, 6, and 5 h, respectively, for butanol, dichloromethane, and saponification, to extract polycyclic aromatic hydrocarbons from previously spiked, then aged soil. Increasing the soil mass to butanol volume ratio reduced the proportion of polycyclic aromatic hydrocarbon extracted by butanol, highlighting the importance of determining and maintaining a constant soil to solvent ratio for comparative purposes. Drying soil samples before dichloromethane soxtec extraction reduced by 30 to 76% the amount of polycyclic aromatic hydrocarbons extracted. The effect of sample drying is discussed with relevance to enhancing the formation of nonextractable compounds in soil and compound losses previously assumed by volatilization. The optimized extraction procedures provided low variability with relative standard deviations < or = 5.2% for analysis of multiple replicates. The results obtained by the optimized procedures provided equivalent or improved reproducibility to those obtained by other methods reported in the literature.     

超声波提取西兰花中叶黄素的工艺研究

以西兰花真空冻干粉为原料，探明了超声波强化四氢呋喃提取叶黄素的工艺条件。在确定适合提取料液比后，采用正交试验研究了超声波功率、提取温度、超声作用时间对提取量的影响。结果显示，较理想的提取条件为：超声波功率400W、提取温度40℃、超声波作用时间10min。在此条件下，叶黄素提取量最高。通过方差分析可知，温度影响达到0．05的显著水平。     

从抽提叶绿素后的蚕沙中提取叶蛋白

本文分析了从抽提叶绿素后的蚕沙中提取叶蛋白的工艺条件。结果表明：以０７％ＮａＯＨ作提取剂,料比１∶７,于６０℃搅拌提取６ｈ,叶蛋白的提取率为８４１２％;再用（１＋１）ＨＣｌ调ｐＨ值为３５,即得叶蛋白沉淀。按上述工艺条件,叶蛋白得率（以蚕沙干物计）为１００９％,蛋白质含量为７６６８％,提高了蚕沙的综合利用价值     

Studies on solvent extraction of iron(III) as a step for conversion of a waste effluent to a value added product

Solvent extraction of iron(III) from actual sulphate waste pickle liquor was investigated using trialkylphosphine oxide diluted with kerosene. The waste pickle liquor was procured from a local company which deals with the manufacturing of pipes and tubes made of iron and steel. Various parameters were studied to optimise a suitable condition for the maximum extraction of iron. The composition of the aqueous feed used in the experiment was 60.88 g/L Fe(III), 53 g/L acid with traces of Cu, Ni and Co. An ambient extraction at 30 °C yielded acceptable kinetics and loading efficiency for 40% trialkylphosphine oxide with a saturated loading capacity of 51.85 g/L in four contacts at O/A ratio of 1/1 in a multiple contact mode. Iron from the loaded organic was stripped using various strippants such as distilled water, H₂SO₄ and oxalic acid. Since only 32% of loaded Fe could be stripped with 2 M H₂SO₄ in five contacts, further stripping was done with 5% oxalic acid which showed a very promising result. It was found that almost 100% of Fe(III) could be stripped out with 5% oxalic acid at O/A of 1/1 in five contacts.     

超声辅助大蒜多糖提取研究

大蒜多糖具有众多的生理功能，有很高的经济价值。以大蒜为原料，采用超声辅助酶解法提取大蒜多糖，具有高速、高效、节能、环保等优点。在单因素试验的基础上，通过正交试验进一步优化提取工艺条件，确定影响提取率的主次因素分别为超声酶解时间、料液比、提取温度和提取时间。结果表明，先期酶解条件为温度50℃、pH5．O、酶用量5．0％，最佳提取条件为超声波酶解时间40min、料液比（m／V）1：3、提取温度85℃、提取时间50min，多糖提取率达72．64％。     

Optimal conditions of Al and Fe extraction from laterite soil using D-optimal design

This paper reports pioneering work in identifying an alternative coagulation agent of wastewater treatment, given the availability of commonly used agents are of a higher cost relative to more natural sources, such as soil. The alternative proposed is laterite soil from northern Malaysia because it contains high amounts of Al and Fe, which are well-known coagulants. The soil was grinded and sieved to obtain uniform particle sizes of <250???m. Al and Fe were extracted from the soil. Extraction agents: (1) HCl, (2) NaOH, and (3) HCl?+?NaCl were chosen. It was found that the most effective agent to extract Fe was 5?N HCl while to extract Al was HCl?+?NaCl, 2 and 4?N, respectively. D-optimal design observed that extraction time t, temperature T, and ratio of amount of laterite soil to amount of extractants r, showed a significant effect on Al extraction. In contrast, the combination of factors t and r exhibited insignificant effect on Fe extraction while other factors were significant. The optimum conditions for extraction of both Al and Fe were 90?°C, 40?min, for r?=?1:15, which gave [Fe]?=?1,870?mg/l and [Al]?=?0.17?mg/l and 90?°C, 90?min, for r?=?1:10, which gave [Fe]?=?2,900?mg/l and [Al]?=?0.130?mg/l. Since concentration of Fe extracted from laterite soil was high, it was concluded that laterite soil can be considered as an alternative and novel source of coagulant applicable in a wastewater treatment coagulation process.     

综合利用江油电厂粉煤灰的研究(二)——从自粉化料中提取氧化铝

本文利用正交设计研究了浸取剂浓度、浸取温度、浸取时间、料液比对从自粉化料中提取氧化铝的影响;找出了影响提取氧化铝的主要因素;推荐了从自粉化料中提取氧化铝的最佳条件。